Regency Wraps I2400M manuale d’uso

FPI FIREPLACE PRODUCTS INTERNA TIONAL L TD. 6988 V enture St., Delta, BC Canada, V4G 1H4 918-171a MODELS: I2400M WOOD Fireplace Insert 07/18/06 Owners & Installation Manual Installer : Please complete the details on the back cover and leave this manual with the homeowner . Homeowner: Please keep these instructions for future reference. T ested [...]

Regency I2400M 2 Thank-you for purchasing a REGENCY FIREPLACE PRODUCT . The pride of workmanship that goes into each of our products will give you years of trouble-free enjoyment. Should you have any questions about your product that are not covered in this manual, please contact the REGENCY DEALER in your area. Keep those REGENCY FIRES burning. SA[...]

Regency I2400M 3 THE REGENCY I2400 WOOD INSERT T ABLE OF CONTENTS SAFETY LABEL Safety Label ................................................................. 4 UNIT DIMENSIONS Unit Dimensions ........................................................... 5 INST ALLA TION Before InstallingY our Insert ........................................... 6 Chimn[...]

Regency I2400M 4 SAFETY LABEL This is a copy of the label that accompanies your Regency Insert . W e have printed a copy of the contents here for your review . NOTE: Regency units are constantly being improved. Check the label on the unit and if there is a difference, the label on the unit is the correct one. UNITED ST A TES ENVIRONMENT AL PROTECTI[...]

Regency I2400M 5 UNIT DIMENSIONS[...]

Regency I2400M 6 INST ALLA TION CHIMNEY SPECIFICA TIONS Before installing, check and clean your chimney system thoroughly . If in doubt about its condi- tion, seek professional advice. Y our Regency Insert is designed for installation into a masonry fi replace that is constructed in accordance with the requirements of "The Standard for Chimne[...]

Regency I2400M 7 INST ALLA TION View from Rear of Insert OPTIONAL FLUE CONNECT OR KIT The Straight Flue Adaptor (Part #846-504) shown here, may be used to produce a secure connection between your fl ue connector and the insert collar . Detailed installation instructions are included with the kit. INST ALLING YOUR INSERT Y our insert is very heavy [...]

Regency I2400M 8 Clearance diagram for Installations Side and T op facing is a maximum of 1.5" thick. Floor protection must be non-combustible, insula- tive material with an R value of 1.1 or greater . * Hearth thickness of 0.5" with k value = 0.84", R value = 6 or greater . ** A non-combustible mantel may be installed at a lower hei[...]

Regency I2400M 9 1) Positive Flue Connection with Cleanout FLUE CONNECT OR BRACKET Package contains: 3 brackets and 6 screws. These brackets are to be used to hold the fl ue liner (not supplied) to the Insert and keep the connection. The brackets are screwed into the top of the Insert in the pre-punched holes and then screwed into the fl ue liner[...]

Regency I2400M 10 INST ALLA TION Faceplate Assembly Prior to sliding your insert into its fi nal position and attaching the connector or liner pipe, the faceplate side panel plates must be installed as follows: 1) Slide the spring nuts (supplied) over the slots in the insert’s side convection panels (the spring nuts may need to be squeezed with [...]

Regency I2400M 11 Ground Fan Fan Ground Green Neutral Live White Fan Switch Manual/ Auto Switch Black Black High (Black) Low (Red) Black Fan Thermodisc (normally open) 120V AC 60 Hz Thermo Switch Sensor INST ALLA TION STEP-BY -STEP INST ALLA TION OF THE F AN/BLOWER Blower/Fan Wiring Diagram 3) Slide the supports into the clips. The tension holding [...]

Regency I2400M 12 Pull Open Push Closed ensure the tube will not move when the unit is burning. Though there are four air tubes in the medium units. 2) Slide the left baffl e over the air tubes from the front and then push it to the back. 4) Important: push both baffl es so they are tight against the side walls. Side View Front View Front View 3)[...]

Regency I2400M 13 OPERA TING INSTRUCTIONS FIRST FIRE When your installation is completed and in- spected, you are ready for your fi rst fi re. 1) Open draft control fully . 2) Open fi rebox door and build a small fi re using paper and dry kindling on the fi rebrick hearth, wait a few minutes for a good updraft in the fl ue to establish the ?[...]

Regency I2400M 14 ASH DISPOSAL During constant use, ashes should be removed every few days. Please take care to prevent the build-up of ash around the start-up air housing located inside the fi rebox, under the loading door lip. DO NOT ALLOW ASHES TO BUILD UP TO THE LOADING DOORS. Only remove ashes when the fi re has died down. Even then, expect [...]

Regency I2400M 15 MAINTENANCE OF GOLD-PLA TED DOORS The gold electroplated fi nish on the doors requires little maintenance, and need only be cleaned with a damp cloth. DO NOT use abrasive materials or chemical cleaners, as they may harm the fi nish and void the warranty . DOOR GASKET If the door gasket requires replacement, 7/8" diameter ma[...]

Regency I2400M 16 MAIN ASSEMBL Y & OPTIONS - I2400M P ARTS LIST Part # Description 142-917 Fan Assembly 24) 910-157/P Fan Motor 120 V olts 25) 910-678 Power Cord 120 V olts 27) 910-142 Fan Thermodisc 28) 910-140 Fan Speed Hi / OFF / Low Switch (3-way) 29) 910-138 Auto / Manual On / OFF Switch 30) * Grommet Strain Relief 36) 033-953 Air T ube 3/[...]

Regency I2400M 17 P ARTS LIST F ACEPLA TES - I2400M Part # Description 140-91 1 Faceplate & T rim Set - Regular 285) 143-161 Trim Right Regular 286) 143-158 Trim T op Regular 287) 143-160 Trim Left Regular 288) * Faceplate Side Regular 289) * Faceplate T op Regular 140-913 Faceplate & T rim Set - Oversize 295) 143-164 Trim Right Oversize 29[...]

Regency I2400M 18 P ARTS LIST BRICK P ANELS - I2400M Part # Description 70) 902-1 1 1 Brick Regular Full Size: 1-1/4" x 4-1/2" x 9" 75) 802-122 Brick Partial: 1-1/4 x 4-1/2" x 2" 76) 802-152 Brick Partial: 1-1/4" x 2" x 9"[...]

Regency I2400M 19 W ARRANTY Regency Fireplace Products are designed with reliability and simplicity in mind. In addition, our internal Quality Assurance T e am carefully inspects each unit thoroughly before it leaves our door . Regency Industries Ltd. is pleased to extend this limited lifetime warranty to the original purchaser of a Regency Product[...]

Printed in Canada Installer: Please complete the following information Dealer Name & Address: ______________________________________________ ___________________________________________________________________ Installer: ___________________________________________________________ Phone #: _________________________________________________________[...]