Kenmore 625.348242 manual

OWNER'S MANUAL MODEL NOS. 625.348235 Clarifier 625.348242 Neutralizer 625.348252 Taste & Odor Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. If you have questions when installing, operating or main- taining your filter, and when setting the timer, call this toll-free number... 1-800-4[...]

W A R R A N T Y SEARS RESIDENTIAL WATER FILTER FULL ONE YEAR WARRANTY ON FILTER For one year from the date of purchase, when this filter is installed and maintained in accordance with our instructions, Sears will repair, free of charge, defects in material or workmanship in this water softener. FULL FIVE YEAR WARRANTY AGAINST LEAKS For five years f[...]

T A B I_ E O F C O N T E N SECTION 1 FILTER START UP PAGE NO. A. SAFETY GUIDES 1-1 B. CHECK LIST OF STEP-BY-STEP GUIDES TO INSTALL 1-2 C. PROGRAM THE TIMER 1-3 to 1-4 D. SANITIZING THE WATER FILTER 1-5 SECTION 2 HOW YOUR WATER FILTER WORKS A. FACEPLATE TIMER FEATURES B. FILTER APPLICATIONS C. FILTERED WATER SERVICE, AND BACKWASH SECTION 3 A. B. C. [...]

SECTION 1 IWATER FILTER START UP A. SAFETY GUIDES S C T I O N • Read all steps, guides and rules carefully before installing and us- ing your new water filter. Follow all steps exactly to correctly install. Failure to follow them could cause personal injury or property dam- age. Reading this book will also help you to get all of the benefits from[...]

SECTION 1 IWATER FILTER START UP B. CHECK LIST OF ALL STEP-BY-STEP GUIDES TO INSTALL I _J[_il Refer to the Installation Manual, part number 7146611, for step-by-step guides. To be sure you have done all the steps to install the filter, read the following list. Page numbers referred to are in the Installation Manual. w" w" Is the house wat[...]

SECTION 1 IWATER FILTER START UP C. PROGRAM THE TIMER display / / A UP button SDecia!_v Filtr_'_ V i "> 2r RECHARGE button °J DOWN button SELECT button When the transformer is plugged into the electrical outlet a model code is displayed for a few seconds followed by a test number (example: J1.1). Then, 12:00 PM and the words PRESE[...]

SECTION 1 iWATER FILTER START UP C. PROGRAM THE TIMER 2. SET DAYS TO RECHARGE This setting is the number of days the filter will go between recharges. The default setting is 3 days, with a maximum setting of 99. 3. SET RECHARGE TIME The filter is factory set to begin recharge at 12:00 AM. If a different recharge time is desired, or needed, do the f[...]

SECTION 1 IWATER FILTER START UP D. SANITIZING THE WATER FILTER Care is taken at the factory to keep your water filter as clean and sanitary as possible. However, it is sug- gested that the sanitizing procedure below is follo- wed ,_1_ lo o o Press and hold the RE- CHARGE button until "RECHARGE NOW" begins to flash in the display. Water w[...]

SECTION 2 HOW YOUR WATER FILTER WORKS A. FACEPLATE TIMER FEATURES S E C T N RECHARGE NOW For times you expect to use more water than usual, use the RE- CHARGE NOW feature. Press the RECHARGE button and hold in for three seconds. "RECHARGE NOW" begins to flash in the dis- play and a recharge starts right away. You will have filtered water [...]

SECTION 2 HOW YOUR WATER FILTER WORKS A. FACEPLATE TIMER FEATURES The default settings for backwash (25 minutes) and fast rinse (5 minutes) cycles of regeneration are fac- tory set for maximum performance of the filter. Use the following procedures to check for correct cycle times, or to change if desired. However, only trained technicians should c[...]

SECTION 2 HOW YOUR WATER FILTER WORKS B. FILTER APPLICATIONS IMPORTANT: Sears water filters are sometimes installed alone in the water system, but most often other wa- ter treating equipment is needed. Always be sure to have your water tested by a qualified testing laboratory. If you need help, ask at your Sears store, or call the Kenmore Water Lin[...]

SECTION 2 HOW YOUR WATER FILTER WORKS C. FILTERED WATER SERVICE, AND BACKWASH CLARIFIER FILTER SERVICE During service (Figure 6) water goes into the filter and DOWN through the bed of mineral. The mineral takes the dirt, sand, silt, clay and other sediments out of the water and holds it in the bed. Clear, clean water goes out of the filter and into[...]

S E C T N A. KEEP THE FILTER FROM FREEZING If the filter is installed where it could freeze (summer cabin, lake home, etc.), you must drain all wa- ter from it to stop possible damage caused by freezing. To drain the fil- ter - . 5. Unplug the transformer at the wall outlet. Pull the holding clip to remove the drain fitting, with drain hose attache[...]

B. ADDING MINERAL... NEUTRALIZER FILTER STEPS TO ADD MINERAL . Press the RECHARGE button and hold in for three seconds until "RECHARGE NOW" be- gins to flash in the display. . When water begins to flow from the valve drain hose, place the bypass valve(s) in BYPASS posi- tion, see Figure 9, page 4-1. CAUTION: BE SURE TO DO STEPS 1 AND 2 AS[...]

C. REPLACING MINERAL... TASTE & ODOR FILTER Average life of the activated carbon mineral bed is about one year (see page 2-4). It's time to replace the bed when the tastes and/or odors begin to return in the water supply. Do the following. STEPS TO REMOVE AND ADD MINERAL . Press the RECHARGE button and hold in for three seconds until "[...]

D. BEFORE YOU CALL FOR SERVICE...HELPFUL HINTS CHECKLIST PROBLEM FILTER WILL NOT BACKWASH LOW WATER PRESSURE AT HOUSE FAUCETS FILTERED WATER CONTAINS SED- IMENTS, IRON, DIRT, SAND, ETC. NEUTRALIZER FILTER ONLY: FIL- TER WATER IS ACID OR PARTLY ACID NOTE: Trace plumbing to be sure faucet(s) is on filtered water service. TASTE & ODOR FILTER ONLY:[...]

SECTION 4 I OTHER THINGS TO KNOW S E C T N A. DIMENSIONS / SPECIFICATIONS BYPASS VALVES SINGLE-PLASTIC PULL STEM OUTWARD FOR SERVICE Push Inward For ! Bypass 3-VALVEsERVICE ! Valve £ C Close Bypass Valve Open Inlet & Outlet Valves YS Open Bypass Valve Close Inlet & Outlet Valves Bypass I Valve Inlet Valve 55" 139.6 cm .9 c_l Inlet-Out[...]

SECTION 5 SERVICE mECH. INFORMATION S C T N A. TROUBLESHOOTING WIRING SCHEMATIC 24VAC TRANSFORMER J_. NC NO POSITION SWITCH FACE PLATE TIMER _v A NgW F_oI_ _c_¢ 3 _c0#_s 5-1 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

SECTION 5 SERVICE mECH. INFORMATION A. TROUBLESHOOTING ALWAYS MAKE THESE INITIAL CHECKS FIRST 1. Does the time display show the correct time of day? ...If display is blank, check power source to the filter. ...If time is flashing, power was off for over two days. The filter resumes normal operation but re- charges occur at the wrong time. 2. Plumbi[...]

SECTION 5 SERVICE mECH. INFORMATION A. TROUBLESHOOTING MANUAL ADVANCE DIAGNOSTICS Use the following procedures to advance the filter valve through the regeneration cycles to check op- eration. Remove the top cover to observe cam and switch op- eration during valve rotation. DISPLAY MUST SHOW TIME AND DAY 1. Press and hold the RECHARGE button for 3 [...]

SECTION 5 SERVICE mECH. INFORMATION A. TROUBLESHOOTING NEUTRAUZER FILTER FILTERED WATER IS ACID (LOW pH) TASTE & ODOR RLTER FILTERED WATER bIAS TASTE AND/OR ODOR NEEDS REFILL OF i I NEEDS REPLACEMENT NEUTRALITE M INERAL OF ACTIVATED CARBON MINERAL ALL FILTERS I FILTERED WATER CONTAINS SEDIMENTS, (SAND, StLT,,DIRT, ETC.) OR IRON ! I IRON IN WATE[...]

SECTION 5 SERVICE mECH. INFORMATION B. ROTARY VALVE SERVICE BEFORE WORKING ON THE VALVE, TURN OFF THE WATER SUPPLY AND DISCONNECT FROM ELECTRICAL POWER. TO RELIEVE PRESSURE. ... THREE VALVE BYPASS: Close the inlet and open a filtered water faucet. Then close the outlet valve and open the bypass valve. ... SEARS SPECIAL BYPASS: Slide the bypass valv[...]

SECTION 5 SERVICE mECH. INFORMATION C. WATER FLOW THROUGH THE FILTER VALVE ERVICE CYCLE ._ _1:> POSITION SWITCH E INLET VALVE OUTLET _j i I_ MINERAL_ " the valve Internal valve ,_ _ 0 porting routes the water down and out the top distributor, intothe BED • _ Hard, unfiltered water enters inlet port. '*,_p 4_,._ _./ _ mineral tank. Th[...]

S E C T N Kenmore Clarifier, Model No. 625.348235 Neutralizer, Model No. 625.348242 Taste & Odor, Model No. 625.348252 14 16 12 _ _ _ _ 17 7 4_ 19 1 6-1 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

Kenmore Clarifier, Model No. 625.348235 Neutralizer, Model No. 625.348242 Taste & Odor, Model No. 625.348252 KEY PART DESCRIPTION NO. NUMBER 1 7105047 Bottom Distributor & Standpipe 2 7092202 Mineral Tank 3 7088855 Top Distributor 4 7170270 O-Ring, 2-3/4 x 3 5 7170254 O-Ring, 13/16x1-1/16 6 7170296 O-Ring, 2-7/8 x3-1/4 7 7088033 Clamp Retai[...]

Kenmore Clarifier, Model No. 625.348235 Neutralizer, Model No. 625.348242 Taste & Odor, Model No. 625.348252 3O 2 4 5 8 10 18 11 12 16 17 14 15 36 37 38 6-3 Problems, Questions? Call 1-800-426-9345 Kenmore Water Line[...]

SEARS WATER FILTERS Clarifier, Model No. 625.348234 Neutralizer, Model No. 625.348241 Taste & Odor, Model No. 625.348251 KEY PART DESCRIPTION NO. NO. 1 7131755 Screw, #6-20 x 7/8 (2 req'd) 2 7285936 Motor 3 0900857 Screw, #6-20 x 3/8 (2 req'd) 4 7288112 Motor Plate 5 0503288 Bearing 6 7284964 Cam & Gear 7 7142942 Clip (Drain) 8 70[...]

Your Home For repair-in your home-of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no ma_er who sold it! For the replacement pa_s, accessories and owner's manuals that you need to do-it-yourself. For Sears professional installation of home appliances and items like garage door ope[...]