Pride Mobility INFMANU3351 manual

Jazzy Select 6 with Power Seat Jazzy Select 6 with Power Seat Date Inspected Inspector Inclusion of all Part s Joystick Seri al Number Controller Serial Number Left Motor Se rial Number Right Motor Seria l Number Fit and Finish Performance *INFMANU3351* Product Serial # J AZZY SELECT SERIES Including Models: Jazzy Sele ct, Jazzy Select 6, and Jazzy[...]

WARNING! An authorized Pride Provider or a qualified technician must perform the initial setup of this power chair and must perform all of th e procedures in this manual. The symbols below are used throughout this owner’s manual and on the pow er chair to identify warnings and important information. It is very important for you to read th em and [...]

Jazzy Select Series www.pridemobility.com 3 I. INTRODUCTION .............................................................................................................................. ... 4 II. SAFETY .............................................................................................................................. ...................[...]

4 www.pridemobility.com Jazzy Select Series I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products (Pride). The power chair you have purchased combines state-of-the-art components with safety , comfort, and styling in mind. We are confident that these design features will provide you with the conveniences you e xpect during your daily activitie [...]

Jazzy Select Series www.pridemobility.com 5 II. SAFETY Read and follow the information in the owner’s manu al. PRODUCT SAFETY SYMBOLS The symbols below are used on the power chair to identi fy warnings, mandatory acti ons, and prohibited actions. It is very important for you to read and understand them completely. Do not allow unsupervised childr[...]

6 www.pridemobility.com Jazzy Select Series II. SAFETY Do not connect an extension cord to the A C/DC co nverter or the battery charger. Removal of grounding prong can create elec trical hazard. If necessary, properly install an approved 3-pronged adapter to an el ectrical outlet having 2-pronged plug access. Wear safety goggles. Corrosive chemical[...]

Jazzy Select Series www.pridemobility.com 7 II. SAFETY Explosive conditions exist! Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. Keep tools and other metal objects away from battery terminals. Contact with tools can cause electrical shock. Battery Set Configuration: + = Positive (Red) Termina l Post - = N[...]

8 www.pridemobility.com Jazzy Select Series II. SAFETY Contains Lead. Do not place power chair in freewheel mode on an incline. Do not place power chair in freewheel mode on a decline. Unlocked and in freewheel mode. Locked and in drive mode. Disposal and recycling — contact your aut horized Pride Provider for information on proper disposal and r[...]

Jazzy Select Series www.pridemobility.com 9 GENERAL GUIDELINES MANDATORY! Do not operate your new power chair for the first time wi thout completely reading and understanding this owner’s manual. Your power chair is a stat e-of-the-art life-enhancemen t device designed to increase mobility. Pride provides an extensive variety of products to best [...]

10 www.pridemobility.com Jazzy Select Series Weight Limitations Your power chair is rated fo r a maximum weight capacity. Please refer to the spe cifications table for this limit. Keep in mind that the maximum weight capacity includes the combined wei ght of the user and any accessories mounted to the power chair. MANDATORY! Stay within the specifi[...]

Jazzy Select Series www.pridemobility.com 11 WARNING! If your power chair is equipped with a reclining seatback, do not attempt to negotiate inclines with the seat in a reclined position. Do not attempt to negotiate o bstacles with the seat in a reclined position unless an at tendant is present to help stab ilize the chair. Failure to heed could re[...]

12 www.pridemobility.com Jazzy Select Series II. SAFETY Public Streets and Roadways WARNING! You should not operate your power chair on public streets and ro adways. Be aware that it may be difficult for traf fic to see you when you are seated on your power chair. Obey all local pedestrian traffic rules. Wait until your path is clear of traffic, an[...]

Jazzy Select Series www.pridemobility.com 13 Stairs and Escalators Power chairs are not designed to tr avel up or down stairs or escalators. Always use an elevator. WARNING! Never use your power chai r to negotia te steps or escalators. Doors  Determine if the door opens toward or away from you.  Drive your power chair gently and slowly forwa[...]

14 www.pridemobility.com Jazzy Select Series Positioning Belts Your authorized Pride Provider, therap ist(s), and other healthca re professionals are responsible for determining your requirement for a positi oning belt in order to operate your power chair safely. WARNING! If you re quire a positioning belt to safe ly o perate your power chair, make[...]

Jazzy Select Series www.pridemobility.com 15 WARNING! Before transferring, position yourself as far ba ck as possible in the power chair seat to prevent the power chair from tipping forward d uring transfer. WARNING! Avoid putting all of your weight on the power chair armrests and do not use the armrests for weight bearing purposes, such as transfe[...]

16 www.pridemobility.com Jazzy Select Series Alcohol/Smoking The power chair user must exercise care and common sense when operating his/her power chair. This includes awareness of safety issues while under th e influence of alcohol or while smoking. WARNING! Do not operate your power chair whil e you are under the influence of alcohol, as this may[...]

Jazzy Select Series www.pridemobility.com 17 III. YOUR POWER CHAIR THE JAZZY SELECT SERIES POWER CHAIR The Jazzy Select Series Power Chair has two main assemblies: the seat a ssembly and the power base assembly. See figure 5. Typically, the seat assembly includes the armrests , seatback, and seat base . The power base assembly includes two motor/br[...]

18 www.pridemobility.com Jazzy Select Series III. YOUR POWER CHAIR Figure 7. The Jazzy Select 6 Power Base MAIN CIRCUIT BREAKER Figure 6. The Jazzy Select Power Base REAR SHROUD CONTROLLER CONNECTOR FRONT CASTER WHEELS SEAT POST FRONT COVER REAR CASTER WHEEL REAR SHROUD SEAT POST MAIN CIRCUIT BREAKER CONTROLLER CONNECTOR ANTI-TIP WHEELS CASTER WHEE[...]

Jazzy Select Series www.pridemobility.com 19 Figure 8. The Jazzy Sel ect 6 with Power Seat REAR SHROUD POWER SEAT ACTUATOR MAIN CIRCUIT BREAKER FRONT COVER III. YOUR POWER CHAIR FRONT CASTER WHEELS REAR CASTER WHEEL CONTROLLER CONNECTOR[...]

20 www.pridemobility.com Jazzy Select Series CONTROLLER CONNECTOR III. YOUR POWER CHAIR Figure 9. Jazzy Select Series Electrica l Components (Jazzy Select 6 Shown) Electrical Components The electrical components are located either on or inside the power base . The main circuit br eaker is located on the front of the power base. The power m odule is[...]

Jazzy Select Series www.pridemobility.com 21 Figure 10. Jazzy Select 6 with Power Seat Electrical Components III. YOUR POWER CHAIR CONTROLLER CON NECTOR BATTERY CONNECTORS MOTOR CONNECTOR S MAIN CIRCUIT BREAKER BATTERY CONNECTORS[...]

22 www.pridemobility.com Jazzy Select Series Manual Freewheel Levers Your power chair has a manua l freewheel lever on each motor. Manual fr eewheel levers enable you to disengage the drive motors from the gearboxe s and maneuver the chair manually. WARNING! Do not use the power cha ir while the drive mo tors are disengaged! Do not disengage the dr[...]

Jazzy Select Series www.pridemobility.com 23 IV. ASSEMBLY INITIAL ASSEMBLY Your power chair may require some assembly eith er before initial use or after transportation. NOTE: Any nylon insert lock nut removed during the disassembly or adjustment of the power chair must be replaced with a new nylon insert lock nut. Nylon insert lock nuts should not[...]

24 www.pridemobility.com Jazzy Select Series Seat Installation (Sel ect 6 with Power Seat only) It may be necessary to inst all the seat either prior to initial operation or after transporting your power chair. Most seats are attached to the power base with the Uni- versal Mounting System (UMS). The UMS consists of universal parts that may be attac[...]

Jazzy Select Series www.pridemobility.com 25 Figure 16. Select 6 with Po wer Seat Controller Routing IV. ASSEMBLY Figure 15. Seat Latch Safety ENGAGED DISENGAGED WIRE TIES[...]

26 www.pridemobility.com Jazzy Select Series V. COMFORT ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair’s operation, you may find th e need to make some adjustments to increase your comfort, such as seat height, armrest angle, foot platform height and a ngle, and controller position. Refer to the following informatio[...]

Jazzy Select Series www.pridemobility.com 27 JOYSTICK ACTUATOR LIGHT ACTUATOR KEY ON/OFF KEY ACTUATOR LIGHT ACTUATOR KEY V. COMFORT ADJUSTMENTS Seat Height Adjustment (Sel ect 6 with Power Seat Only) Your power chair is equipped with a power elevating seat. You ca n change the seat height through the controller. To change the seat height: 1. Push t[...]

28 www.pridemobility.com Jazzy Select Series NOTE: The most common configuration of the seat adjustment hardware is shown in figure 19. Your product may be equippe d with a different configuration. All conf igurations operate in a similar manner. Manual Recline Seatback Adjustment If your power chair is equi pped with a manual recline seatback, you[...]

Jazzy Select Series www.pridemobility.com 29 Armrest Height Adjustment To change the armrest height: 1. Loosen the setscrews on the armrest. See figure 19. 2. Raise or lower the armrest to the desired height. 3. Tighten the setscrews to secure the armrest. Controller Position You can move the controller in toward or out away from the armrest, or ch[...]

30 www.pridemobility.com Jazzy Select Series ADJUSTMENT SCREW HARDWARE V. COMFORT ADJUSTMENTS Figure 22. Select 6 and Select 6 with Power Seat Foot Platform Adjustment Foot Platform Height Adjustment The foot platform height is easily adjusted to different heights in 0.5-in. (1.27-cm) increments. To raise or lower the foot platform: 1. Remove the h[...]

Jazzy Select Series www.pridemobility.com 31 Figure 24. Elevating Leg Rests V. COMFORT ADJUSTMENTS Figure 23. Swing-Away Footrests Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the footrests to the side before you transfer onto or off of your power chair. See figure 23. To rotate the SFRs: 1. Push in the release lever. 2. Ro[...]

32 www.pridemobility.com Jazzy Select Series Anti-Tip Wheels (Select Only) The anti-tip wheels are designed to give your power chair increased stab ility on rough surf aces. The anti-tip wheels are preset at the factory for smooth surfaces or indoor use only. If you plan on using your power chair on rough surfaces, it may be necessary to ad just th[...]

Jazzy Select Series www.pridemobility.com 33 BATTERIES AND CHARGING Your power chair uses two l ong-lasting, 12-volt, deep-cycle batteries. Th ese batteries are seal ed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) le vel. Deep -cycle batteries are designed to handle a longer and deeper discharg e. T[...]

34 www.pridemobility.com Jazzy Select Series VI. BATTERIES AND CHARGING Battery Break-in To break in new batterie s for maximum efficiency: 1. Fully recharge any new battery prior to its initial us e. This brings the battery up to about 90% of its peak performance level. 2. Operate your power chair throughout the house and yard. Move slowly at firs[...]

Jazzy Select Series www.pridemobility.com 35  Daily Use If you use your power chair on a daily basis, charge the batteries as soon as you ar e finished using your power chair. Your power chair will be re ady each morning to give you a full da y’s service. It is recommended that you charge the batteries 8 to 14 hours after daily use.  Infreq[...]

36 www.pridemobility.com Jazzy Select Series VI. BATTERIES AND CHARGING It might take a few days for the temper ature of the battery to stabilize and adjust to its new ambient temperature. More importantly, it will take a few “charging cycles” (a partial drain — th en a full recharge) to establish the critical chemical balance that is esse nt[...]

Jazzy Select Series www.pridemobility.com 37 CARE AND MAINTENANCE Your Jazzy is a sophisticated power ch air. Like any motorized vehicle, it requires routine maintenance checks. You can perform some of these checks , but others require assistance from your authorized Pride Provider. Pre- ventive maintenance is very important. If you follow the main[...]

38 www.pridemobility.com Jazzy Select Series  All wheel bearings are prelubricated and seal ed. They require no s ubsequent lubrication.  The body shroud has been sprayed with a clear sealant co ating. You can apply a light coat of car wax to help it retain its high-gloss appearance.  Check all electrical connections. Make sure they ar e t[...]

Jazzy Select Series www.pridemobility.com 39 Yearly Checks Take your power chair to your authorized Pride Provider for yearly maintenance, es pecially if you use your power chair on a daily basis. This helps en sure that your power chai r is functioning properly and helps prevent future complications. Storage Your power chair should be stored in a [...]

40 www.pridemobility.com Jazzy Select Series WARNING! The wheels on your power chair should only be serviced or replaced by an authorized Pride Provider or a qualified technician. WARNING! Be sure that the power to the contro ller is turned off and the power chair i s not in freewheel mode before performing this procedure. WARNING! When changing a [...]

Jazzy Select Series www.pridemobility.com 41 VII. CARE AND MAINTENANCE Battery Replacement A battery wiring diagra m is printed on a decal locate d on the power base. See VI. “B atteries and Charging” for correct batte ry specifications. MANDATORY! Battery posts, terminals, a nd related accessories contain lead and lead compounds. Wear goggles [...]

42 www.pridemobility.com Jazzy Select Series VII. CARE AND MAINTENANCE Figure 29. Battery Installation (Seat Removed for Clarity — Select 6 Shown) CORRECT CONNECTION INCORRECT CONNECTION REAR SHROUD FRONT COVER SIDE COVER FRONT BATTERY YELLOW THUMBSCREWS REAR BATTERY[...]

Jazzy Select Series www.pridemobility.com 43 VII. CARE AND MAINTENANCE When to See Your Authorized Pride Provider for Service The following symptoms could indicate a serious problem with your power chair. If necessary, contact your authorized Pride Provider. When calli ng, have the model number, serial number, nature of the problem, and the error c[...]

44 www.pridemobility.com Jazzy Select Series VIII. WARRANTY FIVE-YEAR LIMITED WARRANTY For five (5) years from the da te of purchase, Pride will re pair or replace at our opti on to the original purchaser, free of charge, any of the following parts found upon exa mination by an authorized representative of Pride to be defective in material and/or w[...]

Jazzy Select Series www.pridemobility.com 45 VIII. WARRANTY SERVICE CHECKS AN D WARRANTY SERVICE Warranty service must be performed by an authorized Pride Provider. Do not return faulty parts to Pride without prior written authorization. All transportation costs and shipping dama ge incurred while submitting parts for repair or replacement are the [...]

46 www.pridemobility.com Jazzy Select Series APPENDIX I – SPECIFICATIONS 1 Varies with base model, user weight, te rrain type, batter y amp hour rating (Ah), ba ttery char ge, battery condition, mo tors, controller type, tire type, and tire condition. This specification can be s ubject to a varia nce of +10%, -5%. 2 Due to manufacturing to leranc[...]

Jazzy Select Series www.pridemobility.com 47 APPENDIX I – SPECIFICATIONS Figure 30. Jazzy Select Dimens ions and Ground Clearance Figure 31. Jazzy Select 6 and Jazzy Select 6 wi th Power Seat Dimensio ns and Ground Clearance 41.75 in. (106.04 cm) 35.75 in. (90.8 cm) 20 in. (50.8 cm) 2.3125 in. – 4.3125 in. (5.87 cm – 10.95 cm) 23.75 in. (60.3[...]

48 www.pridemobility.com Jazzy Select Series NOTES[...]

Jazzy Select Series www.pridemobility.com 49 NOTES[...]

50 www.pridemobility.com Jazzy Select Series NOTES[...]

Jazzy Select 6 with Power Seat Jazzy Select 6 with Power Seat Date Inspected Inspector Inclusion of all Part s Joystick Seri al Number Controller Serial Number Left Motor Se rial Number Right Motor Seria l Number Fit and Finish Performance *INFMANU3351* Product Serial # J AZZY SELECT SERIES Including Models: Jazzy Sele ct, Jazzy Select 6, and Jazzy[...]