Toshiba M60 manuale d’uso

[CONFIDENTIAL] Toshiba Personal Computer Satellite M 60 Maintenance Manual TOSHIBA CORPORATION[...]

ii [CONFIDENTIAL] Satellite M 60 Maintenance Manual Copyright © 2004 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein. Toshiba Personal Comput[...]

Satellite M 60 Maintenance Manual [CONFIDENTIAL] iii Preface This mainten ance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Satellite SATELLITE M60 , referred to as the M60 Series in this manual. The procedures described in this manual are intended to help service technicians isol ate faulty Field R[...]

iv [CONFIDENTIAL] Satellite M 60 Maintenance Manual The manual is divided into the following parts: Chapter 1 Hardware Overview describes the M60 Series system unit and each FRU. Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems. Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operati[...]

Satellite M 60 Maintenance Manual [CONFIDENTIAL] v Conventions This manual uses the following formats to describ e, identify, and highlight terms and operating procedures. Acronyms On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example: Read Only Memory (ROM) Key[...]

Chapter 1 Hardware Overview 1[...]

1 Hardware Overview 1 - ii T ec ra A3/S2 Series Maintenance Manual[...]

1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - iii Chapter 1 Contents 1.1 Features ...................................................................................................................... 1 - 5 1.2 System Unit ..............................................................................................................[...]

1 Hardware Overview 1 - iv T ec ra A3/S2 Series Maintenance Manual[...]

1.2 System Unit 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 5 1.1 Features The TECRA A3/S2 Series Personal Computer uses extensive Large Scale Integration (LSI), and Complementary Metal - Oxide Semiconductor (CMOS) technology extensively to provide compact size, minimum weight and high reliability. This computer incorporates the [...]

1 Hardware Overview 1.2 System Unit 1 - 6 T ec ra A3/S2 Series Maintenance Manual ? BIOS ? 1 M B Flash ROM for system BIOS. a) Suspend to RAM/Disk. b) Password protection (System). c) Various hot key for system control. d) Refreshable e) ACPI compliant BIOS ? Power ? 12 - cell Li - Ion smart battery pack with 10.8V*8600mAh c apacity or 6 - cell Li [...]

1.2 System Unit 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 7 ? Keyb oard An easy - to - use 87 - key keyboard provides a numeric keypad overlay for fast numeric data entry or for cursor and page control. It supports software that uses a 101 - or 102 - key enhanced keyboard. Includes one Windows ® key and one Application key. ? [...]

1 Hardware Overview 1.2 System Unit 1 - 8 T ec ra A3/S2 Series Maintenance Manual ? PCMCIA Card Organization ? Accommodate one typ e II device for TECRA A3 or two type II devices/one type III device for TECRA S2. ? SRAM, OTPROM, FLASH ROM, mask ROM memory card up to 64MB ? MODEM/LAN card ? Card bus card ? ACPI 1.0 Compliant ? Full ACPI 1.0B support[...]

1.2 System Unit 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 9 ? TV - out port Plug a 4 - pin s S - video cable into this connector for output of NT SC or PAL TV standard, supporting Macrovision copy protection. ? LAN port The computer comes with an RJ - 45 Local Area Network (LAN) port. The LAN port provides connectivity for LAN.[...]

1 Hardware Overview 1.2 System Unit 1 - 10 T ec ra A3/S2 Series Maintenance Manual 1.2 System Unit The system unit is composed of the following major components: ? Processor ? Intel Celeron M CPU up to 1.5GHz 0.09u, 1M L2, FSB 400MHz ? Intel Pentium M CPU up to 2.13GHz 0.09u, 2M L2, FSB 533MHz ? Micro FC - PGA package CPU ? System Logic ? Intel 915[...]

1.2 System Unit 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 11 ? High Speed 16C550 A Compatible UARTs with Send/Receive 16 - Byte FIFO ? Supports 230k and 460k Baud ? Programmable Baud Rate Generator ? Modem Control Circuitry Infrared Communications Controller ? IrDA v1.2 (4Mbps), HPSIR, ASKIR, Consumer IR Support ? 1 IR Ports ? [...]

1 Hardware Overview 1.2 System Unit 1 - 12 T ec ra A3/S2 Series Maintenance Manual ? HRTF 3D positional audio. ? 3D Stereo Enhancement. TI PCI74 1 1 Card Bus Host Adapter ? 3.3V operation with 5V Tolerance ? The PCI74 1 1 controller is availble in the 288 - terminal MicroStar B GA package(GHK). ? Compliant with ? PCI Local Bus Specification, Revisi[...]

1.2 System Unit 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 13 Marvell 88E8053 for Giga LAN ? PCI Express base specification 1.0a compliant ? x 1 PCI Express interface with 2.5 GHz signaling ? Advanced error reporting ? Message signaled interrupts ? C onfigurable 48 KB deep buffer ? On - chip VLAN insertion and re moval ? TCP, IP[...]

1 Hardware Overview 1.3 2.5 - inch Hard Disk Drive 1 - 14 T ec ra A3/S2 Series Maintenance Manual 1.3 2.5 - inch Hard Disk Drive The internal HDD is a random access non - volatile storage device. It has a non - removable 2.5 - inch magnetic disk and mini - Winchester type magnetic heads. The computer supports a 30/ 40/ 60/ 8 0/ 100 / 120GB HDD.[...]

1.4 Removable Drive s 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 15 1.4 Optical Devices module The module comp artment s can accommodate the following removable modules: ? DVD - ROM drive ? CD - RW/DVD - ROM drive ? DVD ± R/ ± RW drive ? DVD Super Multi drive ? CD - ROM driver 1.4.1 DVD - ROM Drive The DVD - ROM drive (Toshiba[...]

1 Hardware Overview 1.4 Removable Drive s 1 - 16 T ec ra A3/S2 Series Maintenance Manual Supported formats CD: CD - Audio CD - ROM (mode 1 and mode 2) CD - ROM XA (mode 2, form 1 and form 2) CD - I Bridge CD - I (mode 2, form 1 and form 2) CD - TEXT Video CD CD - RW Photo CD CD - R 1.4.3 CD - RW/DVD - ROM Drive The CD - RW/DVD - ROM combo drive (To[...]

1.5 Power Supply 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 17 1.4.4 DVD ± R/ ± RW Drive The DVD ± R/ ± RW drive (Pioneer DVR - K15) is capable of driving either 12cm (4.72 - inch) or 8cm (3.15 - inch) DVD s and CD s without using an adaptor. Read speeds DVD - ROM M aximum 8 times faster rotational speed CD - ROM M aximum 24[...]

1 Hardware Overview 1.5 Power Supply 1 - 18 T ec ra A3/S2 Series Maintenance Manual DVD - RAM S tandard rotational speed Write speeds CD - R Maximum 24 times faster rot ational speed CD - RW Maximum 10 times(High/Ultra Speed) faster rotational speed DVD - R Maximum 8 times faster rotational speed DVD - RW Maximum 4 times faster rotational speed DVD[...]

1.5 Power Supply 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 19 1.5 Power Supply The power supply supplies seven different voltages to the system board and performs the following functions: 1. A/D conversion The EC uses 8 - bit sampling for A/D conversion to determine the following values: ? AC adaptor curr ent ? Battery and temp[...]

1 Hardware Overview 1.5 Power Supply 1 - 20 T ec ra A3/S2 Series Maintenance Manual 6. Power ON/OFF sequence When power is turned on or off, the EC starts the power on or off sequence. ? SQ0 - 4 = power ON sequence ? SQ5 - B = power OFF sequence 7. Battery charging control The EC controls the following. ? The quick c harging ON/OFF ? The detection [...]

1.6 Batteries 1 Hardware Overview T ecra A3/S2 Series Maintenance Manual 1 - 21 1.6 Batteries The computer has two types of batter y : ? Main battery pack ( 18650 size ) ? RTC battery The removabl e main battery pack is the computer’s main power source when the AC adaptor is not attached. The battery specifications are listed in the t able below [...]

1 Hardware Overview 1.6 Batteries 1 - 22 T ec ra A3/S2 Series Maintenance Manual NOTES 1. The time required fo r normal charge is affected by the amount of power the system is consuming. Use of the fluorescent lamp and frequent disk access diverts power and lengthens the charge time. 2. Using quick charge, the power supply microprocessor automatica[...]

[CON FIDENTIAL] Chapter 2 Troubleshooting Procedures 2[...]

2 Troubleshooting Procedures 2 - ii [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manua l Chapter 2 Contents 2.1 Troubleshooting Introduction ..................................................................................... 2 - 1 2.2 Troubleshooting Flowchart ................................................................................[...]

2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - iii Figures Figure 2 - 1 Troubleshooting flowchart (1/2) .................................................................... 2 - 3 Figure 2 - 1 Troubleshooting flowchart (2/2) .................................................................... 2 - 4 Figure[...]

[...]

2.1 Troubleshooting Introduction 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 1 2.1 Troubleshooting Introduction Chapter 2 describes how to determine if a Field Replaceable Unit (FRU) in the computer is causing the computer to malfunction. The FRUs covered are: 1. Display 6. Touch P ad 11. IEEE 1394 po[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2 - 2 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.2 Troubleshooting Flowchart If you know the location of the malfunction, turn directly to the appropriate section of this chapter. If the problem is unspecified, u se the flowchart in Figure 2 - 1 as a guide for determining [...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 3 START Connect the AC adapter to the DC-IN socket Is the DC-IN LED on? Is the Battery LED on? Turn the Power switch on Is the Power On LED on? Is the "Toshiba" logo message display? If the "password" mess[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2 - 4 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual A Does typed characters appear correctly? Insert the diagnostics disk into the FDD. Then run the diagnostics test program. Is the diagnostics test loaded? Allow each test to perform automatically Is an error detected by any of[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 5 If the diagnostics program cannot detect an error, the problem may be intermittent. The t est program should be executed several times to isolate the problem. When a problem has been locate d, perform the appropriate troubl[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2 - 6 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual Other problems that are not covered by the diagnostics program may be discovered by a user. 1. If an error is detected when using an external USB device , perform the External USB Devices Troubleshooting p rocedures in Section[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 7 2.3 Power Supply Troubleshooting ST AR T Are the DC-IN and Battery LEDs lit? Can you turn the computer on? Are the internal power connections secure? END Check Power Supply Status (Procedure 1) No Yes Check power supply con[...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2 - 8 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual The power supply controls many functions and components. To determine if the power supply is functioning properly, start with Procedure 1 and continue with the other Procedures as instructed. The flowchart in Figure 2 - 2 give[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 9 Table 2 - 2 DC - IN LED AC - IN LED Power supply status Solid on AC power exists (LED is solid green). Off No AC power exists. To check t he power supply status, install a battery pack and connect an AC adaptor to the DC - [...]

2 Troubleshooting Procedures 2.2 Troubleshooting Flowchart 2 - 10 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual Procedure 3 Power sup ply connection check The power supply wiring diagram is shown below: AC adaptor System board Battery AC adaptor cord AC power cord Any of the connectors may be disconnected. Perform Check 1. Check 1 Disc[...]

2.3 Power Supply Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 11 Procedure 4 Diagnostic check The power supply may not charge the battery pack. Perform the following procedures: 1. Reinstall the battery pack. 2. Attach the AC adaptor and turn on the power. If you cannot turn on the powe[...]

2 Troubleshooting Procedures 2.4 Display Troubleshooting 2 - 12 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.4 Display Troubleshooting Perform external display check (Procedure 1) START Does the external display function ok? Perform diagnostic check (Procedure 2) No Was a display problem detected? Perform connector and replacement c[...]

2.4 Display Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 13 This section describes how to determine if the computer’s display is functioning properly. The process is out lined in Figure 2 - 3. Start with Procedure 1 and continue with the other procedures as instructed. Procedure 1: Ex[...]

2 Troubleshooting Procedures 2.4 Display Troubleshooting 2 - 14 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual Procedure 3 Connector and replacement check The FL inverter board, LCD module, and system board are connected to the display circuits. Any of these components may be damaged. Refer to Chapter 4, Replacement Procedur es, for ins[...]

2.5 Keyboard Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 15 2.5 Keyboard Troubleshooting Perform external keyboard check (Procedure 1) START Does the external keyboard function ok? Perform diagnostic check (Procedure 2) Was a keyboard problem detected? Perform connector and replacement[...]

2 Troubleshooting Procedures 2.5 Keyboard Troubleshooting 2 - 16 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual To determine if the computer’s keyboard is functioning properly, perform the following procedures. Figure 2 - 5 outlines the process. Start with Procedure 1 and continue with the other procedures as instructed. Procedure 1: [...]

2.6 External USB Devices Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 17 2.6 External USB Devices Troubleshooting Replace system board (Procedure 2) END Original USB device is faulty Perform external device and connection check (Procedure 1) START Does the device function when connected[...]

2.6 External USB Devices Troubleshooti ng 2 Troubleshooting Procedures 2 - 18 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual To determine if the computer’s external USB devices are functioning properly, perform the following procedures. Figure 2 - 6 outlines the process. Start with Procedure 1 and continue as instructed. Procedure 1: [...]

2.7 TV - Out Failure Troubleshooting 2 Troubleshoo ting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 19 2.7 TV - Out Failure Tro ubleshooting Perform TV connection check (Procedure 1) START Does replacement TV cable function properly? Perform TV set check (Procedure 2) Replace system board END No Replace TV cable No TV [...]

2 Troubleshooting Procedures 2.7 TV - Out Failure Troubleshooting 2 - 20 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual To determine if the computer’s TV - out port is functioning properly, perform the following procedures. Figure 2 - 7 outlines the process. Start with Procedure 1 and continue as instructed. Procedure 1: TV connection[...]

2.8 Touch Pad Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 21 2.8 Touch P ad Troubleshooting ST AR T END TouchPad connection check (Procedure 1) TouchPad replacement check (Procedure 2) Replace system board Figure 2 - 7 TouchPad troubleshooting process[...]

2 Troubleshooting Procedures 2.8 TouchPad Troubleshooting 2 - 22 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual To determine if the computer’s built - in TouchPad is functioning properly, perform the following procedures. Figure 2 - 9 outl ines the process. Start with Procedure 1 and continue as instructed. Procedure 1: TouchPad conne[...]

2.9 Speaker Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 23 2.9 Speaker Troubleshooting ST AR T Do all sources have same problem? END Perform earphone test (Procedure 2) Do earphones function correctly? Perform connection check (Procedure 3) Perform replacement check (Procedure 4) Perfo[...]

2 Troubleshooting Procedures 2.9 Speaker Troubleshooting 2 - 24 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual To determine if the computer’s built - in speakers are functioning properly, perform the following procedures. Figure 2 - 10 outlines the process. First adjust the speaker volume to an appropriate level. Start with Procedure [...]

2.10 Optical Drive Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 27 2.10 O ptical Drive Troubleshooting ST AR T Audio CD functions ok? END Perform software check (Procedure 3) Perform diagnostic test (Procedure 4) Perform connection and replacement check (Procedure 5) Perform audio CD ch[...]

2 Troubleshooting Procedures 2.10 Optical Drive Troubleshooting 2 - 28 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual This section describes how to determine if the computer’s internal optical drive is functioning properly. The Satellite P10 module bays can accommod ate the following optical drives : ? DVD - R/RW device ? DVD - ROM de[...]

2.10 Optical Drive Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 29 P rocedure 5 Connect ion c heck and r eplacement c heck The optical drive connects to the system board . The drive may be disconnected, or the drive or system board may be damaged. Disassemble the computer following the [...]

2 Troubleshooting Procedures 2.11 Modem Troubleshooting 2 - 30 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.11 M odem Troubleshooting ST AR T Computer unable to detect telephone signal? END Perform connection check (Procedure 2) Perform replacement check (Procedure 3) Perform telephone line connection check (Procedure 1) Check / rep[...]

2.11 Modem Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 31 This section describes how to determine if the computer's modem is functioning properly. Figure 2 - 12 outlines the process. Perform the steps bel ow starting with Procedure 1 and continuing with the other procedures as req[...]

2 Troubleshooting Procedures 2.12 PCMCIA Troubleshooting 2 - 32 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.12 PCMCIA Troubleshooting ST AR T Do errors occur during SYCARD test? Perform PCMCIA socket replacement check (Procedure 2) R eplac e system board END PCMCIA unit is not faulty. Perform SYCARD test (Procedure 1) No Yes Figure[...]

2.12 PCMCIA Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 33 This section describes how to determine if the PCMCIA card player is functioning properly. The process is summarized in Figure 2 - 13. P erform the steps below starting with Procedure 1 and continuing with the other procedures [...]

2 T roubleshooting Procedures 2.13 IEEE 1394 Troubleshooting 2 - 34 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.13 I EEE 1394 Troubleshooting START Perform IEEE 1394 device check (Procedure 1) Is IEEE 1394 transmission ok? Perform diagnostic check (Procedure 2) Was an IEEE 1394 problem detected? Perform connection and replacement c[...]

2.13 IEEE 1394 Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 35 To determine if the computer ’ s IEEE 1394 system is functioni ng properly, perform the following procedures. Figure 2 - 14 outlines the process. Start with Procedure 1 and continue with the other procedures as instructed.[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2 - 12 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.14 Wireless LAN Troubleshoot ing START Perform diagnostic test (Procedure 1) Was a wireless LAN problem delected? Perform connector and replacement check (Procedure 2) Replace wireless LAN antenna/unit Replace system bo[...]

2.1 4 Wireless LAN Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 13 The wireless LAN a ntenna wire, w ireless LAN unit or system board may each be the source of a wireless LAN fault. Any of these components may be damage d . To determine if the computer’s wireless LAN system is functio[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2 - 14 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.15 Express Card Troubleshooting ST AR T Do errors occur during Express CARD test? Perform Express card socket replacement check (Procedure 2) R eplac e system board END Express unit is not faulty. Perform Express CARD t[...]

2.1 4 Wireless LAN Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 15 This section describes how to determine if the Express card player is functioning properly. The process i s summa rized in Figure 2 - 14. Perform the steps below starting with Procedure 1 and continuing with the other pr[...]

2 Troubleshooting Procedures 2.14 Wireless LAN Troubleshooting 2 - 16 [CONFIDENTIAL] Satellite M60/M65 Series Maintenance Manual 2.12 Bluetooth Troubleshooting START Preform diagnostic test (Procedure 1) Was a Bluetooth problem detect? Bluetooth is not faulty. Continue troubleshooting-refer to Figure 2.1 Replace system board Perform connector and r[...]

2.1 4 Wireless LAN Troubleshooting 2 Troubleshooting Procedures Satellite M60/M65 Series Maintenance Manual [CONFIDENTIAL] 2 - 17 The Bluetooth a ntenna wire, Bluetooth module or system board may be the reason of a Bluetooth fault. Any of these components may be damage d . To determine if the computer’s Bluetooth is functioning properly, perform [...]

[CONFIDENTIAL] Chapter 3 Test and Diagnostic Operation Handbook Version 1.0 May . 20 2005 released[...]

Test and Diagnostic Operation ii [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook Contents 1. The Diagnostic Test ......................................................................................................... 1 2. Executing the Diagnostic Test .............................................................................[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 1 1. The Diagnostic Test This chapter explains how to use the Test & Diagnostic program ( based on Charlotte10 T&D Version: 1.0 ) to test the functions of the computer’s hard ware modules. The Test & Diagnostic Program is stored on the T&a[...]

Test and Diagnostic Operation 2 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook The following sections explain how to execute the Test & Diagnostic Progra m and detail the tests within the program. 2. Executing the Diagnostic Test Toshiba MS - DOS is required to run the DIAGNOSTICS PROGRAM. To start the DIAGNOSTIC PROGRAM, fo[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 3 If the test result passes, the following display will show up:[...]

Tests and Diagnostics Operation 4 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook If an error is detected and a test fails, the following message displays: Then press any key for next actions – the below display presented if copying test log file onto diskette is necessa ry. This action will be executed when “ Y ” key press[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 5 It will skip this process if “ N ” key pressed. And then it will check if it’s necessary to leave this program. Program will quit when “ Y ” key pressed and it will go back main menu for next te st if “ N ” key pressed.[...]

Tests and Diagnostics Operation 6 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook NOTE : Press Pause to pause a test and Enter to resume.[...]

3.3 Parallel Port Test 3 Tests and Diagno stics Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 7 2.1. Config Check Test The config check test checks unit configuration. It includes: ? CPU type (P4/CEL; Dothan; Cache ; CPU speed ;CPU FSB) ? System memory size (*** MB) ? ODD ty pe ( DVD - SuperMulti ; COMBO; … ) ? LCD Type (AU&a[...]

Test and Diagnostic Operation 8 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

3.13 IEEE 1394 P ort T est 3 Tests and Diagnostics Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 9 2.2. DMI Check Test This test will check if the computer’s Desktop Management Interface (DMI) is correct. DMI includes: ? Manufa cturer ? Production Name ? Version ? Serial Number ? UUID ? OEM String It needs to input unit Part [...]

Test and Diagnostic Operation 10 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2.3. Speaker Audio Test The speaker audio test allows the user to aurally confirm the speaker functions. And check both speakers if they are OK w ithin 3 times “Beep” sound generated. NOTE : Remember to tune up the volume as “ Maximum ” befor[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 11 2.4. Fan ON/OFF Test The fan t est allows the user to test aurally whether the fan is working. And follow the below procedures for this test: ? The computer will let the fan be “ON” after any key pressed. Listen to c heck whether the fan is worki[...]

Test and Diagnostic Operation 12 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2.5. Main Battery Charge Test NOTE : The AC adaptor ( 75 W, 19V ) should be connected to successfully run this test. This test shows and measures the main battery: ? Battery type ( Lion) ? Manufacturer (Sanyo) ? Remain charge capacity (0 ~ 100%) ? Ch[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 13 2.6. FDD Test NOTE : Before running the FDD test, pre pare a formatted work diskette (1.44 MB). Remove the diagnostics diskette and insert the work diskette into the FDD. The contents of the floppy diskette maybe erased. The Floppy Disk Test includes[...]

3 Tests and Diagnostics 3.5 Floppy Disk Test 14 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook[...]

3.6 Audio Test 3 Tests and Diagnostics Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 15 2. 7. CD - ROM Test The CD - ROM test allows a user to aurally confirm the CD - ROM functions. NOTE : A CD disc (in cluding data file) must be inserted into the CD - ROM drive before this test starts. The CD - ROM test includes two subtests [...]

Test and Diagnostic Operation 16 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 8. Keyboard Test The keyboard test checks the all keys function. NOTE: The Num Lock and the Overlay mode must be off to execute the keyboard test. When you execute this test, the keyboard layout is drawn on the display. When any key is pressed, th[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 17 Pressing a key also reveals that key’s scan codes in the upper right hand corner of the screen. When the key is depressed, its make code is disp layed. When the key is released, the break code is shown.[...]

Test and Diagnostic Operation 18 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 9. Mouse (Pad) Test The Mouse test allows the user to select and assign values to the following, using the Touch Pad or “ Tab ” key to move between selections: 1. Mouse Speed (on a scale from slow to fast) 2. Acceleration (Off, Low, Medium, Hi[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 19 After checking T/Pad buttons and cursor’s function, use “Tab” k ey or use T/Pad cursor to click the “OK” column will end this test. It will indicate whether the subtests pass or fail after three questions. NOTE: The above figure has three c[...]

3 Tests and Diagnostics 3.7 Battery Test 20 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 10. LCD Pixels Mode Test This LCD pixels mode test checks whether video display is fine. This test includes two modes of the test: 1. Text Mode - including 40*25 (16 colors) and 80*25 (2/16colors). 2. VGA Mode - including 320*200 (4/16/[...]

3.8 Display Test 3 Tests and Diagnostics Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 21 2. 11. Lid Switch Test The lid switch test checks the lid function of the unit. When LCD cover closed, the lid should enable to turn off the display. NOTE : Remember to tune up the volume as “ Maximum ” before th is test starts. Follow[...]

Test and Diagnostic Operation 22 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 12. HDD R/W Test The HDD R/W test allows the use r to test aurally HDD read/write function. For data security concern, it is necessary to input password - “ hard disk ” before HDD write test starts. The HDD test includes three subtests of the:[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 23 NOTE : Press “ Ctrl + Break ” keys can terminate the current subtest. The screen should display as previous picture, indicating whether the subtest is passed or failed when finished. NOTE : The AC adaptor should be connected to successfully run t[...]

Test and Diagnostic Operation 24 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 13. LAN Test The LAN test checks the LAN full - duplex environment. NOTE: LAN loopback needs to plug in before test begins. And LAN information will show on the test screen: ? IO Base – Po rt: 3000H ? IRQ – AH, it’s “IRQ 10”. ? Node – [...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 25 The screen should display as below, indicating whether the subtests pass or fail when finished.[...]

3 Tests and Diagnostics 3.13 System Running Test 26 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 14. RTC Test Checks the computer’s RTC (Real Time Clock) and calendar functions by comparing the DOS and CMOS values. The test runs automaticall y. The screen should display as below, indicating whether the test is passed or f[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 27 .2. 15. CD Control Button Test The CD control button test allows the user to manually test each of the five CD control buttons and one Internet butt on . Key ” WWW” need to press first. One will hear one “ bi ” sound when press ” WWW” or [...]

3 Tests and Diagnostics 3.13 System Running Test 28 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 16. Spea ker EQ Type Check&Re - Write This test will check if the computer’s EEPROM EQ type is correct. The EQ Type test includes two subtests of the: 1. Read EQ Type from EEPROM 2. Re - Write EQ Type to EEPROM NOTE : To e[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 29 The Item2 figure below will be displayed NOTE : Write speaker EQ must reboot to enable EQ.[...]

3 Tests and Diagnostics 3.13 System Running Test 30 [CONFIDENTIAL] Satellite M60/M65 Series T&D Operation Handbook 2. 17. Read 1394 GUID This test will check if the computer’s EEPROM 1394GUID cod e is correct. NOTE: Must open the RAM Door to see RAM connector GUID bar code before test item begins. The figure below will be displayed[...]

Test and Diagnostic Operation Satellite M60/M65 Series T&D Operation Handbook [CONFIDENTIAL] 31[...]

[CONFIDENTIAL] 4 Chapter 4 Replacement Procedures[...]

4 Replacement Procedures 4 - ii [CONFIDENTIAL] Satellite M60 Series Maintenance Manual[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - iii Chapter 4 Contents 4.1 General ........................................................................................................................ 4 - 5 4.2 Battery ............................................................................................[...]

4 Replacement Procedures 4 - iv [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Figures Figure 4 - 1 Removing the battery pack ................................................................................... 4 - 12 Figure 4 - 2 Pressing the eject button ......................................................................................[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 5 4.1 General This chapter explains how to disassemble the computer and replace Field Replaceable Units (FRUs). It may not be necessary to remove all the FRUs in order to replace one. The chart below is a guide to which FRUs need to be removed in order to remove oth[...]

4 Replacement Procedures 4 - 6 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual The example below shows FRUs to be removed before the Direct Play button board can be removed and repaired or replaced. The Direct Play button board is overlapped by the top cover which must be removed before the Direct Play button board can be reached. The remova[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 7 Safety Precautions Before you begin disassembly, read the following safety precautions and observe them carefully as you work. DANGER: 1. Always use the lithium ion battery pack or backup battery that is authorized by Toshiba or compatible with the unit. Since oth[...]

4 Replacement Procedures 4 - 8 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual recommended by Toshiba.[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 9 Before You Begin Look over the procedures in this section before you begin disassembling the computer. Fa miliarize yourself with the disassembly and reassembly steps. Begin each procedure by removing the AC adaptor and the battery pack as instructed in section 4.[...]

4 Replacement Procedures 4 - 10 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Disassembly Proc edures The computer has two basic types of cable connectors: ? Pressure Plate Connectors ? Standard Pin Connectors To disconnect a Pressure Plate connector, lift up the tabs on either side of the connector’s plastic pressure plate and slide the[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 11 Tools and Equipment The use of Electrostatic Discharge (ESD) equipment is very important for your safety and the safety of those around you. Proper use of these devices will increase the success rate of your repairs and lower the cost for damaged or destroyed par[...]

4 Replacement Procedures 4 - 12 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.2 Battery Removing the Battery Pack To remove the battery pack from the battery bay , follow the steps below . 1. Turn the computer upside down . 2. Unlock the battery double lock and s lide the battery bay latch to release the battery pack . Then yo u can remo[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 13 Installing the Battery Pack To install the battery pack in the battery bay , follow the steps below and refer to the figure in the preceding section . WARNING: The battery is a lithium ion battery and can explode if not properly replaced, used, handled or dispose[...]

4 Replacement Procedures 4 - 14 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.3 PC Card Removing a PC Card To remove a PC Card, follow the steps below. 1. Click the Safely Remove Hardware icon on the Task Bar. 2. Click the PC Card you want to r emove. 3. Press the eject button of the PC Card to extend it. 4. Press the extended eject butt[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 15 Installing the PC Card To install the PC Card, follow the steps below and refer to the f igures in the preceding section . 1. Insert the PC Card. 2. Press gently to ensure a firm connection. Figure 4 - 3 Installing the PC card[...]

4 Replacement Procedures 4 - 16 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.4 HDD CAUTION : When handling the HDD, do not press the top surface as shown by the arrow. Hold it by th e sides. Figure 4 - 4 HDD Removing the HDD Module F ollow the steps below to remove HDD module: 1. Turn the computer upside down 2. Remove two black M2.5x 4[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 17 Figure 4 - 5 Removing the HDD door 4. Remove four M3x3 silver screws that secure the HDD case and bracket to the HDD. 5. Remove the HDD from the HDD case.[...]

4 Replacement Procedures 4 - 18 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the HDD To install the HDD, follow the steps below and refer to the f igures in the preceding section . 1. Seat the HDD in the HDD case and bracke t , and secure it with two M 3 ? 3 black screws . 2. Insert the HDD unit in to the HDD slot . 3. Secure t[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 19 4.5 Optical Drive Module Removing the Optical Drive Module To remove the optical drive module, you need to remove th e keyboard first. Follow the steps below: 1. Turn the computer upside down. 2. Remove the screw M2.5x 4 securing the optical drive module. 3. Use [...]

4 Replacement Procedures 4 - 20 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Insta lling the Optical Drive Module To install a device in the optical drive module bay , follow the steps below and refer to the figure in the preceding section . 1. Slide the device into the optical drive module bay. 2. Use the screw M2.5x 4 to secure the opti[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 21 4.6 Optical Drive This computer may be fitted with a : CD - RW/DVD - ROM device DVD dual device DVD Super Multi device Disassembling the Optical Drive To disassemble the optical drive, first remove the drive from its module bay, then follow the steps below. 1. Re[...]

4 Replacement Procedures 4 - 22 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Reassembling the Optical Drive To reassemble a n optical drive, follow the steps below and refer to the figure in the preceding section . 1. Position the optical drive bracket plate to the rear panel of optical drive. 2. Secure the optical drive bracket plate wit[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 23 4.7 Keyboard Removing the Keyboard Follow the steps below to remove the keyboard: 1. Open the display panel. 2. Insert a thin tool into the gap between the strip cover and keyboard to lever the strip cover up and then release the strip cover. Figure 4 - 8 Removin[...]

4 Replacement Procedures 4 - 24 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 3. Remove four M2.5 x 3 blac k screws securing the keyboard . Push the center of the strip cover and lift the keyboard out and place over the display hinges, revealing the keyboard cable. (Note: There are 6 screw holes, but only 4 are used.) Figure 4 - 9 Removing[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 25 4. Disconnect the key board cable and remove the keyboard. Figure 4 - 10 Disconnecting the keyboard cable Installing the Keyboard To install the keyboard, follow the steps below and refer to the f igures in the preceding section . 1. Connect the keyboard cable to[...]

4 Replacement Procedures 4 - 26 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.8 Wireless LAN Unit Removing the Wireless LAN Unit To remove wireless LAN unit, you must remove strip cover and keyboa rd first, then follow the steps below to remove wireless LAN unit. 1. Remove the embedded M2.5x4 screw securing the wireless LAN door, and the[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 27 Figure 4 - 12 Removing the wireless LAN unit CAUTION : Do not touch the connec tors on the wireless LAN unit or on the computer. Debris on the connectors may cause malfunction. Installing the Wireless LAN Unit To install the wireless LAN unit, follow the steps be[...]

4 Replacement Procedures 4 - 28 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.9 Expansion Memory Removing the Expansion Memory To remove the memory module, make sure the computer is in boot mode then remove the wireless LAN compartment cover: 1. Push the latches securin g the memory module to the outside to release it. A spring will forc[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 29 Installing the Expansion Memory CAUTION : Do not touch the connectors on the expansion memory or on the computer. Debris on the connectors may cause memory access problems . To install a memory module, follow the steps below and refer to the f igures in the prece[...]

4 Replacement Procedures 4 - 30 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.10 Modem Removing the Modem To remove the installed modem, first remove the wireless LAN compartment cover, then follow t he steps below: 1. Remove two M2x3 screws securing the modem module. 2. Carefully lift the unit off its connector 3. Disconnect the modem c[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 31 Installing the Modem To install a modem , follow the steps below and r efer to the f igures in the preceding section . 1. Connect the modem cable to the modem module. 2. Fit the modem onto its connector and secure it with two black M2x3 screws.[...]

4 Replacement Procedures 4 - 32 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.11 Display Assembly Removing the Display Assembly To remove the display assembly, first remo ve the keyboard and wireless LAN, then follow the steps below: 1. Disconnect the LCD power cable from the top chassis. Figure 4 - 16 Disconnecting the LCD cable 2. From[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 33 Figure 4 - 17 Removing the display assembly[...]

4 Replacement Procedures 4 - 34 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the Display Assembly To install the display assembly, follow the steps below and refer to the figures in the preceding section. 1. Seat the display assembly taking care not to crush to the LCD display cab le , the LCD power cable, or wireless LAN anten[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 35 4.12 Top Cover Removing the Cover To remove the top cov er, first remove the battery pack, keyboard, display assembly, optical drive module, HDD, and memory module and wireless LAN as described in the preceding sections, then follow the steps below: 1. Remove thr[...]

4 Replacement Procedures 4 - 36 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Figure 4 - 19 Removing the top cover - 2 4. Turn the computer upright to lift off the top cover.[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 37 Instal ling the Top Cover To install the top cover, follow the steps below and refer to the f igures in the preceding section. 1. Seat the top cover and secure the upper FFC cable and Touch pad FFC cable to the computer’s top chassis. 2. Secure the top cover wi[...]

4 Replacement Procedures 4 - 38 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.13 TouchPad Removing the TouchPad To remove the TouchPad, first remove the top cover, then follow the steps below: 1. Disconnect the TouchPad FFC cable from t he TouchPad. 2. Remove two M2.5x3 black screws securing the control button board. Slide it and l ift i[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 39 Installing the TouchPad T o install the TouchPad, follow the steps below and refer to the figures in the preceding section: 1. With the top cover upside down, place the TouchPad, the Track Pad Bracket, and control button board in position. 2. Secure the Track Pad[...]

4 Replacement Procedures 4 - 40 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.14 Speakers Removing the Speakers To remove the speakers, first remove the top cover, then follow the steps below: 1. Remove the four M2.5 x 4 screws . 2. D isconnect the speaker cable from the system board . Figure 4 - 21 Removing the speakers 3. Lift out the [...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 41 3. Attach the speaker cable to the system board.[...]

4 Replacement Procedures 4 - 42 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.15 System Board Removing the System Board To remove the system board, first remove the LCD assembly, top cover and HDD, then follow the steps below: 1. Remove two M2.5x4 sc rews from the system board . Figure 4 - 22 Removing the system bo a rd 2. Remove two hex[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 43 Installing the System Board To install the system board, follow the steps below and refer t o the figures in the preceding section. 1. Seat the system board in the chassis. 2. Secure two hexagonal screws to the back of the system board. 3. Secure two M2.5x4 screw[...]

4 Replacement Procedures 4 - 44 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.16 Fan & CPU Removing the Fan & CPU To remove the Fan, Heat Sink, and CPU , you must first remove the panel, keyboard, top cover and bottom chassis to reveal the system board, then follow the steps below: 1. Remove two M2.5x4 fan screws and then lift ou[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 45 3. Turn the CPU screw cam to loosen it, then lift it out. Figure 4 - 25 Removing the CPU[...]

4 Replacement Procedures 4 - 46 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the CPU To install the CPU, follow the steps below and refer to the f igures in the preceding section . CAUTION: If you r emove the heat sink, you should use the CPU grease tool to remove the grease on the CPU and heat sink. Reapply fresh grease before[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 47 4.17 Display Mask Removing the Display Mask To remove the display mask, first remove the display assembly as described earlier, then follow the steps below: 1. Remove the mask seals to expose four low er inner corner screws securing the display mask . 2. Remove f[...]

4 Replacement Procedures 4 - 48 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual Installing the Display Mask To install the display mask, follow the steps below and refer to the f igures in the preceding section . 1. Seat the display mask and secure the snaps on each side. 2. Secure the display mask with four M2.5x 4 screws at the bottom inne[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 49 4.18 LCD Module Removing the LCD Module To remove the LCD module, first remove the display assembly and display mask, then follow the steps below . 1. Remove two M2x3 black screws securing the LCD cable and FL inverter board. 2. Disconnect the LCD cable from the [...]

4 Replacement Procedures 4 - 50 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 5. Remove six M2x3 screws securing LCD module bracket to LCD module. Remove LCD cable. NOTE : If the LCD module malfunctions, remove the LCD cable and LCD bracket . Then replace the whole LCD module unit.[...]

4 Replacement Procedures Satellite M60 Series Maintenance Manual [CONFIDENTIAL] 4 - 51 Installing the LCD Module To install the LCD module, follow the steps below and refer to the f igures in the preceding section . 1. Set the LCD module in the display assembly . 2. Connect the FL cable and the HV cable to the FL inverter board . 3. Se at the LCD m[...]

4 Replacement Procedures 4 - 52 [CONFIDENTIAL] Satellite M60 Series Maintenance Manual 4.19 FL Inverter Board Removing the FL Inverter Board To remove the FL inverter board, first remove the battery pack, the display assembly, display mask, and LCD module, then follow the steps below . 1. Remove one M2x3 black screw securing the FL invert bo ard to[...]

Satellite M 4 0X Series Maintenance Manual [CONFIDENTIAL] A - 1 Appendix A Appendix A Handling the LCD Module Precautions for handling the LCD module The LCD module can be easily damaged during assembly or disassembly. Therefore, p lease observe the following precautions when handling it: 1. When installing the LCD module in the LC D cover, be sure[...]

A - 2 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual 3. If the panel’s surface gets dirty, wipe it with cotton or a soft cloth. If it is still dirty, try breathing on the surface to create a light condensate and wipe it again. If the surface is very dirty, we recommend a CRT cleaning agent. Apply th e agent to a cloth and then wipe the[...]

Satellite M 4 0X Series Maintenance Manual A - 3 5. Glass is used in the panel, so be careful not to drop it or let it strike a hard object, which could cause breakage or cracks. 6. CMOS - LSI circuits are used in the module, so guard against damage from electrostatic discharge. Be sure to wear a wrist or ankle ground when handling the module.[...]

A - 4 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual 7. Do not expose the mod ule to direct sunlight or strong ultraviolet rays for long periods. 8. Do not store the module at temperatures below specifications. Cold can cause the liquid crystals to freeze, lose their elasticity or otherw ise suffer damage. 9. Do not disassemble the LCD m[...]

Satellite M 4 0X Series Maintenance Manual A - 5 10. If you transport the module, do not use packing material that contai ns epoxy resin (amine) or silicon glue (alcohol or oxime). These materials can release gas that can damage the panel’s polarization.[...]

A - 6 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual[...]

Satel lite M 4 0X Series Maintenance Manual [CONFIDENTIAL] B - 1 Appendix B Appendix B Board Layout B.1 System Board (FRDSY*) T OP View A B JP4 JP2 J P8 J P5 PJP2 J P 9 JP 1 C JP 3 I[...]

B - 2 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual B.2 System Board (FRDSY*) B UTTOM View F J P 30 JP 23 JP 26 H JP 13 JP 19 JP 32 E JP 31 JP 15 J P20 JP2 4 D P JP1 G JP 14 JP 16 J P27 JP 18 JP 22[...]

Satellite M 4 0X Series Maintenance Manual [CONFIDENTIAL] B - 3 Table B - 1 System board ICs ( top and bottom ) Mark Number Name A U 4 1394 T SB 4 3AB21 B U 7 Marrell 8036 C U 18 Intel ICH6 D U 34 I ntel 915PM E U 32 L AN CHIP F U 38 I CS95226 G U 40 K b 910 H U 43 AC97 CODEC ALC250 - VD I U21 ENE 714[...]

B - 4 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual Table B - 2 System board connectors ( top and bottom ) Number Name JP 1 L VDS Connector JP 2 P OWER/B Connector JP 3 F AN Connector JP 4 T /P Connector JP 5 K B Connector JP 8 N EWCARD Connector JP 9 A UDIO Connector JP 10 HDD Connector JP 13 C RT Connector JP 14 T v - out Connector JP[...]

Satellite M 4 0X Series Maintenance Manual [CONFIDENTIAL] B - 5[...]

Satellite M 60 Series Maintenance Manual [CONFIDENTIAL] C - 1 C. Appendix C Pin Assignments System Board C.1 JP 23, JP26 Table C - 1 SODIMM I/F pin assignments ( 200 - PIN ) (1/4) Pin No. Signal name I/O Pin No. Signal Name I/O 1 VREF O 2 GND O 3 GND O 4 DDRA_S DQ 4 I/O 5 DDR A_SDQ0 I/O 6 DDRA_S DQ 2 I/O 7 DDR A_SDQ1 I/O 8 GND O 9 GND O 10 DDRA_S D[...]

C - 2 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual Table C - 1 SODIMM I/F pin assignments ( 200 - PIN ) (2/4) Pin No. Signal name I/O Pin No. Signal Name I/O 51 DDR A _ S DQ S2 I/O 52 DDRA_S D M2 I/O 53 GND O 54 GND O 55 DDRA_SDQ18 I/O 56 DDRA_S DQ 22 I/O 57 DDR A _ S DQ 19 I/O 58 DDRA_S DQ 23 I/O 59 GND O 60 GND O 61 DDRA_S DQ 24 I/O 6[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 3 Table C - 1 SODIMM I/F pin assignments ( 200 - PIN ) (3/4) Pin No. Signal name I/O Pin No. Signal Name I/O 115 DDRA_S CS#1 I/O 116 DDRA_S MA13 I/O 117 +1.8V O 118 +1.8V O 119 DDRA_ ODT1 I/O 120 NC - 121 GND O 122 GND O 123 DDRA_S DQ 32 I/O 124 DDRA_S DQ 36 I/O 125 DDRA_S DQ 33 I/O 126 DD[...]

C - 4 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual Table C - 1 SODIMM I/F pin assignments ( 200 - PIN ) (4/4) Pin No. Signal name I/O Pin No. Signal Name I/O 181 DDRA_S DQ 57 I/O 182 DDRA_S DQ 61 I/O 183 GND O 184 GND O 185 DDRA_S D M7 I/O 186 DDRA_S DQ S7 # I/O 187 G ND O 188 DDRA_S DQ S7 I/O 189 DDRA_SDQ58 I/O 190 GND O 191 DDRA_S DQ [...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 5 C.2 JP 13 Table C - 3 RGB I/F pin assignments ( 15 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 CRT _R _L O 2 CRT _G _L O 3 CRT _B _L O 4 GND - 5 GND - 6 GND - 7 GND - 8 GND - 9 +CRT_ VCC - 10 GND - 11 NC - 12 DSUB_12 I/O 13 HSYNC _L O 14 VSYNC _L O 15 DSUB_15 I/ O[...]

C - 6 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual C.3 JP 24 Table C - 4 HDD I/F pin assignments ( 44 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 PIDE_HRESET# O 2 GND - 3 PIDE_HDD7 I/O 4 PIDE_HDD8 I/O 5 PIDE_HDD6 I/O 6 PIDE_HDD9 I/O 7 PIDE_HDD5 I/O 8 PIDE_HDD10 I/O 9 PIDE_HDD4 I/O 10 PIDE_ HDD11 I/O 11 PIDE_HDD3 I/O 12 PIDE[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 7 C.4 JP 27 Table C - 5 ODD I/F p in assignments ( 52 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 INT _ CD _L I 2 INT _ CD _ R I 3 CD_ AGND - 4 GND - 5 SIDE_RST# O 6 S D_D 8 I/O 7 S D_D 7 I/O 8 S D_D 9 I/O 9 S D_D 6 I/O 10 S D_D 10 I/O 11 S D_D 5 I/O 12 S D_D 11 I/O 13 S D_D 4[...]

C - 8 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual C.5 JP 12 Table C - 7 PC Card I/F pin assignments ( 84 - pin) (1/ 2 ) Pin No. Signal name I/O Pin No. Signal Name I/O 1 GND - 2 S1_D3 - 3 S1_D4 I/O 4 S1_D5 O 5 S1_D6 I/O 6 S1_D7 I/O 7 S1_CE1# I/O 8 S1_A10 I/O 9 S1_OE# I/O 10 S1_A11 I/O 11 S1_A9 I/O 12 S1_A8 I/O 13 S1_A13 I/O 14 S1_A14 I[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 9 Table C - 7 PC Card I/F pin assignments ( 84 - pin) (2/ 2 ) Pin No. Signal name I/O Pin No. Signal Name I/O 61 S1_REG# I/O 62 S1_BVD2 I/O 63 S1_BVD1 I/O 64 S1_D8 I/O 65 S1_D9 I/O 66 S1_D10 I 67 S1_CD 2# - 68 GND -[...]

C - 10 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual C.6 JP 30 Table C - 8 Mini PCI I/F pin assignments (124 - pin) (1/2) Pin No. Signal name I/O Pin No. Signal Name I/O 1 NC - 2 NC - 3 NC - 4 NC - 5 NC - 6 NC - 7 NC - 8 NC - 9 NC - 10 NC - 11 NC - 12 NC - 13 SWITCH O 14 NC - 15 NC - 16 NC - 17 PCI_PIRQH# I 18 +5VS - 19 +3VS O 20 PCI_PIR[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 11 Table C - 8 Mini PCI I/F pin assignments (124 - pin)(2/2) Pin No. Signal name I/O Pin No. Signal Name I/O 61 IRDY # I/O 62 GND - 63 + 3.3V O 64 FRAME # I/O 65 PM_ CLKRUN # I/O 66 TRDY # I/O 67 PCI_ SERR # I /O 68 STOP # I/O 69 GND - 70 + 3.3V O 71 PCI_PERR# O 72 DEVSEL # I/O 73 C / BE1 [...]

C - 12 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual C. 7 JP 1 Table C - 9 LVDS I/F pin assignments ( 30 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 B+ - 2 B + - 3 NC - 4 +3VS - 5 LCD_ CLK - 6 LCD_DATA - 7 GND - 8 TZOUT0 - - 2 9 TZOYT0+ - 10 GND - 11 T Z OUT 1+ - 12 T ZOUT1 - - 13 GND O 14 TZOUT2+ - 15 TZOUT2 - - 16 GND - 17[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 13 C. 8 JP 32 4IN1 CONN Pin No. Signal name I/ O Pin No. Signal Name I/O 1 GND 2 MSBS_XDD1 3 MSD1_XDD6 4 MSD0_XDD2 5 MSD2_XDD5 6 MSINS# 7 MSD3_XDD3 8 MSCLK_XDRE # 9 VCC 10 GND 11 SDDA2_XDCL 12 SDDA3_XDD4 13 SDCM_XDALE 14 GND 15 VCC 16 SDCK_XDWE# 17 GND 18 NC 19 SDDA0_XDD7 20 SDDA1_XDD0 21 [...]

C - 14 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual C. 9 JP 21 Table C - 9 - 1 JP 21 Fan I/F pin assignments ( 3 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 FAN 1 _VOUT I 2 FAN - SPEED1 O 3 GND - C.1 0 P JP1 Table C - 10 AC Adaptor Connector pi n assignments ( 6 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 DC_IN[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 15 13 GND - 14 GND - C.1 3 JP 16 Table C - 13 Double USB Connector pin assignments ( 12 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 +USB_VCC A I 2 USB20 _N0 I 3 5 7 9 11 USB20 _P0 +USB_VCC A USB20 _P2 GND GND I - - I - 4 6 8 10 12 GND USB20 _N2 GND GND GND - I - - I C.1 4 JP 1[...]

C - 16 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual 25 AC97_RST# O 26 AC97_SDIN1 I 27 29 GND GND - - 28 30 GND AC97_BITCLK - I C.1 6 JP 2 Table C - 16 P W/LED Connector pin assignments ( 14 - pin) Pin No. Signal name I/O P in No. Signal Name I/O 1 NC - NC MODE_LED# O 3 5 7 9 D INBTN# PWR_SUSPLED 0# MOBELLED# GND O O I I 4 6 8 10 PWR_LED[...]

Satellite M30X Series Maintenance Manual [CONFIDENTIAL] C - 17 13 15 17 19 21 23 25 KS O15 KSO 13 KS O11 KS O9 KSO 7 KS O5 KSO 4 O O O O O O O 14 16 18 20 22 24 26 KS O14 KSO 12 KS O10 KSO 8 KSO 6 KSO 2 KSO 3 O O O O O O O C. 19 JP2 2 Table C - 19 1394 Connector pin assignments ( 4 - pin) Pin No. Signal name I/O Pin No. Signal Name I/O 1 TPB0 - I /[...]

C - 18 [CONFIDENTIAL] Satellite M 60 Seri es Maintenance Manual 13 P ERST# 14 +3VS 15 +3VS 16 CLKREQ# 17 EXP_CPPE# 18 CLK_PCIE_CARD# 19 CLK_PCIE_CARD 20 GND 21 PCIE_PTX_C_IRX_N 2 22 PCIE_PTX_C_IRX_P2 23 GND 24 PCIE_ITX_C_PRX_N2 25 PCIE_ITX_C_PRX_P 2 26 GND 27 GND 28 GND C.2 2 PJP2 Table C - 22 BATT Con nector pin assignments ( 7 - pin) Pin No. Sign[...]

Satellite M 60 Series Maintenance Manual D - 1 Appendix D Appendix D Keyboard Scan/Character Codes Table D - 1 Scan codes (set 1 and set 2) (1/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 01 ‘ ~ 29 A9 0E F0 0E 02 1 ! 02 82 16 F0 16 03 2 @ 03 83 1E F0 1E 04 3 # 04 84 26 F0 26 05 4 $ 05 85 25 F0 25 06 5 % 06 86 2E F0 2E 07 6 ^[...]

D - 2 Satelli te M 60 Series Maintenance Manual Table D - 1 Scan codes (set 1 and set 2) (2/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 29 | 2B AB 5D F0 5D *5 30 Caps Lock 3A BA 58 F0 58 31 A 1E 9E 1C F0 1C 32 S 1F 9F 1B F0 1B 33 D 20 A0 23 F0 23 34 F 21 A1 2B F0 2B 35 G 22 A2 34 F0 34 36 H 23 A3 33 F0 33 37 J 24 A4 3B F0 3[...]

Satellite M 60 Series Maintenance Manual D - 3 Table D - 1 Scan codes (set 1 and set 2) (3/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 58 Ctrl (L) 1D 9D 14 F0 14 *3 60 Alt (L) 38 B8 11 F0 11 *3 61 Space 39 B9 29 F0 29 62 ALT (R) E0 38 E0 B8 E0 11 E0 F0 11 64 Ctrl(R) E0 1D E0 9D E0 14 E0 F0 14 75 Ins E0 52 E0 D2 E0 70 E0 F0 70[...]

D - 4 Satelli te M 60 Series Maintenance Manual Table D - 1 Scan codes (set 1 and set 2) (4/4) Code set 1 Code set 2 Cap No. Keytop Make Break Make Break Note 122 F11 57 D7 78 F0 78 *3 123 F12 58 D8 07 F0 07 *3 124 PrintSc *6 *6 *6 *6 *6 126 Pause *7 *7 *7 *7 *7 X Fn — — — — *4 X Win E0 5B E0 DB E0 1F E0 F0 1F x App E0 5D E0 DD E0 2F E0 F0 [...]

Satellite M 60 Series Maintenance Manual D - 5 Table D - 2 Scan codes with left Shift key Code set 1 Code set 2 Cap No. Key top Make Break Make Break 55 / E0 AA E0 35 E0 B5 E0 2A E0 F0 12 E0 4A E0 F0 4A E0 12 75 INS E0 AA E0 52 E0 D2 E0 2A E0 F0 12 E0 70 E0 F0 70 E0 12 76 DEL E0 AA E0 53 E0 D3 E0 2A E0 F0 12 E0 71 E0 F0 71 E0 12 79 ? ? E0 AA E0 4B [...]

D - 6 Satelli te M 60 Series Maintenance Manual Table D - 3 Scan codes in Numlock mode Code set 1 Code set 2 Cap No. Key top Make Break Make Bre ak 75 INS E0 2A E0 52 E0 D2 E0 AA E0 12 E0 70 E0 F0 70 E0 F0 12 76 DEL E0 2A E0 53 E0 D3 E0 AA E0 12 E0 71 E0 F0 71 E0 F0 12 79 ? ? E0 2A E0 4B E0 CB E0 AA E0 12 E0 6B E0 F0 6B E0 F0 12 80 Home E0 2A E0 47[...]

Satellite M 60 Series Maintenance Manual D - 7 Table D - 5 Scan codes in overlay mode Code set 1 Code set 2 Cap No. Keytop Make Break Make Break 09 8 (8) 48 C8 75 F0 75 10 9 (9) 49 C9 7D F0 7D 11 0 (*) 37 B7 7C F0 7C 23 U (4) 4B CB 6B F0 6B 24 I (5) 4C CC 73 F0 73 25 O (6) 4D CD 74 F0 74 26 P ( – ) 4A CA 7B F0 7B 37 J (1) 4F CF 69 F0 69 38 K (2) [...]

D - 8 Satelli te M 60 Series Maintenance Manual Table D - 7 No.126 key scan code Code set 1 Code set 2 Key top Shift Make Make Pause Common E1 1D 45 E1 9D C5 E1 14 77 E1 F0 14 F0 77 Ctrl E0 46 E0 C6 E0 7E E0 F0 7E *: This key generates only make codes.[...]

S atellite M 60 Se ries Maintenance Manual [CONFIDENTIAL] E - 1 Appendix E Appendix E Key Layout E.1 United Kingdom (UK) Keyboard Figure E - 1 UK - English_ keyboard E.2 United States (US) Keyboard Figure E - US _ keyboard[...]

E - 2 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E.3 Spanish (SP) Keyboard Figure E - 3 SP keyboard E.4 Turkish ( T R ) Keyboard Figure E - 4 TK keyboard[...]

S atellite M 60 Series Maintenance Manual [CONFIDENTIAL] E - 3 E. 5 Korean ( KO ) Keyboard Figure E - 5 KO keyboard E. 6 Canada France ( CF ) Keyboard Figure E - 6 CF keyboard[...]

E - 4 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E. 7 Portuguese (PO) Keyboard Figure E - 7 PO keyboard E. 8 US - INTE (INTE) Keyboard Figure E - 7 I ntrnational English_KB[...]

S atellite M 60 Series Maintenance Manual [CONFIDENTIAL] E - 5 E. 9 Germanic (GR) Keyb oard Figure E - 9 GR keyboard E. 10 France (FR) Keyboard Figure E - 10 FR keyboard[...]

E - 6 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E. 11 Chinese (CH) Keyboard Figure E - 1 1 CH keyboard E. 12 Swiss - Germanic (S W ) Keyboard Figure E - 1 2 Swiss - Germanic keyboard[...]

S atellite M 60 Series Maintenance Manual [CONFIDENTIAL] E - 7 E. 13 I talian (IT) Keyboard Figure E - 13 IT keyboard E. 14 B e lgiun (BE) Keyboar d Figure E - 14 BE keyboard[...]

E - 8 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E. 15 Arabic (AR - E) Keyboard Figure E - 15 AR - E keyboard E. 16 C zech (CZ) Keyboar d Figure E - 16 CZ keyboard[...]

S atellite M 60 Series Maintenance Manual [CONFIDENTIAL] E - 9 E. 17 Swedish ( SD ) Keyboard Figure E - 1 7 SWE keyboard E. 18 G ree ce (G K ) Keyboar d Figure E - 18 G R keyboard[...]

E - 10 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E. 19 H ebrew (HB) Keyboard Figure E - 19 HB keyboard E. 20 H ungary (HG) Keyboard Figure E - 20 H G Keyboard[...]

S atellite M 60 Series Maintenance Manual [CONFIDENTIAL] E - 11 E. 21 N orwegian (NW) Keyboard Figure E - 21 NW keyboard E. 22 D anish (D M ) Keyboard Figure E - 22 DN keyboard[...]

E - 12 [CONFIDENTIAL] Satellite M 60 Series Maintenance Manual E. 23 Russian (RU) Keyboard Figure E - 24 RU keyboard[...]

Satellite M40X Series Maintenance Manual [CONFIDENTIAL] F - 1 F. Appendix F Series Screw Torque List Table F - 1 Series Screw Torque List SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAC925003Z0 M2.5*3(NL)NI ( ?? ) 1 TRACK PAD BRKT TO LOGIC UP 2.0~2.5kgfcm MAC925003Z0 M2.5*3(NL)NI ( ?? ) 1 BATT LATCH TO BAT KNOB 2.0~2 .5kgfcm MAC925003Z0 M2[...]

F - 2 [CONFIDENTIAL] Satellite M40X Series Maintenance Manual SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MMCK25040Z2 M2.5*4(NL)NI 2 VGA BOARD TO M/B 2.5~3.0kgfcm MMCK25040Z2 M2.5*4(NL)NI 2 FAN TO MB 2.5~3.0kgfcm MMCK25040Z2 M2.5*4(NL)NI 4 CPU THERMAL MODULE TO MB 2.5~3.0kgfcm MMCK25040Z2 M2.5*4(NL)NI 3 VGA THERMAL MODULE TO VGA BOARD 2.5~[...]

Satellite M40X Series Maintenance Manual [CONFIDENTIAL] F - 3 SCREW P/N SCREW SPEC Q'ty LOCATION SCREW TORQUE MAAA0015320 M2*3(NL) 2 CARD BUS TO MLB 2.5~3.0kgfcm MAAA0015320 M2*3(NL ) 2 EXPRESS CARD TO MLB 2.5~3.0kgfcm MAAA0015320 M2*3(NL) 2 MDC BOARD TO MDC STANDOFF 2.5~3.0kgfcm MAAA0015320 M2*3(NL) 2 ODD brk to ODD Module 2.5~3.0kgfcm MA0000[...]

Satellite M 4 0X Series Maintenance Manual [CONFIDENTIAL] G - 1 Appendix G Appendix G Reliability The following table shows MTBF (Mean Time Between Failures) for each component. Table G - 1 MTBF Component Time (hours) LCD 50,000 Keyboard 40,000 HDD 300,000 Removable FDD 3 0,000 Optical ( DVD / CD ) drive 60 ,000 AC adaptor 60 ,00 0[...]

G - 2 [CONFIDENTIAL] Satellite M 4 0X Series Maintenance Manual[...]