Multiquip AR13HA manuale d’uso

OPERA TION AND P AR TS MANUAL THIS MANU AL MUST A CCOMP ANY THE EQUIPMENT A T ALL TIMES. T o find the latest re vision of this publication, visit our website at: www .multiquip.com MODELS AR13HA AR13HAR RIDE-ON T ANDEM DRUM ROLLER SERIES DRIVE SYSTEM (HONDA GX630RQZB2 GASOLINE ENGINE) Serial No. 110301 and ABOVE Re vision #0 (06/22/11)[...]

P A GE 2 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) PROPOSITION 65 W ARNING[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 3 T ABLE OF CONTENTS AR13HA/HAR Ride-On T andem Roller Proposition 65 Warning ........................................... 2 T able Of Contents .................................................... 3 Saf ety Inf or mation .................[...]

P A GE 4 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) SAFETY INFORMA TION Do not operate or service the equipment bef ore reading the entire manual. Saf ety precautions should be follo wed at all times when operating this equipment. F ailure to read and understand the safety messages and [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 5 SAFETY INFORMA TION GENERAL SAFETY CA UTION  NEV ER ope ra te this equ ipm ent wit hou t pro per pro tec tiv e clothing, shatter proof glasses, respirator y protection, hea ring pr ote cti on, ste el- toe d bo ots an d ot her pr ote[...]

P A GE 6 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) SAFETY INFORMA TION ROLLER SAFETY D ANGER  N E V E R op e r at e th e eq u i p m e n t in an e xp l o s i v e a t m o sp h er e o r ne ar c o m b us ti b l e ma te ri a l s . An e xp lo si on o r fi re co ul d re su lt c a us i ng [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 7 SAFETY INFORMA TION NO TICE  NEVER r un engine without an air fi lter or with a dir ty air fi lter . Sev ere engine damage may occur . Ser vice air fi l ter frequently to pre vent engine malfunction.  NEVER tamper with the fac[...]

P A GE 8 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) SAFETY INFORMA TION rinse skin or clothing immediately with plenty of water .  If the batter y liquid (dilute sulfuric acid) comes into contact with eyes , rinse ey es immediately with plenty of water and contact the nearest doctor [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 9 SPECIFICA TIONS T able 1. Specifications (Roller) Shipping W eight 2,572 lbs. (1,167 Kg.) Dr y Weight 2,428 lbs. (1101 Kg.) Operating Weight 3,088 lbs. (1,400 Kg.) Operating Weight w/ Drum Ballast 3173 lbs. (1,439 Kg.) Over all Length[...]

P A GE 10 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) SPECIFICA TIONS T able 2. Specifications (Engine) Model Honda GX630RQZB2 Engine T ype Air-Cooled 4 Stroke , Overhead V alve, 2 cylinders (90 degree V -T win), Gasoline Engine. Piston Displacement 37.5 cu. in. (614 cc) [Bore x Stroke][...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 11 DIMENSIONS Figure 1. Roller Dimensions T able 3. Dimensions (Roller) Wheelbase A 45.0 in. (1,143 mm.) Drum Diameter B 22.6 in. (574 mm.) Curb Clearance C 7.75 in. Left, 19.0 in. Right ( 197 mm., 483 mm.) Drum Width D 35.7 in. (907 mm.[...]

P A GE 12 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) GENERAL INFORMA TION The AR13HA/HAR roller has been designed for asphalt a pp l ic a ti o n an d c om p ac t io n o f g ra nu l ar s o il s u s e d i n site preparation. Use the machine only for the pur pose intended and by e xperienc[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 13 GENERAL INFORMA TION The forward-re verse control le ver operates the h ydrostatic pump which gov er ns the roller speed and direction of tra vel. The speed in which movement of this lev er is made is directly related to the amount of[...]

P A GE 14 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) COMPONENTS 2 1 6 7 3 17 9 4 14 1 1 12 13 21 16 18 19 20 25 22 23 5 8 10 15 24 Figure 4. Roller Components[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 15 COMPONENTS Figure 4 shows the location of the components and basic co mpo nen ts f or the AR13 HA com pac tio n roll er . The fun cti on of each component or control is described below: 1. Battery — Provides +12VDC to the electrical[...]

P A GE 16 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) COMPONENTS 31 28 32 39 27 26 30 33 34 29 35 37 36 38 42 40 41 Figure 5 shows the location of additional components f or the AR13HA compaction roller . The function of each component or control is described below: 26. Front Sprinkler S[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 17 BASIC ENGINE Figure 6. Engine Components The engine (Figure 6) must be checked for proper lubrica tion and filled with fuel prior to opera tion. Ref er to the manuf acturer's engine manual for operation and ser vicing inf or mat[...]

P A GE 18 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) INSPECTION BEFORE ST ARTING 1. Read saf ety instructions at beginning of manual. 2. Clean the roller , removing dir t and dust, par ticularly the engine cooling air inlet, carburetor and air cleaner . 3. Check the air filter f or dir[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 19 INSPECTION FUEL CHECK 1. T o check the engine fuel lev el, place the roller on secure le vel g round with the engine stopped. 2. Tilt the operator's seat (Figure 10) forw ard to gain access to the fuel tank. Figure 10. Fuel T ank[...]

P A GE 20 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) INSPECTION 3. If the h ydraulic oil le vel is low , remove the hydr aulic oil cap (Figure 14) and fill with type ISO 46 anti-wear type hydr aulic oil to the recommended operating lev el. Figure 14. Hydraulic Oil Reser v oir Filler P [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 21 OPERA TION ST ARTUP 1. Place your foot into the roller's foot step , grab hold of the hand rail located on the steering console, and lift yourself onto the platf or m. 2. Sit down in the operator's seat and adjust the seat f[...]

P A GE 22 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) OPERA TION P ARKING BRAKE 1. T o release the parking brake, press and hold the release button (Figure 21) pull up slightly on the parking lev er , then push the parking brake le ver all the wa y down. Figure 21. Brake Release Lever SH[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 23 MAINTENANCE MAINTENANCE P erform roller maintenance as indicated by Figure 25 and T able 5. Figure 25. Roller Maintenance Schedule 4 5 6 7 3 6 2 7 Weekly Daily 1 8 9 5 Bi-Weekly 10 3 Months 6 Months Y early 14 12 13 T able 5. Roller M[...]

P A GE 24 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) HYDRA ULIC OIL SYSTEM The hydr aulic system consists of a two-pump stack directly coupled to the engine. A hydr aulic valve bloc k (manifold) is provided for quick and easy testing and troubleshooting. Hydraulic oil is filtered by a [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 25 MAINTENANCE Remember the freewheel engagement valv e should only be used in emergencies when the roller cannot be dr iv en due to engine or h ydraulic system problems . When towing of the roller has been completed, this valv e must be[...]

P A GE 26 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) F ORWAR D / R EV E R S E H Y D R A U L IC P R ES S U R E TEST 1. P ark the machine on a solid flat surface and stop the engine. Set the par king brake and block the front drum securely . 2. Check h ydraulic oil lev el by viewing the [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 27 MAINTENANCE FOR W ARD/REVERSE RELIEF V AL VES DRIVE ADJUSTMENT The f orward and rev erse relief valv es (Figure 30) are located in the hydrostatic pump (not on the manifold block) under plugs 1 and 2 . Plug 2 is located in the same lo[...]

P A GE 28 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) REMO VING AND REPLACING HYDROST A TIC PUMP 1. Set the parking brake . 2. Disconnect the batter y . 3. Clean the pump and all connections. 4. Mark and disc onn ect all hose s and line s fro m the pump . 5. Disconnect the f orward / re [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 29 MAINTENANCE STEP 2 STEP 1 Q P Q P STEP 3 1. JACK FRAME UP SLIGHTL Y A T ARTICULA TION JOINT . 2. REMOVE THE FOUR ALLEN HEAD SCREWS HOLDING THE SIDE COVER OF THE DRUM SUPPOR T PLA TE. 3. MARK AND DISCONNECT HOSES FROM MOTOR AND MANIFOL[...]

P A GE 30 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) MAINTENANCE M 1. JACK FRAME UP SLIGHTL Y A T ARTICULA TION JOINT . 2. REMOVE THE EIGHT ALLEN HEAD SCREWS HOLDING THE SIDE COVER OF THE DRUM SUPPOR T PLA TE. 3. MARK AND DISCONNECT HOSES FROM MOTOR. 4. REMOVE FOUR ALLEN HEAD SCREWS FRO[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 31 MAINTENANCE Figure 34. Rear Drum Removal/Installation REAR DRUM 1. JACK FRAME UP SLIGHTL Y A T ARTICULA TION JOINT . 2. REMOVE THE FOUR ALLEN HEAD SCREWS SECURING THE DRUM SUPPORT PLA TE TO THE FRAME. 3. REMOVE NUTS SECURING BEARING F[...]

P A GE 32 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) MAINTENANCE AL TERNA TOR/REGULA T OR This roller is equip ped with a 20-amp charging system. This system uses three charge coils connected in parallel. The windings of each coil are wound with heavy-duty insulated wir e and are fur th[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 33 PREP ARA TION FOR LONG-TERM STORAGE ROLLER ST ORA GE F or storage of the roller f or over 30 days, the f ollowing is recommended: 1. Drain the fuel tank completely , or add ST A-BIL to the fuel. 2. Run the engine until the fuel in the[...]

P A GE 34 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) MANIFOLD TEST POR TS[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 35 HYDRAULIC SYSTEM DIAGRAM W EXCITER V AL VE M 1 2 VIBRA TION EXCITER MOTOR MANIFOLD P EXCITER RELIEF V AL VE 2000 PSI G1 STEERING RELIEF V AL VE 700 PSI 3 P T 4 M W W R L STEERING CYLINDER STEERING V AL VE CHARGE PRESSURE RELIEF V AL V[...]

P A GE 36 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) HYDRAULIC HOSE CONNECTIONS FROM OPERA TOR’S POSITION D FROM OPERA TOR’S POSITION D G A A E E B F G H B F C C NOTES HOSES SHADED FOR VISUAL CLARITY . FRONT LEFT SIDE FRONT RIGHT SIDE MANIFOLD HYDRAULIC DRIVE PUMP[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 37 HYDRAULIC HOSE CONNECTIONS NOTES HOSES SHADED FOR VISUAL CLARITY . FROM OPERA TOR’S POSITION M K STEERING COLUMN L N J I REAR LEFT MOTOR FRONT RIGHT MOTOR P O Q P Q O I J MANIFOLD K L N M FRONT LEFT MOTOR[...]

P A GE 38 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) TROUBLESHOOTING T roubleshooting (Roller) SYMPT OM POSSIBLE PROBLEM SOLUTION Low Vibration Low engine RPM? Check and adjust engine speed. Low h ydraulic pressure? Check and adjust h ydraulic pressure. No Vibration No voltage to 12 v o[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 39 TROUBLESHOOTING T roubleshooting (Engine) Symptom P ossible Problem Solution Diffi cult to star t, fuel is availab le, but no spark at spark plug. Spark plug bridging? Check gap , insulation or replace spar k plug. Carbon deposit on [...]

P A GE 40 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) WIRING DIAGRAM WHT BLU TB1 FUEL PUMP RED HOUR METER CHASSIS GND. BLK 30 AMP FUSE +12VDC (B) (S) WHT CHASSIS GND. M CHASSIS GND. BA TTERY POSITIVE NEGA TIVE CHASSIS GND. ST ARTER MOTOR WHT WHT S B (BA TT .) G L M YEL YEL FUEL CUT -OFF [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 41 NOTES[...]

P A GE 42 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) EXPLANA TION OF CODE IN REMARKS COLUMN The following section explains the diff erent symbols and remarks used in the P ar ts section of this manual. Use the help number s fo und on the back page of the manual if ther e are any questio[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 43 SUGGESTED SP ARE P AR TS AR13HA RIDE-ON T ANDEM DRUM R OLLER (with Honda GX630RQZB2 Engine) 1 T O 3 UNITS Qty . P/N Description 1............510229 .................. CABLE, THRO TTLE 1............506239 .................. CABLE, CHOK[...]

P A GE 44 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) NAMEPLA TE AND DECALS REAR ROLLER 4 3 2 1 5 7 15 8 9 10 6 12 13 14 ENGINE HOURS 513457 CHOKE CAUTION WARNING! 345336 High RPM: RPM Low RPM: RPM USE WA TER ONL Y 5 1 3 6 9 8 THROTTLE REVERSE WA TER VAL VES FRONT PUSH TO START OPEN VIBR[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 45 NAMEPLA TE AND DECALS NO . P ART NO . P ART NAME QTY . REMARKS 1 513457 DECAL: STEERING CONSOLE 1 2 13118 DECAL: POWDER CO A TED 1 3 511726 DECAL: HYDRA ULIC OIL LEVEL INDICA T OR 1 4 511736 DECAL: W ARNING 1 5 511740 DECAL: MUL TIQUI[...]

P A GE 46 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) NAMEPLA TE AND DECALS 21 20 19 16 17 18 25 26 21 20 22 23 24 18 18 26 26 AR-13HA AR-13HA 511724 Read instruction manual before operation. Never leave machine unattended with the engine running. Keep unauthorized and untrained people a[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 47 NAMEPLA TE AND DECALS CONTINUED NO . P ART NO . P ART NAME QTY . REMARKS 16 513529 DECAL: AR-13H MQ LOGO 1 17 511738 DECAL: DANGER 1 18 513393 DECAL: SECURING POINT INDICA TOR ..........4................ POINT ARRO W UP 19 513469 DECA[...]

P A GE 48 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) FRONT DRUM ASSY .[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 49 FRONT DRUM ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 2 513280 FRONT R OLLER 1 4 506145 HOUSING BEARING 1 6 506147 BEARING 1 8 506136 RING, RET AINING 1 10 508665 COUPLER 1 12 506142 MOUNT , VIBRA TION MOT OR 1 14 011208025 BOL T[...]

P A GE 50 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) EXCITER ASSY . FRONT DRUM 70 74 76 64 46 58 66 52 62 74 70 64 60 54 48 46 44 INNER BEARINGS ARE INCLUDED WITH ITEM 64. 1 NOTES: 1[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 51 EXCITER ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 44 EM963610 CAPSCREW , 3/8" NC X 1-1/4" G8 ....................6................ REPLACES 492375 46 3019092 W ASHER, FLA T 3/8" ...................................[...]

P A GE 52 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) REAR DRUM AND CHASSIS ASSY .[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 53 REAR DRUM AND CHASSIS ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 2 513291 REAR DR UM 1 4 505988 ALLEN PLUG 1 6 492584 NUT , LOCK 1/2 IN. 1 8 503735 BEARING, FLANGE ..........................................1................ INCLU[...]

P A GE 54 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) COVERS AND FRAME AR TICULA TION LOCK ASSY . 30 161 138 140 138 136 32 34 33 238 240 142 6 4 170 162 164 167 166 168 22 STEERING CONSOLE 20 A 246 247 248[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 55 COVERS AND FRAME AR TICULA TION LOCK ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 4 513315 REAR W A TER T ANK CO VER 1 6 509177 BOL T 5/16 IN. 4 20 515416 FLOOR PLA TE/W ALUMINUM CO VER 1 22 509177 BOL T 5/16 X 5/8 IN. 10 30 514243[...]

P A GE 56 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) HOOD AND REAR P ANEL ASSY .[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 57 HOOD AND REAR P ANEL ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 2 515096 HOOD 1 6 492364 SCREW , HHC 5/16 X 18 X 1 IN. 2 8 505679 FLA T W ASHER 5/16 IN. 2 10 2105164 NUT , NYLON 5/16- 18 .......................................2..[...]

P A GE 58 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) STEERING COLUMN AND HYDRAULIC AR TICULA TION ASSY CLUTCH CABLE CONNECTS TO ENGINE 1 NOTES: SEE HYDRAULIC HOSE CONNECTIONS P AGES 34-35 K L L K HOSES CONNECT TO MANIFOLD STEERING V AL VE K L 174 180 182 176 184 58 26 30 34 36 28 52 32 [...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 59 STEERING COLUMN AND HYDRAULIC AR TICULA TION ASSY NO . P ART NO . P ART NAME QTY . REMARKS 14 EM923348 W ASHER, LOCK 5/8 IN. 2 16 EM969023 NUT , LOCK 5/8 IN. .............................................2 ................ REPLACES 492[...]

P A GE 60 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) AR TICULA TION ARM ASSY . 4 2 6 8 10 8 4 2 6[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 61 AR TICULA TION ARM ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 2 513294 ROD END 2 4 514347 BOL T 3/4 IN. x 2-1/2 IN. 2 6 EM505069 NUT 3/4 IN. 2 8 513295 NUT 3/4 IN. 2 10 513296 ROD , DIRECTION ST ABILIZER 1[...]

P A GE 62 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) HYDRAULIC DRIVE PUMP ASSY . 200 202 201 62 204 206 209 196 199 60 38 52 50 38 46 48 190 192 191 56 54 58 72 70 203 74 64 68 66 87 202 200 45 44 40 42 A B C F E D NOTES SEE HYDRAULIC HOSE CONNECTIONS A B 192 A C B D 88 89 90[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 63 HYDRAULIC DRIVE PUMP ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 38 500214 KEY SQU ARE 1 40 EM969013 NUT LOCK 3/8 IN. .............................................4................ REPLA CES 492583 42 3019092 W ASHER, FLA T 3/8 IN[...]

P A GE 64 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) MANIFOLD AND HYDRAULIC OIL FIL TER ASSY . 164 160 162 172 176 178 172 174 156 1 19 184 183 1 19 182 181 158 166 168 170 30 108 1 10 106 134 144 136 138 132 130 128 83 187 183 124 122 120 1 12 87 1 19 157 1 18 1 16 1 14 140 142 126 126[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 65 MANIFOLD AND HYDRAULIC OIL FIL TER ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 83 513334 HOSE 1 87 513335 HOSE 2 106 507278 HYDRA ULIC T ANK CAP 1 108 506218 STRAIGHT FITTING 3/4" 1 110 506221 FIL TER, GAS 1 112 508667 OIL FI[...]

P A GE 66 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) FUEL T ANK ASSY . LEFT SIDE CHASSIS FUEL T ANK 204 205 207 213 216 124 214 218 268 266 248 224 228 227 226 248 223 250 258 222 221 252 256 212 210 320 330 310 300 208 220 FUEL T ANK 224 REAR ENGINE COVER T o Engine Carburetor T o Engi[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 67 FUEL T ANK ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 94 513314 BOL T , 1/4" NC X 3/4" G 1 124 508302 P AD , R UBBER T ANK 2 204 520831 FUEL T ANK, STEEL EP A REQ. 1 205 514467 BRACKET , FUEL T ANK SUPPOR T 1 206 23514 [...]

P A GE 68 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) W A TER T ANK ASSY . P ART OF FRAME 1 NOTES 1 132 128 18 270 130 266 1 268 132 128 18 270 130 266 268 1 16 1 16 1 16 10 12 13 18 18 93 1 16 8 14 18 100 102 92 98 90 84 104 88 86 1 16 96 1 19 16[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 69 W A TER T ANK ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 8 513316 W A TER T ANK 1 10 EM963055 BOL T 3/8”X3/4” ..................................................1................ REPLA CES 492373 12 3019092 W ASHER, FLA T 3/8?[...]

P A GE 70 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) ENGINE AND MUFFLER ASSY . 212 216 214 215 210 36 212 220 218 222 212 221 400 430 450 440 420 500 256 257 258 640 460 470 510 480 278 280 282 280 265 265 266[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 71 ENGINE AND MUFFLER ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 36 GX630RQZB2 ENGINE, HOND A 20 HP 1 210 513449 MUFFLER PIPE (MODIFIED) 1 212 506257 U- BOL T ASSY . 1-1/2" 3 214 514711 TUBE 1.25” FLEX 1 215 506207 HOSE CLAMP[...]

P A GE 72 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) THROTTLE ASSY . ITEM 1 14 BOL TS TO ENGINE 1 NOTES: 1 2 3 1 12 1 10 1 14 106 134 108 THROTTLE CABLE CONNECTS TO ENGINE 2 ITEM 1 10 CONNECTS TO ITEM 64, SEE P AGE 66 3 136 135[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 73 THROTTLE ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 106 513323 TRA VEL LEVER (FWD/REV) 1 108 513324 CABLE, FORW ARD/REVERSE 1 110 514742 JOINT BALL 1 112 508451 LOCK NUT 1/4" - 28 NF 1 114 513325 AD V ANCE CABLE SUPPORT 1 13[...]

P A GE 74 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) BRAKE CONTROL ASSY . 36 42 40 62 64 48 66 54 44 46 82 78 265 72 268 74 56 58 60 38 76 70 68 266 267 269[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 75 BRAKE CONTROL ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 36 506046 LEVER, BRAKE 1 38 506158 BOL T 5/16" NC x 3/4" G5 4 40 492365 BOL T 5/16" NC x 1/1/4" G5 1 42 EM923023 W ASHER, FLA T 5/16” ................[...]

P A GE 76 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) BA TTER Y ASSY . 160 158 150 152 146 148 154 156 144[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 77 BA TTER Y ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 144 514391 BA TTER Y 12V 1 146 513446 CABLE (-) BA TTER Y 1 148 513445 CABLE (+) BA TTER Y 1 150 505624 BA TTER Y TERMINAL CO VER ..........................1................ BL[...]

P A GE 78 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) SCRAPPER ASSY . PART OF FRAME 1 NOTE: 1 A A 120 122 1 18 1 12 1 14 1 10 108 106 1 16[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 79 SCRAPPER ASSY . NO . P ART NO . P ART NAME QTY . REMARKS 106 513290 SCRAPER, SUPPORT 4 108 508433 SCRAPER, R UBBER 4 110 508434 PLA TE BACKING 4 112 EM963057 BOL T 3/8” ..........................................................12...[...]

P A GE 80 — AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) P A YME NT TERMS T er ms of payment for par ts are net 30 days. FREIG HT POLICY Al l p ar t s or d er s wi ll b e s hi pp ed c o ll ec t o r prepaid with the charges added to the invoice. A l l s h i p m e n t s a r e F . O. B . p o i[...]

AR13HA/AR13HAR ROLLER (S/N 110301 & UP) • OPERA TION AND P ARTS MANU AL — REV . #0 (06/22/11) — P A GE 81 NOTES[...]

OPERA TION AND P AR TS MANUAL Y our Local Dealer is: HERE’S HOW TO GET HELP PLEASE HA VE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING United St a teS Multiquip Corporate Office MQ P ar ts Department 18910 Wilmington A ve. Carson, CA 90746 Contact: mq@multiquip .com T el. (800) 421-1244 F ax (800) 537-3927 800-427-1244 310-537-3700 F ax: 800-[...]