Pride Mobility PMV520CRED manual

Owner ’ s Manual Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pri demobility .com The Ultimate In S tyle & Performance ® A TTENTION: R ead ev er ything in this manual before operating y our Scooter[...]

2 Boxter Please read and follow all instr uctions in this owners manual before attempting to oper ate your Scooter for the first time. If there is anything in this man ual you do not understand, or if you requir e additional assistance f or set-up, contact y our local authorized Pride provider . Using y our Pride product safel y depends upon y o[...]

CONTENTS I. INTRODUCTION ........................................................................................................................ 4 II. SAFETY ......................................................................................................................................... 6 III. EMI/RFI ......................................[...]

4 Boxter I. INTRODUCTION W elcome to Pride Mobility Products Corporation (Pride). Congratulations on the purchase of your new Pride Scooter . Y our scooter design combines the most advanced state-of-the-art components with modern, attractive styling. W e are certain that the design features and trouble-free operation will add convenience to your da[...]

5 Boxter I. INTRODUCTION Pride Owners Club As a Pride product owner, you are invited to register your product s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed registration card or by visiting Pride s web site at www .pridemobility .com . As a registered member , each time you visit our [...]

6 Boxter As you begin to use your Boxster during your daily activities, you will encounter situations that, at first, may require some practice to negotiate on your Boxster PMV . Simply take your time as you operate your Boxster and you will soon be in full and confident control as you maneuver through doorways, on and off of elevators, up and down[...]

7 Boxter These tests were conducted with the Boxster  s seat in the highest position and adjusted backward on the seat base to its farthest rearward position. Use this information as a guideline. Y our Boxster  s ability to travel up inclines is af fected by your weight, your PMV s speed, your angle of approach to the incline, and your PMV[...]

8 Boxter SAFETY PRECAUTIONS n Do not operate your new Boxster for the first time without completely reading and understanding this owner  s manual. n Do not carry passengers on your Boxster . n If your Boxster is equipped with a reclining seat, DO NOT operate the vehicle with the seat in the reclined position. n Do not leave the key in the key s[...]

9 Boxter EMI/RFI W ARNINGS Laboratory tests performed by the Food and Drug Administration (FDA) have shown that radio waves can cause unintended motion of electric PMVs. Radio waves are a form of electromagnetic ener gy (EM). When electromagnetic energy adversely af fects the operation of an electrical device, that adverse effect is called Electrom[...]

10 Boxter Has anyone been injured by the erratic, unintended motion of an electric PMV? The FDA has reports of injuries that resulted from uncontrolled motion of electric PMVs, but it is not clear just how many of those injuries were actually caused by EMI/RFI. Are all PMVs susceptible to EMI/RFI? Each make and model of electric PMV dif fers in its[...]

11 Boxter n Be aware that adding accessories and/or components, or modifying your Boxster in any way , may change its EMI/RFI resistance level and may make it more susceptible to interference from radio wave sources. What should I do if my Boxster moves unexpectedly? If unintended motion or unintended brake release occurs, turn of f your Boxster (b[...]

12 Boxter I V . SPECIFICA TIONS 25.5 " 18 " Boxster T urning Radius Boxster Length 5" 24" 70" 75˚ 8 " 59" 18" - 20" 20.5 " 20" 43"- 45" Figure 4. Boxster Dimensions[...]

13 Boxter Specification s Model Numbers PMV520CRED; PMV5 20V BLU; PMV520HGRN; PMV520OBLK Length 59 in. ( 56 in. without fr o nt & rear bumpers ) Wid th 25 .5 i n. Tire s Type: Pneumatic: 4 in. x 13 in. Weight Capacity 300 lbs. m aximum Batter y Type (Batter ies not inc lu ded ) Two 12V, 32 AH, U-1 type, SLA (Seale d Lead Acid) two 12V, 40AH SLA[...]

14 Boxter Y our Boxster is a motorized electric PMV designed to enhance your personal mobility . Y our Boxster is an indoor/outdoor PMV designed to travel primarily on smooth surfaces such as sidewalks, roads, parking lots, floors, and driveways. For easy transportation or storage, you can disassemble your Boxster into seven components. See figure [...]

15 Boxter SPEED ADJUSTMENT DIAL n This dial allows you to pre-select and limit your Boxster  s top speed. n The image of the tortoise represents the slowest speed setting. n The image of the hare represents the fastest speed setting. 4MPH - 8MPH SWITCH This switch limits the Boxster  s top speed to either 4 or 8 mph. THROTTLE CONTROL LEVER n [...]

16 Boxter BA TTER Y CONDITION METER Whenever you have the key fully inserted, this meter gives an approximate reading of your Boxster  s battery voltage. HORN BUTTON n The key must be fully inserted into the key switch for the horn to be operational. n This button activates a warning horn. n Do not hesitate to use the warning horn when you feel [...]

17 Boxter REAR SECTION The on-board battery charger , the charger power cord receptacle, the anti-tip wheels, the batteries (not shown), the electronic controller module, the main circuit breaker reset button, the manual freewheel lever , and the motor/transaxle assembly are located on the rear section of your Boxster . See figure 7. See IX. Dis[...]

18 Boxter BA TTERIES The batteries store the electrical ener gy that powers your Boxster . See VI. Batteries and Char ging. ELECTRONIC CONTROLLER MODULE The electronic controller module is located behind the batteries and at the forward left corner of the Boxster  s rear section. This module receives electrical signals from the control con[...]

19 Boxter Y our Boxster uses two long-lasting, 12-volt, deep-cycle batteries that are sealed and maintenance free. They are recharged by an on-board 3-amp char ging system designed for ease of use and convenience. See figure 7. n Char ge your Boxster  s batteries prior to using it for the first time. n Keep your batteries fully charged to keep y[...]

20 Boxter What does the LED on the Onboard Battery Charger indicate? The green LED turns on after the batteries have been fully charged, In some instances, the green LED may stay on after the charger has been unplugged from the wall outlet. Although users may perceive this as a charger malfunction, it is a normal condition. The green LED goes off w[...]

21 Boxter Use these specifications to reorder deep-cycle batteries: T ype: Deep-cycle (sealed lead-acid, or gel cell) Size: U-1, 40 AH, or NF-22 V oltage: 12 volts each Amperage: 32 AH, 40 AH, 45 AH, 55 AH (amp hours) TO CHANGE A BA TTER Y IN YOUR BOXSTER: 1. Remove the seat and the rear shroud. See IX Disassembly and Assembly . 2. Remove the[...]

22 Boxter More importantly , it takes a few charging cycles (a partial drain followed by a full recharge) to establish the critical chemical balance that is essential to a deep-cycle battery s peak performance and long life. Follow these steps to break in your Boxster s new batteries for maximum efficiency and life. 1. Fully rechar ge any new[...]

23 Boxter GETTING ON YOUR BOXSTER 1. Make certain that the key is removed from the key switch. 2. S tand at the side of your Boxster . 3. Push down on the seat lock lever and rotate the seat until it is facing you. 4. Make certain that the seat is locked securely in position. 5. Position yourself comfortably and securely in the seat. 6. Push down o[...]

24 Boxter NOTE: The r ear wheel drive transaxle gives your Boxster maximum traction with minimal steering effort on your part . GETTING OFF OF YOUR BOXSTER 1. Bring your Boxster to a complete stop. 2. Make certain that the key is removed from the key switch. 3. Push down on the seat lock lever and rotate the seat until you are facing toward the sid[...]

25 Boxter TILLER ANGLE ADJUSTMENT WARNING! R emov e the k ey before adjusting the tiller . Y ou can adjust the tiller to many positions. The tiller adjustment lever locks the tiller in place. It has a spring-loaded mechanism that enables you to rotate it and change its position. LOWER SEA T POST UPPER SEA T POST BALL DETENT PIN LOCA TING HOLES (TIL[...]

26 Boxter FRONT - T O-BACK SEA T ADJUSTMENT Y ou can reposition the Boxster  s seat forward or rear - ward to adjust the distance between the seat and the tiller . See figure 10. 1. Disengage the seat sliding lever . 2. While holding the lever up, slide the seat forward or rearward. 3. Release the seat sliding lever once the seat is in the desir[...]

27 Boxter The Boxster requires no tools for disassembly . Always disassemble or assemble your Boxster on a level, dry surface with sufficient room for you to work and move around your PMV . Keep in mind that the disassembled sections of the Boxster will take up more floor space than the assembled Boxster . DISASSEMBL Y 1. Remove the key from the ke[...]

28 Boxter ASSEMBL Y 1. Pull up on the manual freewheel lever . Putting your Boxster in freewheel may make it easier for you to maneuver the rear section because the drive wheels are free to turn. See figure 7. 2. Position the front and rear sections of your Box- ster as shown in figure 16. 3. Align the lower slots on the rear of the front sec- tion[...]

29 Boxter Any electromechanical device occasionally requires some troubleshooting. However , most of the prob- lems that may arise can usually be solved with a bit of thought and common sense. Many of these problems occur because the batteries are not fully charged or because the batteries are worn down and can no longer hold a charge. What if all [...]

30 Boxter Y our Boxster requires a minimal amount of care and maintenance. If you do not feel confident of your ability to perform the maintenance listed below , you may schedule inspection and maintenance at your authorized Pride provider . The following areas require periodic inspection an or care and maintenance. XI. CARE AND MAINTENANCE TIRE PR[...]

31 Boxter XII. O PTIONAL ACCESSORIES For information concernig these optional accessories see your authorized Pride provider . • Flag • Rear Basket[...]

32 Boxter XIII. W ARRANTY THREE-YEAR LIMITED WARRANTY Structural frame components; including platform, fork, seat post, and frame. Drive train; including transaxle, motor , and brake. First year: 100% replacement of parts cost Second year: 67% replacement of parts cost Third year: 50% replacement of parts cost THREE-YEAR WARRANTY EXCEPTIONS T ransa[...]

33 Boxter There is no other express warranty . Implied warranties, including those of merchantability and fitness for a particular purpose, are limited to one (1) year from the date of original purchase and to the extent permitted by law . Any and all implied warranties are excluded. This is the exclusive remedy . Liabilities for consequential dama[...]

34 Boxter NOTES[...]

INFMANU1298/REV D/JUNE 2001 182 Susquehanna A venue Exeter , P A 18643 1-800-800-8586 www .pridemobility .com[...]