Kenmore 415.1615111 manual

Use & Care Guide Model: 415.16151110 ® ® ® P/N G550-001-020801 Sears Brands Management Corporation Hoffman Estates, IL 60179 U.S.A. www.kenmore.com www,sears,com Model 464220311 ° Sept02-10[...]

If you smell gas: |. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lld. 4. If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department. |. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. 2. An LP Tank not conne[...]

For Your Safety ...................................... 2 Grill Information Center .............................. 2 Product Record Information ........................... 2 Safety Symbols ...................................... 2 Installation Safety Precautions ......................... 2 l<enmore Grill Warranty .............................. 3 Us[...]

LP Tank / x, II _/ • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cyllnder beyond 80°/0 full. • if the information in the two points above is not followed exactly, a fire causing death or serious injury may occur. • An overfilled or improperly stored cylinder is a hazard due to possible[...]

LP Tank Exchange * Many retailers that sell grills offer you the option of replacing your empty LP tank through an exchange service. Use only those reputable exchange companies that inspect, precision fill, test and certify their tanks. Exchange your tank only for an OPD safety feature-equlpped tank as described in the "LP Tank" section o[...]

Hold coupllng nut and regulator as shown for proper connection to LP tank valve. Leak Testing Valves, Hose and Regulator 1. Turn all grill control knobs to OFF. 2. Be sure regulator is tightly connected to LP tank. 3. Completely open LP tank valve by turning OPD hand wheel counterclockwise. If you hear a rushing sound, turn gas off immediately. The[...]

For Safe Use of Your Grill and to Avoid Serious Injury: • Do not let children operate or play near grill. • Keep grill area clear and free from materials that burn. • Do not block holes in sides or back of grill. • Check burner flames regularly. • Use grill only in welt-ventilated space. NEVER use in enclosed space such as carport, garage[...]

Turn controls and gas source or tank OFF when not In use. if ignition does NOT occur in 5 seconds, turn the burner controls OFF, wait 5 minutes and repeat the lighting procedure, if the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accldently ignite with risk of injury. Match-Lighting A Do not lea[...]

f CAUTION SPIDER ALERT! if you notice that your griIJ is getting hard to light or that the flame isn't as strong as it should be, take the time to check and dean the burner tubes. SPIDER WEBS CONTROL PANEL INSIDE BURNER TUBE i BURNER Spiders or smafl insects have been known to create "flashback" problems. The spiders spin webs, buiJd[...]

Indirect Cooking Poultry and large cuts of meat cook slowly to perfection on the grill by indirect heat. Place food over unlit burner(s); the heat from lit burners circulates gently throughout the grill, cooking meat or poultry without the touch of a direct flame. This method greatly reduces flare-ups when cooking extra fatty cuts because there is [...]

I I Key Qty Description Part# 1 1 LEFT LEG ASSEMBLY G550-1300-W1 2 1 MATCH HOLDER G401-OO79-W1 3 1 RIGHT LEG ASSEMBLY G550-1400-W1 4 1 BOTTOM SHELF G550-0800-W1 5 1 FRONT PANEL G550-O900-W2 6 2 TANK EXCLUSION WIRE G550-0004-W1 7 1 AXLE ROD G550-0009-W1 8 2 WHEEL G401-0058-W1 9 2 LEG EXTENDER G430-0023-W1 10 1 TOP LID G550-1200-W1 11 1 LOGO PLATE G5[...]

® _ii ¸ _i!i_!i © 12 o 464220311[...]

CAUTION: When unpacking grill components, two people should raise grill head from the shipping box. E1 Bottom Shelf to Legs [] Place bottom shelf end with cut out hole for LP cylinder between leg assembly with axle holes. Attach to right and left leg assemblies with (4) 1/4-20x1-1/2" screws and (4) 1/4-20 flange nuts. [] Tighten securely. Matc[...]

B Front Panel [] Attach front panel to grill cart with (6) #8-32x3/8" sheet metal screws. Make sure metal tabs for tank exclusion wires are toward the bottom of cart. #8-32x3/8" sheet metal screws Qty. 6 Tank Exclusion Wire [] Hang tank exclusion wire onto front panel brackets; attach other ends to bottom shelf with (2) #8-32x3/8" sh[...]

Wheels and Leg Extenders to Cart [] Turn cart assembly upside down. [] Insert axle rod through wheel, wheel spacer, legs and other wheel. Be sure to face "cone" side of wheel against leg. Attach with (t) axle washer and hitch pin. [] Hammer leg extenders into right legs. Wheel Spacer Hitch Pin Qty. 1 Axle Washer Qty. 1 Qty. 1 Leg Extender[...]

Grill Head to Cart [] Stand cart upright. [] This step requires two people to lift and position grill head onto cart. [] Carefully lower the grill head onto the cart. Make sure the regulator hose is hanging outside the cart. Attach head to cart with (4) 1/4-20xl/2" screws. Grill Head Y 1/4-20xl/2" screws Qty. 4 16 - 464220311[...]

Right Side Shelf [] Attach towel bar to right side shelf with (2) #10-24x3/8" screws, 5mm lock washers and 5ram flat washers (A). [] Hook side walt of shelf over support brackets on side of firebox (B). [] Insert (4) 7ram fiber washers and (4) t/4-20xl/2" screws through inside front of firebox and through outside back of firebox as shown [...]

Side Burner Shelf [] Hook side wall of side burner shelf over support brackets on side of firebox (A). [] Inside firebox insert (4) fiber washers and (4) 1/4-20xl/2" screws as shown (B). [] Attach shelf using (4) 1/4-20 flange nuts (C). Lid removed for clarity Side Burner Shelf / 1/4-20xl/2" screws Qty. 4 7mm Fiber Washers Qty. 4 1/4-20 F[...]

Sideburner Valve, $ideburner Sideburner Bezel, Ignitor Wire, Control Knob [] Position valve behind fascia and line up holes (A). [] Insert (1) of the #8-32x3/8" stainless steel screws, but do not fully tighten. [] Slip bezel under inserted screw and position as shown (A). [] Line up other hole and insert (1) #8-32x3/8" stainless steel scr[...]

Heat Shield [] Attach heat shield over burners inside front of grill with (2) #8-32x3/8" sheet metal screws. Heat Shield / #8-32x3/8" sheet metal screws Qty. 2 Lid removed for clarity ;ril! Front 20 o 464220311[...]

Heat Diffusers [] Place heat diffusers over burners by inserting tabs into slots in front of firebox. Opposite ends of heat diffusers rest on pins in back of firebox. Cooking Grate and Swing Away [] Place cooking grates onto grate rests. [] Insert ends of Swing Away pivot wire into holes in sides of grill lid. insert ends of Swing Away leg wire int[...]

Grease Cup Cllp, Grease Cup, Grease Tray [] Hang grease cup clip from bottom of grease tray and place grease cup into grease cup clip. Place the tray into the cart. Tio. Failure to install grease cup clip and cup will cause hot grease to drip From bottom of grill with risk of fire or propertydamage. Grease Tray Grease Cup Cti F Grease Cup_ _'_[...]

EMERGENCIES: Jf a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire or continuous excessive flam[...]

Troubleshootlng (continued) Burner(s) will not light using ignitor. (See Electronic Ignition Troubleshooting also) Burner(s) will not match light. Sudden drop in gas flow or low flame. Flames blow out. Flare-up. ELECTRONIC IGNMON: No spark, no ignition noise. No spark, some ignition noise. Sparks, but not at electrode or at full strength. See _GAS [...]

Troubleshooting - Electronic Ignltion SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II No sparks appear at any electrodes when Electronic Ignition Button is pressed; noise can be heard from spark module. • Battery not installed properly. • Dead battery. [...]

26 o 464220311[...]

464220311 o 27[...]

iiiiiiiiiiiiiiiiiiiiii!ii_Y iiiiiiiiiiiiiiiiiiiiii _ iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii iiiiiiiiiiiiiiiiiiiiii Your Home For troubleshooting, product manuals and expert advice: managemylife wv, rw.managemylife.com %:¸:¸:¸:¸:¸:¸:¸:¸:¸:¸:?[...]