Wells WFPE-30F manuale d’uso

PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD, LLC 2 ERIK CIRCLE, P . O. Box 280 V erdi, NV 89439 www .wellsbloomfield.com telephone: 775-689-5703 fax: 775-689-5976 IMPORTANT: DO NOT DI SCARD THIS MANUAL This manual is considered to be part of the appli ance and is to be given to the OWNER or MANAGER of the restaurant, or to the pers on re[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer Unless otherwise specified, all commercial cooking equipment manufactured by WELLS BLOOMFIELD, LLC is warranted against defects in ma terials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factor y, whichever co[...]

W A R R A N T Y x i SPECIFICATIONS 1 FEATURES & OPERATING CONTROLS 2 AGENCY LISTING INFORMATION 4 PRECAUTIONS & GENERAL INFORMATION 5 I N S T A L L A T I O N 6 PREPARATION PRIOR TO OPER ATION 8 O P E R A T I O N 1 1 MAINTENANCE INSTRUCTIONS F I L T E R O P E R A T I O N 1 2 D I S C A R D I N G U S E D O I L 1 5 C L E A N I N G 1 6 TROUBLESH[...]

FEATURES & OPERATING CONTROLS 2 1 POWER SWITCH (FRYER-OFF-FILTER) FRYER position energizes the FRYER and POWE R LIGHT; de-energizes FILTER PUM P . HEATING ELEMENTS energized and regulate to setting on CO NTROL T HERMOSTAT (8). OFF position de-energi zed FRYER and FILTER PUMP. FILTER position de-energizes FRYER; e nergizes FILTER PUMP SWITCH (6)[...]

FEATURES & OPERATING CONTROLS (continued) 3 7 HI-LIMIT THERMOSTAT Provides over-temperature protection by de-e ne r gizing HEATING ELEMENTS should oil temperature exceed factory pre -set limits. 8 TEMPERAT URE C ONTROL THERMOSTAT Controls oil temperature. Range: 250ºF (121ºC) 375ºF (191ºC) 9 FILTER PUM P MOTOR RESET BUTTON (located at rear [...]

AGENCY LISTING INFORMATION FEATURES & OPERATING CONTROLS (continued) 4 This appliance conforms to NSF Standard 4 for sanitation only if installed in accordance with the supplie d Installation Instructions and maintained according to the in structions in this manual. Domestic fryers are and listed under UL File E6070 for 208V and 240V. Export (E[...]

This appliance is intended for use in commercial establishments only. This appliance is intended to prepare food for human consumpti on. No other use is recommended or autho rized by the manufacturer or its agents. DO NOT open any panel that require s the use of tools for access. Live electric circuits may be expose d by open ing such panels. Openi[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer INSTALLATION NOTE: DO NOT discard the carton or other packing materials until you have inspected the appliance for hidden damage and tested it for proper operation. Refer to SHIPPING DAMAGE CLAIM PROCEDURE on the inside front cover of this manual. WARNING: FIRE HAZARD Do not store gasoline o[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer ELECTRICAL INSTALLATION Refer to the nameplate on the front of the fryer and to the specifications listed on page 1 of this manual. Verify that electric service voltage, phase and amperage cap acity meet or exceed these specifications. Field wiring must be no less than 12 ga . Solid copper w[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer PREPARATION PRIOR TO OPERATION 8 PRE-CLEANING PROCEDURE Slide the LID AND YOLK back. Press POWER SWITCH OFF . Close DRAIN VALVE (lever horizontal) . Fill FRYPOT with 4 gallons of cold water. Press POWER SWITCH to FRYER . When water comes to a full boil, press POWER SWIT CH OFF . When boiling[...]

PREPARATION PRIOR TO OPERATION (continued) 9 PREPARE FILTER RESERVOIR Install SUCTION TUBE O-RINGS, FILTER PAPER and FILTER PAPER HOLDER in to RESERVOIR. Install assembled FILTER RESERVO IR in place a bottom of FRYER. Install DRIP PAN (item 17) into mounting bracket behind fryer door. Close DRAIN VALVE (item 11) by turning lever to horizontal posit[...]

PREPARATION PRIOR TO OPERATION (continued) 10 Fill the FRYPOT to the COLD (MAX) line on OIL LEVEL INDICATOR with room temperature commercia l-quality LIQUID SHORTENING. This requires 30lbs. of oil. Check operation of FRYER and all CO NTROLS. Load product, and determine maximum load. NOTE: Fill frypot with 30 lbs of LIQUID SHORTENING ONLY . DO NOT U[...]

OPERATION 11 PRE-HEATING FRYER Make sure FRYPOT is filled with 30 LB. of cooking o il. Open door and set THERM OSTAT (item 10) to de sired cooking temperature. CLOSE THE DOOR. Set POWER SWITCH (item 1) to FRYER . POWER LIGHT (item 2) and HEAT LIGHT (item 3) will glow. HEAT LIGHT wil l cycle on and off with the HEATING ELEMENTS. When HEAT LIGHT firs[...]

MAINTENANCE - FILTER OPERATION 12 FILTER PAPER INSTALLATIO N 1. Open FRYER DOOR and re move FILTER RESERVOIR. 2. Remove FILTER PAPER HO LDER, used FILTER PAPER and FILTER SCREEN. Discard used f ilter paper and make sure filter reservoir, filter screen and filter paper holder a re clean and dry. 3. Install FILTER SCREEN in reservoir wi th spring cli[...]

MAINTENANCE - FILTER OPERATION (continued) 13 FILTERING OIL NOTE: Oil should be at least 300ºF (149ºC) DO NOT attempt to filter cold oil. DO NOT attempt to pump oil when less than 300ºF. Cold oil will not pass through the filter paper. Filtering cold oil will re su lt in the premature failure of the filter pump. Damage as a result of pumping col[...]

MAINTENANCE - FILTER OPERATION (continued) 14 (CONTINUED FR OM PAGE 13) 6. Brush down sides and bottom of frypot using p r ovided hi-temperature brush. Loosen crumb s and other debris to flush them into filter reservoir. 7. Rotate DRAIN VALVE LEVER (item 11) to the horizontal position when filtering is complete, 8. Observe the oil returning to fryp[...]

MAINTENANCE - DISCARDING USED OIL 15 1. Press POWER SWITCH to OFF. Allow oil to cool to 120ºF (49ºC) or less before attempting to drain oil from fryer. 2. With a suitable METAL container un der DRAIN VALVE, slowly rotate DRAIN VALVE LEVER to the vertical position. Fill the container no more than 4” (100mm) d ee p. 3. Move the DRAIN VALVE LEVER [...]

OPTIONAL OIL WAND WASH OUT FRYPOT or DISCARD OIL 1. If discarding oil, be sure a suitable hot o il disposal container is available. Otherwise, prepare filter reservoir pa n for filtering (see page 12). 2. Turn DRAIN VALVE HANDLE vertical to open the drain and fill filter reservoir. 3. Connect wand (female) fitting to the fryer (male) fitting: a. Sl[...]

OPTIONAL OIL WAND RETURN FRYER TO NORMAL OPERATION 1. After washing down frypot, turn DRAIN VALVE HANDLE horizontal to close the frypot drain. IMPORTANT: Drain handle must be fully closed in order to activate HEATER SAFETY SWITCH. Drain handle must be horizontal before for frye r heating element can be energized. 2. At conclusion of use, pre ss FRY[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer MAINTENANCE - CLEANING INSTRUCTIONS 18 122 306626 OpM anual for HDG-Series Griddles 122 306626 OpM anual for HDG-Series Griddles DANGER: BURN HAZARD Contact with hot oil will cause severe burns. Allow the fryer to cool before cleaning. Always wear protective clothing and heat resi stant glov[...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer MAINTENANCE - CLEANING IN STRUCTIONS (continued) 19 PREPARATION Drain oil from fryer before cleaning FREQUENCY Monthly, or as needed TOOLS Low-foaming commercial fryer clea nser Metal disposal container FRYPOT CLEANING - HOT BOILOUT PR OCEDURE Slide the LID AND YOLK back. Press POWER SWITCH [...]

362 301626 OpM anual for WFPE-30F Electric Pressure Fryer TROUBLESHOOTING 20 SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Fryer will not heat Unit disconnected from electric power Reconnect to power Check/reset circuit breaker Temp control thermostat (item 6) not set Set thermostat to desired temperature Hi-Limit thermostat (item 7) tripped Allow unit t[...]

DESCRIPTION PART NO. BRUSH, CLEANING HEATING ELEMENT 21647 FILTER PAPER, 30-SERIES FRYER (pk100) 21711 FLAVOR-SAVER OIL FILTER POWDER (pk45) 22410 WAOC-1 MOBILE OIL DISPOSAL CADDY 22470 PADDLE, STIRRING CHICKEN 22515 BRUSH, CLEANING F R YPOT 22516 *FILTER WAND ASSY 23188 *NOTE: The filter wand assembly involv es a differe nt plumbing arrangement th[...]

Genuine Parts Protect - YOU - All - W ays SER VICE TRAINING - QUALITY SER VICE SER VICE TRAINING - QUALITY SER VICE CUSTOMER SA TISF ACTION CUSTOMER SA TISF ACTION Commercial Food Equipment Service Association Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association PRINTED IN UNITED ST A TES OF AMERICA WELLS BLOOMFIELD[...]