Frigidaire Electric Patio Grill manual

Grill Assembly Built-In Instructions 5-12 13-15 21-22 16-19 17 20 23[...]

W elcome & Congratulations Please record Grill information for future reference and service work: Model #: Serial #: Date of Purchase: Gas T ype: Please retain this manual for future reference © 2004 Electrolux Home Products, Inc All rights reserved Congratulations on your purchase of a new gas grill! At Electrolux Home Pr oducts , we are very[...]

TESTED IN ACCORDANCE WITH ANSI Z21.58b-2002/CGA 1.6b-M02 ST ANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONL Y . Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1-2002 and the Nationa[...]

3 Grill Featur es: FD30 1. Roll top grill hood 8. W arming shelf 2. Grilling/Cooking surface 9. Infrared back burner 3. Side Shelf 10. Electronic ignitor: main, rear infrared & side burner 4. Control knob: back infrared burner 1 1. Cart w/doorr 5. Control knobs: main burners 12. Ignitor access opening 6. Convection vents 13. Side Burner 7. Hand[...]

Car t Parts 2 L-shaped side pieces 1 U-shaped back side piece 1 Base 2 Wheel channels Car t Door Parts 1 Door handle kit 1 Nylon bushing 1 Door pivot screw and nut Grill Par ts 1 Stainless steel grill head 1 Stainless steel side shelf 1 Side burner (side shelf) 1 Electronic ignitor 5 Flavor grids 3 Stainless steel bar grates 1 Stainless steel warmi[...]

5 Cart Assembly , Door Stops & Door Pivot Bolts 1. Attach the two L-shaped sides to the back portion of the cart, making sure the two holes face up & the key holes are on the top, using the (4) self tapping hex head screws. (See Fig. 1) Note: A power screwdriver is requir ed to install the screws-be cautious not to over -tighten and strip t[...]

Attaching Grill Head to Cart 1. While keeping the Grill on the foam base lean it onto its back. (be sure to hold the hood shut when doing this.) W ith the Grill on its back, loosen all 4 bolts on the bottom side of the Grill, but do not remove.(See Fig. 5) 2. Using 2 self tapping hex head screws, attach the magnetic door catch in the 2 holes in the[...]

Installing the Cart Door Handles 1. Using a 5/32” allen wrench insert 1 screw through the inside of the door front into a bar handle end and tighten securely . (See Fig. 9) 2. Insert Bar Handle into the End Cap attached to the door and then into the other End Cap and tighten End Cap with allen wrench and screw . (See Fig. 10) 3. Complete Door . ([...]

Side Shelf Attachment 1. Attach the shelf to the left side of grill by inserting the shelf hooks into the slots on the side of the grill and pushing down on the shelf assembly until level with grill. (See Fig. 13) 2. Lock the shelf in place by inserting (2) self taping screws into shelf. (See Fig. 14) Interior par ts installation 1. Check to make s[...]

1. Attach the Side Burner to the grill by inserting the shelf hooks into the slots on the side of the grill and pushing down on the shelf assembly until level with the grill (See Fig. 19) 2. Lock the Side Burner in place by re-inserting (2) hex head screws in the front & rear edge of side burner . (See Fig. 20) Note: A power screwdriver extensi[...]

SIDE BURNER P AR TS ASSEMBL Y Install grate over burner (See Fig. 23) LEAK TESTING Make sure all burners are turned to “OFF”. T urn on the gas at the cylinder (LP models) or main valve (Natural models). DO NOT turn on the side burner . Perform a leak test at all connections and fittings by spraying a 50/50 solution of water and soap. If any bub[...]

11 Built-In Instructions Planning and Design Start by identifying the number and size of components you want to include: Grill, side burner , access doors for storage or other items you may wish to furnish such as: refrigerator , sink, warming drawer . Countertops must be constructed with non-combustible, outdoor-safe materials. Consider outdoor li[...]

Built-In Instructions 12 35 1 / 2 ” Max. 27 1 / 2 ” Min. B D E C *Gas Cutout 2” Opening for access door(s) A B C D E A B C D E 30” Grill 30 1 / 8 ” 21 1 / 8 ” 10 15 / 16 ” N/A N/A 30” Grill 30 1 / 2 ” 21 1 / 2 ” 10 15 / 16 ” N/A N/A 26” Grill 26 1 / 8 ” 19 1 / 2 ” 8 5 / 8 ” N/A N/A 26” Grill 26 1 / 2 ” 19 3 / 4 ”[...]

13 General Information V erify the type of gas supply to be used, either Natural Gas (NG) or Liquid Propane (L.P)., and make sure the marking plate (located on the back of the unit) agrees with that of the supply . Note: Never attach an unr egulated gas line to the appliance. For Natural Gas installations, an installer must supply a gas shutoff val[...]

L.P . Gas Installation Frigidaire Gas Grills that are set to operate with L.P . gas come with a high capacity hose and regulator assembly . (Note: Only use the pressur e regulator and hose assembly supplied with the grill or a r eplacement pr essure r egulator and hose assemblies specified by Frigidair e). This assembly is designed to connect direc[...]

General Information Although all gas connections on the grill are leaked tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Periodically check the whole system for leaks, or immediatel[...]

Grill Location Do not use the grill in garages, breezeway , sheds or any enclosed area. Never operate the grill in enclosed areas as this could lead to a carbon monoxide buildup, which could result in injury or death. Place the grill on a level surface. A void moving the grill while it is operation. Note: The grill will operate best if it is not fa[...]

Befor e Lighting W arning: Important! Before Lighting... Check the gas supply line for cuts, wear or abrasion. Always keep your face and body as far away from the grill as possible when lighting. Grill Burner Lighting Lighting the Grill with electronic ignitor Always open the lid before attempting lighting. Push and turn one of the control knobs co[...]

The grill rotisserie system is designed to cook items from the back using infrared heat. The rotisserie burner is an infrared type which provides intense searing radiant heat. Preferred by chefs over other cooking methods, this intense heat is magnificent for searing in the natural juices and nutrients found in quality cuts of meats. Once lit, the [...]

Rotisserie Lighting Open the lid. Push and turn the control knob counter clockwise to the “HIGH” position. W ait 5 seconds . Then press and hold the electronic ignitor button. Y ou’ll hear a snapping sound. If the burner does not light in 4 seconds, turn the control knob to OFF and wait 5 minutes before trying again. Once lit, turn the contro[...]

Drip T ray The drip tray located below the grill, inside the cart, should be cleaned periodically to prevent heavy buildup of debris. Note: Allow the drip tray to cool before attempting to clean. Cooking Grates The cooking grates can be cleaned immediately after cooking is completed and after turning off the flame. W ear a barbecue mitt and scrub t[...]

General T r ouble Shooting Y ou should inspect the burners at least once a year or immediately if any of the following conditions occur: The smell of gas in conjunction with the burner flames appearing yellow . The Grill does not reach temperature. The burners make a popping noise. The Grill heats unevenly . Befor e calling customer service If the [...]

22 Problem Flame is erratic Flare-Ups Burner flame is yellow or orange, in conjunction with the odor of gas. Cart door does not align properly with cart Solution Check gas connection. Fuel level may be low . Grill may be in need of cleaning. Check flavor grids and cooking grates for excess build-up. Ensure Grill is not placed directly in path of wi[...]

LIMITED LIFETIME W ARRANTY If you have other questions, please contact Customer Service Hotline (800) 320-0859 Because of continuing product improvement these specifications are subject to change without notice. 1/2004 23 Frigidaire Grills have a Lifetime W arranty on all stainless steel panels, 15 years on stainless burners and a 5 year warranty o[...]