Guardian Technologies 004270-3 manual

Owner’ s Man ual and Installation Instructions Liquid-cooled Recreational V ehic le Generator • Model: 004270-3 QUIETP A CT™ 75D This manual should remain with the unit.[...]

Generac ® Pow er Systems, Inc. I NTRODUCTION Thank you for purchasing this model of the QUIETP ACT™ product line by Generac P ower Systems, Inc. This model is designed and manufac- tured to supply electrical power for recreational vehi- cles. R EAD THIS MAN UAL THOROUGHL Y If any portion of this manual is not understood, con- tact the nearest Ge[...]

T able of Contents QUI ETP ACT™ 7 5D Recreational V ehicle Generator Generac ® Pow er Systems, Inc. 1 P ar t I – Owner’s Manual Introduction ......................................Inside Front Cover Read This Manual Thoroughly ....................................IFC Contents ....................................................................[...]

2 Generac ® Pow er Systems, Inc. Study these SAFETY RULES carefully before installing, operating , or servicing this equipment. Become familiar with this manual and with the unit. The generator can operate safely , efficiently , and reli- ably only if it is properly installed, operated, and maintained. Many accidents are caused by failing to follo[...]

Generac ® Pow er Systems, Inc. 3 • When working on this equipment, remain alert at all times. Never work on the equipment when physically or mentally fatigued. • Inspect the generator regularly , and contact the nearest Generac Authorized Service Dealer imme- diately for parts needing repair or replacement. • Before performing any maintenanc[...]

4 Generac ® Pow er Systems, Inc. Section 1 – General Information QUI ETP ACT™ 7 5D Recreational V ehicle Generator Please recor d the following information from the generator DA T A DECAL or information decal, located below the user control panel. 1. Model Number ____________________ 2. Serial Number __________________ 3. kW Rating ___________[...]

Generac ® Pow er Systems, Inc. 5 Section 1 – General Information QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.2 GEN ER A T OR AP P LICAB I LIT Y These generators have been designed and manufac- tured for supplying electrical power to recreational vehicles. DO NOT modify the generator nor use it for any application other than for what it[...]

6 Generac ® Pow er Systems, Inc. Section 1 – General Information QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.5.2 F UEL CONSUM PTION (GAL/H R) 1.5.3 ENGI NE OI L R EQ UIRE MEN T S Use a high- quality detergent oil with American P etroleum Institute (API) classification “F or Service CC.” Detergent oils keep the engine cleaner and re[...]

Generac ® Pow er Systems, Inc. 7 Section 2 – Operation QUI ETP ACT™ 7 5D Recreational V ehicle Generator 2.1 GENER A T OR C ONTROL P AN EL The following features are mounted on the generator control panel (Figure 2.1): Figure 2.1 – Generator Control Panel 2.1.1 HO URME TE R This indicates the length of time the engine/generator has operated,[...]

8 Generac ® Pow er Systems, Inc. Section 2 – Operation QUI ETP ACT™ 7 5D Recreational V ehicle Generator 2.3.2 ENGI NE L U BR ICA TION Before starting the engine, have the engine crankcase properly serviced with the recommended oil. Refer to Section 1.5.3 and Sections 3.1 and 3.2 for oil servic- ing procedures and recommendations. Any attempt [...]

Generac ® Pow er Systems, Inc. 9 Section 2 – Operation QUI ETP ACT™ 7 5D Recreational V ehicle Generator 2. If the engine is cold, press the Preheat switch for a maximum of 15 to 30 seconds. 3. While pressing the Preheat switch to crank the engine, hold the engine Start/Stop switch in the ST ART position. When the engine starts, release the sw[...]

10 Generac ® Pow er Systems, Inc. Section 2 – Operation QUI ETP ACT™ 7 5D Recreational V ehicle Generator Figure 2.2 – Engine Protective Devices 2.7 .3 O VERSP EED SH UTDO WN A DC control circuit board senses engine speed from the frequency of the alternator AC output. Should the alternator output frequency exceed approximately 72 Hertz (4,3[...]

Generac ® Pow er Systems, Inc. 11 Section 3 – Maintenance QUI ETP ACT™ 7 5D Recreational V ehicle Generator 2.8.4 OP ERA TION I N H IGH GRASS OR B RUSH Never operate the generator while the vehicle is parked over high grass, weeds, brush, leaves, or other combustible substance. Such materials can ignite and burn from the heat of the exhaust sy[...]

12 Generac ® Pow er Systems, Inc. Section 3 – Maintenance QUI ETP ACT™ 7 5D Recreational V ehicle Generator 8. Screw the new filter on by hand, until its gasket lightly contacts the oil filter adapter . Then, tight- en the filter an additional 3/4 to one turn. 9. Remove the dipstick, and wipe it dry with a clean, lint -free cloth. This will be[...]

Section 3 – Maintenance QUI ETP ACT™ 7 5D Recreational V ehicle Generator Be sure to r einstall the hex pipe cap tightly to the spark arrestor cleanout pipe. Vibration could cause a loose cap to fall out, resulting in hot engine exhaust being drawn through the centrifugal cooling fan and out beneath the unit. This could result in damage to the [...]

14 Generac ® Pow er Systems, Inc. Do not open or mutilate the battery . Released electrolyte has been known to be harmful to the skin and eyes, and to be toxic. The electrolyte is a dilute sulfuric acid that is harmful to the skin and eyes. It is electrically conductive and corrosive. The following procedur es are to be observed: • Wear full eye[...]

Generac ® Pow er Systems, Inc. 15 3.1 2 OUT -OF-SERVICE P ROCEDU R E 3.1 2.1 R EMOV AL F ROM SERVICE Prepare the generator for storage as follows: 1. Start the engine and let it run until it is thoroughly warmed up (at least five minutes), then shut off the engine. 2. While the engine is still warm from running, drain the oil completely (see Secti[...]

3.1 3 SERVICE S CH EDU LE A TTENTION: It is recommended that all service work be performed by the nearest Generac Authorized Service Dealer . SYSTEM/COMPONENT PROCEDURE FREQUENCY X = Action Inspect Change Clean D = Daily W = W eekly R = Replace/Adjust as Needed M = Monthly Y = Y early * = T o Be Completed by a H = Hours Generac Authorized Service D[...]

P ART I I – I NS T ALL A TION I NS TR UCTIONS ONL Y QUALIFIED ELECTRICIANS OR CONTRACTORS SHOULD A TTEMPT INST ALLA TION!! D ANGER[...]

18 Generac ® Pow er Systems, Inc. NO TICE T O I NS T ALLER These Installation Instructions have been published by Generac to aid in the installation of the products described in this manual. Generac assumes that installation personnel are familiar with the procedures for installing such products, or similar products that Generac manufactures. Gene[...]

Generac ® Pow er Systems, Inc. 19 ELE CTR ICAL HA Z AR DS • The generator covered by this manual produces dangerous electrical voltages that can cause fatal electrical shock. A void contact with bare wires, ter- minals, connections, etc., while the unit is running . Ensure all appropriate covers, guards, and barri- ers are in place before operat[...]

20 Generac ® Pow er Systems, Inc. 1.1 P U R POSE AND S C OP E OF TH E MAN U AL These Installation Instructions have been prepared especially for the purpose of familiarizing installers and owners of the applicable equipment with the product's installation requirements. Give serious consideration to all information and instructions in the manu[...]

Generac ® Pow er Systems, Inc. 21 Figure 1.2 – Major Features and Dimensions Section 1 – General Information QUI ETP ACT™ 7 5D Recreational V ehicle Generator Major Features and Dimensions — Drawing No. 0D2 650-A [ .94" ] 595.0 [ 23.43" ] 604 [ 23.78" ] O VER SC REW S 929 [ 36.57" ] O VER SC REW S OIL DIPSTICK O IL FIL [...]

22 Generac ® Pow er Systems, Inc. 2.1 L OCA TION AN D SU P PORT 2.1.1 GEN ERA T OR L OCA TION The most desirable location for the generator set is between the vehicle's main frame members. Many recreational vehicles have been factory- equipped with an area for the generator set. Some may even have a generator compartment provided by the vehic[...]

Generac ® Pow er Systems, Inc. 23 2.1.4 GEN ERA T OR R E STRAI NT Use four 3/8"-16 hardened steel bolts (Grade 5) to fas- ten the generator to the supporting frame or the sup- port tubing . These bolts must pass through (a) the gen- erator mounting base, (b) the compartment floor (if a compartment is used), and (c) the supporting frame- work [...]

24 Generac ® Pow er Systems, Inc. • Seams and joints of the galvanized steel (whether used as a liner or for the compartment itself) must be lapped and mechanically secured. Such seams may be manufactured, welded, bolted, riveted, or screwed. Manufactured lock seams are shown in Figure 2.4. Installer - constructed compartments typically utilize [...]

Generac ® Pow er Systems, Inc. 25 Figure 2.5 – T ypical Noise Abatement 2.2.4 COMP ARTM ENT F L OOR CUT OUTS Provide openings in the generator compartment for the following items (Figure 2.6): • Engine exhaust and cooling air outlets • Generator cooling air inlet and front service door • F our holes for passage of generator mounting bolts.[...]

26 Generac ® Pow er Systems, Inc. 2.3 C OOLI NG AN D VENTI L A TI NG AI R It is absolutely essential that an adequate flow of air for cooling, ventilation, and engine combustion be supplied to the generator set. W ithout sufficient air- flow , the engine/generator quickly overheats. Such overheating can cause serious operating difficulties and als[...]

Generac ® Pow er Systems, Inc. 27 Figure 2.10 – Air Inlet Using Ductwork Figure 2.11 – Air Inlet in V ehicle Skirt 2.3.3 COMP ENS A TING FOR R ES TR ICTIONS Materials, such as, screening, louvers, or expanded metal, can restrict the free flow of air . Compensate for this restriction by making the actual air opening pro- portionately larger . S[...]

28 Generac ® Pow er Systems, Inc. Because diesel fuels are less volatile than gasoline or gaseous fuels, they are considered safer from the standpoint of storage and handling . As a result, installers may tend to be careless in their installation practices, which can result in poor engine perfor- mance. F or example, a poorly tightened fuel line m[...]

Generac ® Pow er Systems, Inc. 29 2.5 EXHAUS T S YS TEM The generator exhaust system must be safely and properly installed. Only approved exhaust system parts must be used. A properly installed exhaust sys- tem must be vapor -tight, quiet, and completely safe. The generator engine gives off DEADL Y carbon monoxide gas through its exhaust system. T[...]

30 Generac ® Pow er Systems, Inc. • Use exhaust system parts recommended by Generac. Using unapproved exhaust mufflers and exhaust system parts is the responsibility of the person(s) installing such unauthorized parts. • Do not terminate the exhaust system under any opening, window , or vent that can be opened or is not permanently sealed from[...]

Generac ® Pow er Systems, Inc. 31 2.6.3.1 Generator Coversion to 1 20 V olts Only — Dual Circuits NOTE: Conversion of a QUIETP ACT™ generator from "120/240 volt dual voltage" to "120 volts only - dual circuits" (or vice -versa) requires rerouting wires within the unit enclosure. It is recommend- ed that this conversion be p[...]

32 Generac ® Pow er Systems, Inc. 2.6.4 CONDU IT Route the connections between the generator and the junction box through approved, flexible conduit. The following general rules apply: • All wiring, conduit, and interconnections must be installed in compliance with applicable codes, standards, and regulations. • Cut wiring to the required leng[...]

Generac ® Pow er Systems, Inc. 33 2.7 B A T TER Y INST ALL A TION 2.7 .1 REC OM M ENDED BA T TER Y Install a battery that meets the following require- ments: • The battery must be a 12-volt, automotive -type storage battery . • Use a battery with minimum ratings of 70 amp - hours and 360 cold- cranking amps. NOTE: If the battery is to be used [...]

34 Generac ® Pow er Systems, Inc. 2.7 .4 B A T TER Y COMP ARTM ENT Install the generator battery in its own, vented com- partment. Place the battery compartment away from any source of heat, sparks, or flame. Provide ventilation openings in the battery compart- ment. The minimum size of openings should be 2 square inches at the top of the compartm[...]

Generac ® Pow er Systems, Inc. 35 3.1 POS T INST ALL A TION TE ST S The generator set was factory-tested and adjusted. It is not necessary to adjust the unit any further , except under special circumstances. Do not make any unnecessary adjustments. Factory settings are corr ect for most applica- tions. When making adjustments, however , be careful[...]

36 Generac ® Pow er Systems, Inc. 3.5 I NS T ALL A TION CH E CKLIST L OCA TION AN D SU PPORT ❑ Generator is properly located. ❑ Generator is properly supported. ❑ Generator is properly restrained. GEN ERA T OR COMP ARTM ENT ❑ Compartment construction is proper . ❑ Holes/Openings are vapor - sealed. ❑ Compartment size is correct. ❑ Co[...]

Generac ® Pow er Systems, Inc. 37 Appendix 1 – T roubleshooting QUI ETP ACT™ 7 5D Recreational V ehicle Generator TROU B LE SHOO TI NG GU I DE P ROB LEM CAUSE C OR R E CTION The engine will not crank. 1. System control fuse blown 1. Replace fuse. 2. Loose corroded or defective 2. Tighten, clean, or replace, battery cables as necessary . 3. Def[...]

38 Generac ® Pow er Systems, Inc. Appendix 2 – Notes QUI ETP ACT™ 7 5D Recreational V ehicle Generator[...]

Generac ® Pow er Systems, Inc. 39 Appendix 2 – Notes QUI ETP ACT™ 7 5D Recreational V ehicle Generator[...]

40 Generac ® Pow er Systems, Inc. Appendix 3 — Electrical Data QUI ETP ACT™ 7 5D Recreational V ehicle Generator Electrical Schematic – 1 20/2 40 V AC Output– Drawing No. 0D2 792-A[...]

Generac ® Pow er Systems, Inc. 41 Appendix 3 — Electrical Data QUI ETP ACT™ 7 5D Recreational V ehicle Generator Electrical Schematic – 1 20/2 40 V AC Output – Drawing No. 0D2 792-A[...]

42 Generac ® Pow er Systems, Inc. Appendix 3 — Electrical Data QUI ETP ACT™ 7 5D Recreational V ehicle Generator Wiring Diagram 1 20/2 40 Dual V oltage– Drawing No. - 0D27 93-B Part 1[...]

Generac ® Pow er Systems, Inc. 43 Appendix 3 — Electrical Data QUI ETP ACT™ 7 5D Recreational V ehicle Generator Wiring Diagram 1 20 V AC– Drawing No. - 0D2 7 93-B Part 2[...]

44 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator Engine, Alternator Drive and Starter Assembly – Drawing No. 0F458 1 ITEM P A RT N O. QT Y . DESCRIPTION 1 0C5598 1 Bearing Carr ier , F ront 2 0C9674 1 Bearing Carr ier , Upper 3 0C6055H 1 Rotor Assembly 4 0C6054H[...]

Generac ® Pow er Systems, Inc. 45 ITEM P A RT N O. QT Y . DESCRIPTION 1 0D2126 1 Base F rame W eldment 2 0D2131 1 Door , Ser vice Rear 3 0C5088 1 Door , Ser vice F ront 4 0C5644 4 Slide Latch Flush 5 056326 2 Vinyl T r im -Black 180mm 6 029451 677mm Rubber T ape 1/8 x ½" 7 0C7857 4 Grommet 1/8 x 13/32 8 070936E 4 Vibration Mount 9 0C6721 1 G[...]

46 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator Enclosure – Drawing No. 0D23 58-E ITEM P A RT N O. QT Y . DESCRIPTION 1 0D2315 1 Enclosure Panel RH 2 0C4534 1 Enclosure Panel T op 3 0C4532 1 Enclosure Panel LH 4 0C4535 1 Enclosure Panel F ront 5 0C4536 1 Enclos[...]

Generac ® Pow er Systems, Inc. 47 ITEM P A RT N O. QT Y . DESCRIPTION 1 0C4551 1 Cover Plate , Scroll W eldment 2 0C4550 1 Housing, F an Scroll Weldment 3 0C4552 1 F an, Squirrel Cage 4 0C4554 1 Shaft, F an 5 0C4555 1 Carrier, Bearing 6 0C4557 1 Ke y , Square 3/16" x 3/16" x ½" 7 0C4556 1 Pulley , Fan 4-7/8" 8 0C4553 1 Bearing[...]

48 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator Electrical Enclosure Assembly – Drawing No. 0D23 6 1 -E 19 17 16 5 14 11 15 28 27 25 26 6 0 12 2 20 1 4 3 9 31 7 25 26 27 28 13 28 8 18 33 3 2 27 29 3 1 11 ITEM P A RT N O. QT Y . DESCRIPTION 1 0D2412 1 Weldment, [...]

Generac ® Pow er Systems, Inc. 49 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator Intake and Exhaust System – Drawing No. 0F45 83 ITEM P A RT N O. QT Y . DESCRIPTION 1 075674 1 EXHA UST GASKET 2 0C7564 1 VINYL CLAMP 1.94 3 0C4880 1 AIR FIL TER 4 0F4366 1 HOSE, AIR INLET 5 0C4727 1 MUFFLER WELDM[...]

50 Generac ® Pow er Systems, Inc. TO GLOW PLUG S 17 17 17 2 6 1 0 8 25 2 2 6 12 1 3 4 4 1 9 4 5 28 30 1 2 27 12 1 5 12 2 0 M O T O R B O L T T O S TARTE R 1 6 T O S TARTER M O T OR 6 1 6 2 9 2 3 14 4 9 7 21 1 6 27 1 8 T O S TAT OR 7 2 5 2 1 0 11 3 9 22 24 T O G R OU N D 4 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreati[...]

Generac ® Pow er Systems, Inc. 51 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator Customer Controls Assembly – Drawing No. 0D23 64-E ITEM P A RT N O. QT Y . DESCRIPTION 1 080825 1 Star t / Stop Switch 2 0C4540 1 Cover , Engine Control Box 3 0C1457 1 Hour Meter 4 081904 1 Fuse Holder , SFE-14 5 [...]

52 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Camshaft – Drawing No. 0F62 30 9 8 1 0 1 3 6 5 4 5 2 7 ITEM P ART N O . QT Y . DESCRIPTION 1 0F28730164 1 CAMSHAFT ASSEMBL Y 2 0709390233 1 CAMSHAFT GEAR 3 0709390195 1 KEY 4 0709390234 1 GEAR 5 0[...]

Generac ® Pow er Systems, Inc. 53 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Cylinder Block– Drawing No. 0F62 2 7 ITEM P A RT N O. QT Y . DESCRIPTION 1 0F28730100 1 COMPLETE CYLINDER BLOCK 2 0709390104 1 BLANK PLUG 3 0F28730101 1 SEALING CAP 4 0F2730102 2 SEALING CAP 5 0F2[...]

54 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Cylinder Head – Drawing No. 0F45 84 1 6 1 5 3 2 1 3 6 1 8 5 17 1 0 11 8 2 7 9 12 4 1 14 3 ITEM P ART N O . QT Y . DESCRIPTION 1 0F28730118 1 CYLINDER HEAD ASSEMBL Y 2 0F28730119 8 SEALING CAP 3 0F[...]

Generac ® Pow er Systems, Inc. 55 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Crankshaft, Piston and Flywheel – Drawing No. 0F62 29 ITEM P ART N O . QT Y . DESCRIPTION 1 0F28730152 1 COMPLETE CRANKSHAFT 2 0709390194 1 CRANKSHAFT GEAR 3 0709390195 1 KEY 4 0709390196 1 DOWEL [...]

56 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Oil Pump – Drawing No. 0F62 31 12 2 4 3 6 11 1 0 1 9 8 7 ITEM P ART NO. QT Y . DESCRIPTION 1 0709390250 1 IDLER GEAR ASSEMBL Y 2 0709390251 1 THRUST W ASHER 3 0709390252 1 SPRING 4 0709390253 1 RO[...]

Generac ® Pow er Systems, Inc. 57 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Rocker Arm Assembly – Drawing No. 0F62 28 ITEM P A RT N O. Q TY . DESCRIPTION 1 0F28730128 1 ROCKER ARM ASSEMBL Y 2 0F28730129 3 INT AKE ROCKER ARM 3 0F28730130 3 EXHA UST ROCKER ARM 4 0709390173 [...]

58 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Injector Pump – Drawing No. 0F62 35 ITEM P A RT N O. QT Y . DESCRIPTION 1 0F28730200 1 INJECTION PUMP ASSEMBL Y 2 0F28730201 1 ADJUSTING SHIM SET 3 0709390298 2 NUT 4 0F28730202 2 BOL T 5 0F287302[...]

Generac ® Pow er Systems, Inc. 59 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel F uel Supply – Drawing No. 0F623 8 ITEM P A RT N O. QT Y . DESCRIPTION 1 0F28730215 1 FUEL FIL TER SUPPORT ASSEMBL Y 2 069858 1 FUEL FIL TER 3 0C8008 AR HOSE, 5/16" SAE 30R7 4 0C8008 250MM HO[...]

60 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel T iming and Governor – Drawing No. 0F623 2 ITEM P A RT N O. QT Y . DESCRIPTION 1 0F28730186 1 HOUSING, TIMING GEAR 2 0709390286 1 SPRING PIN 3 0F28730187 1 GASKET 4 0709390288 1 OIL SEAL 5 0F28730[...]

Generac ® Pow er Systems, Inc. 61 Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel Engine Block – Drawing No. 0F4585 ITEM P A RT N O. QT Y . DESCRIPTION 1 0709390139 1 OIL P AN 2 0709390140 20 BOL T 3 0F28730116 1 BOL T 4 0709390142 1 SEAL W ASHER 5 0C4641 1 DIPSTICK TUBE 6 0D71[...]

62 Generac ® Pow er Systems, Inc. Appendix 4 — Exploded Views and P ar ts Lists QUI ETP ACT™ 7 5D Recreational V ehicle Generator 1.0 Liter Diesel W ater Pump – Drawing No. 0F45 86 4 3 5 1 9 2 0 5 2 12 14 17 1 5 1 6 1 8 1 3 11 1 7 9 1 0 7 8 6 21 ITEM P A RT N O. QT Y . DESCRIPTION 1 0F28730169 1 W A TER PUMP ASSEMBL Y 2 0F28730170 1 GASKET 3[...]

Generac ® Pow er Systems, Inc. 63 Appendix 5 — Notes QUI ETP ACT™ 7 5D Recreational V ehicle Generator[...]

64 Generac ® Pow er Systems, Inc. Appendix 6 – W arranty QUI ETP ACT™ 7 5D Recreational V ehicle Generator F EDER AL AN D CALI FOR N IA EM IS SIONS CONTROL W AR R ANT Y S T A TEM ENT (for non-road Diesel engines rated under 19 kW) Y OU R W AR R ANT Y R IGHTS AND OB LIGA TIONS The U .S. Environmental Protection Agency (EP A), the California Air[...]

Generac ® Pow er Systems, Inc. 65 Appendix 6 – W arranty QUI ETP ACT™ 7 5D Recreational V ehicle Generator OB LIGA TIONS AN D R IGHTS OF THE MAN UF ACTUR ER AN D OWNER The new model year , class of diesel engine, and emission application determination for your engine are identified on the emission control information label affixed to the right[...]

Part No. 0F4474 Revision 0 (04/06/05) Printed in U.S.A. Appendix 6 – W arranty QUI ETP ACT™ 7 5D Recreational V ehicle Generator GENERA C PO WER SYSTEMS’ THREE-YEAR LIMITED W ARRANTY FOR GU ARDIAN RECREA TIONAL VEHICLE GENERA TORS NO TE: ALL UNITS MUST BE INST ALLED BY GENERA C PO WER SYSTEMS A UTHORIZED SER VICE F ACILITIES. F or a period of[...]