Desa (V)T32P manual

NA TU RA L GA S “ T U D O R ” M O D E L ( V ) T 3 2 N , ( V ) T 3 6 N S E R I E S , C H D V 3 2 N R , C T D V 3 6 N R P R O P A N E / L P G A S “ T U D O R ” M O D E L ( V ) T 3 2 P , ( V ) T 3 6 P S E R I E S W ARNING: Improper installation, adjust- ment, alteration, service, or maintenan ce can cause injury or property damage. Refer to th[...]

www .desatech.com 108661-01F 2 SAFETy INFORMA TION W ARNING: This product contains and/or generates          cancer or birth defects, or other reproductive harm. IMPORT ANT : Read this owner ’[...]

www .desatech.com 108661-01F 3 12. Do not use this replace to cook food or burn paper or other objects. 13. Do not use any solid fuels (wood, coal, paper , cardboard, etc.) in this replace. Use only the gas type indicated on replace nameplate. 14. This appliance, when installed, must be electrically grounded in accordance with local codes [...]

www .desatech.com 108661-01F 4 PRE-INST ALLA TION PREP ARA TION    Determine the safest and most efcient location for your DESA direct-vent replace. Make sure that rafters and wall studs are not in the way of the venting system. Choose a location wher[...]

www .desatech.com 108661-01F 5 B C A FRAMING AND FINISHING Fig ure 4 sh ows typ ica l fr ami ng o f th is r ep lac e. F igu re 5 show s fr am - ing fo r c or ner in sta lla ti on. All mi nim um cl ear anc es mu st be met . For available accessories for this replace, see Accessories on page 31. If you are using a separate combustible mantel pi[...]

www .desatech.com 108661-01F 6 Fixed Closed O p en a b l e Fixed Closed Openable V V V V V V V V X X V X G G J F B B K N H I A N E L D B M A C B V V A G G B TERMINA TION CAP AIR SUPPL Y INLET GAS METER RESTRICTED AREA (TERMINA TION PROHIBITED) A = clearance above grade, veranda, porch, deck, or balcony [*12" (30.5 cm) minimum] B = clearance to[...]

www .desatech.com 108661-01F 7 VENTING INST ALLA TION INSTR UCTIONS       attempting installation. These models are tested and approved for use with DESA (direct- vent) pipe components and termination[...]

www .desatech.com 108661-01F 8 Fig ure 10 - Installing Horizontal V ent Cap Wood Screw V ent Cap Apply Mastic to All Four Sides VENTING INST ALLA TION INSTR UCTIONS Continued 2. Direct vent pipe sections and components are designed with special twist-lock connections.    The female ends[...]

www .desatech.com 108661-01F 9 VENTING INST ALLA TION INSTR UCTIONS Continued Figure 1 1 - Installing Siding Standoff V ent Cap (Horizontal T ermination) Interior W all Surface W all Firestop Horizontal V ent Pipe Figure 12 - Connecting V ent Cap with Horizontal V ent Pipe Screw Cut Siding Away to Fit Standoff Wood Screw Screws Standoff V ent Cap A[...]

www .desatech.com 108661-01F 10 V ertical (V) Required Horizontal (H) 32" 36" V ertical Pipe (32"/36")  40 1 / 2 " min. 43 1 / 4 " min. None 30" max. 51 1 / 2 " min. 54 1 / 4 " min. 1 ft. 48" max. 63 1 / 2 " min. 66 1 / 4 " min. 2 ft. 60" max. 75 1 / 2 " min. 78 1 / 4 " m[...]

www .desatech.com 108661-01F 1 1 SNORKEL TERMINA TION INST ALLA TION Recommended Applications: • Installations requiring a vertical rise on building exterior • Any installation using snorkel termination to achieve one foot above ground Snorkel terminations are available for installations requiring a vertical rise on the exterior of the building[...]

www .desatech.com 108661-01F 12                 No t e: V er ti c al re s tr i ct or m us t b e i n st all e d in a ll ve rti c al in s ta l la tio n s. 1. Determine the route your vertical venting will take. If ceiling joists, roof rafter[...]

www .desatech.com 108661-01F 13 VENTING INST ALLA TION INSTR UCTIONS Continued    Figures 21 through 24 show four dif ferent congurations for verti - cal termination. V enting with T wo 90° Elbow s V ertical (V) Horizontal (H 1 ) + Horizontal ([...]

www .desatech.com 108661-01F 14 VENTING INST ALLA TION INSTR UCTIONS Continued HIGH AL TITUDE INST ALLA TION Y our DESA direct-vent replace has been CSA tested and approved for elevations from 0-2000 feet (USA) and elevations from 0-4500 feet (Canada). When installing this replace at an elevation above 2000 feet (in the USA), you may need to [...]

www .desatech.com 108661-01F 15 3. Place the bl ower a gainst the lo wer rea r wall of the rebox outer wrap per wit h th e ex hau st p ort direct ed upward. The blo wer wil l t inside the back opening and be held in position against the back wall by the magnets (see Figure 25). 4. Be certain that all wire terminals are securely attached to te[...]

www .desatech.com 108661-01F 16 FIREPLA CE INST ALLA TION Continued Figure 29 - Blower Wiring Diagram for Thermostat-Controlled Models Blower Wiring Diagram         when servicing controls. Wiring errors[...]

www .desatech.com 108661-01F 17 FIREPLA CE INST ALLA TION Continued For propane/LP connection only , the installer must supply an external regulator . The external regulator will reduce incoming gas pressure. Y ou must reduce incoming gas pressure to between 1 1" and 14" of water . If you do not reduce incoming gas pressure, replace re[...]

www .desatech.com 108661-01F 18 Open FIREPLA CE INST ALLA TION Continued  W ARNING: T est all gas piping and connections for       [...]

www .desatech.com 108661-01F 19 T o Wall Thermostat FIREPLA CE INST ALLA TION Continued INST ALLING OPTIONAL WIRELESS HAND-    ?[...]

www .desatech.com 108661-01F 20 FIREPLA CE INST ALLA TION Continued           -   ?[...]

www .desatech.com 108661-01F 21 FIREPLA CE INST ALLA TION Continued Figure 42 - Installing Rear Brick Panel Figure 43 - Installing Left Side and T op Brick Panels Rear Brick Panel Left Side Brick Panel T op Brick Panel ((V)T36 Series and CTDV36NR Only)     [...]

www .desatech.com 108661-01F 22 FIREPLA CE INST ALLA TION Continued 3. Place log #3 (crossover log) onto the rear and front logs. Make sure it is seated properly on the smooth surface on the front log and on the pin on the back log as shown in Figure 46. 4. Place log #4 (right log) on the pin on the right side of front log as shown in Figure 47. 5.[...]

www .desatech.com 108661-01F 23 OPERA TING FIREPLACE FOR YOUR SAFETY READ BEFORE LIGHTING TO TURN OFF GAS   1. Open lower louver panel. 2. Set selector switch in the OFF position to prevent draining battery . 3. T urn off all electrical power to the appliance if service is to be performed. 4. Push in gas contr ol[...]

www .desatech.com 108661-01F 24 OPERA TING FIREPLACE Continued OPTIONAL HAND-HELD REMOTE OPERA TION Note: All remote contr ol accessories must be purchased sepa- rately (see Accessories , page 31). Follow instructions included with the remote contr ol.       ?[...]

www .desatech.com 108661-01F 25 OPERA TING FIREPLACE Continued INSPECTING b URNERS Check pilot ame pattern and burner ame patterns often. PILOT ASSEMBL Y The pilot assembly is factory preset for the proper ame height. Alterations may have occurred during shipping and handling. Call a qualied service person to readjust the pilot if neces[...]

www .desatech.com 108661-01F 26  Use only the tempered glass door replacement intended for this replace (see Replacement Parts , page 30 for detail on ordering). No substitutions may be made. See Removing/Replacing Glass [...]

www .desatech.com 108661-01F 27 TR OUbLESHOO TING Note: All troubleshooting items are listed in order of operation. W ARNING: T urn off heater and let cool before ser-      and repair heat[...]

www .desatech.com 108661-01F 28 OBSERVED PROBLEM Burner does not light after pilot is lit Delayed ignition burner Burner backring during combustion Slight smoke or odor during initial operation Heater produces a whistling noise when burner is lit Glass soots Fireplace produces a clicking/ticking noise just after burners are lit or shut off Remot[...]

www .desatech.com 108661-01F 29 TR OUbLESHOO TING Continued W ARNING: If you smell gas • Shut off gas supply . • Do not try to light any appliance. • Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor ’ s phone. Follow the gas supplier ’ s instructions.  [...]

www .desatech.com 108661-01F 30 SPECIFICA TIONS   (V)T32N(R) (V)T36N(R) (V)T32P(R) (V)T36P(R) Btu 12,000/18,000 Btu/hr 18,000/26,000 Btu/hr 1 1,000/17,000 Btu/hr 17,000/24,000 Btu/hr Gas T ype Natural Natural Propane/LP Propane/LP Ignition Piezo Piezo Piezo Piezo Manifold Pressure 3.5" w .c. 3[...]

www .desatech.com 108661-01F 31 A CCESSORIES           Purchase these replace accessories from your local retailer . If they can not supply [...]

www .desatech.com 108661-01F 32 ILL USTRA TED P ARTS bREAkDO WN MODELS (V)T32N, (V)T32NB, (V)T32NR, (V)T32NRB, (V)T32P , (V)T32PB, (V)T32PR, (V)T32PRB  6 7 21 18 19 10 13 2 1 1 20 8 22-2 22-6 22-4 22-5 22-3 22-1 1 14 9 12 17 3 15 4 16 5 16 9-3 9-2 9-1 9-13 9-14 9-18 9-15 9-16 9-19 9-4 9-5 9-9 9-7 9-8 9-6 9-12 9-1[...]

www .desatech.com 108661-01F 33 P ARTS LIST MODELS (V)T32N, (V)T32NB, (V)T32NR, (V)T32NRB, (V)T32P , (V)T32PB, (V)T32PR, (V)T32PRB  This list contains replaceable parts used in your replace. When ordering parts, follow the instructions listed under Replacement Parts on page 30 of this manual. KEY NO. P ART NO.[...]

www .desatech.com 108661-01F 34 ILL USTRA TED P ARTS bREAkDO WN MODELS (V)T36N, (V)T36NB, (V)T36NR, (V)T36NRB, (V)T36P , (V)T36PB, (V)T36PR, (V)T36PRB  6 7 21 18 19 10 13 2 1 1 20 8 12 23-1 23-4 23-3 23-6 23-5 23-2 1 14 9 22 17 3 15 4 16 5 16 9-10 9-12 9-4 9-5 9-9 9-7 9-3 9-2 9-1 9-13 9-8 9-14 9-1 1 9-18 9-20 9-1[...]

www .desatech.com 108661-01F 35 VT36NB, VT36NRB (V)T36N, (V)T36NR T36NB, T36NRB VT36PB, VT36PRB (V)T36P , (V)T36PR T36PB, T36PRB     ___ 108080-02 108080-01 Rear Refractory Brick Panel 1 ___ 108081-02 108081-01 T op Refractory Brick Panel 1 ___ 108082-02 108082-01 Right Refractory[...]

LIMITED WARRANTy DIRECT -VENT FIREPLACE DESA warrants this product to be free from defects in materials and components for two (2) years from the date of rst purchase, provided that the product has been properly installed, operated and maintained in accordance with all applicable instructions. T o make a claim under this warranty the Bill of Sal[...]