Toro 38515 manuale d’uso

Form No. 3360-738 Rev A CCR™ 2450 GTS ® Snowthrower Model No. 38515—Serial No. 290000001 and Up Operator's Manual Introduction R ead this infor mation carefully to lear n ho w to operate and maintain your product properly and to av oid injur y and product damage. Y ou are responsible for operating the product properly and safely . Y ou ma[...]

T raining • R ead, understand, and follow all instr uctions on the machine and in the man ual(s) before operating this unit. Be thoroughly familiar with the controls and the proper use of the equipment. Kno w ho w to stop the unit and diseng age the controls quickly . • Never allo w children to operate the equipment. Never allow adults to opera[...]

• Disengag e po wer to the rotor blades when sno w throw er is transported or not in use. • Never operate the sno w thro wer without g ood visibility or light. Always be sure of your footing, and keep a r m hold on the handles . W alk; never r un. • Never touch a hot engine or mufer . Clearing a Clogged Discharge Chute Hand contact with[...]

Safety and Instructional Decals Important: Safety and instr uction decals are located near areas of potential danger . Replace damaged decals. 60-9480 104-2767 104-2775 104-4135 105-1978 Reorder part no. 108-7335 4[...]

105-1980 Reorder part no. 105-3521 Setup Loose Parts Use the chart below to verify that all parts have been shipped. Procedure Description Qty . Use 1. No parts required – Unfold the handle. Discharge chute 1 Chute handle 1 Phillips head screws 3 W ashers 3 2. Locknuts 3 Install the discharge chute. 1. Unfolding the Handle Procedure 1. Cut the pl[...]

3. Hook the end of the control cable spring into the bottom hole of the control bar (Figure 4). Figure 4 4. Fully inser t the handle bolts (Figure 5). Important: Ensure that you do not pinch the control ca ble (Figure 5). Figure 5 5. Tighten the knobs until they are sn ug . 6. Adjust the control cable . R efer to Adjusting the Control Cable. 2. Ins[...]

Figure 8 1. Key switch 3. Recoil start 2. Primer 4. Choke lever Operation Note: Deter mine the left and right sides of the mac hine from the nor mal operating position. Gasoline is extremely ammable and explosi v e. A re or explosion from gasoline can bur n y ou and others. • T o prevent a static charge from igniting the gasoline, place the[...]

Starting the Engine 1. T urn the ignition key clockwise to the On position (Figure 11). Figure 1 1 2. Mov e the chok e lever to the right (Figure 12). Figure 12 3. Fir mly push in the primer 2 times with your thumb , holding the primer in for a second before releasing it eac h time (Figure 13). Figure 13 4. Pull the recoil star ter (Figure 14). Fig[...]

Adjusting the Discharge Chute T o adjust the discharge chute , mo v e the chute handle and the chute deector handle as shown (Figure 18). Figure 18 1. Chute handle 2. Chute deector handle Preventing Freeze-up after Use • Let the engine r un for a few min utes to prev ent moving par ts from freezing . Stop the engine , w ait for all mo ving [...]

Adjusting the Control Cable Checking the Cable Ser vice Inter v al: After the rst hour Y early—Chec k the control cable and adjust it if necessary . Important: Check the control ca ble for proper adjustment initially , after the r st operating hour, and then annually thereafter . 1. Mov e the control bar bac k to ward the handle to remov e [...]

Inspecting the Rotor Blades Ser vice Inter v al: Y early Before eac h season, inspect the rotor blades for wear . When a rotor blade edge has worn do wn to the w ear indicator hole , hav e an A uthorized Ser vice Dealer replace the rotor blades and the scraper (Figure 22) Figure 22 1. Wear indicator hole Storage Storing the Snowthrower • Gasoline[...]

Conditions and Products Covered under The T oro Starting Guarantee The T oro Company and its af fi liate, T oro W arranty Company , guarantee that your T oro GTS (Guaranteed to Start) engine, when used for residential purposes*, will start on the fi rst or second pull for fi ve (5) years from the date of purchase, if you provide the routine main[...]