United States Stove PELLET 5660(I) manuale d’uso

1  Report  #:  215 ‐ S ‐ 32 ‐ 4 and 215 ‐ S ‐ 33 ‐ 4 Installation  and  Operating  Manual  Models  5660( I )     Safety  Notice  Please  read  this  en tire  manual  before  installation  and  use  of  this  pellet  fuel ‐ bu rning  room  heater.  F[...]

2  TABLE  OF  CONTENTS  Topic   Page(s)   Introduction   3  Safety  Information     4 ‐ 5  Specifications    6  Dimensions    [...]

3  Introduction   The  entire  family  of  United  States  Stove  Company  thanks  you  for  pur chasing  your  new  pellet  burning  room  hea ter.  At  U.S.  Stove,  we  build  all  of  our  products  with  a  ha nds ‐ on  approach  to  d[...]

4  SAFETY  INFORMATION   Be  sure  to  read  the  entire  owner’s  manual  prior  to  installing  and  operating  this  Pellet  heater.  Failure  to  follow  these  instruction s  could  result  in  fire,  property  damage,  bodily  injury  or ?[...]

5  SAFETY  INFORMATION  ‐ continued   Keep  foreign  objects  out  of  the  hopper.  Contact  your  local  building  officials  to  obtain  a  permit  and  information  on  any  installation  restrictions  or  inspection  requirements  in  your  are[...]

6  SPECIFICATIONS   Heating  Specifications:   Burn  Rate:   *43,900  btu’s  per  hour  or  5.1  lbs.  of  fuel  per  hour  Hopper  Capacity:   55  lbs.   *Dependent  upon  quality  and  heating  value  of  pellet  fuel.  [...]

7  DIMENSIONS  ‐ continued  The  minimum  installation  dimensions,  of  the  insert  opening,  are:   32”  (813mm)  wide  x  22 ‐ 3/4”  (578mm)  high  x  12 ‐ 1/4”  (311mm)  deep.   Figure  2      [...]

8  OPERATING  INSTRUCTIONS  Check  and  Fill  the  Fuel  Hopper  with  Pellets:  This  Pellet  Stove  is  available  as  a  freestanding  unit  or  as  a  fireplace  insert.  There  is  a  different  method  for  filling  the  hopper  for  ea[...]

9    OPERATING  INSTRUCTIONS  ‐  continued   When  the  pellets  have  ignited  and  flame  has  been  established,  the  start ‐ up  cycle  will  end;  this  procedur e  takes  between  8  and  12  minutes.  If  the  control  is  set [...]

10  OPERATING  INSTRUCTIONS ‐ continued   Control  Board  Functions:   MODE  Button:  The  MODE  button  allows  you  to  switch  operating  mode  on  your  Pellet  Stove  Room  Heater.  Depress  the  MODE  button  to  switch  between  Manu[...]

11  OPERATING  INSTRUCTIONS  ‐  continued   the  Auger  feed  rate  will  help  keep  the  flames  from  extinguishi ng  on  the  minimum  heat  level  setting.  You  can  also  use  the  AUGER  TRIM  button  to  lower  heat  output  on [...]

12    THERMOSTAT  INSTALLATION   Optional  thermostats  are  available  for  use  with  your  pellet  stove.  A  thermostat  can  help  you  maintain  a  constant  room  temperature.  The  thermostat  option  will  require  the  installation  of  a[...]

13  USA 6” CANADA 8” USA 6” CANADA 8” CLEARANCES  TO  COMBUSTIBLES  INSTALL  ALL  VENTS  AT  CLEARANCES  SPECIFIED  BY  THE  VENT  MANUFACT URER!   When  your  Pellet  Stove  Room  Heater  is  being  installed  on  a  combustible  floor  it  is  mandat[...]

14   INSTALLING  YOUR  ROOM  HEATER    You  have  already  made  the  important  decision  of  choosing  your  U.S.  Stove  Pellet  Burning  Room  Heater;  now  your  next  step  is  to  determine  where  to  install  your  new  pellet  st[...]

15  INSTALLING  YOUR  ROOM  HEATER  ‐ continued   HORIZONTAL  EXHAUST  VENT  INSTALLATION   1. Locate  your  pellet  stove  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does  not  interfere[...]

16  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  HORIZONTAL  EXHAUST  VENT  INSTALLATION   [...]

17   INSTALLING  YOUR  ROOM  HEATER  ‐ continued  FREESTANDING  INTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it [...]

18  INSTALLING  YOUR  ROOM  HEATER ‐ continued  FREESTANDING  EXTERIOR  VERTICAL  INSTALLATION   1. Locate  your  Pellet  Stove  Room  Heater  in  a  location  which  meets  the  requirements  of  this  manual,  but  in  an  area  where  it  does[...]

19  [...]

20  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk [...]

21  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS  Images  courtesy  of  Selkirk    UP  &  OUT  HORIZONTAL  TERMINATION  KIT   Figure  12     [...]

22  INSTALLING  YOUR  ROOM  HEATER ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk    STRAIGHT  OUT  HORIZONTAL  TERMINATION  KIT   Figure  13   [...]

23  INSTALLING  YOUR  ROOM  HEATER  ‐ continued  SELKIRK  DIRECT ‐ TEMP  VENT  SYSTEM  FOR  PELLET  STOVE  HEATERS   Images  courtesy  of  Selkirk   THROUGH  THE  ROOF  VERTICAL  TERMINATION  KIT   Figure  14  [...]

24  MOBILE  HOME  INSTALLATION  Mobile  home  installation  shoul d  be  done  in  accordance  with  the  Manufactured  Home  and  Safety  Stan dard  (HUD),  CFR  3280,  Part  24.  Canadian  installations  require  that  the  heater  must  be  co nnected[...]

25  INSERT  PELLET  STOVE  INSTALLATION   U.S.  Stove  Pellet  Burning  Room  Heaters  are  also  available  as  an  insert  into  existing  masonry  of  factory ‐ built  fireplaces.  Do  not  alter  the  existing  fireplace  in  any  way  eit he[...]

26  INSERT  PELLET  STOVE  INSTALLATION  ‐ continued    Step  3:  Sh roud  Top:  Facing  the  back  of  the  unit  take  the  top  shroud  side  piece  and  fasten,  as  shown,  with  4  screws  provided.     Step  4:  Control  Boa[...]

27  INSERT  PELLET  STOVE  INSTALLATION ‐ continued   Minimum  Clearance  to  Combustibles  and  Floor  Protection                A :  Side  wall:  16”  to  side  of  appliance  B :  Top  Trim:  5”  above  top  of ?[...]

28  Installation  into  a  Masonry  Fireplace:            1. Your  chimney  must  be  inspected  by  a  certified  chimney  sweep  or  installer  to  determine  its  structural  condition.  2. Measure  amount  of  venting  required  to [...]

29  VENT  TERMINATION  LOCATIONS   Figure  22  [...]

30  MAINTENANCE  FAILURE  TO  CLEAN  AND  MAINTAIN  THIS  UNIT  AS  INDICATED  MAY  RESULT  IN  POOR  PERFORMANCE  AND  HAZARDOUS  SITUATIONS.  CLEAN  THE  HEATER  FREQUENTLY  AS  ACCUMULATION  OF  SOOT,  CREOSOTE  OR  FLYASH  MAY  OCCUR.  NEVER  CLEA[...]

31  MAINTENANCE  ‐ continued   Ash  Removal ‐ Freestanding  Unit:   If  left  neglected  ashes  will  eventually  fill  the  ash  pan.  Remove  the  ashes  per iodically  to  avoid  unnecessary  ash  build  up.  Ash  removal  is  as  follows[...]

32  MAINTENANCE  ‐ continued   Cleaning   Heat  Exchanger  Tubes  –  Your  Pellet  Stove  Room  Heat er  is  designed  with  a  built  in  heat  exc hanger  tube  cleaner.  This  should  be  used  every  2  or  3  days  to  remove  ash[...]

33  MAINTENANCE  ‐ continued  Chimney/Vent  System  Cleaning:  1. Soot  Formation  –  When  wood  products  are  burned  slowly  they  produce  tar  and  other  organic  vapors  which  combine  with  expelled  moisture  to  form  soot.  The  soot [...]

34  TROUBLE  SHOOTING   See  figure  26,  page  31,  for  component  locations .   The  heater  will  not  light:   Check  that  the  heater  is  plugged  in  and  that  the  wall  outlet  has  power.   Unplug  the  unit  then  check ?[...]

35  TROUBLE  SHOOTING ‐ continued   The  auger  motor  does  not  function  normally.   If  the  auger  shaft  does  not  turn  but  the  motors  armature  tries  to  spin  then  this  is  a  sign  your  auger  is  jammed.  Try  to[...]

36  TROUBLE  SHOOTING  ‐ continued   Door  Glass  has  soot  buildup  at  a  fast  rate  and  flame  is  lazy  with  black  tips.   The  vent  pipe  (including  air  intake)  may  be  dirty  or  partially  blocked  restricting  airflow  [...]

37  WIRING  DIAGRAM    [...]

38  REPLACEMENT  PARTS   Contact  your  authorized  U.S.  Stove  Pellet  Burning  Room  Heater  dealer  to  obtain  any  of  these  parts.  Never  use  substitute  materials.  Use  of  non ‐ approved  parts  can  result  in  poor  performance,  safe[...]

39  LIMITED WARRANTY United States Stove Company warrants to the original purchaser its Pellet Heaters against premature failure of any component du e to workmanship, quality, or materials as follows: TIME PERIOD: Firebox / Firepot ......................................................................................................... T hree Ye[...]

40  [...]