Heat & Glo LifeStyle DAKOTA-AU manual

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 1 Installation & Operation Instructions MODEL: Dakota-AU Australian Gas Association Certi fi cation Number: 7145 This manual must be used for installation and retained by Homeowner for operation and maintenance. This product may be covered by one or more of the follo[...]

2 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Read this manual before installing or operating this fi replace. Please retain this owner ’ s manual for future reference. Congratulations on selecting a Heat & Glo LifeStyle Collec- tion gas fi replace—an elegant and clean alternative to wood burning fi repl[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 3 T able of Contents 1 Listing and Code Approvals 4 A. Fireplace Certi fi cation . . . . . . . . . . . . . . . . . . . . . . . . . 4 2 Getting Started 4 A. Design and Installation Considerations . . . . . . . . . . . . 4 3 Framing and Clearances 5 A. Select Fireplace Loc[...]

4 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 1 1 Listing and Code Approv als A. Design and Installation Considerations 2 2 G ett ing Star ted Before installation check that local distribution conditions, nature of gas and pressure, and adjustment of the fi replace are compatible. This fi replace must be installe[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 5 A E Note: If this surface is inside the building’s warm air envelope... ...then this surface must be an exterior wall system. B C D D B C E D 1.47 M 2.08 M Note: • Illustrations re fl ect typical installations and are FOR DESIGN PURPOSES ONL Y . • Illustrations/d[...]

6 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 B. Clearances 1.17 m 1.17 m Header height. Use only non-combustible material below the top of the top standoffs. 629 mm 1.24 m 2.13 m to ceiling 0 mm 0 mm to level of stando ffs Combustible Object 914 mm Combustible flooring may be installed next to the front of the app[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 7 An enclosure with walls on all sides, but at least one permanent opening at ground level and no overhead cover . Figure 3.3 Four Sides and a Permanent Opening C. Outdoor Enclosure Options Any enclosure in which the appliance is used shall comply with one of the followin[...]

8 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 4 4 Fireplace Preparation Sharp Edges • Wear protective gloves and safety glasses during installation. CAUTION A. Remove Logs and Shipping Cover Remove locking screw at the top of the doors (shown in Fig- ure 4.1). Open the doors by sliding the handles toward the outs[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 9 5 5 Gas Infor mation Note: G as line MUS T be r un from right side of fi replac e. W ARNING CHECK FOR GAS LEAKS Fire Risk Explosion Risk Asphyxiation Risk • Check all fi ttings and connections. • Do not use open fl ame. • After the gas line installation is comp[...]

10 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Batt er y p o la r it y m us t be c or r e ct o r m o du le da ma ge w il l occur . CAUTION 6 6 El ectr ical Inform ation Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. V erify proper operation [...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 1 1 A. Mantel Projections Figure 7.1 shows the minimum vertical dimension of fi replace mantels or other combustible projections above the top front edge of the fi replace. Mantel B A 2.13 m minimum ceiling height Overhang 305 mm max. combustible mantel depth Figure 7.1[...]

12 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Sealant Material 0 mm. 0 mm. 0 mm. Finish wall material may be combustible, top & sides. Upper front can be covered with non-combustible material or removed and replaced with non-combustible material. Fire Risk Do NOT obstruct air inlet or outlet grilles. Do NOT mo[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 13 A. Clean the Fireplace Clean/vacuum any materials that may have accumulated inside the fi rebox. Figure 8.1 Back Legs in Grate Brackets (front view) 8 8 Fireplace Setup Figure 8.5 Left Rear Log (SRV728) (front view) Figure 8.3 Right Rear Log (SRV720) (front view) C. P[...]

14 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Figure 8.9 Front Log (SRV727) (front view) Figure 8.7 Left Side Log (SRV723) (front view) Place the fork of log onto the left front bar and rest its back on left rear log. Place front log in front of the main grate with its left end resting on left side log as shown. F[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 15 Place right front corner log between the right side wall and right side grate bar as shown. Place right side log against the rightmost front grate bar and rest its rear on right rear log, angled towards the corner as shown. Place right center log between the 4th and 5t[...]

16 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Handle glass with care. • Inspect the glass for cracks, chips or scratches. • Do NOT strike, slam or scratch glass. • Do NOT operate fi replace with glass door removed, cracked, broken or scratched. • Replace glass door assembly as a complete assembly . W ARNI[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 17 Fire Risk Burn Risk HOT! DO NOT TOUCH. SEVERE BURNS MA Y RESUL T . CLOTHING IGNITION MA Y RESUL T Glass and other surfaces are hot during operation and cool down. W ARNING • Supervise young children when they are in the area of the appliance. • CAREFULL Y SUPER VIS[...]

18 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 C. Lighting the Fireplace Electronic Ignition LIGHTING INSTRUCTIONS T O TURN OFF GAS T O FIREPLACE 1. Push the ‘OFF’ button on remote. 2. Remove batteries from receiver . FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly [...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 19 • Prevent accidental fi replace operation when not attended. • Remove batteries from remote switch if absent or if fi replace will not be used for an extended period of time. • Property damage possible from elevated temperatures. CAUTION Fire Risk Keep combusti[...]

20 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Although the frequency of fi replace servicing and maintenance will depend on use and the type of installation, a quali fi ed service technician should perform an fi replace check-up annually . Debris from any outside source and/or soot must be removed from the fi [...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 21 A. V alve Access and Service Figure 10.1 Lift Out Doors Figure 10.3 Loosen Refractory Retaining Strip Figure 10.4 Remove V alve Access Panel Figure 10.5 Remove Exterior V alve Access Panel Figure 10.6 Connect Manometer • The gas valve can be accessed behind the cemen[...]

22 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 B. Battery Replacement • Remove switch cover plate from the control box. • Slide access panel. • Replace four AA batteries. • Replace access panel and switch cover plate. Ground Wire Control Box Switch Cover Plate Access Panel Batteries Ensure ground wire is at[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 23 C. Maintenance and Service T asks: Inspect Maintenance T asks Doors, surrounds and fronts 1 Inspect for scratches and nicks that can lead to breakage when exposed to heat. 2 Verify no obstructions to air fl ow through the louvers. 3 Verify proper clearance to combusti[...]

24 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 With proper installation, operation and maintenance your gas fi replace will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a quali fi ed service person in the diagnosis of a problem and the corrective ac[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 25 A. Fireplace Dimension Diagram Dimensions are actual fi replace dimensions. Use for reference only . For framing dimensions and clearances refer to Sec- tion 3. Figure 12.1 Fireplace Dimensions 1 2 12 Refere nce Materials 1.22 m 1.07 m 587 mm 943 mm 171 mm 1.12 m 787 [...]

26 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 B. Service Parts List Service Parts Diagram Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date: June 2007 Ending Manufacturing Date: Active 25 16 17 18 22 20 21 24 24 26 27 19 28 4 7 10 10 15 14 13 12 11 11 8 3 2 1 1 9 23 5 6 Left Door A[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 27 Service Parts List Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date: June 2007 Ending Manufacturing Date: Active # Description of Part DAKOT A-AU DAKOT A LP-AU Qty . req. 1 Door Grille Bar 4036-177 4036-177 4 2 T op Door Support Assemb[...]

28 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Service Parts Diagram Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date: June 2007 Ending Manufacturing Date: Active 17 15 16 18 25 2 1 13 14 12 4 5 7 8 10 6 9 11 3 3 21 22 23 24 19 20[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 29 Service Parts List Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date:June 2007 Ending Manufacturing Date: Active # Description of Part DAKOT A-AU DAKOT A LP-AU Qty . req. 1 ON/OFF Gas V alve 15697 15697 1 2 Flex Assembly 2098-022 2098-0[...]

30 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 Service Parts Diagram Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date: June 2007 Ending Manufacturing Date: Active  SRV720 SRV722 SRV723 SRV724 SRV728 SRV740 SRV742  SRV727 [...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 31 Service Parts List Outdoor Gas Fireplace Service Parts DAKOT A-AU SERIES Beginning Manufacturing Date: June 2007 Ending Manufacturing Date: Active # Description of Part DAKOT A-AU DAKOT A LP-AU Qty . req. Log Set - Box 1 of 3 4036-71 1 4036-71 1 1 Log SRV720 SRV720 1 L[...]

32 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 This page intentionally left blank.[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 33 This page intentionally left blank.[...]

34 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 For Service or Replacement Parts Contact: Melbourne Jetmaster 444 Swan Street Richmond 3121 (03) 9429-5573 Sydney Jetmaster 10 Martin A venue Arncliff 2205 (02) 9597-7222 Perth Fireplace Corner 277 Lord Street East Perth 6000 (08) 9228-2600[...]

Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 35 C. W arranty HEA T & GLO LIFESTYLE COLLECTION LIMITED 10 YEAR W ARRANTY In order to presumptively establish the dates to which your HEA T & GLO Limited Warranty runs, you must mail the completed warranty card to HEA T & GLO, 20802 Kensington Boulevard, Lake[...]

36 Heat & Glo Lifestyle Collection • Dakota-AU• 4036-914 Rev B • 06/07 D. Contact Information Please contact your Heat & Glo LifeStyle Collection dealer with any questions or concerns. For the number of your nearest Heat & Glo LifeStyle Collection dealer , please refer to page 34 of this manual or visit www .heatnglo-lifestyle.com[...]