Pride Mobility Hurricane PMV manuale d’uso

Owner’ s Manual The Ultimate In S tyle & Performance ® Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com[...]

SAFETY GUIDELINES Copyright ©2005 Pride Mobility Products Corp. INFMANU2635/Rev C/September 2005 NOTE: This owner ’ s manual is compiled from the latest specifications and product information available at the time of publication. W e reserve the right to make changes as they become necessary. Any changes to our products may cause slight variatio[...]

3 Hurricane www .pr idemobility .com CONTENTS I . INTRODUCTION ......................................................................................................................... 4 I I . SAFETY ......................................................................................................................................... 5 III. EMI/R[...]

4 www .pridemobility . com Hurricane I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The product you have purchased combines state of the art components with safety , comfort and styling in mind. W e are confident the design features will provide you with the conveniences you expect during your daily activities. Under[...]

5 Hurricane www .pr idemobility .com II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the PMV to identify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely . Pinch/Crush points cr eated during assembly . Corr osive chemicals contained in batter y . Use only AGM or[...]

6 www .pridemobility . com Hurricane II. SAFETY Front-to-rear plug orientation. Do not raise or lower the power seat while the PMV is in motion. Do not remove anti-tip wheels. Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid e xposure to rain, snow , ice, salt, or standing water w hene v er possible[...]

7 Hurricane www .pr idemobility .com II. SAFETY GENERAL Y our PMV is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best fit the individual needs of the PMV user . Please be aware that the final selection and purchasing decision regarding the type of PMV to be used is th[...]

8 www .pridemobility . com Hurricane II. SAFETY PRE-RIDE SAFETY CHECK Get to know the feel of your PMV and its capabilities. Pride recommends that you perform a safety check before each use to make sure your PMV operates smoothly and safely . For details on how to perform these necessary inspections, see XI. “Care and Maintenance.” Perform the [...]

9 Hurricane www .pr idemobility .com II. SAFETY When climbing an incline, try to keep your PMV moving. If you must stop, start up again slowly , and then acceler- ate cautiously . When driving down an incline, do so by setting the speed adjustment dial to the slowest setting and driving in the forward direction only . If your PMV starts to move dow[...]

10 www .pridemobility . com Hurricane II. SAFETY CORNERING INFORMA TION Excessively high cornering speeds can create the possibility of tipping. Factors which affect the possibility of tipping include, but are not limited to, cornering speed, steering angle (how sharply you are turning), uneven road surfaces, inclined road surfaces, riding from an [...]

11 Hurricane www .pr idemobility .com II. SAFETY OUTDOOR DRIVING SURF A CES Y our PMV is designed to provide optimum stability under normal driving conditions—dry , level surfaces com- posed of concrete, blacktop, or asphalt. However , Pride recognises that there will be times when you will encoun- ter other surface types. For this reason, your P[...]

12 www .pridemobility . com Hurricane II. SAFETY INCLEMENT WEA THER PRECA UTIONS Exposure of your PMV to inclement weather conditions should be avoided whenever possible. If suddenly caught up in rain, snow , severe cold or heat while operating your PMV proceed to shelter at the earliest oppurtunity . Thoroughly dry your PMV before storing, chargin[...]

13 Hurricane www .pr idemobility .com II. SAFETY ELEV A T ORS Modern elevators have a door edge safety mechanism that, when pushed, reopens the door(s). ! If you are in the doorway of a elevator when the door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contact the PMV and the door will reopen. ! Use care that po[...]

14 www .pridemobility . com Hurricane II. SAFETY GETTING ONT O AND OFF OF Y OUR PMV Getting onto and off of your PMV requires a good sense of balance. Please observe the following safety tips when getting onto and off of your PMV : ! Remove the key from the key switch. ! Ensure that your PMV is not in freewheel mode. See V . “Y our PMV .” ! Mak[...]

15 Hurricane www .pr idemobility .com II. SAFETY PRESCRIPTION DR UGS/PHYSICAL LIMIT A TIONS The P MV user must exercise care and common sense when operating his/her P MV . This includes awareness of safety issues when taking prescribed or over-the-counter drugs or when the user has specific physical limitations. WARNING! Consult your physician if y[...]

16 www .pridemobility . com Hurricane III. EMI/RFI Electromagnetic and Radio Frequency Interference (EMI/RFI) Laboratory tests have shown that electromagnetic and radio frequency waves can have an adverse affect on the performance of electrically-powered mobility vehicles. The interference can come from sources such as cellular phones, mobile two-w[...]

17 Hurricane www .pr idemobility .com IV . SPECIFICA TIONS Figure 4A. Hurricane Tire Dimensions (Front and Rear) Figure 4. Hurricane Dimensions R E V E R S E REVERSE F O R FOR W A R D ARD 16.5" - 19.5" 4" 52" 18" 18" 24" 19" 65" 24" TURNING RADIUS 20.5" 46.5"- 51" 4" 13"[...]

18 www .pridemobility . com Hurricane Mo d e l N umb e r PM V5001 Co l or s Candy A p pl e Red , V i per B lue , Cham pa gn e O v e ra ll L en g th 52 i n. O v e ra ll W id th 24 i n. T o ta l W e igh t 285 l bs. T otal W eigh t W i th ou t B at teries 209 l bs. H ea viest Piece W h en D is a ssem b led R ear sec ti on: 82 l bs. Tur ning Ra d ius 6[...]

19 Hurricane www .pr idemobility .com 400/181 V . YOUR PMV TILLER CONSOLE The tiller console houses all of t he controls need ed to drive your PMV , including the speed adjustment dial, h al f /full speed switch, throttle control lever , battery condition meter , lights switch, hazard lights switch, turn signal buttons, status LED, and horn buttons[...]

20 www .pridemobility . com Hurricane Key Switch ! Insert the key into the key switch and turn it clockwise to power up (turn on) your PMV . ! T urn the key counterclockwise to power down (turn of f) your PMV . Lights Switch This switch controls your PMV’ s lights. ! T oggle the switch forward to turn on your PMV’ s rear running lights and fron[...]

21 Hurricane www .pr idemobility .com V . YOUR PMV REAR SECTION The batteries (not shown), the main circuit breaker (reset button), the manual freewheel lever , the anti-tip wheels, and the motor/transaxle assembly (not shown) are located on the rear section of your PMV . See figure 6. Tiller Console Fuses These fuses help protect your PMV’ s fro[...]

22 www .pridemobility . com Hurricane V . YOUR PMV Motor/T ransaxle Assemb ly (Not Sho wn) The motor/transaxle assembly is an electromechanical unit that converts electrical energy from your PMV’ s bat- teries into the controlled mechanical energy that drives the PMV’ s wheels. Manual Freewheel Lever Whenever you need or want to push your PMV f[...]

23 Hurricane www .pr idemobility .com VI . B A TTERIES AND CHARGING Y our PMV requires two long-lasting, 12-volt, deep-cycle batteries that are sealed and maintenance free. They are recharged by an off-board charging system. ! Charge your PMV’ s batteries prior to using it for the first time. ! Keep the batteries fully charged to keep your PMV ru[...]

24 www .pridemobility . com Hurricane VI . B A TTERIES AND CHARGING 3. Make certain that the manual freewheel lever is in the drive position. 4. Plug the 3-pin charger power cord into the off-board charger port. See figures 9 and 10 . 5. Extend the charger power cord and plug it into the wall outlet. 6. T urn the charger on. See figure 8 . 7. When [...]

25 Hurricane www .pr idemobility .com VI . B A TTERIES AND CHARGING What if my PMV’ s batteries won’t charge? ! Ensure the red (+) and black (-) battery cables are connected properly to the battery terminals. ! Ensure both battery harnesses that extend from the batteries are plugged into their mating harness leading to the charger . ! Ensure bo[...]

26 www .pridemobility . com Hurricane VI . B A TTERIES AND CHARGING What type and size of battery should I use? W e recommend deep-cycle batteries that are sealed and maintenance free. Both AGM and Gel Cell are deep-cycle batteries that are similar in performance. Do not use wet-cell batteries, which have removable caps. WARNING! Cor rosive c hemic[...]

27 Hurricane www .pr idemobility .com More importantly , it takes a few charging cycles (partial draining followed by full rechar ging) to establish the critical chemical balance that is essential to a deep-cycle battery’ s peak performance and long life. Follow these steps to properly break in your PMV’ s new batteries for maximum efficiency a[...]

28 www .pridemobility . com Hurricane VII. OPERA TION BEFORE GETTING ON Y OUR PMV ! Have you fully charged the batteries? See VI. “Batteries and Charging.” ! Is the manual freewheel lever in the drive (backward) position? Never leave the manual freewheel lever pushed forward unless you are manually pushing your PMV. GETTING ONT O Y OUR PMV 1. M[...]

29 Hurricane www .pr idemobility .com VII. OPERA TION ! Pull on the left handgrip to steer your PMV to the left. ! Pull on the right handgrip to steer your PMV to the right. ! Move the tiller to the center position to drive straight ahead. ! T o stop, slowly release the throttle control lever . After you release the throttle control lever , gently [...]

30 www .pridemobility . com Hurricane SEA TB A CK ADJUSTMENT T o adjust your PMV's reclining seat, perform these steps. See figure 12A. 1. W ith your back pressed up against the seatback, lift up on the seatback adjustment lever and lean forward or rearward to adjust the seatback angle. 2. Release the seatback adjustment lever once the seat is[...]

31 Hurricane www .pr idemobility .com VIII. COMFORT ADJUSTMENTS ARMREST ANGLE ADJUSTMENT The armrest angle of your PMV can be adjusted up- ward or downward by turning the adjustment dial. See figure 12B. NOTE: Pivot the armrests upward to make get- ting onto and off of your PMV easier . SEA T HEIGHT ADJUSTMENT Y ou can change the seat height to one[...]

32 www .pridemobility . com Hurricane VIII. COMFORT ADJUSTMENTS PO WER SEA T (OPTIONAL) Y our PMV may be equipped with a power seat. The power seat actuator is designed to raise or lower the seat automatically with minimal effort on the part of the operator . The power seat switch is located on the tiller console. Operating your power seat: 1. Rele[...]

33 Hurricane www .pr idemobility .com IX. DISASSEMBL Y AND ASSEMBL Y DISASSEMBL Y Y ou can disassemble the PMV into seven pieces: the seat, the front section, the rear section, the rear shroud, the basket, and the batteries. See figure 14. No tools are required to disassemble or assemble your PMV . Since the disassembled sections of the PMV take up[...]

182 Susquehanna A ve. Exeter , P A 18643 1-800-800-8586 www .pridemobility .com[...]

34 www .pridemobility . com Hurricane IX. DISASSEMBL Y AND ASSEMBL Y T oggle Latch Release 1. Push in the toggle latch release button while pulling back the toggle latch. See figures 16 and 16A. 2 . Position the toggle latch buckle over the top of the toggle latch. See figure 16B. TOGGLE LA TCH TOGGLE LA TCH RELEASE BUTTON Figure 16. T oggle Latch [...]

35 Hurricane www .pr idemobility .com X. BASIC TR OUBLESHOO TING What if all the systems on my PMV seem to be “dead”? ! Make certain that the key is in the “on” position. ! Check that the batteries are fully charged. ! Push in the main circuit breaker reset button. See V . “Y our PMV .” ! Make certain that both T -handle battery harness[...]

36 www .pridemobility . com Hurricane X. BASIC TR OUBLESHOO TING What if the main circuit breaker repeatedly trips? ! Char ge the PMV’ s batteries more frequently . See VI. “Batteries and Charging.” ! If the problem continues, have both of your PMV’ s batteries load tested by your authorized Pride Provider . ! Y ou may also perform the load[...]

37 Hurricane www .pr idemobility .com XI. CARE AND MAINTENANCE Y our PMV requires a minimal amount of care and maintenance. If you do not feel confident in your ability to perform the maintenance listed below , you may schedule inspection and maintenance at your authorized Pride Provider . The following areas require periodic inspection and/or care[...]

38 www .pridemobility . com Hurricane XI. CARE AND MAINTENANCE LIGHT BULB REPLA CEMENT The PMV’ s light bulbs are easily replaceable. Do not use regular automotive-type 12-volt light bulbs; your PMV is equipped with a 24-volt electrical system. Replacement light bulbs can be purchased from your authorized Pride Provider . NOTE: Use only 24-volt l[...]

39 Hurricane www .pr idemobility .com XII. WARRANTY THREE-YEAR LIMITED WARRANTY For three (3) years from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material and/or workmanshi[...]

40 www .pridemobility . com Hurricane XII. WARRANTY ! Circumstances beyond the control of Pride ! Labor , service calls, shipping, and other charges incurred for repair of the product, unless specifically autho- rized, IN ADV ANCE, by Pride Mobility Products Corporation ! Repairs and/or modifications made to any part without specific consent from P[...]

41 Hurricane www .pr idemobility .com NO TES[...]

182 Susquehanna A ve. Exeter , P A 18643 1-800-800-8586 www .pridemobility .com[...]