Cal Flame KD6016 manual

[...]

Copyright 2011 LMS, Inc. All rights reserved. Duplication without written consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement progr ams, all models, operation, and/or specications are subject to change without prior notice. L TR50001101, Rev . A 2/1/11 250-391 California Proposition 65 Warn- ing:[...]

1 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Planning the Best Location Here are some of the things that you will need to consider when determin- ing where to place your new barbecue island. Safety First Do not place your barbecue island near trees and shrubs. Be certain that your installation will meet all [...]

2 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Preparing a Good Foundation Y our barbecue island needs a solid and level foundation. Damage caused by inadequate or improper foundation support is not covered by the warranty . It is the responsibility of the owner to provide a proper foundation for the barbecue [...]

3 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Natural Gas Installation Y ou do not need to hire a contractor to install your natural gas service, but you need to make sure you have all required permits and ensure the installation complies with State and local code. We recommend you hire a certied contracto[...]

4 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Assembly This manual describes the assembly for both the KD6002 and KD6016 barbecue islands. Although the model shown in these instructions is the KD6002, assembly for both models is the same except where it is specically called out. Three base slats Base for r[...]

5 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m T wo side pieces Front piece[...]

6 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Counter top Back piece Note: Back piece shown above is for model KD6002. Model KD6016 has an attached shelf .[...]

7 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Assembly Locate the three base slats and place them where the barbecue 1. island will be built. Place the back piece on the base slats as shown. 2.[...]

8 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Do the same for the front piece. 4. Screw the back piece down using the provided screws. 3.[...]

9 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Slide the rst side piece in place. 5. Attach the side piece with four nuts and w ashers as shown below . 6.[...]

10 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Slide the other side piece in place and bolt it to the fr ont and back 7 . frame pieces. Place the granite counter top on the frame. There are ve bolts 8. welded to the bottom of the counter top that go through holes in the fr ame. When all v e bolts are se[...]

11 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Attach the counter top to the fr ame with nuts and washers in ve 9. places. Set the platform for the refriger ator in place. It does not need to 10. be attached to the platform.[...]

12 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m The barbecue island is manufactured as a single unit and is split apart after stucco has been applied. After you have assembled all of the pieces, you may notice a small seam in the stucco. If you wish to eliminate the seam, you can apply a small amount of grout.[...]

13 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Cleaning and Maintenance About Natural Stone A natural characteristic of granite and marble is its inherent lack of uniformity . Because it is a completely natural material, it can have a great deal of variation in color , shade, nish, tint, hardness, strength[...]

14 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Granite Top Clean stone surfaces with a few drops of neutr al cleaner , stone soap (av ailable fr om Monticello Granite) or a mild liquid dishwashing deter- gent and warm water . Use a clean r ag for best results. T oo much cleaner or soap may leav e a lm and [...]

15 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Tile If spillage occurs, then clean up as soon as possible. Care Protect against chipping by using a cutting boar d. • Protect against scratches, especially on natur al stone tiles. • Avoid har d blows that can chip the tile. • Standing water or other liqui[...]

16 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m DO’s and DON’Ts of Tile Care Do test scouring pads in a small area rst. • Do use a silicone sealer on grout joints if continuous staining is a • problem. Do read and follow label directions f or all cleaners. • Do keep this information and r efer to [...]

17 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Stainless Steel All exposed stainless steel surfaces require special attention if you want to keep them looking clean and bright. F ollowing these simple instruc- tions will help avoid scratching or damaging the nish and keep your stainless steel attractiv e. [...]

18 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Cleaning Products and Materials Avoid using these common cleaning products and materials – they will damage the surface of your stainless steel. CLR • Lime-A way • Oven cleaner • Cleansers such as Ajax or Comet • Ammonia • Bleach • Chlorine • Stee[...]

19 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil. Rinse 2. Thoroughly rinse all surfaces and dry them completely with a clean towel. Do not[...]

20 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof . If not properly protected and maintained, it can corrode, pit, and discolo[...]

21 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Cleaning the Interior of Your Grill Thoroughly clean stains, food, and grime using a sponge or damp 1. cloth with warm water and a mild dish soap. Use F antastik or For- mula 409 to remove hea vier soil. Thoroughly rinse all surfaces and dry them completely with [...]

22 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Cooking Grates Use a solution equal parts detergent and hot water just as you would for any cooking equipment. A sti ff wire brush or steel wool may also be helpful in removing grime and f ood deposits. Note Do not use a wire brush or stainless steel on any other[...]

23 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Limited Warranty All Cal Flame barbecue islands are manufactured with the highest qual- ity appliances and are warr anted to be free from defects in material and workmanship at time of delivery . LMS warrants barbecue islands from deterior ation, corrosion, and d[...]

24 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m qualied to repair stone and tile or a service agent licensed to repair gas or electrical appliances. In the event the consumer is unable to obtain satisfactory customer service from the selling dealer or service agent, written notication must be given to th[...]

25 Barbecue Island Assembly L TR50001101, Rev . A w ww . c a l  a m e b b q . c o m Damage caused by dirt, sand, and/or water damage. • Damage caused by salty and humid conditions (especially in beach • or seaside communities) Damage caused by continued operation of the barbecue with ei- • ther known or unknown problems. Damage caused by d[...]

L TR50001101, Rev . A 2/1/11 LMS Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SP AS F ax: 1-909-629-3890 www.calspas.com[...]