Bakers Pride Oven BCO-G manual

INST ALLA TION AND OPERA TING INSTRUCTIONS Cyclone SERIES G AS CONVECTION O VENS Models: BCO-G and GDCO-G INTENDED FOR OTHER THAN HOUSEHOLD USE. RET AIN THIS MANUAL FOR FUTURE REFERENCE. OVEN MUST BE KEPT CLEAR OF COMBUSTIBLES A T ALL TIMES. This equipment has been engineered to provide you with year round dependable service when used according to [...]

I. INST ALLA TION INSTRUCTIONS Section Item Page A Receiving 2 B Set Up / Mounting 2 C Installation with Casters (Optional) 3 D Location & Minimum Clearances 4 E Gas Connections 4 F Electrical Connection 5 G Flue Connection V entilation 5 H Burner Operation 5 I System Check Rotary Control 5 J Programming Menus 6 II. OPERA TING INSTRUCTIONS A Ge[...]

3 For a single unit: Refer to Figure 4 (1) T ilt Oven over to left-hand side and attach two 31” legs on the right-hand side with three ½” bolts and washers. T ighten firmly . (2) Using proper lifting equipment, lift up the left-hand side and attach two 31” legs on the left-hand side the same way . For a stack of two ovens: Refer to Figure 3 [...]

D. LOCA TION AND MINIMUM CLEARANCES: Move the oven to its final location keeping the minimum clearance from the back of the oven to the wall. This clearance is necessary for safe operation and to provide proper air flow to the burner chamber . MINIMUM CLEARANCES FROM COMBUSTIBLE AND NONCOMBUSTIBLE CONSTRUCTION Under V entilation Hood Direct V entin[...]

F . ELECTRICAL CONNECTION: The oven, when installed, must be electrically grounded in accordance with local codes and/or the latest edition of the National Electrical Code ANSI/NFP A No. 70 in the USA (Canadian Electrical Code CSA Standard C22.1, Part 1 in Canada). In Europe, the appliance must be connected by an earthen cable to all other units in[...]

(4) Press Oven Light switch. Oven light will go on and will go off when switch is released. (5) T urn Gas Cock Dial to “ON” position (only for USA and Canada). (6) T urn the thermostat knob. The indicator light near the thermostat will illuminate and the burners will come on. (7) T urn the T imer Knob and set a time of 2 minutes. At the end of [...]

(6) T urn the timer knob to the desired bake time and timer will start counting down. (7) When timer reaches zero, a buzzer will sound. (8) T urn the timer knob to “O” position. (9) Remove the product from the oven. NOTE: TIMER IS A SIGNAL DEVICE ONL Y AND DOES NOT CONTROL THE OVEN. Cook and Hold Rotary Control: (1) Close the oven doors. (2) T [...]

8 Clean The Stainless Steel Interior: Baked on splatter , oil, grease or discoloration on the stainless steel inside of the oven may be removed with stainless steel cleaner , or any other similar cleaning agent. NEVER use vinegar or any corrosive cleaner . Use only cleaners approved for stainless steel. NEVER use cleaning solvents with a hydrocarbo[...]

9 Motor Blower Wheel Set Screw (2) Wheel Puller Bolt 3/8” Hex Item 1 Item 2 Item 3 E3770A E3771A 3/8”-16 Bolt 1. Attach two item 2 to two item 1 using item 3, 4 and 5. 2. Attach two item 7 to two item 1 using item 3, 4 and 5. 3. U s i n g p r o p e r l i f t i n g equipment attach item 1 to th e c o rr e sp o n di n g ho l e pat te rns l oc ate[...]

B LA CK P 1P 2 P 3 P4 C OM N C N O T6 T 7 T8 T 9 T1 0T 11 BL UE Y EL LO W G R OU N D S TU D P O WE R L IG H T T -S TA T L IG H T S W IT C H L IG H T S 6 0 M IN T IM E R P O W E R S W IT C H D O O R S W IT C H F L A M E SE N S O R IG N IT E R HIGH LOW CENTRIFUGAL SWITCH FAN MOTO R COM 1 20 V WH ITE G RO UN D 2 4V 4 P O S S W IT C H T -S TA T LI G H [...]

WIRING DIAGRAM - BCO-G & GDCO-G 240V , 1 PHASE (DIAL CONTROL) WIRING DIAGRAM - GDCO-G 240V , 1 PHASE (PUSH-BUTTON CONTROL) 1 1 8806658 8806660 B LA C K P 1P 2 P 3 P4 C OM N C N O T6 T 7 T8 T 9 T1 0T 11 BL UE Y EL LO W G R OU N D S TU D P O WE R L IG H T T -S TA T L IG H T S W IT C H L IG H T S 6 0 M IN T IM E R P O W E R S W IT C H D O O R S W [...]

12 PROBLEM CAUSE SOLUTION Food browns unevenly Improper heating temperature. Preheat until desired temperature is reached. Several pans crowded together . Baking pans too large. Use smaller pan. Baking pan dark or glass. Lower oven temperature 25°F (-3.8°C) for this type of pan. Oven temperature too high Lower oven temperature Oven door opened to[...]

P AR TS LIST Model Number: BCO - G & GDCO-G T ype of Gas: Natural L.P . Other 30 Pine Street • New R ochelle • New Y ork • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www .bakerspride.com fax US & Canada web address B AKE R S P RI D E Cyclone SERIES 4/05 Note: When ordering, AL W A YS specify Part #, Model #, Serial #[...]

Exterior / Interior / Controls / Doors 4/05 Note: When ordering, AL W A YS specify Part #, Model #, Serial #, V oltage/Phase & type of Gas. Page 2 of 4 (Not Shown) E8752A KIT , 25" LEGS BLACK W/3" ADJ FEET E8753A KIT , 25" LEGS BLACK W/PLA TE CASTER E8754A KIT , 25" LEGS S/S W/3" ADJ FEET E8755A KIT , 25" LEGS S/S [...]

Item Part # Description Quan Item Part # Description Quan 4/05 Note: When ordering, AL W A YS specify Part #, Model #, Serial #,V oltage/Phase & type of Gas. Page 3 of 4 1 2 3 4 5 6 7 8 9 10 1 1 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 E8189A E8138A M9208A S1 195A E8160A S6810A M1 [...]

16 WHA T IS COVERED This war ranty covers defects in material and workmanship under normal use, and applies only to the original pur chaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is properly installed, adjusted, operated and maintained in accordance with National a[...]