IBM MT 9442 manual

T hinkP a d ® Z6 1t Hard w ar e M a in t e n a n c e Ma nu a l October 2007 This manual supports: ThinkPad Z61t (MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448)[...]

[...]

T hinkP a d ® Z6 1t Hard w ar e M ain t e n an c e Ma nu a l[...]

Note Before using this information and the pr oduct it supports, be sure to read the general information under “Notices” on page 163. Third Edition (October 2007) © Copyright Lenovo 2006, 2007. All rights reserved. LENOVO products, data, computer softwar e, and services have been developed exclusively at private expense and are sold to governm[...]

Contents About this manual . . . . . . . . . .1 Introduction . . . . . . . . . . . . .3 Important service information . . . . . . . .3 Strategy for replacing FRUs . . . . . . . . .3 Strategy for replacing a har d disk drive . . . .4 Important notice for replacing a system boar d . .4 How to use error messages . . . . . . . .4 Strategy for replacing[...]

iv MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

About this manual This manual contains service and refer ence information for ThinkPad ® Z61t (MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448) products. Use this manual along with the advanced diagnostic tests to troubleshoot pr oblems. The manual is divided into sections as follows: v The common sections provide general information, guidelines, [...]

2 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

Introduction Important service information Important BIOS and device driver fixes are customer -installable. The BIOS and device drivers are posted on the customer support site http://www.lenovo.com/ support Advise customers to contact the Customer Support Center at 800-426-7378 if they need assistance in obtaining or installing any software fixes,[...]

Attention: The setup configuration on the computer you are servicing may have been customized. Running Automatic Configuration may alter the settings. Note the current configuration settings (using the V iew Configuration option); then, when service has been completed, verify that those settings remain in ef fect. Strategy for replacing a hard disk[...]

v The PEW recor d is the 4-digit MT and 3-digit model, where model = “CT O” (Example: 1829-CTO). v eSupport will show both the CTO and CMV machine type models (Example: 1829-CTO and 1829-W15 will be found on the eSupport site.) v The HMM will have the 4-digit MT and 3-digit CTO model only (Example: 1829-CTO). Again, CMVs ar e custom models and [...]

For the Remaining FRUs (the complete list of FRUs at the MT Model level) v eSupport can be used to view the complete list of FRUs for a machine type and model. v To view the complete list of FRUs, type in the machine type and model (Example: 1829-CTO) under QUICK P A TH. Under “V iew by Document T ype” select PA R T S INFORMA TION. Under “Fil[...]

Diskette compatibility matrix The compatibility of each of the drives with the diskettes for it is as follows: Diskette drive Diskette capacity Compatibility 3.5-inch 1.0 MB Read and write 2.0 MB Read and write 4.0 MB Not compatible Safety notices: multilingual translations In this manual, safety notices appear in English with a page number refer e[...]

Safety notice 2 D ANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery , recharge it, throw it into fire or water , or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery [...]

Safety notice 3 D ANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water , or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result[...]

Safety notice 4 D ANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector , disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water . Dispose of the battery as required by local ordinances or regulations. Use only the battery in the app[...]

Safety notice 5 Safety notice 6 D ANGER If the LCD breaks and the fluid fr om inside the LCD gets into your eyes or on your hands, immediately wash the affected ar eas with water for at least 15 minutes. Seek medical care if any symptoms fr om the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous[...]

Safety notice 7 D ANGER Safety notice 8 D ANGER Though the main batteries have low voltage, a shorted or grounded battery can produce enough current to burn personnel or combustible materials. Bien que le voltage des batteries principales soit peu élevé, le court-circuit ou la mise à la masse d’une batterie peut produire suffisamment de couran[...]

Safety information The following section presents safety information with which you need to be familiar before you service a ThinkPad computer . General safety Follow these rules to ensur e general safety: v Observe good housekeeping in the area of the machines during and after maintenance. v When lifting any heavy object: 1. Make sure that you can[...]

Important Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electr ostatic discharges. Do not use this type of mat to[...]

v Do not service the following parts with the power on when they are r emoved from their normal operating places in a machine: – Power supply units – Pumps – Blowers and fans – Motor generators and similar units. (This practice ensures corr ect grounding of the units.) v If an electrical accident occurs: – Use caution; do not become a vic[...]

9. Check that the power-supply cover fasteners (scr ews or rivets) have not been removed or tamper ed with. Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electr ostatic discharge (ESD.) ESD damage can occur when there is a dif fe[...]

Laser compliance statement Some models of ThinkPad computer are equipped fr om the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requir ements of the Department of Health and Human [...]

A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: D ANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio lase[...]

General descriptions The descriptions in this chapter apply to any ThinkPad model that has the PC-Doctor ® for DOS diagnostics program. Some descriptions might not apply to your particular computer . Read this first Before you go to the checkout guide, be sur e to read this section. Important notes v Only certified trained personnel should service[...]

Following is a list of some common items that are not cover ed under warranty and some symptoms that might indicate that the system was subjected to stress beyond normal use. Before checking pr oblems with the computer , determine whether the damage is covered under the warranty by r eferring to the following list: The following are not covered und[...]

Related service information This section provides information about the following: v “Service We b site” v “Restoring the factory contents by using Product Recovery discs” v “Passwords” on page 22 v “Power management” on page 24 Service We b site When the latest maintenance diskette and the system program service diskette become ava[...]

A total progr ess bar allows you to audit this process, which will take about 8 minutes. The final recovery disc may be safely r emoved during this time, but may also be left in the optical drive since it is not bootable. 7. Yo u will then be prompted to r estart the computer . Select Ye s . A warning window appears, giving you one last chance to s[...]

Attention: If the user HDP has been for gotten, check whether a master HDP has been set. If it has, it can be used for access to the hard disk drive. If no master HDP is available, Lenovo does not provide any services to r eset either the user or the master HDP , or to recover data fr om the hard disk drive. The har d disk drive can be replaced for[...]

How to remove the hard-disk password Attention: If User only mode is selected and the user HDP has been forgotten and cannot be made available to the servicer , Lenovo does not provide any services to reset the user HDPs or to r ecover data from the hard disk drive. The hard disk drive can be r eplaced for a scheduled fee. To remove a user HDP that[...]

Standby mode When the computer enters standby mode, the following events occur in addition to what occurs in screen blank mode: v The LCD is powered of f. v The hard disk drive is power ed off. v The CPU stops. To enter standby mode, press Fn+F4. Note: If you are using the ACPI operating system, you can change the action of Fn+F4. In certain circum[...]

Also, the computer goes into hibernation mode automatically in either of the following conditions: v If a “hibernation time” has been set on the timer , and if the user does not do any operation with the keyboard, the T rackPoint, the hard disk drive, the parallel connector , or the diskette drive within that time. v If the timer conditions are[...]

Checkout guide Use the following procedur es as a guide in identifying and correcting problems with the ThinkPad computer . Note: The diagnostic tests are intended to test only ThinkPad pr oducts. The use of non-ThinkPad products, pr ototype cards, or modified options can lead to false indications of errors and invalid system r esponses. 1. Identif[...]

Note: In the following procedur e, you can select an item not only with the arrow keys, but also with the T rackPoint pointer . Instead of pressing Enter , click the left button. 1. Insert the PC-Doctor disk into the diskette drive; then power on the computer . If the computer cannot be powered on, go to “Power system checkout” on page 30, and [...]

The options on the test menu are as follows: Diagnostics Interactive T ests v Run Normal T est v Run Quick T est v CPU/Coprocessor v Systemboard v V ideo Adapter v Serial Ports v Parallel Ports v Fixed Disks v Diskette Drives v Other Devices v ThinkPad Devices v Communication v W ir eless LAN v Memory T est – Full v Memory T est – Quick v Keybo[...]

Detecting system information with PC-Doctor PC-Doctor can detect the following system information: Hardware Info v System Configuration v Memory Contents v Physical Disk Drives v Logical Disk Drives v VGA Information v IDE Drive Info v PCI Information v PNPISA Info v SMBIOS Info v VESA LCD Info v Hardwar e Events Log Utility v Run External T ests v[...]

Checking the ac adapter Yo u are her e because the computer fails only when the ac adapter is used. v If the power problem occurs only when the port r eplicator is used, replace the port replicator . v If the power-on indicator does not turn on, check the power cor d of the ac adapter for correct continuity and installation. v If the computer does [...]

Note: If the battery pack becomes hot, it may not be able to charge. Remove it from the computer and leave it at r oom temperature for a while. After it cools down, reinstall and r echarge it. To check the battery pack, do the following: 1. Power off the computer . 2. Remove the battery pack and measure the voltage between battery terminals 1, 2 (-[...]

ThinkPad Z61t Product overview . . . . . . . . . . . .3 4 Specifications . . . . . . . . . . . . .3 4 Status indicators . . . . . . . . . . . .3 7 FRU tests . . . . . . . . . . . . . .3 9 Fn key combinations . . . . . . . . . .4 1 Symptom-to-FRU index . . . . . . . . . .4 4 Numeric error codes . . . . . . . . . .4 4 Error messages . . . . . . . . .[...]

Product overview This section presents the following pr oduct-unique information: v “Specifications” v “Status indicators” on page 37 v “FRU tests” on page 39 v “Fn key combinations” on page 41 Specifications The following table lists the specifications of the ThinkPad Z61t: Feature Description Processor v Intel ® Celeron ® M Proc[...]

Feature Description Optional memory v 256-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 1 v 512-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 1 v 1-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card × 1 v 2-GB DDR2-533 SDRAM SO-DIMM (PC2-4200) card × 1 (maximum of 2048 MB) CMOS RAM v 256 bytes Hard disk drive v 40 GB, 5400 rpm, 9.5 mm high, S ATA interface [...]

Feature Description PCI Express Mini car d for wireless LAN v ThinkPad 1 1a/b/g W ireless LAN Mini PCI Expr ess Adapter v Intel PRO W ireless 3945ABG Mini-PCI Expr ess Adapter v ThinkPad 1 1a/b/g/n W ireless LAN Mini-PCI Expr ess Adapter PCI Express Mini car ds for wireless WA N v Sierra W ireless EV -DO W ireless WA N Mini PCI Express Adapter v Si[...]

Status indicators The system status indicators show the status of the computer , as follows: 11 123456789 1 0 8 9 10 Product overview ThinkPad Z61t 37[...]

Indicator Meaning 1 W ireless LAN status Green: The wireless featur e (the IEEE 802.1 1 standard) is on, and the radio link is ready for use. Blinking green: Data is being transmitted. 2 Bluetooth status R Note: Some models do not have this indicator . Green: Bluetooth wireless is operational. This indicator is on when Bluetooth wireles[...]

Indicator Meaning 9 AC power status Green: The computer is connected to the ac power supply . 10 Standby status Green: The computer is in standby mode. Blinking green: The computer is entering standby mode or hibernation mode, or is resuming normal operation. 11 Ultrabay Slim status Green: An Ultrabay Slim device is installed and [...]

FRU Applicable test Keyboard 1. Diagnostics --> Systemboard --> Keyboard 2. Interactive T ests --> Keyboard Hard disk drive Enter the BIOS Setup Utility and change Serial ATA ( S ATA ) setting to Compatibility , and run Diagnostics --> Fixed Disks Yo u can also diagnose the hard disk drive without starting up the operating system. To di[...]

Fn key combinations The following table shows the function of each combination of Fn with a function key . Key combination Description Fn+F1 Reserved. Fn+F2 Reserved. Fn+F3 Select a power scheme that has been created by Power Manager . When you press this combination, a panel for selecting a power scheme appears. Notes: 1. To use the Fn+F3 key comb[...]

Key combination Description Fn+F7 Apply a presentation scheme dir ectly , with no need to start Presentation Dir ector . To disable this function and use the Fn+F7 key combination for switching a display output location, start Presentation Dir ector , and change the settings. Switch a display output location v External monitor (CR T display) v Comp[...]

Key combination Description Fn+F10 Reserved. Fn+F1 1 Reserved. Fn+F12 Put the computer into hibernation mode. To return to normal operation, press the power button for less than four seconds. Note: To use Fn+F12 for hibernation, you must have the ThinkPad PM device driver installed on the computer . Fn+PgUp T urn the ThinkLight on or off. Note: Thi[...]

Symptom-to-FRU index The symptom-to-FRU index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: Do the FRU replacement or other actions in the sequence shown in the column headed “FRU or action, in sequence.” If replacing a FRU does not solve the problem, put the [...]

Symptom or error FRU or action, in sequence 0190 Critical low-battery error 1. Charge the battery pack. 2. Battery pack. 0191 System Security—Invalid Remote Change requested. 1. Run BIOS Setup Utility , and then save current setting by pressing F10. 2. System board. 0192 System Security— Embedded Security hardwar e tamper detected. System board[...]

Symptom or error FRU or action, in sequence 0252 Password checksum bad—The passwor d is cleared. Reset the password by running BIOS Setup Utility . 0260 System timer error . 1. Charge the backup battery for more than 8 hours by connecting the ac adapter . 2. Replace the backup battery and run BIOS Setup Utility to reset the time and date. 3. Syst[...]

Symptom or error FRU or action, in sequence 2000 Hard Drive Active Pr otection sensor diagnostics failed. Press <Esc> to continue. Press <F1> to enter SETUP 1. Undock docking station or port replicator if it is attached to the ThinkPad computer , and place the computer on a horizontal surface. Do not apply any physical shock to the comp[...]

Error messages Symptom or error FRU or action, in sequence Device address conflict. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Allocation error for device. 1. Load “Setup Defaults” in the BIOS Setup Utility . 2. Backup battery . 3. System board. Failing bits: nnnn. 1. DIMM . 2. System board. In[...]

Beep symptoms Symptom or error FRU or action, in sequence One beep and a blank, unreadable, or flashing LCD. 1. Reseat the LCD connector . 2. LCD assembly . 3. External CR T . 4. System board. One long and two short beeps, and a blank or unreadable LCD. 1. System board . 2. LCD assembly . 3. DIMM. Tw o short beeps with error codes. POST error . See[...]

LCD resolution Bright dots Dark dots Bright and dark dots XGA, WXGA 5 6 6 WXGA+, SXGA+, WSXGA+ 5 8 10 UXGA, WUXGA, QXGA 5 13 13 Notes: 1. Lenovo will not provide r eplacement if the LCD is within specification as we cannot guarantee that any replacement LCD will have zer o pixel defects. 2. A bright dot means a pixel is always on (white or color .)[...]

Intermittent problems Intermittent system hang problems can be due to a variety of causes that have nothing to do with a hardwar e defect, such as cosmic radiation, electrostatic discharge, or softwar e errors. FRU replacement should be consider ed only when a problem r ecurs. When analyzing an intermittent problem, do the following: 1. Run the dia[...]

FRU replacement notices This section contains notices related to r emoving and replacing parts. Read this section carefully befor e replacing any FRU. Screw notices Loose screws can cause a r eliability problem. In the ThinkPad computer , this problem is addr essed with special nylon-coated screws that have the following characteristics: v They mai[...]

v “Retaining the UUID” v “Reading or writing the ECA information” Restoring the serial number of the system unit When the computer was manufactured, the EEPROM on the system boar d was loaded with the serial numbers of the system and all major components. These numbers need to remain the same thr oughout the life of the computer . If you re[...]

To check what ECAs have been previously applied to the machine, use the ECA Information Read/W rite function on the ThinkPad Hardware Maintenance Diskette V ersion 1.73 or later . 1. Insert the ThinkPad Hardwar e Maintenance Diskette V ersion 1.73 or later , and restart the computer . 2. From the main menu, select 6. Set ECA Information . 3. To rea[...]

Removing and replacing a FRU This section presents dir ections and drawings for use in removing and replacing a FRU. Be sure to observe the following general r ules: 1. Do not try to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before r eplacing any FRU, review “FRU r epl[...]

1010 Battery pack D ANGER Unlock the battery release lever 1 . Holding the battery r elease lever in the unlocked position 2 , remove the battery pack in the dir ection shown by arrow 3 . 1 2 3 When installing: Install the battery pack along the slide rails of the slot. Then make sure that the battery r elease lever is locked, as [...]

1020 Ultrabay Slim device Note Ultrabay Slim does not accept any of the following devices: v Ultrabay Plus devices v Ultrabay 2000 devices Note: When you release the switch in step 1 , the lever pops out. In step 2 , pull the lever a little to release the device fr om the bay . 1 2 3 Removing and replacing a FRU ThinkPad Z61t 57[...]

1030 Hard disk drive cover , hard disk drive, and hard disk drive rubber rails For access, remove this FRU: v “1010 Battery pack” on page 56 Attention v Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock. Impr oper handling can cause damage and permanent loss of data. v Before r[...]

3 2 4 5 When installing: Make sure that the har d disk drive connector is attached firmly . (continued) Removing and replacing a FRU ThinkPad Z61t 59[...]

6 6 When installing: Rubber rails of the hard disk drive must be attached to the replacement drive. Otherwise the har d disk drive cannot be properly installed to the computer . Removing and replacing a FRU 60 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

1040 Palm rest or palm rest with fingerprint reader For access, remove this FRU in or der: v “1010 Battery pack” on page 56 Note In models with the fingerprint reader , the sensor has been attached to the palm rest FRU as the child part. If the fingerprint r eader has any defects and needs to be replaced, you need to r eplace the palm rest by t[...]

2 3 4 Removing and replacing a FRU 62 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

When installing the palm rest, do as the following pr ocedure. 1. Attach the touch pad connector firmly . 2. Attach the palm rest as shown in this figur e. 1 2 (continued) Removing and replacing a FRU ThinkPad Z61t 63[...]

3. Press the left-top edge and the right-top edge of the palm r est to latch the palm rest to the frame firmly . 4. Close the LCD cover and turn over the computer . 5. Fasten the provided scr ews to secure the palm r est in order as shown in this figure. 1 4 3 2 Removing and replacing a FRU 64 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

1050 DIMM For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 2 1 1 When installing: Insert the notched end of the DIMM into the socket. Press the DIMM firmly , and pivot it until it snaps into the place. Make sure that it is fixed firmly in the slot a[...]

1060 Keyboard For access, remove this FRU: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 1 Step Icon Screw (quantity) Color T orque 1 M2 × 14 mm, flat-head, nylon-coated (1) Black 0.196 Nm (2.0 kgfcm) Lift the keyboard a little in the dir ection shown by arrow 2 , and then [...]

When installing: Make sure that the keyboar d edges a are under the frame as shown in this figure. a a Removing and replacing a FRU ThinkPad Z61t 67[...]

1070 Modem daughter card (MDC-1.5) For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 2 1 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) In step 2[...]

T urn the card over 3 , and detach the modem connector 4 . 4 3 When installing: Make sure that the modem connector and the connector on the underside of the card ar e attached firmly . Removing and replacing a FRU ThinkPad Z61t 69[...]

1080 PCI Express Mini card for wireless WA N For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 In steps 1a and 1b , unplug the jacks by using the removal tool for antenna RF connector (P/N: 08K7159), or pi[...]

3 When installing: Plug the red cable into the jack labeled MAIN on the card, and the blue cable into the jack labeled DIV . Removing and replacing a FRU ThinkPad Z61t 71[...]

1090 PCI Express Mini card for wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 In steps 1a and 1b , unplug the jacks by using the removal tool for antenna RF connector (P/N: 08K7159), or pic[...]

3 When installing: Plug the gray cable into the jack labeled MAIN on the card, and the black cable to the jack labeled AUX . Removing and replacing a FRU ThinkPad Z61t 73[...]

1 100 PCI Express Mini card for 802.1 1 a/b/g/n wireless LAN For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 In steps 1a , 1b , and 1c , unplug the jacks by using the removal tool for antenna RF co[...]

3 When installing: Plug the gray cable (MAIN) into the jack labeled TR1 , the white cable (3rd) into jack labeled R0 , and the black cable (AUX) into jack labeled TR2 on the card. Removing and replacing a FRU ThinkPad Z61t 75[...]

111 0 Backup battery D ANGER For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 2 1 When installing: Make sure that the battery connector is attached firmly . Use only the battery specified in the parts list for your c[...]

1 120 Keyboard bezel For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1060 Keyboard” on page 66 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 1 1 Step Screw (quantity) Color T orque 1 M2 × 14 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) (continued) Removing and repla[...]

2 2 2 2 3 Step Screw (quantity) Color T orque 2 M2 × 3 mm, flat-head, nylon-coated (4) Black 0.196 Nm (2.0 kgfcm) 3 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.196 Nm (2.0 kgfcm) 4 4 5 5 Removing and replacing a FRU 78 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

1 130 Speaker assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel” on page 77 1 1 1 1 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (4) Black 0.196[...]

3 3 2 When installing: Make sure that the speaker cables ar e routed along the cable guides 3 and that the connector 2 is attached firmly . 5 5 4 4 4 4 4 Removing and replacing a FRU 80 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

1 140 SIM card slot For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel” on page 77 1 2 Step Screw (quantity) Color T orque 1 M2 × 3 mm, flat-head, nylon-coated (1) Black 0.196 Nm (2.[...]

1 150 Fan assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel” on page 77 v “1 130 Speaker assembly” on page 79 1 1 Step Screw (quantity) Color T orque 1 M2 × 5 mm, flat-[...]

When installing: v Before you attach the fan assembly to the computer , apply thermal gr ease on the part marked a as in the following figure. a v Make sure that the fan connector is attached firmly . v When attaching the fan assembly to the frame, take care not to damage the heat sink ( b ) of the fan assembly . b b Removing and replac[...]

1 160 CPU For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1 120 Keyboar d bezel” on page 77 v “1 150 Fan assembly” on page 82 Attention: CPU is extr emely sensitive. When you service the CPU, avoid any ki[...]

1 170 Wireless WA N antenna (DIV) For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1080 PCI Express Mini car d for wireless W AN” on page 70 Strip the tape that secures the wir eless WA N antenna 1 , and[...]

1 180 LCD assembly For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 PCI Express Mini ca[...]

4 4 2 3 a a b In step 3 , release the antenna cables fr om the cable guides. Step Screw (quantity) Color T orque 4 M2 × 5 mm, flat-head, nylon-coated (2) Black 0.245 Nm (2.5 kgfcm) When installing: 1. Make sure that the antenna cables ar e routed along the cable guides. In the parts indicated by circle a in the figur e, do not te[...]

5 5 Removing and replacing a FRU 88 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

1 190 Base cover For access, remove these FRUs, in or der: v “1010 Battery pack” on page 56 v “1020 Ultrabay Slim device” on page 57 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 58 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “[...]

In step 2 , lift the MG frame a little in the direction shown by the arr ow , and then remove it in the dir ection shown by arrow 3 . Attention: Befor e step 2 , be sur e that the Ultrabay Slim device eject lever is not popped out and it is housed in its position properly as shown in the figur e a . 2 3 a Removing and replac[...]

Note: Applying labels to the base cover When you replace the base cover , you need to stick some labels on the new base cover . Some of the labels have been shipped with the new base cover , and some may need to be reused fr om the old base cover . Following labels are the typical labels stuck on the bottom side of the computer when it is shipped. [...]

1200 USB sub card with cable For access, remove these FRUs, in or der: v “1010 Battery pack” on page 56 v “1020 Ultrabay Slim device” on page 57 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 58 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on p[...]

1210 MG (Magnesium) frame For access, remove these FRUs, in or der: v “1010 Battery pack” on page 56 v “1020 Ultrabay Slim device” on page 57 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 58 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1050 DIMM” on page 65 [...]

Remove the ac power jack cable a and the modem cable b . 1 2 3 3 4 b a When installing: Make sure that the connectors 1 and 3 ar e attached firmly , and that the cables are r outed as in the figure above. (continued) Removing and replacing a FRU 94 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

Remove the CPU support plate c . 5 6 c 5 5 Step Screw (quantity) Color T orque 5 M2 × 3 mm, flat-head, nylon-coated (6) Black 0.196 Nm (2.0 kgfcm) 9 9 7 7 7 7 7 8 8 Step Screw (quantity) Color T orque 7 M2 × 3 mm, flat-head, nylon-coated (5) Black 0.196 Nm (2.0 kgfcm) 8 M2 × 9 mm, flat-head, nylon-coated (2) Black 0.196 N[...]

Remove the system board and the PC Car d slot assembly from the MG frame together , in the direction shown by arrow 11 . 10 10 11 When installing: Attach the system board so that the two small pr ojections on the MG frame 10 fit into the holes provided, and then secur e the system board with the scr ew . Removing and replacing a FRU 96 [...]

1220 System board and PC Card/ExpressCard slot assembly For access, remove these FRUs, in or der: v “1010 Battery pack” on page 56 v “1020 Ultrabay Slim device” on page 57 v “1030 Hard disk drive cover , har d disk drive, and hard disk drive rubber rails” on page 58 v “1040 Palm rest or palm r est with fingerprint reader” on page 61[...]

Important notice for handling the system board When handling the system board, bear the following in mind. v At every point in the process, be sur e not to drop or stack the system board. v The system board has an acceler ometer , which can be broken by applying several thousands of G-forces. Note: Dropping a system boar d from a height of as littl[...]

Following components soldered on the system boar d are extremely sensitive. When you service the system board, avoid any kind of r ough handling. a Accelerometer chip for the HDD Active Pr otection System b MCH (Memory ControllerHub) c ICH (I/O Controller Hub) d Security chip e CPU a d e b c Removing and replacing a FR[...]

2 2 2 2 1 Step Screw (quantity) Color T orque 2 M2 × 5 mm, flat-head, nylon-coated (4) Black 0.196 Nm (2.0 kgfcm) T urn over the system board, and then disconnect the PC Car d slot assembly from the system board. 3 When installing: v Make sure that the connector of PC Car d slot is attached to the system board firmly . v When you attach the [...]

2010 LCD front bezel For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 PCI Express Mini [...]

In step 3 , while sliding the LCD latch lever in the direction shown by the arr ow , remove the bezel in the dir ection shown by arrow 4 . 2 2 2 2 2 2 2 2 3 4 Removing and replacing a FRU 102 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

2020 Inverter card For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 PCI Express Mini ca[...]

2030 Bluetooth daughter card (BDC-2) For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 P[...]

When installing: Make sure that connector is attached firmly , and that the car d is attached to the guide as in this figure. Removing and replacing a FRU ThinkPad Z61t 105[...]

2040 Wireless WA N antenna cable (MAIN) or wireless LAN 3rd antenna cable For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wi[...]

When installing: In step 2 , press the part indicated by the arr ow until it snaps into place. 1 3 1 2 Cable routing: Route the antenna cable as shown in this figure. In the part indicated by circle a , do not tense the cable. To do so, the cable may get damaged by the hinge, and may cause a broken wir e. a Removing and replacing a FRU [...]

2050 Integrated camera For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 PCI Express Min[...]

2060 LCD panel, LCD cable, and hinges For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page 70 v “1090 [...]

3 5 4 6 (continued) Removing and replacing a FRU 11 0 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

Remove the hinges a from the LCD panel. 7 7 7 7 8 8 a a Step Screw (quantity) Color T orque 7 M2 × 3 mm, small-head, nylon-coated (4) Silver 0.196 Nm (2.0 kgfcm) Remove the LCD cable assembly b from the LCD panel. 9 10 b When installing: When replacing any LCD FRUs, be sur e not to pinch the antenna cables. Make sure that the cab[...]

2070 LCD rear cover and wireless LAN antenna cables For access, remove these FRUs in or der: v “1010 Battery pack” on page 56 v “1040 Palm rest or palm r est with fingerprint reader” on page 61 v “1060 Keyboard” on page 66 v “1070 Modem daughter card (MDC-1.5)” on page 68 v “1080 PCI Express Mini car d for wireless W AN” on page[...]

Remove the LCD latches before you r emove the antenna cables. 3 4 5 (continued) Removing and replacing a FRU ThinkPad Z61t 11 3[...]

When installing: Attache the latches as shown in this figure. 3 4 1 2 7 6 6 6 6 7 (continued) Removing and replacing a FRU 11 4 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

Cable routing: Route and secure the antenna cables as shown in the following figures. W ireless LAN antenna cable (AUX: black) a (continued) Removing and replacing a FRU ThinkPad Z61t 11 5[...]

W ireless LAN antenna cable (MAIN: gray) a Removing and replacing a FRU 11 6 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

Locations Front view 1 ThinkLight 2 Status indicators Note: For the description of each indicator , see “Status indicators” on page 37. 3 W ireless WA N antenna or wireless LAN 3rd antenna (for some models) 4 Security key hole 5 Universal serial bus (USB) connectors 6 Ultrabay Slim status indicator 7 Ul[...]

Rear view 1 Status indicators Note: For the description of each indicator , see “Status indicators” on page 37. 2 RJ-45 (Ethernet) connector 3 RJ-1 1 (modem) connector 4 External monitor connector 5 AC power connector 6 V ideo-out connector 1 2 3 4 5 6 Bottom view 1 Battery pack 2 Battery pack lat[...]

Parts list Overall 1 2 3 4 6 5 9 8 7 10 12 11 13 14 16 b 17 c 18 19 21 23 24 22 20 15 a d Parts list ThinkPad Z61t 11 9[...]

v Each FRU is available for all types or models, unless specific types or models are specified. v FRU with specific models listed and described as xxU (where U is an example of a country designator) should be used for all models ending in U. v FRU with specific models listed and described as 3Dx (where 3D is an example of a unique configuration) sh[...]

No. FRU FRU no. RoHS ID CRU ID 3 Palm rest assembly with fingerprint r eader v 9440-CTO, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Px, 2Qx, 2Tx, 31x, 32x, 33x, 34x, 35x, 36x, 37x, 38x, A8x, ACx, ADx, AGx, AHx, AJx, AKx, AMx, ANx, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, B6x, B7x[...]

No. FRU FRU no. RoHS ID CRU ID 4 Magnesium base frame with speakers v 9440-CTO, 24x, 27x, 29x, 2Ax, 2Bx, 2Cx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 36x, 37x, 38x, A4x, A5x, A6x v 9441-CTO, 34x, 45x, 49x, 4Ax, 4Bx, 4Cx, 4Fx, 4Gx, 4Jx, 4Kx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 4Sx, 4Tx, 51x, 52x, 53x, 54x, 56x, 57x, 58x, 59x, 5Ax, 5Bx,[...]

No. FRU FRU no. RoHS ID CRU ID 4 Magnesium frame v 9440-CTO, A8x, ACx, ADx, AGx, AJx, AKx, AMx, ANx, B6x, B7x, B8x, B9x, BAx, BCx, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BMx, BNx, BPx, C1x, C2x, C3x, C4x, C5x, C7x, C8x, CEx, CFx, CGx, D4x, D5x, D6x, D7x, D8x, D9x, DAx, DBx, DCx, DFx, DGx, DHx, DJx, DKx, DLx, DYx v 9441-CTO, K2x, K3x, K4x, K5x, K6x, K7x[...]

No. FRU FRU no. RoHS ID CRU ID 6 Intel PRO W ireless 3945ABG Mini-PCI Expr ess Adapter v 9440-CTO, 21x, 23x, 24x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Tx, 36x, 37x, 38x, A8x, ACx, ADx, AGx, AHx, AJx, AKx, ANx, B8x, B9x, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BMx, C1x, C2x, C3x, C4x, C7x, CEx, C[...]

No. FRU FRU no. RoHS ID CRU ID 7 Sierra W ireless EV -DO W ireless WA N PCI Express Mini Adapter v 9440-CTO, 27x, 2Ax, 2Bx, 2Cx, 36x, 37x, 38x, ADx, DAx, DBx, DCx, DFx, DGx, DHx, DJx, DKx, DLx v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 41W1 177 R ** Sierra W ireless MC8755 PCI Expr ess MiniCard v 9440-CTO, 2Hx, 2Jx, CEx v 9441-CTO, 4Bx, 4Cx, 6Hx, [...]

No. FRU FRU no. RoHS ID CRU ID 11 System board assembly with Intel Graphics Media Accelerator 950, Entry v 9440-CTO, 2Kx, 2Nx, 2Rx, 2Sx v 9441-CTO, 42x, 43x, 44x, 4Hx v 9442-CTO, 44x, 78x, 7Ax v 9443-CTO v 9448-CTO, 8Ax, 8Dx 41W1282 R N System board assembly with Intel Graphics Media Accelerator 950 v 9440-CTO, 21x, 22x, 23x, 24x, 25x, 26x, 27x, 28[...]

No. FRU FRU no. RoHS ID CRU ID 11 System board assembly with Intel Graphics Media Accelerator 950, DVI OA2 v 9440-CTO, A5x, A6x, A7x, A8x, ACx, ADx, AGx, AHx, AJx, AKx, AMx, ANx, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, B6x, B7x, B8x, B9x, BAx, BCx, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BMx, BNx, BPx, C1x, C2x, C3x, C4x, C5x, C6x[...]

No. FRU FRU no. RoHS ID CRU ID 13 Battery pack, Li-ion (4 cell) v 9440-CTO, 21x, 22x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, A4x, A5x, A6x, A7x, A8x, ACx, ADx, AGx, AHx, AJx, AKx, AMx, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, B6x, B7x, B8x, B9x, BAx, B[...]

No. FRU FRU no. RoHS ID CRU ID 14 DVD/CD-R W combo drive, 9.5mm v 9440-CTO, 21x, 22x, 25x, 26x, 27x, 2Kx, 2Lx, 2Nx, 2Sx, 2Tx, A4x, A5x, A6x, A7x, A8x, AHx, ARx, ASx, A Tx, A Vx, B2x, B3x, B4x, B5x, BGx, BHx, C1x, C3x, C6x, C7x v 9441-CTO, 41x, 42x, 43x, 44x, 45x, 47x, 4Dx, 4Fx, 4Gx, 4Hx, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Kx, 5Lx, 5Mx, 5Nx, 5[...]

No. FRU FRU no. RoHS ID CRU ID 15 Base cover for 8747 WW v 8747-CTO 42W3601 R N T aiwan v 8747-CTO 42W3603 R N Base cover for 8749 WW v 8749-CTO 42W3602 R N T aiwan v 8749-CTO 42W3604 R N Base cover for 9440 WW v 9440-CTO, xxU, xxF , xxL, xxP , xxS, xxY , xxG, xxM, xxQ, xxA, xxT , xxB, xxH, xxC, xxE, xxJ, xxK 41W4845 R N T aiwan v 9440-CTO, xxV 41W[...]

No. FRU FRU no. RoHS ID CRU ID 17 256-MB DDR2-667 SDRAM SO-DIMM (PC2-5300) card OP v 9440-CTO, 21x, 2Kx, 2Sx, 2Nx, 4Dx, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 7Px, 8Ax, 8Dx, A4x, A5x, K5x, RCx v 9441-CTO, 4Dx, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, K5x v 9442-CTO, 7Px, RCx v 9443-CTO v 9448-CTO, 8Ax, 8Dx 40Y8401 R ** 512-MB DDR2-6[...]

No. FRU FRU no. RoHS ID CRU ID 17 1-GB DDR2-667 SDRAM SO-DIMM (PC2-5300) card OP v 9440-CTO, 24x, ADx, AMx, ANx, B6x, B7x, BAx, BCx, DYx, C5x, CEx v 9441-CTO, 4Ax, 4Cx, NAx, NBx v 9442-CTO, 4Ax, 4Cx, 7Jx, 7Mx, CKx, CLx, CMx, CNx, P5x, R3x, R5x, R9x, RBx, RNx, RV x v 9443-CTO, 9Ex, 9Fx, 9Gx, 9Lx, 9Mx, 9Px, 9Qx, 9Rx, 9Sx, 9Tx v 9448-CTO 40Y8403[...]

No. FRU FRU no. RoHS ID CRU ID 18 Hard disk drive, 80 GB, 9.5 mm, 5,400 rpm v 9440-CTO, 27x, 28x, 2Dx, 2Fx, A7x, A8x, AHx, APx, AQx, ARx, ASx, A Wx, B1x, B2x, B3x, BDx, BFx, BGx, BHx, C1x, C3x, CFx, CGx v 9441-CTO, 4Gx, 4Sx, 4Tx, 51x, 52x, 53x, 54x, 55x, 56x, 6Fx, 6Lx, 6Mx, K1x, K3x, K8x, K9x, KVx, M1x, M2x, M3x, M4x, M5x, M6x, M7x, MBx, MCx, MDx, [...]

No. FRU FRU no. RoHS ID CRU ID 20 CPU assembly , Intel Celeron M processor 410 (1.46 GHz) v 9440-CTO, 21x, 25x, 2Kx, 2Nx, 2Sx, 31x v 9441-CTO, 53x, 54x, 55x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5Lx, 5Mx, 5Nx, 5Px, 67x, 6Lx, 6Mx, 6Nx, 6Px, 6Qx, 6Rx v 9442-CTO v 9443-CTO v 9448-CTO 41W5181 R N CPU assembly , Intel Ce[...]

No. FRU FRU no. RoHS ID CRU ID 20 CPU assembly , Intel Core Duo processor T2300 (1.66 GHz) v 9440-CTO, 24x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Rx, 2Tx, 33x, 36x v 9441-CTO, 44x, 45x, 47x, 4Sx, 4Tx, 5Ux, 5Wx, 66x, 6Gx, 6Hx, 7Dx, E1x, E3x v 9442-CTO, 26x, 44x, 45x, 72x, 7Ax, 7Dx, 7Px, 8Gx, E1x, E3x v 9443-CTO, 45x, 7Dx, 96x, 98x, 9Ex, 9Fx, 9Gx, 9Hx, E1x,[...]

No. FRU FRU no. RoHS ID CRU ID 20 CPU assembly , Intel Core 2 Duo processor T7200 (2.0 GHz) v 9440-CTO, ADx, AKx, AMx, B6x, B7x, B8x, B9x, C5x, C8x, D3x, D6x, D9x, DCx, DHx, DLx, DYx v 9441-CTO, K9x, KHx, KJx, KMx, KNx, MJx, MKx, MNx, N2x, NDx v 9442-CTO, C3x, C4x, C5x, P2x, P3x, P4x, P6x, PBx, PCx, PDx, PFx, PGx, PHx, PJx, PMx, PMx, RNx, RPx, R Tx[...]

No. FRU FRU no. RoHS ID CRU ID 22 Fan and thermal device v 9440-CTO, 21x, 22x, 23x, 24x, 25x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Kx, 2Lx, 2Mx, 2Nx, 2Px, 2Qx, 2Rx, 2Sx, 2Tx, 31x, 32x, 33x, 34x, 35x, 36x, 37x, 38x, A4x, A5x, A6x, A7x, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, C6x v 9441-CTO, 2Dx, 41[...]

LCD FRUs e d a b 1 7 9 8 10 11 3 2 4 5 6 c Parts list 138 MT 8747, 8749, 9440, 9441, 9442, 9443, and 9448[...]

14.0-in. WXGA (200nit) TFT No. FRU FRU no. RoHS ID CRU ID a - e See “Miscellaneous parts” on page 159. 1 LCD front bezel without camera, ster eo microphones v 9440-CTO, 21x, 22x, 23x, 25x, 26x, 28x, 2Dx, 2Kx, 2Tx, 31x, 32x, 33x, 34x, 35x, A4x, A5x, A6x, A7x, AHx, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, D1x, D2x, D3x v 944[...]

No. FRU FRU no. RoHS ID CRU ID 4 Hinge pair , Z61t v 9440-CTO, 22x, 23x, 25x, 26x, 28x, 2Dx, 2Tx, 31x, 32x, 33x, 34x, 35x, A6x, A7x, AHx, D1x, D2x, D3x v 9441-CTO, 2Dx, 47x, 4Hx, 6Fx, 6Jx, 6Kx, MNx, MRx, MTx v 9442-CTO, 2Dx, 2Lx, 71x, 74x, 75x, 7Sx, PBx, PFx, R1x, R2x, R7x, R8x, RJx, RMx v 9443-CTO, 9Vx v 9448-CTO, 8Hx 41W4838 R N Hinge, black v 94[...]

No. FRU FRU no. RoHS ID CRU ID 6 LCD cover kit (silver) v 9440-CTO, 22x, 23x, 25x, 26x, 28x, 2Dx, 2Tx, 31x, 32x, 33x, 34x, 35x, A6x, A7x, AHx, D1x, D2x, D3x v 9441-CTO, 2Dx, 47x, 4Hx, 6Fx, 6Jx, 6Kx, MNx, MRx, MTx v 9442-CTO, 2Dx, 2Lx, 71x, 74x, 75x, 7Sx, PBx, PFx, R1x, R2x, R7x, R8x, RJx, RMx v 9443-CTO, 9Vx v 9448-CTO, 8Hx 41V9781 R N 7 W ireless [...]

No. FRU FRU no. RoHS ID CRU ID 9 Inverter card, 14.0WXGA v 9440-CTO, 21x, 22x, 23x, 25x, 26x, 28x, 2Dx, 2Kx, 2Tx, 31x, 32x, 33x, 34x, 35x, A4x, A5x, A6x, A7x, AHx, APx, AQx, ARx, ASx, A Tx, A Vx, A Wx, B1x, B2x, B3x, B4x, B5x, D1x, D2x, D3x v 9441-CTO, 2Dx, 41x, 42x, 43x, 44x, 46x, 47x, 4Dx, 4Hx, 55x, 6Jx, 6Kx, 6Lx, 6Mx, 6Nx, 6Px, 6Qx, 6Rx, 6Fx, 6G[...]

14.1-in. WXGA (185nit) TFT No. FRU FRU no. RoHS ID CRU ID a - e See “Miscellaneous parts” on page 159. 1 LCD front bezel without camera, ster eo microphones v 9440-CTO, 27x, 2Ax, 2Ex, 2Hx, 2Sx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, A4x, A5x, A8x, C3x, C6x, CFx, CGx, DAx, DBx, DCx v 9441-CTO, 34x, 45x, 4Fx, 4Gx, 4Nx, 4Px, 4Qx, 4Rx, 51x, 52x, 53x, 54x, 56x, 5[...]

No. FRU FRU no. RoHS ID CRU ID 3 LCD panel, 14.1-in. WXGA 185nit v 9440-CTO, 24x, 27x, 2Ax, 2Ex, 2Hx, 2Sx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, A4x, A5x, A8x, AGx, AJx, AKx, AMx, ANx, C3x, C6x, C7x, C8x, CEx, CFx, CGx, D4x, D5x, D6x, DAx, DBx, DCx, DFx, DGx, DHx v 9441-CTO, 34x, 45x, 4Fx, 4Gx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 51x, 52x, 53x, 54x, 56x, 57x, 58x, 59[...]

No. FRU FRU no. RoHS ID CRU ID 5 W ireless WA N antenna cable (MAIN) (V odafone) v 9440-CTO, 2Hx, R4x, RAx, R Vx, CEx, CLx v 9441-CTO, 6Hx v 9442-CTO, 7Lx, 8Fx, 8Gx v 9443-CTO v 9448-CTO 93P4298 R N W ireless LAN 3r d antenna cable v 9440-CTO, AMx v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 93P4353 R N 6 LCD cover kit (black) v 9440-CTO, 2Nx, 2Sx, [...]

No. FRU FRU no. RoHS ID CRU ID 6 LCD cover kit (silver) v 9440-CTO v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 41V9781 R N 7 W ireless LAN antenna cable, pair v 9440-CTO, 24x, 27x, 2Ax, 2Ex, 2Hx, 2Sx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, A4x, A5x, A8x, AGx, AJx, AKx, AMx, ANx, C3x, C6x, C7x, C8x, CEx, CFx, CGx, D4x, D5x, D6x, DAx, DBx, DCx, DFx, DGx, DHx v 944[...]

No. FRU FRU no. RoHS ID CRU ID 8 LCD cable assembly - 14.1WXGA stereo without microphone/camera v 9440-CTO, 27x, 2Ax, 2Ex, 2Hx, 2Sx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, A4x, A5x, A8x, C3x, C6x, CFx, CGx, DAx, DBx, DCx v 9441-CTO, 34x, 45x, 4Fx, 4Gx, 4Nx, 4Px, 4Qx, 4Rx, 51x, 52x, 53x, 54x, 56x, 57x, 58x, 59x, 5Ax, 5Bx, 5Cx, 5Dx, 5Ex, 5Fx, 5Gx, 5Hx, 5Jx, 5Kx, 5[...]

No. FRU FRU no. RoHS ID CRU ID 9 Inverter card, 14, 15 v 9440-CTO, 24x, 27x, 2Ax, 2Ex, 2Hx, 2Sx, 2Lx, 2Mx, 2Nx, 2Qx, 2Rx, A4x, A5x, A8x, AGx, AJx, AKx, AMx, ANx, C3x, C6x, C7x, C8x, CEx, CFx, CGx, D4x, D5x, D6x, DAx, DBx, DCx, DFx, DGx, DHx v 9441-CTO, 34x, 45x, 4Fx, 4Gx, 4Lx, 4Mx, 4Nx, 4Px, 4Qx, 4Rx, 51x, 52x, 53x, 54x, 56x, 57x, 58x, 59x, 5Ax, 5B[...]

14.1-in. WXGA+ (200nit) TFT No. FRU FRU no. RoHS ID CRU ID a - e See “Miscellaneous parts” on page 159. 1 LCD front bezel without camera, ster eo microphones v 9440-CTO, BDx, BFx, BGx, BHx, BLx, BMx, C1x v 9441-CTO, 4Sx, 4Tx, 5Wx, 65x, 66x, KRx, KSx, KTx, KWx, KVx, M1x, M2x, M3x, N4x v 9442-CTO, 88x, P3x, RNx v 9443-CTO, 88x, 92x, 9Bx, 9Fx, 9Kx[...]

No. FRU FRU no. RoHS ID CRU ID 3 LCD panel, 14.1-in. WXGA+ v 9440-CTO, 29x, 2Bx, 2Cx, 2Fx, 2Gx, 2Jx, 2Px, 36x, 37x, 38x, ACx, ADx, B6x, B7x, B8x, B9x, BAx, BCx, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BMx, BNx, BPx, C1x, C2x, C4x, C5x, D7x, D8x, D9x, DJx, DKx, DLx, DYx v 9441-CTO, 49x, 4Ax, 4Bx, 4Cx, 4Jx, 4Kx, 4Sx, 4Tx, 5Wx, 61x, 63x, 65x, 66x, KDx, KGx[...]

No. FRU FRU no. RoHS ID CRU ID 5 W ireless WA N antenna cable (MAIN) (Cingular) v 9440-CTO v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 93P4332 R N W ireless LAN 3r d antenna cable v 9440-CTO, B6x, B7x, BAx, BCx, BNx, BPx v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 93P4353 R N 6 LCD cover kit (black) v 9440-CTO, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BM[...]

No. FRU FRU no. RoHS ID CRU ID 7 W ireless LAN antenna cable v 9440-CTO v 9441-CTO v 9442-CTO v 9443-CTO v 9448-CTO 91P6954 R N 8 LCD cable assembly - 14.1WXGA stereo without microphone/camera v 9440-CTO, BDx, BFx, BGx, BHx, BLx, BMx, C1x v 9441-CTO, 4Sx, 4Tx, 5Wx, 65x, 66x, KRx, KSx, KTx, KWx, KVx, M1x, M2x, M3x, N4x v 9442-CTO, 88x, P3x, RNx v 94[...]

No. FRU FRU no. RoHS ID CRU ID 10 Bluetooth daughter card (BDC-2) v 9440-CTO, 2Bx, 2Cx, 2Fx, 2Gx, 2Jx, 36x, 37x, 38x, ACx, ADx, B6x, B7x, B8x, B9x, BAx, BCx, BDx, BFx, BGx, BHx, BJx, BKx, BLx, BMx, BNx, BPx, C1x, C2x, C4x, C5x, D7x, D8x, D9x, DJx, DKx, DLx, DYx v 9441-CTO, 49x, 4Ax, 4Bx, 4Cx, 5Wx, 61x, KDx, KGx, KHx, KJx, KMx, KNx, KQx, KRx, KSx, K[...]

Keyboard Language P/N (ALPS) P/N (Chicony) P/N (NMB) RoHS ID CRU ID Arabic 39T7121 39T7181 39T7308 R ** Belgian 39T7122 39T7182 39T0962 Canadian, multilanguage (445) 39T71 19 39T7179 39T0959 Chinese, T raditional 39T7145 39T7205 39T0985 Czech 39T7123 39T7183 39T0963 Danish 39T7124 39T7184 39T0964 Dutch 39T7132 39T7192 39T7314 English, U.K. 39T7142 [...]

Recovery discs Windows XP Professional CDs W indows XP Professional is pr einstalled as the operating system in the following models: v 9440-CTO, 22x, 23x, 24x, 26x, 27x, 28x, 29x, 2Ax, 2Bx, 2Cx, 2Dx, 2Ex, 2Fx, 2Gx, 2Hx, 2Jx, 2Lx, 2Mx, 2Px, 2Qx, 2Rx, 2Tx, A4x, A4x, A5x, A5x, A8x, ACx, ADx, AHx, AJx, AKx, AMx, ANx, APx, AQx, ARx, ASx, A Tx, A Vx, A [...]

Language P/N RoHS ID CRU ID Arabic 42J8673 R * Chinese, Simplified 42J8666 Chinese, T raditional 42J8667 Chinese, T raditional (Hong Kong S.A.R.) 42J8668 Czech 42J8672 Danish 42J8662 Dutch 42J8665 English, Russia 42J8680 English, U.K. 42J8655 English, U.S. 42J8654 Finnish 42J8663 French 42J8656 German 42J8657 Greek 42J8677 Hebrew 42J8670 Hungarian [...]

Windows XP Home Edition CDs W indows XP Home Edition is preinstalled as the operating system in the following models: v 9440-CTO, 21x, 25x, 2Kx, 2Sx, 2Nx, A6x, A7x, AGx v 9441-CTO, 4Lx, 4Mx, 4Qx, 4Rx, 51x, 52x, 55x, 56x, 59x, 5Ax, 5Dx, 5Ex, 5Hx, 5Jx, 5Mx, 5Nx, 5Sx, 5Ux, 6Ax, 6Cx, 6Dx, K1x, K2x, K3x, K4x, K5x, K6x, K7x, K8x, K9x v 9442-CTO v 9443-CT[...]

Windows V ista Business (32 bit) DVDs W indows V ista Business (32 bit) is pr einstalled as the operating system in the following models: v 9440-CTO, C1x, C2x, C3x, C4x, C5x, C6x, C7x, C8x, CEx, CFx, CGx, DYx v 9441-CTO, NDx, NGx, NHx, NJx v 9442-CTO, 8Hx, C3x, C4x, C5x, C6x, CKx, CLx, CMx, CNx, RPx, RRx, RSx, R Tx, R Vx, RW x v 9443-CTO, XFx v 944[...]

Miscellaneous parts FRU P/N RoHS ID CRU ID Screw kit (including nylon-coated scr ews): v M2 × 3 mm (silver), small head (8) v M2 × 3 mm (black), flat head (32) v M2 × 5 mm (black), flat head (26) v M2 × 7 mm (black), flat head (2) v M2 × 9 mm (black), flat head (2) v M2 × 14 mm (black), flat head (7) v M3 × 3 mm (PHILLIPS/slotted) (1) v Hex [...]

FRU P/N RoHS ID CRU ID LCD assembly miscellaneous parts v 9440-CTO, 2xx, 3xx v 9441-CTO, 2xx, 3xx, 4xx, 5xx, 6xx, 7xx, Exx v 9442-CTO, 2xx, 4xx, 7xx, 8xx, Exx v 9443-CTO, 4xx, 7xx, 8xx, 9xx, Exx v 9448-CTO, 2xx, 4xx, 8xx v ( a ) LCD latch L v ( b ) Coil spring v ( c ) Link wire v ( d ) LCD latch R v ( e ) Cable bush v W ireless WA N antenna cover v[...]

AC adapters FRU P/N RoHS ID CRU ID 3-pin (65 W, 20 V) adapter (models CTO, xxG, xxM, xxQ, xxA, xxT , xxB, xxH, xxC, xxK, xxV) OP Delta 92P1 153 R * Lite-On 92P1 157 R * 2-pin (65W , 20 V) adapter (models CTO, xxU, xxL, xxF , xxP , xxS, xxY , xxE, xxJ) OP Delta 92P1 155 R * Lite-On 92P1 159 R * 3-pin (90W , 20 V) adapter (models CTO, xxG[...]

Power cords A ThinkPad power cord for a specific country or r egion is usually available only in that country or region: For 2-pin power cords: Region P/N (Longwell) P/N (V olex) RoHS ID CRU ID Argentina, Uruguay , Paraguay 42T5020 42T5105 R * Brazil 42T5180 42T5183 Canada, U.S. 42T5008 42T5093 Japan 42T5014 42T5099 For 3-pin power cords: Region P/[...]

Notices Lenovo may not offer the pr oducts, services, or features discussed in this document in all countries. Consult your local Lenovo repr esentative for information on the products and services curr ently available in your area. Any refer ence to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo produ[...]

estimated through extrapolation. Actual r esults may vary . Users of this document should verify the applicable data for their specific environment. T rademarks The following terms are trademarks of Lenovo in the United States, other countries or both: Active Protection System Lenovo Rescue and Recovery ThinkLight ® ThinkPad ® ThinkV antage ® T [...]

T rademarks ThinkPad Z61t 165[...]

Part Number: 42T7845_02 (1P) P/N: 42T7845_02[...]