Wagner SprayTech PP119 manuale d’uso

® ProjectPro 119 Airless Sprayer Betriebsanleitung • Owner’s Manual • Manuel d’utilisateur • Manuale dell’utente • Manual de usuario • Gebruikshandleiding • Ejermanual • Användarmanual • Manual do Proprietário 0108 © 2008 Wagner. All rights reserved. Form No. 0418846B D GB F . . . . . . . . . . 2 . . . . . . . . . . 10 . .[...]

2 F E D G H B C A J I 1 1) 2) 3) 2 1) 2) 3) (b) (a) 4 3) SPRAY PRIME 2) 1) O 6 2) 1) 3 5 7[...]

3 1) (a) (b) + 2) SPRAY PRIME 3) 4) 5) l 8 SPRAY PRIME 1) 2) SPRAY PRIM E 3) l 9 (a) (b) 10 11 25 - 30 cm A) B) C) 25 - 35 cm 25 - 30 cm 25 - 30 cm D)[...]

4 A) B) 12 13 A) 2) 3) 1) B) 14 (a) (c) (b) 15 (g) (a) (c) (b) (d) (f) (e) 16 (a) 17[...]

5 1) 2) 18 7 8 5 9 11 6 3 4 1 2 10 23 (a) 1) 2) (b) 19 1) 2) 3) 20 3 2 4 1 21 22[...]

6 PP119 - Safety Information W arning! Never put your fingers, hands or any other parts of the body into the spray jet! Never point the spray gun at yourself, other persons or animals. Never use the spray gun without safety guard. Do not treat a spraying injury as a harmless cut. In case of injury to the skin through coating materials or solvents, [...]

7 PP119 - Safety Information All local regulations in force must be observed. For secure handling of Airless high-pressure spraying units the following safety regulations are to be observed: U Flash point Danger Only use coating materials with a ash point of 21 °C or above without additional heating. The ash point is the lowest temperature a[...]

A minimum distance of 5 m between the unit and spray gun is to be maintained. When working outdoors: Vapors containing solvents may not be allowed to blow toward the unit. Note the direction of the wind. Danger Set the unit up in such a way that vapors containing solvents do not reach the unit and build up there. A minimum distance of 5 m between t[...]

Assembly Figure 2 - Unfolding the Cart 1. Grab the pail bracket to lift up the sprayer. Lift the leg lock and unfold the legs. 2. Move leg lock down to lock into place. 3. Twist the knob on either side of the cart toward the “UP” arrow until it stops. Lift the handle until the motor housing and handle locks into place. Be careful not to pinch t[...]

1 0 PP119 Figure 11 - Spraying Technique A) The key to a good paint job is an even coating over the entire surface. Keep your arm moving at a constant speed and keep the spray gun at a constant distance from the surface. The best spraying distance is 25 to 30 cm between the spray tip and the surface. B) Keep the spray gun at right angles to the sur[...]

1 1 PP119 Figure 16 - Cleaning the Spray Gun 1. Make sure the pump is switched OFF (O). Make sure the PRIME/SPRAY knob is turned to PRIME. Unplug the sprayer. 2. Remove spray gun from the paint hose using adjustable wrenches. 3. Unclip the trigger guard (a) from the lter housing (b) by pulling outward from the lter housing. Unscrew the lte[...]

Figure 23 - Pump section replacement instructions Kit Part Number 0418716 Danger Always wear protective eye wear while servicing the pump. Be sure to follow the Pressure Relief Procedure when shutting the unit down for any purpose, including servicing or adjusting. After performing the Pressure Relief Procedure, be sure to unplug the unit before se[...]

Problem A. The sprayer does not start. B. The sprayer starts but does not draw in paint when the PRIME/ SPRAY knob is set to PRIME. C. The sprayer draws up paint but the pressure drops when the gun is triggered. D. The PRIME/SPRAY valve is on SPRAY and there is ow through the return tube. E. The spray gun leaks. F. The tip assembly leaks. G. The[...]

1 4 D Wichtiger Hinweis zur Produkthaftung Aufgrund einer ab 01.01.1990 gültigen EU-Verordnung haftet der Hersteller nur dann für sein Produkt, wenn alle Teile vom Hersteller stammen oder von diesem freigegeben wurden, bzw. die Geräte sachgemäß montiert und betrieben werden. Bei Verwendung von fremdem Zubehör und Ersatzteilen kann die Haftung[...]

15 Entsorgungshinweis: Gemäß der europäischen Richtlinie 2002/96/EG zur Entsorgung von Elektro-Altgeräten, und deren Umsetzung in nationales Recht, ist dieses Produkt nicht über den Hausmüll zu entsorgen, sondern muss der umweltgerechten Wiederverwertung zugeführt werden! Ihr Wagner-Altgerät wird von uns, bzw. unseren Handelsvertretungen zu[...]

16 D Konformitätserklärung Hiermit erklären wir, dass die Bauart von WAGNER Project Pro 119 folgendeneinschlägigenBestimmungenentspricht: 73/23 EWG, 89/336 EWG, 92/31 EWG, 93/68 EWG, 98/37 EWG. AngewendeteharmonisierteNormen,insbesondere: EN 292-1/-2, EN 1953, EN 55014, EN 60335-1, EN 61000-3. Angewendete nationale technische [...]

Geschätfsführer Unterschrift Entwicklungsleiter Executive Ocer Signature Head of Development Directeur Signature Directeur du developpement Dirigente aaristico Firma Dirigente tecnico Gerente Firma Jefe de Desarrollo Directeur Handtekening Chef ontwikkeling Forretningsfører Underskrift Udviklingslede Verkställande direktör Underskrift Ut[...]

1 8 Hinweis • Notes • Remarques • Note • Notas • Opmerking • Bemærk • Anmärkning • Notas[...]

19 Hinweis • Notes • Remarques • Note • Notas • Opmerking • Bemærk • Anmärkning • Notas[...]

20 W agner Spra ytech Australia Pty . Ltd., 14-16 Kevlar Close, Braeside, VIC 3195/Australia  +61/3/95 87 20 00  +61/3/95 80 91 20 W agner Spra ytech Benelux B.V . Zoonebaan 10 3542 EC Utrecht  +31/30/2 41 41 55  +31/30/2 41 17 87 Adresaservisa: EL-ME-HO Hor vatinčić ev put 2 10436 Rakov P otok/Kroatien  /  +385(-1)65 86 - 02[...]