Vermont Castings VCS4017 manuale d’uso

500 040 60 12 /06 R ev .1 En Model V CS5007 Shown USER’S MANU AL f or Models as Barbecue Grill (Propane & Natural Gas) G V CS4017[...]

W ar nings D ANGER WARNING If y ou smell gas: 1. Shut of f gas to the appliance; 2. Extinguish an y open f lame; 3. Open lid; 4. If odor continues, k eep a w ay from the appliance and immediatel y call y our gas supplier or y our fire depar tment. Do not store or use gasoline or other f lammable liquids or v apors in the vicinity of this or an y ot[...]

W ar nings Pa g e i i The Signal W ords used in this Man ual, and their intended meanings , are as follows : Indicates that a failure to obser ve the safety instr uctions could result in death or catastrophic bodily injur y . Indicates that a failure to obser ve the safety instr uctions could result in serious bodily injur y . Indicates that a fail[...]

A. SAFE LOCATIONS FOR USE OF THIS OUTDOOR GRILL W ar nings P age iii D ANGER: WARNINGS: Nev er use this outdoor Grill inside any building, g arage, shed or breezewa y , or inside any boat, trailer or recreational v ehicle, to prev ent a possible fire and to prev ent the possibility of carbon monoxide poisoning or asphyxiation. Alwa ys confir m that[...]

B. SAFE USE OF LP (PR OP ANE) GAS C . SAFE USE OF N ATURAL GAS Alwa ys store your spare Propane Gas Cylinders in an outdoor area that is w ell-v entilated, shady , cool and remov ed from any heat source . Alwa ys store those cylinders in an upright position. Never store a spare cylinder in the vicinity of this Grill, or in the vicinity of any other[...]

D . PREVENTION OF BURNS E. ELECTRICAL SAFETY Pa g e v Alwa ys promptly shut off the g as supply and immediately extinguish all f lames if you smell gas . Alwa ys seek assistance from your gas supplier or local Fire Depar tment if the g as smell persists , because of the dang er of fire or explosion. Alwa ys confir m that there are no g as leaks bef[...]

FUELS WARNING: WARNING: Nev er use Natural Gas in a Grill that has been configured to burn Propane Gas, and nev er use Propane Gas in a Grill that has been configured to use Natural Gas , to a void possible bodily injury . Always consult the Rating Label on the back of your Grill to confir m which fuel m ust be used with the Grill. Use only the pre[...]

D ANGER: ADDITION AL WARNINGS: a) Do not store a spare LP - Gas Cylinder under or near this appliance b) Nev er fill the cylinder beyond 80% full; and c) If the infor mation in a) and b) is not follow ed exactly , a fire causing death or serious injur y may occur . W ARNING: Always confir m that the openings in the cylinder compar tment of the Gril[...]

Pa g e 4 Fig . 5 Gas Hookup Hooking Up to the LP (Propane) Gas Suppl y FOR Y OUR SAFETY LP (PR OP ANE) GAS SUPPL Y CONNECTION WARNING: CAUTION: 1. 2. 1. 2. 3. Alwa ys conduct a leak test before lighting the Grill, to prev ent a possible fire or explosion (see pag e 5). F or connection of an LP g as g rill to a fix ed pipe LP bulk system, consult yo[...]

N ATURAL GAS SUPPL Y CONNECTION T O CONNECT : T O DISCONNECT : TESTING FOR GAS LEAKS WARNINGS: 1. 2. 3. 1. (for LP and Natural Gas) Before attempting to operate this Grill: 1. 2. 3. 4. 5. 6. Pa g e 5 Push back the Sleev e on the Soc ket as sho wn below (see Fig . 6a). Inser t Plug and release the Sleev e (see Fig . 6b). Push the Plug until Sleev e [...]

CONTR OL FUNCTIONS PR OP ANE T ANK V AL VE WARNING: BURNER CONTR OL V AL VES ACTIV ATING THE IGNITER ELECTR ONIC IGNITION SY STEM PIEZO IGNITION SY STEM Nev er open the T ank V alve unless the Grill is being prepared for use, to prev ent the pooling of propane v apor . Alwa ys open the V alve immediately before lighting the Grill, and alwa ys close[...]

LIGHTING THE MAIN BURNERS WARNING: WARNING: IF THE SELECTED B URNER DOES NOT LIGHT , 1. Nev er stand with your head directly ov er the Grill when preparing to light the main bur ners , to prevent possible bodily injur y . 2. 3. 4. 5. immediately turn the bur ner control knob to the OFF position, to prevent g as buildup . W ait fiv e (5) minutes for[...]

Pa g e 8 Operation TURNING THE BURNERS OFF FLARE-UPS MAT CH LIGHTING THE MAIN BURNERS: WARNING: 1. 2. 3. “Flare-ups” sometimes occur when food drippings fall onto the hot sear plates or burners and ignite. Some f laring is nor mal and desirable, as it helps impart the unique f lav ors associated with g rilled foods . Controlling the intensity o[...]

LIGHTING THE RO TISSERIE B URNER T O ST ART THE R O TISSERIE BURNER: MAT CH LIGHTING THE RO TISSERIE BURNER: WARNING: (if equipped) The Rotisserie burner provides the steady , even heat required to cook poultry and roasts to self-basted perfection. 1. 2. 3. 4. 5. 6. 7. 8. 1. Nev er stand with your head directly o ver the Grill when preparing to lig[...]

Pa g e 1 0 Operation R OTISSERIE SETUP WARNING: (if equipped) The Rotisserie burner is intended to be used for rotisserie cooking only . Nev er use the main bur ners while using the R otisserie bur ner , as that could result in igniting the drippings , or ov erheating y our Grill, which could result in damage of the Grill. The Rotisserie assembly i[...]

Fig . 13 Control knob Igniter LIGHTING THE SIDE BURNER WARNING: NO TE: SHUTTING THE BURNER OFF (if equipped) Nev er stand with your head directly o ver the Grill when preparing to light the side bur ner , to prev ent possible bodily injur y . 1. 2. Obser ve the flame patter n. Soft blue f lames are nor mal ; hard blue f lames or wavy yello w flames[...]

Pa g e 2 2 T roubleshooting Guide PROBLEM Burner will not light Unit w on ’ t heat up (LP) Unit w on ’ t stay lit POTENTIAL CA USE Gas supply turned off Out of propane Blockage in the gas system Misalignment of the g as valv e to the venturi tubes of the bur ner . Improper attachment of the propane hose and regulator Control knob left open at s[...]

Pa g e 2 3 T roubleshooting Guide PROBLEM Uneven burn pattern or Flashback fire Ex cessiv e yellow flame Flare-up Igniter does not spark POTENTIAL CA USE Blockage in the burner or g as system Cor roded burner Improper air shutter opening Ex cessiv ely fatty foods Grease buildup Electrode fouled Electrode improperly gapped Electrode crack ed Lead wi[...]

50004062 11/06 Rev .0 En Pa g e 1 T ools Required: knife or scissors, Phillips or Robertson (square head) screwdriver .. VCS4007 / VCS4017 / VCS4027 / VCS4037 VCS5007 / VCS5017 / 27 37 ASSEMBL Y PROCEDURES VCS50 / VCS50 Model VCS4007 Shown Step 1: Unpack Carton and V erify Contents CAUTION: Use a sharp cutting tool to cut the straps on the packagin[...]

VCS4007 / VCS4017 / VCS4027 / VCS4037 / VCS5007 / VCS5017 / 27 37 Assembly VCS50 / VCS50 Page 2 Step 2: Install the Casters Parts Required: Note: Step 3: Install U-Clip Fasteners Parts Required: (4) Casters, (1) Block (not included) Casters (wheels) may differ from those shown in the illustration depending on the model you purchased. Select a side [...]

Page 3 Step 4: Install the Side Shelf Supports Parts Required: Note: Step 5: Attach Shelves Parts Required: (1) Left Side Shelf Support (1) Left Condiment T ray (1) Right Side Shelf Support (1) Right Condiment T ray (8) 1/4-20 x 1-1/2“ Bolts Only the right side assembly is shown in Fig. 4a and Fig. 4b. T o install Left Side Support and Condiment [...]

Page 4 Step 6: Secure Shelves Parts Required: A. B. Step 7: Secure Side Shelf to Grill Parts Required: Step 8: Secure Condiment T ray to Console Parts Required: (4) 10-24 x 1/2” Bolts (black) Secure each Shelf by inserting (2) 10-24 x 1/2” bolts through the U-Clip fasteners as shown in the diagram. T ighten the four (4) Shelf Support bolts from[...]

Page 5 Step 9: Attach Side Burner Lid Parts Required: Note: Step 10: Attach Knobs Parts Required: Note: (S/B-Single) (1) Side Burner Lid (S/B-Single) (2) #10-24 x 3/4” ( 1/4” Shank)* * Attach the lid marked (S/B-Single) to the Shelf Right top marked VM-S/B using two #10-24 x 3/4” ( 1/4” Shank) bolts. Align the holes at the back sides of the[...]

Page 6 Step 12: Attach the Handle to the Door Parts Required: Note: Note: VCS4007/VCS4017/VCS4027/VCS4037: (1) Handle VCS5007/VCS5017/VCS5027/VCS5037: (3) Handles VCS5007 VCS50 VCS50 5037 (1) Grease Cup (1) Grease Pan Install the Grease Cup into the cut-out in the Upper Base Panel located underneath the grill. It is accessible from the back of the [...]

Page 7 Step 15: Install the Internal Components Parts Required: Note: Caution: VCS4007 / VCS4017 : (4) Sear Plates VCS4027 / VCS4037 (3) Cooking Grates (1) W arming Rack VCS5007 / VCS5017 : (5) Sear Plates VCS5027 / VCS5037 (4) Cooking Grates (1) W arming Rack requires a “AA” Battery . Unscrew the Ignition Button from the console and insert a b[...]

Page 8 Step 17: Install the LP Cylinder (LP Models Only) Parts Required: Note: (1) LP Gas Cylinder (not included) Check your user ’ s manual for the cylinder filling requirements, how to attach the regulator and how to test for leaks before you try lighting the grill. Place the LP Cylinder into the hole in the bottom panel. Next secure it from mo[...]

Page 12 Service Note: If you are experiencing difficulties or are dissatisfied with your purchase, please contact CFM at the telephone number listed above prior to returning your grill to the store. CFM Corporation 410 Admiral Boulevard Mississauga, Ontario L5T 2N6 Canada (800) 668-5323 www .cfmcor p .com[...]