Pride Mobility SC4401 manuale d’uso

*INFMANU2995* CELEBRITY X[...]

WARNING! An authorized Pride Provider or qual ified technician must perform the initial setup of this scooter and must perform all of the procedures in th is manual. The symbols below are used throughout this owner's ma nual and on the scooter to identify warnings and important information. It is very important fo r you to read them and unders[...]

3 Celebrity X www.pr idemobility.com CONTENTS I. INTRODUCTION ......................................................................................................................... 4 II. SAFETY ............................................................................................................................... ........... 5 III. Y OUR [...]

4 www.pridemobility.com Celebrity X I. INTRODUCTION SAFETY WELCOME to Pride Mobility Produc ts Corporation (Pride). The pr oduct you have purchased combines state-of the-art components with safety , comfort, and styling in mind. We are confident the design features will provide you with the conveni ences you expect during your daily activities. Und[...]

5 Celebrity X www.pr idemobility.com II. SAFETY PRODUCT SAFETY SYMBOLS The symbols below are used on the scooter to id entify warnings, mandatory actions, and prohibited actions. It is very important for you to read and understand them completely. Pinch/Crush points created during a ssembly. Corrosive chemicals contained in battery. EMI-RFI — Thi[...]

6 www.pridemobility.com Celebrity X II. SAFETY Maximum seating weight. Place unit on level ground and stand to one side when changing from drive mode to freewheel mode or freewheel mode to drive mode. Locked and in drive mode. Unlocked and in freewheel mode. Front-to-rear plug orientation. Wear safety goggles. Use only AGM or Gel-Cell batteries to [...]

7 Celebrity X www.pr idemobility.com II. SAFETY Do not raise or lower the power seat while the scooter is in motion. Do not remove anti-tip wheels. Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Avoid exposure to rain, snow, ice, sa lt, or standi ng water whenever possible. Maintain and store in a clean [...]

8 www.pridemobility.com Celebrity X II. SAFETY Do not allow unsupervised children to pl ay near the sc ooter while the batteries are charging. Do not use batteries with different amp-hour (Ah) capacities. Do not mix old and new batteries. Always replace both batteries at the sa me time. Battery charger for indoor use only. Disposal and recycling ?[...]

9 Celebrity X www.pr idemobility.com GENERAL MANDATORY! Do not operate your new scoot er for the first time without comp letely reading and understanding this owner’s manual. Your scooter is a state-of-the-art life-enhancement device designed to in crease mobility. Pride provides an extensive variety of products to best fit the individual needs o[...]

10 www.pridemobility.com Celebrity X II. SAFETY Perform the following inspecti ons prior to us ing your scooter:  Check for proper tire infl ation. Maintain but do not exceed the ps i/bar/kPa air pressu re rating indicated on each tire if equippe d with pneumatic tires.  Check all electrical connections. Make sure they are tight and not corro[...]

11 Celebrity X www.pr idemobility.com When climbing an incline, try to keep your scooter moving. If you mu st stop, start up again slowly and then accelerate cautiously. When drivi ng down an incline, do so by setting the speed adjustment dial to the slowest setting and driving in the forward direction onl y. If your scooter starts to move down the[...]

12 www.pridemobility.com Celebrity X II. SAFETY Figure 2. Increased Stability Driving Position Figure 1. Normal Driving Position When you approach an incline, it is best to lean forward. See figures 1 and 2. This shifts the center of gravity of you and your scooter toward the front of the scooter for improved stability. NOTE: When negotiating ramps[...]

13 Celebrity X www.pr idemobility.com OUTDOOR DRIVING SURFACES Your scooter is designed to provide optimum st ability under normal driving conditions—dry, level sur- faces composed of concrete or as phalt. However, Pride recognizes that there will be times when you will encounter other surface types. For this reason, your scooter is designe d to [...]

14 www.pridemobility.com Celebrity X INCLEMENT WEATHER PRECAUTIONS Exposure of your scooter to inclement weather conditions should be avoided whenever possible. If sud- denly caught up in rain, snow, severe cold or heat while operating your scooter, proc eed to shelter at the earliest opportunity. Thoroughly dry your scooter before stori ng, chargi[...]

15 Celebrity X www.pr idemobility.com II. SAFETY ELEVATORS Modern elevators have a door edge safety me chanism that, when pushed, reopens the door(s).  If you are in the doorway of an elevator when th e door(s) begin to close, push on the rubber door edge or allow the rubber door edge to contac t the scooter and the door will reopen.  Use car[...]

16 www.pridemobility.com Celebrity X II. SAFETY MOTOR VEHICLE TRANSPORT Pride recommends that you do not remain seated in y our scooter while traveling in a motor vehicle. The scooter should be stowed in the trunk of a car or in the back of a truck or va n with batteries removed and properly secured. In addition, all removable scooter pa rts, inclu[...]

17 Celebrity X www.pr idemobility.com II. SAFETY POSITIONING BELTS Your authorized Pride Provider, ther apist(s), and other heal thcare professionals ar e responsible for deter- mining your requirement for a positioning belt in order to operate your scooter safely. WARNING! If you require a positioning belt to safely operate your scooter, make sure[...]

18 www.pridemobility.com Celebrity X ELECTROMAGNETIC AND RADIO FREQ UENCY INTERFERENCE (E MI/RFI) WARNING! Laboratory test s have shown th at electromagnetic and radio frequency waves can have an adverse affect on the per formance of electrically-powered mobility vehicles. Electromagnetic and Radio Frequency Interference can come fr om sources such[...]

19 Celebrity X www.pr idemobility.com III. YOUR SCOOTER TILLER CONSOLE The tiller console houses all of the controls needed to drive your scooter, including the sp eed adjustment dial, throttle control lever, battery condition meter, li ghts switch, status LED, a nd horn buttons. See figure 5. PROHIBITED! Do not expose the tiller console to moistur[...]

20 www.pridemobility.com Celebrity X III. YOUR SCOOTER Lights Switch This switch controls your scooter’s lights.  Toggle the switch forward to turn on your sc ooter’s front top li ght and running lights.  Toggle the switch to the middle to turn off the scooter’s lights.  Toggle the switch rearward to turn on all the scooters lights ([...]

21 Celebrity X www.pr idemobility.com III. YOUR SCOOTER Figure 7. Tille r Console Fuses SPARE RUNNING LIGHTS LOWER HEAD LIGHT RIGHT TURN SIGNAL LEFT TURN SIGNAL Figure 8. Rear Section BATTERY BATTERY MANUAL FREEWHEEL LEVER ANTI-TIP WHEELS MOTOR/TRANSAXLE ASSEMBLY REAR SECTION The batteries, main circuit breaker (reset button), man- ual freewheel le[...]

22 www.pridemobility.com Celebrity X III. YOUR SCOOTER Figure 9. Main Cir cu i t Breaker (Reset Button) MAIN CIRCUIT BR EAKER (RESET BUTTON) Figure 8A. Safety Flag Bracket HEX KEY SETSCREW CAP Safety Flag Bracket An accessory bracket for installing an optional safety flag is mounted near each anti-tip wheel. To install the flag, the suppl ied “L?[...]

23 Celebrity X www.pr idemobility.com III. YOUR SCOOTER Figure 10A. Front Securemen t Points Figure 10. Rear Securement Points SECUREMENT POINTS SECUREMENT POINTS NOTE: If the scooter is pl aced in fr eewheel mode (m anual freewheel lever forw ard) while the key is in the “on” position, the scooter will not run until the ma nual freewheel lever[...]

24 www.pridemobility.com Celebrity X CHARGING YOUR BATTERIES PROHIBITED! Never use an extension cord to plug in your battery charger. Plug the charger directly into a properly wired stan dard electrical outlet. PROHIBITED! Removal of the grounding prong can create an electrical hazard. If necessary, properly install an approved 3-pr on ged adapter [...]

25 Celebrity X www.pr idemobility.com NOTE: The LED lights on the charge r indicate different charger cond itions at various times: charger power on, charging in progress, an d charging complete. Re fer to the manual suppl ied with the charger for a complete explanation of these indicators. NOTE: There is a charger inhibit function on your scooter.[...]

26 www.pridemobility.com Celebrity X IV. BATTERIES AND CHARGING How often must I ch arge the batteries? Two major factors must be consid ered when deciding how often to charge your scooter’s batteries:  All day scooter use on a daily basis.  Infrequent or sporadic scooter use. With these considerations in mi nd, you can determine how often [...]

27 Celebrity X www.pr idemobility.com How do I change a battery in my scooter? MANDATORY! Battery posts, terminals, and related accessories contain lead and lead compounds. Wear goggles and gloves when handling batteries and wash hands after handling. WARNING! Always use two batteries of the exact same type, chemistry, and amp-hour (Ah) capacity. R[...]

28 www.pridemobility.com Celebrity X Follow these steps to properly break in your scooter’s new batteries for maximum efficiency and service life: 1. Fully recharge any new battery prior to its initial use. This charging cycle brings the battery up to about 88% of its peak performance level. 2. Operate your new scooter in familiar and safe areas.[...]

29 Celebrity X www.pr idemobility.com V. OPERATION BEFORE GETTING ON TO YOUR SCOOTER  Have you fully charged the batterie s? See IV. “Batteries and Charging.”  Is the manual freewheel le ver in the drive (rearwar d) position? Neve r leave the manual freewheel lever pushed forward unless you are ma nually pushing your scooter.  Is the t[...]

30 www.pridemobility.com Celebrity X V. OPERATION NOTE: Your scooter’s reverse speed is slower than that of the forwar d speed yo u preset with the speed adjustment dial. GETTING OFF YOUR SCOOTER 1. Bring your scooter to a complete stop. 2. Remove the key from the key switch. 3. Disengage the seat rotatio n lever and rotate the seat until you are[...]

31 Celebrity X www.pr idemobility.com TILLER ANGLE ADJUSTM ENT WARNING! Remove the key from the key switch before adjusting the tiller or the seat. Never attempt to adjust the tiller or the seat while the scooter is in motion. Your scooter is equipped with an adjustable pivoting tiller. 1 . While supporting the tiller , turn the tiller adjust- ment[...]

32 www.pridemobility.com Celebrity X VI. COMFORT ADJUSTMENTS Figure 17. Seat Height Adjust ment SEAT HEIGHT ADJUSTMENT The seat can be repositioned to different heights. See figure 17. 1. Remove the seat a nd rear shroud from your scooter. See VII. “Disassembly and Assembly.” 2. Loosen the seat height adjustment nut and remove it from the bol t[...]

33 Celebrity X www.pr idemobility.com VI. COMFORT ADJUSTMENTS Figure 19. Positioning Be lt POSITIONING BELT (OPTIONAL) Your scooter seat may be e quipped with an auto-type posi- tioning belt that can be adjust ed for operator comfort. See figure 19. The positioning belt is designed to help support the operator so that he/she does not slide down or [...]

34 www.pridemobility.com Celebrity X POWER SEAT ADJUSTMENT Your scooter may be equippe d with a power seat. The pow er seat actuator is designed to raise or lower the seat with minimal effort on the part of the operator. Th e power s eat switch is lo cated on the tiller console. WARNING! The power seat is intended for operation only while your scoo[...]

35 Celebrity X www.pr idemobility.com VII. DISASSEMBLY AND ASSEMBLY DISASSEMBLY You can disassemble the sc ooter into seven pieces: the seat, the front section, the rear section, the rear shroud, the basket, and the batteries. See figure 20. No tools are required to disassemble or assemble your scooter, but keep in mind that the disassem- bled sect[...]

36 www.pridemobility.com Celebrity X UPPER FRAME TUBE LOWER FRAME TUBE FRONT-TO -REAR HARNESS REAR LIGHTING HARNESS FRAME HOOK FRAME RELEASE LEVER FRAME LOCK VII. DISASSEMBLY AND ASSEMBLY Figure 22. Harness Connections Figure 23. Frame Release Figure 24. Frame Separation FRAME HOOK 8. Squeeze the tiller adju stment lever and lower the tiller to its[...]

37 Celebrity X www.pr idemobility.com VIII. BASIC TROUBLESHOOTING Any electromechanical device occasionally requires some troubleshoot ing. However, most of the prob- lems that may arise can usually be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not fully charged or becaus e the batteries ar[...]

38 www.pridemobility.com Celebrity X What if my scooter does not move wh en I engage the throttle control lever?  When the manual freewheel lever is pushed forward, the br akes are disengaged a nd all power to the motor/transaxle assembly is cut.  Push rearward on the manual freewheel lever, turn the scooter off and th en turn the scooter on [...]

39 Celebrity X www.pr idemobility.com Your scooter requires a mi nimal amount of care and ma intenance. If you do not feel confident in your ability to perform the maintenan ce listed below, you ma y schedule inspection a nd maintenance at your authorized Pride Provi der. The following areas re quire periodic inspection a nd/or care and maintenance[...]

40 www.pridemobility.com Celebrity X IX. CARE AND MAINTENANCE WHEEL REPLACEMENT If your scooter is equipped with pneumatic tires and you have a flat ti re, you can have th e tube replaced. If your scooter is equipped with a solid tire insert, either the solid insert or the entir e wheel must be replaced depending on th e model. Contact your authori[...]

41 Celebrity X www.pr idemobility.com IX. CARE AND MAINTENANCE Figure 26. Work ing Fuse Figure 26A. Blown Fuse (Replace) WIRING HARNESSES  Regularly check all wiring connections.  Regularly check all wiring insulation, including th e charger power cord, for wear or damage.  Have your authorized Pr ide Provider repair or re place any damage[...]

42 www.pridemobility.com Celebrity X IX. CARE AND MAINTENANCE STORING YOUR SCOOTER If you plan on not using your scooter for an extended period of time , it is best to: 1. Fully charge its batteries prior to storage. 2. Disconnect the batteries from the scooter. 3. Store your scooter in a warm, dry environment. 4. Avoid storing your scooter where i[...]

43 Celebrity X www.pr idemobility.com Model Number s 3-wheel: SC4001, 4- wheel: SC4401 Maximum Allowable Incline 6° (10.5%) Maximum Obstacle Climbing Ability 2 in. (5 cm) Overall Lengt h 3 3-wheel: 46 in. (116.84 cm) , 4-wheel: 46.75 in (118.75 cm) Overall Width 3 24 in. (61 cm) Total Weight Without Batteries 6 3-wheel: 144.5 lbs. (65.5 4 kg), 4-w[...]

44 www.pridemobility.com Celebrity X APPENDIX I - SPECIFICATIONS Figure 27. Scooter Dimensions 18 in. (45.72 cm) (45.72 cm) 24 in. (61 cm) 3-Wheel: 46 in. (116.84 cm) 4-Wheel: 46.75 in. (118.75 cm) 54 in. (137.16 cm) 41.5 in. (105.41 cm) 3-Wheel T urning Radius 4- Wheel T urning Radius 16.5 - 18.5 in. (41.91 - 47 cm) 2.25 in. (5.7 cm) 41.5 in. (105[...]

45 Celebrity X www.pr idemobility.com NOTES[...]

46 www.pridemobility.com Celebrity X NOTES[...]

WARNING! An authorized Pride Provider or qual ified technician must perform the initial setup of this scooter and must perform all of the procedures in th is manual. The symbols below are used throughout this owner's ma nual and on the scooter to identify warnings and important information. It is very important fo r you to read them and unders[...]

*INFMANU2995* CELEBRITY X[...]