Sony KV-34FQ75A manuale d’uso

1 SERVICE MANUAL AE-5A CHASSIS MODEL COMMANDER DEST CHASSIS NO. KV-34FQ75A RM-893 ET SCC-Q45D-A KV-34FQ75D RM-893 A E P SCC-Q41G-A MODEL COMMANDER DEST CHASSIS NO. KV-34FQ75K RM-893 OIRT SCC-Q42C-A[...]

2 T ABLE OF CONTENTS Section T itle Page Section T itle Page Specifications .................... 3 Connectors .................... 4 Self Diagnostic Software .................... 5 1. GENERAL T uning your TV .................... 8 Finding your V ideo Channel .................... 8 Using the TV menu system .................... 8 NexT V iew .........[...]

3 L E D O M M E T I m e t s y S n o i s i v e l e T m e t s y S o e r e t S e g a r e v o C l e n n a h C m e t s y S r o l o C n a i l a t IK / D , H / G / Bo e r e t S N A M R E G 9 6 E - 1 2 E : F H U 2 1 E - 2 E : F H V H / G / B 5 0 S - 1 0 S , 9 6 R - 1 2 R , 2 1 R - 1 0 R : K D M A C E S , L A P 8 5 . 3 C S T N , 3 4 . 4 C S T N ) N I O E D [...]

4 21 pin connector Connected Not Connect ed (op en) * a t 20Hz - 20 kHz Pin No 1 2 4 Signal Signal level 1 Audio output B (rig ht) Standa rd level : 0.5V r ms Output im peden ce : Les s than 1koh m* 2 Audio output B (rig ht) Standa rd level : 0.5V r ms Output i mpeden ce : Mo re tha n 10kohm* 3 Audio output A (left) Standa rd level : 0.5V r ms Outp[...]

5 AE-5A SELF DIAGNOSTIC SOFTW ARE The identification of errors within the AE-5A chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then commu[...]

6 Device acknowledge is used to check IIC errors. Device acknowledge is checked by sending an IIC start sequence during CR T power on. Each device is checked three times, if there is no acknowledge after each attempt, it will be regarded as an error . There are three steps to check for errors. 1. IIC line 0 If all devices except the NVM have errors[...]

7 2. Error Reader Display The error reader display is connected to the service connector to read actual error codes. The part number for the error reader display is S-188-900-10. Once an error has been detected it will then be displayed on the two digit error reader . The errors displayed refer to the following table. e d o C r o r r E e g a s s e [...]

8 5 Installation Before you tune your TV, y ou will be asked to set your language an d country. 6. T uning you r TV : : : : Language/Country Language Country Select Country: Confirm: OK Greece Great Britain Germany France Finland Denmark Czech Rep. Language/Country Language Country Select Language: Confirm: OK Italiano Français Español English De[...]

9 14 Using the TV menu system: Equaliser Adjustment Sel: Adjust: Confirm:OK (Personal) + 0 – 120 500 1,5K 5 K 10 K Auto V ol. Control Off On Dual Sound Mono Stereo NICAM V olume Dual Sound PA P Stereo NICAM Audio Adjustment Equaliser Mode Equaliser Adjustment Balance Loudness Space Auto V ol. Control Dual Sound V olume Dual Sound Stereo Off Off S[...]

10 16 Using th e TV menu sy stem: Re-arranging the TV channels After tuning the TV, yo u can use this feature to change the ord er of the channels on the TV. 1. Press the MENU button on the remote control to display th e menu on the TV screen. 2. Press the V button to select the symbol on the m enu screen then press B to enter the ‘Set Up’ menu[...]

11 18 Using the TV men u system: Using the Further Programme Preset feature With this feature you can a) adjust the attenuation o f each channel, b) individually adjust the volume level of each channel, c) manually fine-tune the TV to obtain a better picture reception if the picture is distorted or d) preset the AV outp ut for the programme positio[...]

12 8 Operation NexTView is an on-screen electro nic programme guide, providin g you with programme informatio n for different broadcasters. NexTVie w* Selecting your NexTView provider Your TV set automatically selects the best NexTView provider for you. This provider is available about 30 minutes after the channel tuning. You can ho wever change th[...]

13 11 Operation T eletext Using the Teletext menu 1. With T ele text switched on, press the MENU button on the remote control to display the menu on the TV screen. 2. Press v or V to select your chosen item on the screen then press B to display the relev ant sub menu. 3. T o remov e the T eletext menu from the screen, press the MENU bu tton. Top/Bo[...]

14 23 Additional Information Specifications TV system B/G/H, D/K Colour system PAL, SECAM NTSC 3.58, 4. 43 (only Vid eo In) Channel coverage See the ‘Cha nnel Display Table’ below. Picture tube FD Trin itron, A pprox. 86 cm (34 inche s) Rear Terminals / 21-pin Euro connector (CENELEC standard) including au dio/ video in put, RGB in put, TV aud [...]

15 Remov e the 12 rear cover f ixing scre ws indicated. T ake care when removing the rear cover not to damage the speaker cables [Disconnect the speaker connector] as speakers are fitted inside the rear co ver . SECTION 2 DISASSEMBL Y 2-1. Rear Cover Removal T o remov e lift the main bracket rear slightly and slide the chassis away from the beznet.[...]

16 2-4. Service Position 2-5. D1 Board Removal 2-6. J Board Removal T o remov e the D1 Board release the clip circled and carefully remove the board in a vertical direction. Position the chassis as indicated to access the its underside. T o gain access to the D Board follo w the instructions on page 19. [Removal and Replacement of the main bracket [...]

17 2-8. Front Control Module Removal => 2-9. F3 and H6 Board Removal T o remov e the F3 and H6 Boards release the clips circled and ease the boards gently away from the main support bracket. Clips 2-10. H5 Board Removal T o remove the H5 Board, f irst remov e the control door from bracket by releasing the clips circled and pushing them through t[...]

18 Anode button a * REMOVING PROCEDURES. T urn up one side of the rubber cap in the direction indicated by the arrow a 1 2 Using a thumb pull up the rubber cap firmly in the direction indicated by the arrow b 3 When one side of the rubber cap is separated from the anode button, the anode-cap can be removed by turning up the rubber cap and pulling i[...]

19 REMOV AL AND REPLACEMENT OF THE MAIN - BRACKET BOTTOM PLA TES. (1) REMOVING THE PLA TES In the event of servicing being required to the solder side of the D Board printed wiring board, the bottom plates fitted to the main chassis bracket require to be removed. This is performed by cutting the gates with a sharp wire cutter at the locations indic[...]

20 • When complete readjustment is necessary or a new picture tube is installed, carry out the following adjustments. • Unless there are specific instructions to the contrary , carry out these adjustments with the rated power supply . • Unless there are specific instructions to the contrary , set the controls and switches to the following set[...]

21 GREEN BLUE RED (1) Screen centre convergence [Static convergence] 1. Input a dot pattern signal from the pattern generator . 2. Normalize the picture setting. 3. [Moving vertically], adjust the V .ST A T magnet so that the vertical red, green and blue dots coincide at the centre of the screen. 3-2. Convergence By opening or closing the V .ST A T[...]

22 4. Correction for HMC [Horizontal mis-convergence] and VMC [V ertical mis-convergence] by using the BMC [Hexapole] magnet. a) . HMC correction by BMC [Hexapole] magnet and movement of the electron beam. b). VMC correction by BMC [Hexapole] magnet and movement of the electron beam. Adjust the HAMP using HAMPL and HAMPR registers in the Dynamic Co[...]

23 3-3. Focus Adjustment 1. Receive a television broadcast signal. 2. Normalize the picture setting. 3. Adjust the focus control located on the flyback transformer to obtain the best focus at the centre of the screen. Bring only the centre area of the screen into focus, the magenta- ring appears on the screen. In this case, adjust the focus to opti[...]

24 1. Turn on the main power switch of the set while pressing P + (plus) and P - (minus) buttons on the front drop down control panel. 2. ‘TT’ will appear in the upper right corner of the screen. 3. Press the ‘MENU’ button twice on the remote commander to obtain the service menu on the screen. 4. Push the joystick up or down on the remote c[...]

25 g n i t t e s e r u t a e F o Nr c s e Dn i Mx a Ma t a D 1P A PF F ON ON O 2T A PF F ON ON O 3X E D N IF F ON ON O 4G P EF F ON ON O 5G P E L L U FF F ON ON O 6s s a p y B t s o o B t c i PF F ON OF F O The menu contains a list with all the available models of this software to set up the TV set in an easy way . The selection of a model is setti[...]

26 d n e k c a B n o i t c e l f e D n o i t c e l f e D t x E e c n e g r e v n o C c i m a n y D 1 r e d o c e D r u o l o C 2 r e d o c e D r u o l o C h c t i w S o e d i V / o i d u A X - d i M X - d i M L L P l a n e t x E d n u o S r e t s o o B e r u t c i P R N g o l a n A Device Register Setting d n u o S o Nr c s e Df e Dn i Mx a Ma t a [...]

27 T able.4-10 e c n e g r e v n o C c i m a n y D o Nr c s e Df e Dn i Mx a Ma t a D 1e g n a R3 603 63 6 2t a t S V6 303 67 1 3t a t S H3 303 61 3 4L p m a H7 303 63 3 5R p m a H6 303 63 3 6Y p U1 30 3 61 3 7Y w o L3 303 61 3 8L p u Y0 303 65 4 9R p u Y0 303 61 3 0 1L w o l Y1 30 3 61 3 1 1R w o l Y0 303 65 4 2 1L p U w o b M1 30 3 61 3 3 1R p U [...]

28 V SIZE V LIN AFC V BOW V POS H POS H SIZE H PIN CUSH H TIL T H UP COR AFC V ANGLE H LOWER COR T able.4-13 n o i t c e l f e D o Nr c s e Df e Dn i Mx a Ma t a D 1e z i S - V1 30 3 61 3 2n o i t i s o P - V1 30 3 60 3 3p m o C - V1 0 3 1 4r a e n i L - V7 0 5 17 5r r o C - S7 0 5 17 6e z i S - H1 30 3 62 3 7C D - W EF F OF F ON OF F O 82 m i T b [...]

29 Is available by pressing the ‘TEST’ button twice, OSD ‘TT’ appears. The functions described below are available by selecting the two numbers. T o release the ‘T est mode 2’, press 0 twice, press the TV button or switch the TV set into Stand-by mode. Pressing the two Local Control buttons (+ and -) during power ON will also switch int[...]

30 Memo[...]

31 32 33 34 5-1. BLOCK DIA GRAMS (1) TO PICTURE TUBE HV TO C BOARD FV 1 5 RELAY RY601 3 2 1 CN6620 CN6700 1 2 CN6700 RELAY RY602 MAIN RECT D6604 T6 601 1 7 6 3 2 5 4 14 12 13 10 8 9 17 15 16 +6.5V RECT D6619 +10.5V RECT D6616 +135V RECT D6617 +4.5V RECT D6620 +22V RECT D6618 T6600 PRT IC603 POWER MODULE 3 1 4 +22V +135V +10.5 V +6.5V +4.5V IC6654 +[...]

35 36 38 37 5-1. BLOCK DIA GRAMS (2) TO A BOARD CN1801 B9 A9 CVBS OUT (TEXT) AUDIO RESET AM1 QSSI IN CN8902 A4V CN8101 (1 /2) 14 SDA 13 SCL 15 YS 3 27 R I 26 G I 25 B I V-M (2) 1 CVBS/YI 48 CI 45 COMB SYS 23 Cr OUT 5 COMB Y BUFFER Q8200 MONO IN (AM) 69 IF IN 2 67 IF IN1 POWER ON RESET 27 SPEAKER OUT R 25 SURROUND OUT 28 SPEAKER OUT L 30 SUBWOOFER O[...]

39 40 41 42 5-1. BLOCK DIA GRAMS (3) CN502 (1/2) 11 IC801 IC802 TO A BOARD CN1200 B3 ( ) 100Hz PROCESSING A25 HP MAIN IN CN502 (2/2) A6 HP100 OUT SCL 201 202 208 210 215 DRCCBIN7 12 DRCCBIN6 13 DRCCBIN5 14 DRCCBIN4 15 DRCCBIN3 16 DRCCBIN2 17 DRCCBIN1 20 DRCCBIN0 21 DRCCRIN7 23 DRCCRIN6 23 DRCCRIN5 24 DRCCRIN4 26 DRCCRIN3 27 DRCCRIN2 28 DRCCRIN1 29 [...]

43 44 46 45 5-2. CIRCUIT BO ARD LOCA TION 5-3. SCHEMA TIC DIA GRAMS AND PRINTED WIRING BO ARDS Note : • All capacitors are in µF unless o therwise noted. • pF : µµF 50WV or less are not indicated except f or electrolytic type s. • Indication of resistance, which does not h av e one for rating electrical power , is as follows . Pitch : 5mm [...]

48 47 H5 [ FR ONT A V , S-VIDEO ] H5 [ PRINTED WIRING BOARD ] F1 [ PRINTED WIRING BO ARD ] F1 [ AC FIL TER FUSE ] H6 [ PRINTED WIRING BOARD ] H6 [ IR RECEIVER FOR SIRCS AND LED ] F3 [ POWER SWITCH ] F3 [ PRINTED WIRING BO ARD ][...]

E [ R, G, B OUT CHROMA ] 50 49[...]

51 E [PRINTED WIRING BO ARD (A side)] E [PRINTED WIRING BO ARD (B side)][...]

52 M1 [PRINTED WIRING BO ARD (B side)] M1 [PRINTED WIRING BOARD (A side)][...]

B A C D E F G 123 4 5 67 8 9 1 0 1 1 1 2 1 3 1 4 1 5 1 6 1 7 1 8 1 9 2 0 H I J K L M N O P Q R S T 21 53 54 55 M1 [ MICROPROCESSOR & TEXT DECODER ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 58 57 56 D1 [ DEFLECTION ][...]

60 59 D1 [ PRINTED WIRING BO ARD ] AB CD EF G H 1 2 3 4 5 C I 4 0 3 6 C I2 - B1 0 1 6 Q2 - H2 1 1 6 Q3 - H7 2 1 6 Q3 - D2 5 2 6 Q2 - D3 0 4 6 Q4 - D4 0 1 6 D4 - G2 0 3 6 D4 - C5 5 3 6 D4 - A 0 0 1 6 C I2 - G1 5 3 6 C I5 - A2 0 1 6 Q3 - H3 1 1 6 Q4 - H8 2 1 6 Q4 - H3 5 2 6 Q2 - H4 0 4 6 Q4 - D5 0 1 6 D3 - G3 0 3 6 D3 - A1 0 4 6 D4 - D 1 0 1 6 C I2 -[...]

NOTE: Portions of the circuit marked as sho wn are high voltage areas. Use care to prevent electric shock during inspection or repair . 62 61 D [ PRINTED WIRING BO ARD ] Semiconductor V oltage T able 5ms/div 5ms/div 10us/div 10us/div 10us/div 20us/div 10us/div 10us/div 10us/div 10us/div 5ms/div 5ms/div 570 mVp-p (V) 58 Vp-p (V) 2.28 Vp-p (H) 2.14 V[...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 64 65 63 D [ PO WER SUPPL Y & DEFLECTION ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 68 67 66 A [ SIGNAL & A UDIO AMPLIFIER ][...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 71 70 69 AB CD E F G HI J K L M 1 2 3 4 5 6 7 8 9 10 11 13 14 15 12 A [ PRINTED WIRING BO ARD ] e l b a T e g a t l o V C I o N f e R o N n i P ) V ( e g a t l o V 6 2 1 1 C I 10 21 1 - 30 1 69 1 - 90 0 11 . 4 2 11 1 - 1 5 1 1 C I 10 21 1 - 30 1 68 1 - 9[...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 72 73 74 AB CD EF G HI J 1 2 3 4 5 6 7 8 9 10 J [ PRINTED WIRING BO ARD ] C I 0 5 1 8 Q5 - A5 0 4 8 Q3 - G0 1 8 8 D4 - G 1 0 1 8 C I5 - B1 5 1 8 Q5 - A6 0 4 8 Q2 - G1 1 8 8 D9 - D 0 5 1 8 C I5 - B2 5 1 8 Q5 - A1 0 5 8 Q6 - F2 1 8 8 D8 - D 1 5 1 8 C I4 - A3 5[...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 75 76 77 J [ INTERF ACE, AUDIO , CHR OMA, COMB FIL TER (Page 1/2) ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 80 79 78 J [ INTERF ACE, AUDIO , CHR OMA, COMB FIL TER (Page 2/2) ][...]

C [ PRINTED WIRING BO ARD ] 82 81 10us/div 10us/div 5us/div 10us/div 5us/div 115 Vp-p (H) 115 Vp-p (H) 108 Vp-p (H) 2.3 Vp-p (H) 2.1 Vp-p (H) TP1 TP2 TP3 TP4 C board Waveforms 5us/div 10us/div 4.64 Vp-p (H) 2.4 Vp-p (H) TP4 TP5 TP6 TP7 e l b a T e g a t l o V C I o N f e R o N n i P ) V ( e g a t l o V 0 0 3 5 C I 10 . 4 38 . 3 52 . 8 70 . 5 5 1 80[...]

BL [ PRINTED WIRING BO ARD [B] SIDE ] 84 83 AB CD E F G H 1 2 3 4 5 6 7 8 9 10 BL [ PRINTED WIRING BO ARD [A] SIDE ] C I 4 0 5 2 Q8 - D 1 0 3 2 C I4 - D5 0 5 2 Q8 - D 1 0 5 2 C I6 - E6 0 5 2 Q8 - E 3 0 5 2 C I7 - F7 0 5 2 Q8 - F 4 0 5 2 C I3 - F8 0 5 2 Q8 - E 5 0 5 2 C I8 - C9 0 5 2 Q8 - E R O T S I S N A R T 0 1 5 2 Q8 - F 0 0 3 2 Q0 1 - G1 1 5 2 [...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 85 86 87 BL [ ANALOGUE NOISE REDUCTION ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 90 89 88 B3 [ PRINTED WIRING BOARD [A] SIDE ] B3 [ 100Hz PROCESSOR (1/6) ] B3 [ PRINTED WIRING BO ARD [B] SIDE ][...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 92 93 B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 91 B3 [ 100Hz PROCESSOR (2/6) ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 94 95 B3 [ 100Hz PROCESSOR (3/6) ] 96[...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 99 98 97 B3 [ 100Hz PROCESSOR (4/6) ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 100 101 B3 [ 100Hz PROCESSOR (5/6) ] 102[...]

B A C D E F G 12 3 4 5 6 7 8 9 1 0 1 11 21 31 41 51 61 7 1 81 92 0 H I J K L M N O P Q R S T 21 105 104 103 B3 [ 100Hz PROCESSOR (6/6) ][...]

17 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 F G H I J K L M N O P Q R S B A C D E 19 18 20 21 108 2 1 3 4 5 1 5 2 4 3 6 6 B C E C B E E C B E C B E C B E C B E C B MARKING SIDE VIEW IMZ1A-T109 IRF614 IRF620 DT A144EK DT A144EK-T146 DTC114EK DTC114YKA-T146 DTC123EK DTC123EK-T146 DTC124EKA-T146 DTC144EK DTC144EK-T146 2SA1037K-T -146-R 2SA1162-G 2SC2412[...]

109 1 2 3 1 2 3 3 2 1 23 1 NC CATHODE ANODE CATHODE ANODE ESAC39M-06C ESAC39M-06CF38 MA3033-L MA3033L-TX MA3056M-TX MA3062M-TX MA3030-H-(TX) MA3051L-TX MA73-TX 1SS355TE-17 RD12SB2 UDZ-TE-17-3.9B UDZ-TE-17-4.7B UDZ-TE-17-6.2B UDZ-TE-17-6.8B UDZ-TE-12B CATHODE ANODE UF4005PKG23 CATHODE ANODE ERD08M-15 CATHODE ANODE D4SB60L D4SB60L-F RBA-402L ERA38-06[...]

110 • Items with no p art numbe r and no de scripti on are not stocked becau se they are sel dom requi red for rout ine service. • The constru ction parts of an assemb led pa rt are in di- cated with a co llation number in th e remarks column. • Items marked “ * “ are not stocked since th ey are seldom requir ed for rout ine servi ce. Som[...]

111 REF. NO. PART.NO DES CRIPTION REMARK REF. NO. PART.NO DESCRIPTIO N RE MARK 6-2. PICTU RE TUB E 51 X-4200-623-1 BEZNET ASSY 52 52 4-203-128-31 SHEET, BLOTTING 53 A-1610-072-A FRONT CONTROL ASSY 54-66 54 4-205-463-11 WINDOW, ORNAMENTAL 55 4-202-555-01 SHAFT, DOOR 56 *A-1646-211-A H6 BOARD, COMPLETE 57 *A-1624-085-A F3 BOARD, COMPLETE 58 *A-1646-2[...]

112 77 *4-205-413-11 DGC CUSHION 78 *4-054-297-01 HOLDER, DGC 79 4-064-945-03 HOLDER, DGC 80 4-067-455-01 BAND, DGC 81 £ 1-251-715-92 CAP ASSY, HIGH VOLTAGE 82 4-203-658-01 SPACER, DY 83 £ 8-735-047-05 PICTURE TUBE (A80LPD80X) 84 4-204-225-01 PT-SCREW 85 4-308-870-00 CLIP, LEAD WIRE 86 1-452-094-00 MAGNET, ROTATABLE DISK; 15MM 87 1-452-032-00 MAG[...]

113 P ARTS LISTI NG T ABLE OF CONTENTS Pag e F3 BO ARD COM PLETE P arts List : ................ ................. ...................... ................. ................. .......... 114 H5 BO ARD COMPLETE P ar ts List : ................. ....................... ................ ................. ................. ......... 114 H6 BO ARD COMPLETE [...]

114 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. *A-1624-085-A MOUNTED PC BOARD, F3 < CONNECTOR > CN7700 £ *1-695-292-11 PIN, CONNECTOR (POWER) CN7733 £ *1-580-844-11 PIN, CONNECTOR (POWER) < S[...]

115 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C333 1-216-295-91 SHORT 0 C337 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C338 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C339 1-164-004-11 CERAMIC CHIP 0[...]

116 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C631 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V C632 1-126-206-11 ELECT CHIP 100UF 20.00% 6.3V C633 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V C634 1-163[...]

117 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. FL512 1-234-177-21 FILTER, CHIP EMI FL601 1-234-177-21 FILTER, CHIP EMI FL602 1-234-177-21 FILTER, CHIP EMI FL603 1-234-177-21 FILTER, CHIP EMI FL606 1-23[...]

118 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R309 1-216-009-91 RES-CHIP 22 5% 1/10W R310 1-216-009-91 RES-CHIP 22 5% 1/10W R311 1-216-009-91 RES-CHIP 22 5% 1/10W R313 1-216-009-91 RES-CHIP 22 5% 1/10W[...]

119 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R608 1-216-295-91 SHORT 0 R609 1-216-073-00 RES-CHIP 10K 5% 1/10W R610 1-216-033-00 RES-CHIP 220 5% 1/10W R611 1-216-073-00 RES-CHIP 10K 5% 1/10W R612 1-2[...]

120 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R845 1-216-009-91 RES-CHIP 22 5% 1/10W R846 1-216-009-91 RES-CHIP 22 5% 1/10W R847 1-216-009-91 RES-CHIP 22 5% 1/10W R848 1-216-009-91 RES-CHIP 22 5% 1/10W[...]

121 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. BL R990 1-216-113-00 RES-CHIP 470K 5% 1/10W R991 1-216-295-91 SHORT 0 R993 1-216-089-91 RES-CHIP 47K 5% 1/10W R994 1-216-033-00 RES-CHIP 220 5% 1/10W R995[...]

122 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C2331 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C2332 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C2333 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C2334 1-[...]

123 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. < IC > IC2301 8-752-067-36 IC CXA1815S IC2302 8-759-542-15 IC TDA9178 IC2303 8-759-337-26 IC MM1115XFBE IC2501 8-759-710-86 IC NJM2233BM(TE2) IC2502[...]

124 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. Q2555 8-729-216-22 TRANSISTOR 2SA1037K-T-146-R Q2558 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR Q2560 8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR Q2561 8-729-[...]

125 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R2407 1-216-041-00 RES-CHIP 470 5% 1/10W R2408 1-216-295-91 SHORT 0 R2411 1-216-049-91 RES-CHIP 1K 5% 1/10W R2413 1-216-641-11 METAL CHIP 390 0.5% 1/10W R[...]

126 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R2586 1-216-073-00 RES-CHIP 10K 5% 1/10W R2587 1-216-055-00 RES-CHIP 1.8K 5% 1/10W R2588 1-216-645-11 METAL CHIP 560 0.5% 1/10W R2589 1-216-055-00 RES-CHIP[...]

127 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C1134 1-126-961-11 ELECT 2.2UF 20.00% 50V C1135 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1136 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C1137 1-126-95[...]

128 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. D1408 8-719-069-55 DIODE UDZS-TE-17-5.6B D1601 8-719-056-83 DIODE UDZ-TE-17-6.8B D1602 8-719-914-43 DIODE DAN202K-T-146 D1626 8-719-914-43 DIODE DAN202K-T-[...]

129 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R1176 1-216-063-91 RES-CHIP 3.9K 5% 1/10W R1177 1-216-063-91 RES-CHIP 3.9K 5% 1/10W R1178 1-216-357-00 METAL OXIDE 4.7 5% 1W R1179 1-216-357-00 METAL OXID[...]

130 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C9113 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C9114 1-164-004-11 CERAMIC CHIP 0.1UF 10.00% 25V C9115 1-115-340-11 CERAMIC CHIP 0.22UF 10.00% 25V C9117 1[...]

131 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R9102 1-216-033-00 RES-CHIP 220 5% 1/10W R9103 1-216-025-91 RES-CHIP 100 5% 1/10W R9104 1-216-073-00 RES-CHIP 10K 5% 1/10W R9105 1-216-073-00 RES-CHIP 10K[...]

132 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R9530 1-216-025-91 RES-CHIP 100 5% 1/10W R9531 1-216-295-91 SHORT 0 < CRYSTAL > X9101 1-781-107-21 VIBRATOR, CERAMIC X9500 1-760-551-21 VIBRATOR, CER[...]

133 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. Q5351 8-729-255-12 TRANSISTOR 2SC2551O-TPE2 Q5352 8-729-216-22 TRANSISTOR 2SB709A-QRS-TX Q5375 8-729-119-78 TRANSISTOR 2SC1740S-RT Q5376 8-729-026-39 TRAN[...]

134 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C4352 1-126-967-11 ELECT 47UF 20.00% 50V C4353 1-107-823-11 CERAMIC CHIP 0.47UF 10.00% 16V C4354 1-107-823-11 CERAMIC CHIP 0.47UF 10.00% 16V C4355 1-164-00[...]

135 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R4309 1-216-045-00 RES-CHIP 680 5% 1/10W R4313 1-216-065-91 RES-CHIP 4.7K 5% 1/10W R4314 1-216-057-00 RES-CHIP 2.2K 5% 1/10W R4315 1-216-295-91 SHORT 0 R4[...]

136 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. 4-039-356-01 SCREW (3X12), (+) BV TAPPING 4-039-357-01 SCREW (3X8), (+) BV TAPPING 4-201-023-01 SPACER, INSULATING 4-202-373-01 SPRING, IC 4-382-854-11 SCR[...]

137 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C6810 1-107-368-11 MYLAR 0.047UF 10.00% 200V C6811 1-107-368-11 MYLAR 0.047UF 10.00% 200V C6812 1-117-214-11 CERAMIC 0.001UF 10.00% 2KV C6813 1-162-115-00[...]

138 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. D6654 8-719-059-23 DIODE P6KE200AG23 D6655 8-719-979-64 DIODE UF4005PKG23 D6656 8-719-063-73 DIODE D1NL20U-TR D6658 8-719-068-00 DIODE ERC04-06SE D6659 8-7[...]

139 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. Q6808 8-729-025-19 TRANSISTOR IRFI740G Q6809 8-729-119-78 TRANSISTOR 2SC1740S-RT Q6810 8-729-026-39 TRANSISTOR 2SA933AS-RT Q6811 8-729-119-78 TRANSISTOR 2[...]

140 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R6811 1-215-897-11 METAL OXIDE 6.8K 5% 2W R6812 1-215-893-11 METAL OXIDE 1.5K 5% 2W R6813 1-215-919-11 METAL OXIDE 2.2K 5% 3W R6814 1-215-880-00 METAL OXID[...]

141 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C6116 1-163-275-11 CERAMIC CHIP 0.001UF 5.00% 50V C6117 1-163-275-11 CERAMIC CHIP 0.001UF 5.00% 50V C6119 1-163-021-91 CERAMIC CHIP 0.01UF 10.00% 50V C612[...]

142 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. D6128 8-719-914-43 DIODE DAN202K-T-146 D6129 8-719-914-43 DIODE DAN202K-T-146 D6198 1-535-465-11 LEAD, JUMPER (5.0MM) D6253 8-719-911-19 DIODE 1SS119-25TD [...]

143 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. Q6467 8-729-026-49 TRANSISTOR 2SA1037AK-T146-R < RESISTOR > R6100 1-216-033-00 RES-CHIP 220 5% 1/10W R6101 1-216-033-00 RES-CHIP 220 5% 1/10W R6102 [...]

144 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R6255 1-216-061-00 RES-CHIP 3.3K 5% 1/10W R6256 1-216-057-00 RES-CHIP 2.2K 5% 1/10W R6257 1-216-061-00 RES-CHIP 3.3K 5% 1/10W R6258 1-216-057-00 RES-CHIP 2[...]

145 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R6419 1-216-073-00 RES-CHIP 10K 5% 1/10W R6420 1-216-089-91 RES-CHIP 47K 5% 1/10W R6421 1-216-629-11 METAL CHIP 120 0.5% 1/10W R6422 1-216-639-11 METAL CH[...]

146 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C8228 1-163-009-11 CERAMIC CHIP 0.001UF 10.00% 50V C8229 1-163-009-11 CERAMIC CHIP 0.001UF 10.00% 50V C8230 1-163-009-11 CERAMIC CHIP 0.001UF 10.00% 50V C8[...]

147 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. C8601 1-115-340-11 CERAMIC CHIP 0.22UF 10.00% 25V C8602 1-115-340-11 CERAMIC CHIP 0.22UF 10.00% 25V C8605 1-115-340-11 CERAMIC CHIP 0.22UF 10.00% 25V C860[...]

148 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. < DIODE > D8150 8-719-421-57 DIODE MA73-TX D8151 8-719-421-57 DIODE MA73-TX D8152 8-719-421-57 DIODE MA73-TX D8153 8-719-056-83 DIODE UDZ-TE-17-6.8B [...]

149 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. Q8154 1-801-806-11 TRANSISTOR DTC144EKA-T146 Q8156 8-729-120-28 TRANSISTOR 2SC2412K-T-146-R Q8157 8-729-120-28 TRANSISTOR 2SC2412K-T-146-R Q8200 8-729-120[...]

150 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R8224 1-216-089-91 RES-CHIP 47K 5% 1/10W R8225 1-216-089-91 RES-CHIP 47K 5% 1/10W R8226 1-216-089-91 RES-CHIP 47K 5% 1/10W R8227 1-216-089-91 RES-CHIP 47K [...]

151 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R8511 1-216-049-91 RES-CHIP 1K 5% 1/10W R8512 1-216-295-91 SHORT 0 R8514 1-216-017-91 RES-CHIP 47 5% 1/10W R8517 1-216-295-91 SHORT 0 R8519 1-216-037-00 R[...]

152 REF. NO. PART.NO DESCRIPTI ON REMARK REF. NO. PART.NO DESCRIPTI ON REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. R8935 1-216-113-00 RES-CHIP 470K 5% 1/10W R8936 1-216-113-00 RES-CHIP 470K 5% 1/10W R8937 1-216-035-00 RES-CHIP 270 5% 1/10W R8938 1-216-057-00 RES-CHIP 2.[...]

153 REF. NO. PART.NO DESCRIPTIO N RE MARK REF. NO. PART.NO DES CRIPTION REMARK The components identified by shading and marked are critical for safety Replace only with the part number specified. < TRANSISTOR > Q5400 8-729-119-78 TRANSISTOR 2SC1740S-RT Q5401 8-729-119-78 TRANSISTOR 2SC1740S-RT Q5402 8-729-119-78 TRANSISTOR 2SC1740S-RT Q5403 8[...]

9-974-99 6 -01 Sony Corporation Sony UK Service Promotions Dept. English 00 G P71 3 7-1 Printed in U.K. © 2000. 7 A n e w TV Repair Assistanc e T ool that combines ease of use and p o werful PC soft w are tools to all o w y ou to s a v e v alua b le time du r ing ma n y TV repair s . Th e TR A CE interface connects to the PC's serial port. It[...]