Pride Mobility 1107 manuale d’uso

Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner’ s Man ual[...]

www .pridemobility .com Jazzy 1 107 SAFETY GUIDELINES Copyright © 2006 Pride Mobility Products Corp. INFMANU2673/Rev C/January2006 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely . WARNING! [...]

Jazzy 1 107 www .pridemobility .com 3 I . INTRODUCTION ................................................................................................................................. 4 II. SAFETY ................................................................................................................................................. 6 III.[...]

4 www .pridemobility .com Jazzy 1 107 I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of- the-art components with safety , comfort, and styling in mind. W e are confident that these design features will provide you with the conveniences you expect during your daily act[...]

Jazzy 1 107 www .pridemobility .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product's warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .pridemobility .com. As [...]

6 www .pridemobility .com Jazzy 1 107 II. SAFETY Cor rosive chemicals contained in ba tter y . Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. EMI-RFI - This product has been tested and passed at an immunity level of 20 V/m. R ead and follo w the inf or mation in the o wner’s manual. Maximum seating weigh[...]

Jazzy 1 107 www .pridemobility .com 7 II. SAFETY Do not remove anti-tip wheels. Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid e xposur e to r ain, sno w , ice, salt, or standing w ater whenev er possible. Maintain and store in a clean and dr y condition. Rem oval of g rounding pr ong can create e[...]

8 www .pridemobility .com Jazzy 1 107 II. SAFETY SAFETY MAND A T OR Y! Do not operate your new pow er chair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best fi[...]

Jazzy 1 107 www .pridemobility .com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity voids y our war ranty and may result in per sonal injur y and/or damage to your power c hair . Pride will not be held responsib[...]

1 0 www .pridemobility .com Jazzy 1 107 II. SAFETY 5 (8.7%) Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications pre- sented in this manual. Doi[...]

Jazzy 1 107 www .pridemobility .com 1 1 II. SAFETY Figure 2. Correct Curb Approach Figure 3. Incorrect Curb Approach Freewheel Mode Y our power chair is equipped with a manual freewheel system to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III.[...]

1 2 www .pridemobility .com Jazzy 1 107 II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or healthcare professional present while learning to properly transfer yourself. T o eliminate the possibility of injury , Pride recommends that you or a trained attendant perform th[...]

Jazzy 1 107 www .pridemobility .com 1 3 II. SAFETY Positioning Belts Y our authorized Pride Provider , therapist(s), and other healthcare professionals are responsible for determining your re- quirement for a positioning belt in order to operate your power chair safely . WARNING! If you r equire a positioning belt to safe l y operate y our power ch[...]

1 4 www .pridemobility .com Jazzy 1 107 II. SAFETY Preventing Unintended Movement WARNING! If y ou anticipate being sea ted in a stationar y position for an extended period of time, tur n of f the power . This will pr ev ent unexpected motion fr om inadv er tent joystic k contact. This will also eliminate the possibility of unintended chair movemen[...]

Jazzy 1 107 www .pridemobility .com 1 5 III. Y OUR POWER CHAIR THE JAZZY 1107 The Jazzy has two main assemblies: the seat assembly and the power base assembly . See figure 5. T ypically , the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/brake assemblies, two drive wheels, two anti-tip whee[...]

1 6 www .pridemobility .com Jazzy 1 107 III. Y OUR PO WER CHAIR Figure 6. The Jazzy 1107 P ower Base SIDE TRAPEZE BARS FRONT TRAPEZE BAR MANUAL FREEWHEEL LEVER MOTOR/BRAKE ASSEMBLY CONTROLLER CONNECTOR BATTERY BOX BATTERY BOX[...]

Jazzy 1 107 www .pridemobility .com 1 7 III. Y OUR PO WER CHAIR J AZZY 1107 SPECIFICA TIONS Suspension: Active Trac Drive Wheels: 10 in., pneumatic, (10 in., solid are optional) Caster Wheels: 6 in., solid, rear-mounted Anti-tip Wheels: 5 in., solid, front-mounted Maximum S peed:¹ Up to 4.5 mp h Brakes: “Intelligent Braking” electronic regener[...]

1 8 www .pridemobility .com Jazzy 1 107 III. Y OUR PO WER CHAIR Battery Harness Connector: This is where the controller connects to the battery boxes. Main Circuit Breaker (located on rear battery box): The main circuit breaker is a safety feature built into your power chair . When the batteries and the motors are heavily strained (e.g., from exces[...]

Jazzy 1 107 www .pridemobility .com 1 9 Manual Freewheel Levers Y our power chair has a manual freewheel lever on each motor . See figure 6. Manual freewheel levers enable you to disengage the drive motors from the gearboxes and maneuver the chair manually . WARNING! Do not use the power chair while the drive motors are disengaged! Do not disengage[...]

2 0 www .pridemobility .com Jazzy 1 107 Figure 10. Jazzy 1107 Assembl y View INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation. It may also require disassem- bly to make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disas- sembled and [...]

Jazzy 1 107 www .pridemobility .com 2 1 Figure 11. Assembly View (Rear Seat Interface Installation) Figure 12. Seat Installation Seat Installation It may be necessary to install the seat either prior to initial operation or after transporting your power chair . Most seats are attached to the power base with the Universal Mountin g System (UMS). The[...]

2 2 www .pridemobility .com Jazzy 1 107 Power Base Disassembly The Jazzy 1 107 power base disassembles into six parts for easy transportation and storage. See figure 13. T o disassemble the power base: 1. Turn off the power to the controller . 2. Disconnect the controller from the power base. See figure 6. 3. Remove the seat. 4. Press the foot plat[...]

Jazzy 1 107 www .pridemobility .com 2 3 Figure 14. Battery Box Removal and Frame Separation BATTERY BOX LATCH (LOCKED) BATTERY BOX LATCH (UNLOCKED) IV . ASSEMBL Y/DISASSEMBL Y CENTER SECTION LATCH[...]

2 4 www .pridemobility .com Jazzy 1 107 V . COMFORT ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort. These adjustments include seat height and angle, armrest angle, foot platform height and angle, and controller position. If your p[...]

Jazzy 1 107 www .pridemobility .com 2 5 Figure 18. Seatback Angle Adjustment Figure 17. Seat Position (Extrusion Location) V . COMFORT ADJUSTMENTS Seat Position Y ou can move the seat forward or rearward by changing the extrusion mounting position. T o change the position: 1. Unplug the controller from the power base. 2 . Remove the seat from the p[...]

2 6 www .pridemobility .com Jazzy 1 107 V . COMFORT ADJUSTMENTS T o change the armrest width: 1. Locate the armrest knob on each side of the armrest receiver bracket. See figure 18. 2 . Loosen each knob. 3. Slide the armrests in or out to the desired width. 4. Tighten each knob. Armrest Angle Adjustment T o change the armrest angle: 1 . Lift the ar[...]

Jazzy 1 107 www .pridemobility .com 2 7 V . COMFORT ADJUSTMENTS T o clamp the quick release fastener: 1. Make sure the lever is in the open position. 2. Turn the nut clockwise until it is snug. 3. Rotate the lever until it is in the fully closed position. NOTE: If the lever will not rotate to the fully closed position, then turn the nut countercloc[...]

2 8 www .pridemobility .com Jazzy 1 107 Multi-Axis Foot Plates The multi-axis foot plate assembly can be installed on either a swing-away footrest or an elevating leg rest. The multi-axis foot plate has four adjustments: leg rest length (A), position (B), tilt (C), and angle (D). See figure 25. T o change leg rest length (A): 1. Remove the hardware[...]

Jazzy 1 107 www .pridemobility .com 2 9 T o change foot plate position (B): 1. Remove the hardware. 2. Move the foot plate to the desired position. 3. Reinstall the hardware. T o change foot plate tilt (C): 1. Loosen the hardware. 2. Tilt the foot plate to desired position. 3. Tighten the hardware. T o change foot plate angle (D): 1. Turn the setsc[...]

3 0 www .pridemobility .com Jazzy 1 107 VI. B A TTERIES AND CHARGING BA TTERIES AND CHAR GING Y our Pride Power Chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a lon[...]

Jazzy 1 107 www .pridemobility .com 3 1 VI. B A TTERIES AND CHARGING T o charge the batteries using the off-board charger: 1. Position your power chair next to a standard electrical outlet. 2. Be certain the controller power is turned off. 3. Plug the off-board charger into the off-board charger/ programming socket on the controller . See VII. “O[...]

3 2 www .pridemobility .com Jazzy 1 107 VI. B A TTERIES AND CHARGING How often must I charge the batteries? Many factors come into play when deciding how often to char ge the batteries. Y ou may use your power chair all day on a daily basis or you may not use it for weeks at a time. ! Daily Use If you use your power chair on a daily basis, char ge [...]

Jazzy 1 107 www .pridemobility .com 3 3 It might take a few days for the temperature of the battery to stabilize and adjust to its new ambient temperature. More importantly , it will take a few “charging cycles” (a partial drain— then a full rechar ge) to establish the critical chemical balance that is essential to the battery’ s peak perfo[...]

3 4 www .pridemobility .com Jazzy 1 107 VII. OPERA TION FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and[...]

Jazzy 1 107 www .pridemobility .com 3 5 VII. OPERA TION Figure 29. FLIGHT Controller Keypad On/Off Key The on/off key turns the FLIGHT on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the c hair . T his will cause the pow er chair to stop a br uptly . WARNING! Alwa ys tur n the power off w hen you are[...]

3 6 www .pridemobility .com Jazzy 1 107 VII. OPERA TION Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease the speed. The speed setting is displayed on the speed indicator . If your power chair was programmed with a drive profile, contact your authorized Pride Provider [...]

Jazzy 1 107 www .pridemobility .com 3 7 VSI ELECTRONIC CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and the condition of your electrical system. The VSI electronic controller is an[...]

3 8 www .pridemobility .com Jazzy 1 107 VII. OPERA TION On/Off Key The on/off key turns the VSI on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to stop the pow er chair . T his will cause the pow er chair to stop abr uptly . WARNING! Always tur n the power off when you are stationar y to pre vent une xpected[...]

Jazzy 1 107 www .pridemobility .com 3 9 Actuator Keys and Actuator Light s (For Optional Equipment) Actuator keys and actuator lights are used for optional equipment such as power elevating leg rests. For specific operation of the actuator keys and actuator lights, contact your authorized Pride Provider . Horn Key The horn key activates the horn. L[...]

4 0 www .pridemobility .com Jazzy 1 107 WARNING! F ailure to pr operl y align the connector s can r esult in damage to the VSI, the charger , and the connectors. Thermal Rollback The VSI controller is equipped with a thermal rollback circuit. This circuit monitors the temperature of the controller , which roughly translates to motor temperature. In[...]

Jazzy 1 107 www .pridemobility .com 4 1 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Pride Power Chair is a sophisticated device. Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your authorized Pride Provider . Preventive mainte- nance is very imp[...]

4 2 www .pridemobility .com Jazzy 1 107 VIII. CARE AND MAINTENANCE ! Check all electrical connections. Make sure they are tight and are not corroded. ! All wheel bearings are prelubricated and sealed. They require no subsequent lubrication. Daily Checks ! W ith the controller turned off, check the joystick. Make sure it is not bent or damaged and t[...]

Jazzy 1 107 www .pridemobility .com 4 3 VIII. CARE AND MAINTENANCE Storage Y our power chair should be stored in a dry place, free from temperature extremes. When storing, disconnect the batteries from the power chair . See VI. “Batteries and Charging.” WARNING! If you fail to store the unit proper ly , the fr ame can rust and the electronics c[...]

4 4 www .pridemobility .com Jazzy 1 107 VIII. CARE AND MAINTENANCE 4. Remove the drive wheel nut and washer from the axle. See figure 32. 5. Pull the wheel off the axle. 1 1. Inflate the pneumatic tire to 35 psi (2.4 bar) . 12. Remove the power chair from the blocks. Battery Replacement A battery wiring diagram is printed on a decal located inside [...]

Jazzy 1 107 www .pridemobility .com 4 5 VIII. CARE AND MAINTENANCE 3. Remove the battery boxes. See IV . “Assembly/Disassembly .” 4 . Disconnect the wiring harness from the batteries. 5. Remove the batteries from the battery boxes. 6. Place new batteries in the battery boxes. See figure 34. 7. Reconnect the battery harnesses according to the ba[...]

4 6 www .pridemobility .com Jazzy 1 107 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material a[...]

Jazzy 1 107 www .pridemobility .com 4 7 IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EXCL USIONS This warranty does not extend to those items which may require replacement due to normal wear and tear . ! ABS Plastic shrouds ! Motor brus[...]

4 8 www .pridemobility .com Jazzy 1 107 NO TES[...]

Jazzy 1 107 www .pridemobility .com 4 9 NO TES[...]

5 0 www .pridemobility .com Jazzy 1 107 NO TES[...]

Thank you for making the Jazzy 1 107 your choice in power chairs. The following checkmarks indicate that we have thoroughly inspected and test driven your power chair . Fit and Finish Performance Pride keeps a mor e detailed report on file at the factory . Quality Control - 1 107 #1 In Quality Control Inclusion of all Parts Controller Serial Number[...]