Olfa 720-0430 manuale d’uso

PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE ABOUT ASSEMBLY OR GRILL OPERATIO N DO NOT RETURN TO THE PLACE OF PURCHASE 100 200 300 400 500 600 700 800 D20Y07P_1 Stainless Steel Gas Grill USE AND CARE GUIDE MODEL NO.: 720-0430 FOR OUTDOOR USE ONLY Consumer: Retain this manual for future r eference. Installer: Leave this manual with consumer[...]

TABLE OF CONTENT S SECTION ONE Table of content / important ………………....... ....1 Precautions……………………………… ……....2-5 SECTION TWO Side burner control panel assembly………………6 Side Shelf wooden mount panel assembly …….7 Side shelf push bar asse mbly……………… .…....8 Side burner a ssembly…[...]

PRECAUTIONS WA RN IN G Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. TESTED IN ACCORDANCE WI T H ANSI Z21.58b CSA 1.6b-2006 STANDARD FOR OUTDOOR COOKING GAS APPLIANCE. THIS GRILL IS FOR OUTDOOR USE ONLY. Grill Installation Codes The installation must conform with local codes or, in the ab[...]

PRECAUTION LP-Gas Supply System  A 20lbs tank of approximately 1/4 inches in diameter by 18-1/4 inches high is the maximum size LP gas tank to use.  This safety feature prevents the tank from being overfilled, which can cause malfunction of the LP gas tank, regulator and/or grill.  The LP gas supply cylinder to be used must be constructed [...]

PRECAUTIONS WARNING Your grill will get very hot. Never lean over the cooking area while using y our grill. Do not touch cooking surfaces, grill housing, lid or any other grill parts while the grill is in operation, or until the gas grill has cooled down after use. Failure t o comply wit h these instr uctions may result in serious bodily injury. ?[...]

PRECAUTIONS Do not heat unopened food containers . A build- up of pressure may cause the containers to burst. Use a co vered hand when opening the gril l lid. Never lean over an open gr ill. When lighting a burne r, pay close a ttention to what you are doin g . Make cert ai n yo u are aware of which burner you are lighting, so you r body and clothi[...]

The scre ws used to attach the s ide shelf are a lready scre wed into the left side she lf and side burner (see the figu re below) . First remove the screw s from the left side she lf and side burner bo wl, then attach left side shelf and s ide burner to firebox or car t-leg and tighten all the screws as in the figure shown below. Attention: a. 4 s[...]

SIDE SHELF WOODEN MOUNT PANEL ASSEMBLY Attach side shel f wooden mount panel after remove 4 screws from it. 800 700 600 500 400 300 200 100 USING STEPS: 1.Use two finge rs to press the h inge which is under the wooden control panel (see below pix 1). 2. Pull up the panel to the lever same as side she lf by hands. See pix 2 . 3. To put panel down re[...]

SIDE SHELF PUSH BAR ASSEMBLY Required tools: Philips Scre wdriver (not included) 1. Remove the four side handle screws fr om the side of the she lf. 2. Align the holes in the s ide shelf handle wi th the holes in the shel f. 3. Insert the fix p ieces and the screws then tighten them. 800 700 600 500 400 300 200 100 1. Insert valve ventur i into the[...]

2. Connect igni te wir e with s ide valve. 100 200 300 400 50 0 600 700 800 REAR BURNER IGNI TER WIRE ASSEMBLY 800 700 600 500 400 300 200 100 Connect the rear burner ign iter wi re into the electr ic ignite r. 9[...]

SIDE BURNER LID BrACKET ASSEMBLY First r emove the sc rews from side burne r lid. Then attach side burner bracket w ith side burner frame as shown belo w from top to bottom with three washers and screws . 800 700 600 500 400 300 200 100 10[...]

100 200 300 400 500 600 700 800 In order to install the battery, remove the ignition bu tton housing. Please keep the pos itive pole of the battery facing toward you. Insert the batte ry into the housing. Replace the ignition button hous ing after battery is installed. BATTERY ASSEMBLY ROTISSERIE KIT ASSEMBLY Screw the rotisserie motor mount on the[...]

PROPANE TANK ASSEMBLY Attach regulator to the propane tank by tu rning the regulator handle cl ockwise (F IGURE A). Turn off LP supply at c ylinder when appliance is not in use. g O P E N C L O S E (FIGURE A) Put the gas tank into bottom panel. Then tighten up the gas tank retention kit for fixing the gas tank as shown in below . 100 200 300 400 50[...]

GAS HOOK UP NEVER CONNECT AN UNREGULATED GAS SUPPLY LINE TO THE APPLIANCE. USE THE REGULATOR/HOSE ASSEMBLY SUPPLIED. This is a liquid propan e config ured grill. Do not attempt to use a natural gas supply unless the grill has been reconfig ured for natural gas use. Total gas consumption (p er ho ur) of this stainless steel gas gr ill with all burne[...]

GAS HOOK-UP 5. When connecting regu lator asse mbly to the valve, hand tighten the quick coupling nut cloc kwise to a complete stop. Do not use a wrench to tighten . Use of a w rench may da mage the quick coupling nut and result in a hazardous condition. 6. Open the tank valve fully (counter clockwise) . Use a soapy w ater solution to check all con[...]

LEAK TESTING GENERAL Although all gas connections on the grill are leak tested at the factor y prio r to shipmen t, a comple te gas tightness check must be per formed a t the installation s ite due to possible mishandling in shipment, or exce ssiv e pressure un kno win gly bei ng applied to the unit. Per iodically check the whole system fo r leaks [...]

OPERATING INSTRUCTIONS CAUTION: PLEASE TAKE OF F THE WARMING RACK WHEN USING THE ROTIS BURNER. THE HIGH HEAT COMING FROM THE ROTIS BURNER MAY CAUSE THE WARMING RACK TO BEND. GRILL LIGHTING INSTRUCTIONS WARNING: IMPO RTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasi[...]

GRILL LIGHTING INSTRUCTIONS TO LIGHT THE GR ILL BURNER: Make sure all knobs are “OFF ” then turn on the gas supply from the LP tank. Always keep your face and body as far from the grill as possible when lighting. Your stainl ess steel grill has an exclusive pat ent ed built-in ignition. The i gniter is built in t o the v alve. To ignite each bu[...]

TO MATCH LIGHT THE GRILL 1. If the burner will not light af ter several at tempts then t he burner can be m atch lit. 2. If you’ ve just atte mpted to ligh t the burner with the ignite r, allow 5 mi nutes fo r any accumu lated gas to diss ipate. Keep your face and hands as far awa y from the g rill as poss ible. Inser t a lit extended match or li[...]

GRILL LIGHTING INSTRUCTIONS FLAME CHARACTERISTICS Check for proper burner flame characteristics. Burner flames should be blue and stabl e with no yellow tips, excessive noise, or lifting. If any of these conditions exist call our customer service line. If the fl ame is yellow, it indicates insufficie nt air. If the flame is noisy and tends to lift [...]

LIGHTING ILLUSTRATIONS 2. The Rear Burner is lit, ad just the knob as desired. Main & side burner lighting illustration 1. Make su re the l id is open. position and hold in for 3-4 seconds while continuing to hold, push electron ic ignition button, until burner is lit. Once it is lit, release elec tronic ig niti on butt o n, still holding in th[...]

CARE AND MAINTENANCE STAINLESS STEEL The grill is m ade from non-rusting and non- magnetic stainless steel. The re are many different stainless steel cleaners available. Always use the mildest clean ing procedure first, scrubbing in the direction of the grain. To touch up noticeable scratches in the stain less steel, sand very lightly with dr y 100[...]

CARE AND MAINTENANCE HOW TO REPLACE MAIN BURNER Step 1. Place the burner onto the orifice. STAINLESS STEEL : There are many differe nt stainless steel cleaners available. Always use the mildest cleaning procedur e first, scrubbing in the direction of th e grain. Do not use steel wool as it will scratch the surface. To touch up noticeable scratches [...]

TROUBLE SHOOTING SPIDER AND INSECT WARNING!!! Spiders and small insects occasionally sp in webs or make nests in the grill burner tubes during transit and warehousing. These webs can lead to gas flow obstruction which could resu lt in a fire in and around burner tubes. This type of fire is known as “FLASH -BACK” and can cause ser ious damage to[...]

TROUBLE SHOOTING PROBLEMS Grill won’t light when the control knob is rotated. CHECK LIST WHAT TO DO Check to see if LP tank is empty. Clean wi re(s) and /or electrode by rubbing w ith alcohol and clean swab. Wipe with dry cloth. Make sure the wire is connected to electr ode assembly. Do other bu rners on the un it operate? Check to see if other b[...]

720-0430 EXPLODED VIEW 10 97 98 23 24 01 100 200 300 400 500 600 700 800 02 03 95 96 96 95 93 94 92 92 91 07 08 09 11 88 87 85 84 83 78 77 76 73 71 72 70 69 68 66 65 61 56 55 54 51 50 51 49 48 47 46 45 35 36 35 31 25 26 29 21 22 20 19 17 16 15 04 79 74 73 72 67 34 39 43 42 44 48 30 33 40 64 82 52 89 90 14 32 37 12 13 06 05 63 57 60 59 58 62 80 42 8[...]

PARTS LIST REF# DESCRIPTION QTY REF# DESCRIPTION QTY 01 Warming Rack 1 31 Left side panel cart leg , Rear 1 02 Cooking Grid With Hole 3 32 Left side panel cart leg, Front 1 03 Flame Tamer 5 33 Right side panel cart leg , Rear 1 04 Main Burner 5 34 Right side panel cart leg , Front 1 05 Greasy tray 1 35 Cart –Caster Insert 2 06 Grease slide panel,[...]

PARTS LIST REF# DESCRIPTION QTY REF# DESCRIPTION QTY 61 Side burner brass connector 1 81 Smoke tray cover 1 62 Side burner fix bracket 1 82 Rotisserie gas valve 1 63 Side burner bracket 1 83 Main gas valve 5 64 Side burner pipe 1 84 Front baffle 1 65 Side burner bowl assembly 1 85 Main burner bowl assembly 1 66 Side burner ring 1 86 Regulator, LP 1[...]

ORDERING PARTS HOW TO ORDER REPLACEMENT PARTS To make sure you obtain the cor rect replacement part(s) for your gas grill, please refer to t he parts list on the previous 2 pages. The follow ing information is required to assure getting the cor rect part. To obtain repl acement parts, con tact customer service 1-800-913 -8999. • Gas grills model [...]

GRILL COOKING CHART FOOD WEIGHT OR THIC KNESS FLAME SIZE APPROXIMATE TIME SPECIAL INSTR UCTI ONS AND TIPS VEGETABLES Fresh Slice.Do t with butte r or margar ine Wrap in heavy-du ty foil.Grill,turnin g occasionally Beets Medium 12 to 20 minute s Carrots Turnips Grill, turning on ce.Brush Occasionally With melted butte r or m argarine Onion 1/2 inch [...]

GRILL COOKING CHART 1-1/ 2 i nc h Hi gh 16 t o 27 m inut es W ell-done 1 inc h M edium 18 t o 30 m inut es 1-1/ 2 i nc hes M edium 16 t o 35 m inut es Lamb Chops & S t eak s Remov e ex c es s f at fr om edge. S las h r e ma in in g f at at 2- inch in ter v a ls . Gr ill, t ur nin g o nce. 1-1/ 2 i nc h Hi gh 14 t o 18 m inut es Medi um 1 i nc h[...]

GRILL COOKING CHART W EI G H T O R APPR OX I MAT E SPEC I AL I N ST R U CT I ON S T H I C KN ESS T I ME AN D T I PS T en de rlo in, P ort erhous e, T -B one, S i rloi n Remov e ex c es s f at fr om edge. S l as h r ema inin g f at at 2- inch in ter v als. Gr ill, t ur nin g o n c e . 1-1/ 2 i nc h High 11 t o 18 m i nut es Medi um 1 inc h M edium t[...]

GRILL COOKING CHART FOOD WEIGHT OR THIC KNESS FLAME SIZE APPROXIMATE TIME SPECIAL INSTRUCTI ONS AND TIPS FISH AND SEAFOOD Steaks Grill,turning once .Brush with melted butter,margarin e or oil To keep moist. Halibut 3/4 t o 1 inch Medium to 8 to 15 minutes Salmon High Swordfish Whole Catfi sh 4 to 8 ounces 4 to 8 ounces Medium to 12 to 20 minutes Gr[...]

GRILL RECIPE SUGGESTIONS BBQ SALMON 2 large salmon steaks 2 tbs. O il Salt & pepper 2 oz. thin bacon slices 2 tbs. Butt er 1 tbs. Lemon ju ice Spring of pa rsley Lemon wedges Preheat the BBQ. Brush the steaks wi th oil and season with sa lt and pepper. Place on BBQ grill and cook for 10 minutes, turning steaks over halfway cooking time. Meanwhi[...]

GRILL RECIPE SUGGESTIONS Preheat grill. Combine cheese, condensed soup, milk, BBQ sauce, oregano, salt and pepper in a large mix ing bowl. Stir in potatoes until well coated. Turn into well butter ed1-1/2 quart rectangular baking dish. Co ver dish with alu min um foil. Bake covered 25 minu tes on mediu m with the lid of your BBQ grill closed. Remov[...]

GRILL RECIPE SUGGESTIONS CHICKEN TANDO ORI STYLE 8 large chicken thighs or drumsticks 1 c. pla in nonfat yogurt ½ c. lemon juice 2 tsp. salt ½ tsp. cayenne ½ tsp. black pepper ½ tsp. crushed garlic ½ tsp. gr ated ginger 1 tbs. co rn oil Combine all the ing redients in a large mixing bowl and marinate the chicken for 8 hours in the refrigerator[...]

LIMITED WARRANTY LIMITED WARRANTY MODEL 720-0430 STAINLESS STEEL OU T DOOR GAS GRILL Nexgrill Industries warrants to the original consumer purchaser of ea ch Outdoor Gas Grill that when subject to normal residential use, it is f ree from de fects in workmanship and materials for the periods specified below. This warranty excludes grills used in ren[...]

37[...]