Lennox Hearth EBVSTNM-B manual

INST ALLER: Leave this manual with the appliance. CONSUMER: Retain this manual for future reference. INST ALLA TEUR : Laissez cette notice avec l'appareil. CONSOMMA TEUR : Conservez cette notice pour consultation ultérieure. MODELS DON’T THROW IT AW AY ! This manual contains important operating and safety information. Wait... ™ EBVST B-V [...]

2 S a f et y a nd Y our Fireplace  T o prevent severe burns and injuries, install a screen or physical barrier to prevent direct contact with the glass. T o order a FREE Lennox ® SAFETY GUARD for your fireplace, see details at left.  Follow the safety instructions below and be sure everyone in your household understands this burn hazard: Th[...]

3  Afin d'éviter de vous brûler gravement ou de vous blesser , installez une grille ou une barrière physique pour empêcher tout contact direct avec la vitre. Pour commander un P ANNEAU DE PROTECTION Lennox ® GRA TUIT pour votre foyer , consultez les détails dans la partie gauche.  Suivez les instructions de sécurité ci-dessous e[...]

4 Important Safety Information WARNING: Do not operate appliance with the glass front 1. removed, cracked or broken. Replacement of the glass should be done by a licensed or qualified service person . Do not use this appliance if any part has been under water . 2. Immediately call a qualified service technician to inspect the appliance and to rep[...]

5 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A P P O S I TI O N D ES M I SE S E N G A R D E R E L A TI VE S À LA SÉCURITÉ D’UTILISA TION V ot r e fo y e r a é t é li v r é av e c de s é t i q u e t te s d e sé c u r i t é qu i doivent être collées à côté des dispositifs de contrôle du foyer . Une étiquette de sécurité[...]

6 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. General Information The fireplace models covered in this manual are b-vented decorative fireplaces designed for residential application. The Millivo lt appliances have a millivolt gas control valve with piezo ignition system. If any optional accessories which require electrical power are bei[...]

7 BTU Input These fireplaces are designed as supplemental hea ter s. There for e, it is advi sa ble to have an alternate primary heat source when installed in a dwelling. Millivolt Models - The millivolt appliances are manually controlled and feature a spark igniter (piezo) that allows the appliance's pilot gas to be lit without the use of ma[...]

8 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. 8 OPERA TION AND CARE OF YOUR APPLIANCE W ARNING Y oung children should be carefully supervised when they are in the same room as the appliance. T oddlers, young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individua[...]

9 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Figure 3 Honeywell Electronic Gas Valve Figure 2 Note: The piezo ignitor is located on the modesty panel - refer to Figure 1. Variable Flame Height Adjustment ( Millivolt Appliances only) 1. All Millivolt appliances are equipped with a variable gas control valve. Flame height for these models [...]

10 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. T o open the outside air shutter , open the botttom contr ol access pane l, reach into the gap betwe en the firebox bottom and the modesty panel, and pull the outside air control lever all the way out. The outsi de air shutte r should be fully open when the fireplace is in use and completel[...]

11 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. MAINTENANCE (See Maintenance Schedule, Page 25) Refer to the maintenance schedule for maintenance tasks, procedures, periodicity and by whom they should be performed. Always verify proper opera - tion of the appliance after servicing. Replacing Logs If the logs become damaged by accident or i[...]

12 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Front Glass Enclosure Panel, Removal and Installation W ARNING Any safety screen or guard removed for ser vicing the appli- ance must be replaced prior to operating the appliance. A VERTISSEMENT T out écran ou protecteur retiré pour permettre l’entretien de l’appareil doit être remis e[...]

13 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. READ WARNINGS ON THIS PAGE BEFORE PROCEEDING. FOLLOW THE LOG PLACEMENT INSTRUCTIONS EXACTL Y 1. Remove the front glass enclosure panel (see Glass Enclosure Panel Removal and Installation Instructions , Page 12 ) . 2. Remove the following from firebox ; log set, bag of embers and bag of vermi[...]

14 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. EBVPF AND EBVST LOG PLACEMENT Figure 9 Catalog Number for the entire log set: 55M04 Log Part Number Description Number 1 Log, Corner 55M18 2 Log, Rear/Left 55M19 3 Log, Front/Left 55M20 4 Log, Rear/Right 55M21 5 Log, Front/Center 55M22 6 Log, Center/T op 55M23 2 6 5 4 1 3 Position Groove At T[...]

15 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. EBVPF AND EBVST LOG PLACEMENT (CONTINUED) Catalog Number for the entire log set: 55M04 Log Part Number Description Number 1 Log, Corner 55M18 2 Log, Rear/Left 55M19 3 Log, Front/Left 55M20 4 Log, Rear/Right 55M21 5 Log, Front/Center 55M22 6 Log, Center/T op 55M23 2 6 5 4 1 3 Figure 10 3 Grate[...]

16 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. BURNER ADJUSTMENTS (QUALIFIED TECHNICIANS ONL Y) Flame Appearance and Sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame may be blue and will gradually turn yellowis[...]

17 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNINGS • Air shutter adjustment should only be performed by a quali - fied professional ser vice tech - nician. • Ensure front glass panel are in place and sealed during adjustment. CAUTIONS • Soot will be produced if the air shutter is closed too much. Any damage due to sooting, re[...]

18 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A TTENTION: AU MOMENT DE L'ENTRETIEN DES COMMANDES, ÉTIQUETEZ TOUS LES FILS A V ANT DE LES DÉBRANCHER. DES ERREURS DE CÁBLAGE PEU-VENT ENTRAÎNER UN FONCTIONNEMENT INADÉQUA T ET DANGEREUX. LENNOX HEARTH PRODUCTS 1508 Elm Hill Pike, Suite 108 Nashville, TN 37210 visit us at www .Lenno[...]

19 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. Product Reference Information Cat. No. Model Ship. Weight Ship. Volumn H7826 EBVSTNM 282 lbs. (36.2 cu.ft.) H7828 EBVSTNE 282 lbs. (36.2 cu.ft.) H7827 EBVSTPM 282 lbs. (36.2 cu.ft.) H7829 EBVPFNM 270 lbs. (36.2 cu.ft.) H7831 EBVPFNE 270 lbs. (36.2 cu.ft.) H7830 EBVPFPM 270 lbs. (36.2 cu.ft.) [...]

20 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED OFF/ON Wall Switch Kit The OFF/ON wall switch kit may be used to control the operation of the fireplace burner . Install the OFF/ON wall switch in a convenient location near the fireplace. White Wall Switch Kit Cat. No. Model No. Description 85L87 FWSK OFF/ON [...]

21 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Polished Brass and Brushed Stainless Louvers Kits Decorative louvers are available for use with all Multi-Open Series appliances. These louvers are designed to replace the standard radiant panels that are provided with the appliance. These kits include a top 3-p[...]

22 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. The brickaded liner kits include ceramic panels as shown here. The panels have brick-li ke feature s in relief. ACCESSORY COMPONENTS CONTINUED H0779 (T op Vent) H0778 (T op Vent) H0780 & H0781 (T op Vent) H0779 (Rear Vent) H0778 (Rear Vent) H0780 & H0781 (Rear Vent) Bricaded Panel Lin[...]

23 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Style View Doors - Style View Doors come in 4 beautiful styles. They are easy to install and will not require hardware to attach them to the standard glass door frame. The door includes heavy duty magnet door latches and functional twin-pane doors. Style View Do[...]

24 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED This screen panel kit can be installed on the glass enclosure panel to prevent direct contact with the hot glass surface. The panel kit adds a new design choice with a handsome textured iron fin - ish. The screen panel kit cannot be used in conjunction with eit[...]

25 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. MAINTENANCE T ASK ACCOMPLISHING PERSON PROCEDURE Inspecting/Cleaning Burner , Logs and Controls Qualified Service T echnician Inspect valve and ensure it is properly operating. Check piping for leaks. V acuum the control compartment, fireplace logs and burner area. Check Flame Patterns and [...]

26 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTL Y , A FIRE OR EXPLO- SION MA Y RESUL T CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. 6. W ait five (5) minutes to clear out any gas. If you then smell gas, STOP! Follow “B” in the safety information above on this page. I[...]

27 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A VERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE EXPLOSION CAUSANT DES DOMMAGES MA TÉRIELS, DES BLESSURES CORPORELLES OU MÊME DES PERTES DE VIE. INSTRUCTIONS D’ALLUMAGE – V ANNE GAZ MILLIVOL T INSTRUCTIONS D'ALLUMAGE[...]

28 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. A. When lighting the appliance, follow these instructions exactly . B. BEFORE OPERA TING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor . WHA T TO DO IF YOU SMELL GAS • Extinguish any open ?[...]

29 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC INSTRUCTIONS D’ALLUMAGE POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE A. Lorsque vous allumez l’appareil, suivez exactement ces instruc- tions. B. AV ANT L ’ALLUMAGE: Assurez-vous que vous ne détectez aucune odeur de gaz autour de l’apareil ainsi que près du sol; certains gaz,[...]

30 TROUBLESHOOTING THE MILLIVOL T GAS CONTROL SYSTEM 1. Spark ignitor will not light pilot after repeated triggering of ignitor button. 2. Pilot will not stay lit after carefully following the light- ing instructions. 3. Pilot burning, no gas to burner , Valve knob “ON,” Wall Switch “ON.” 4. Frequent pilot/burner outage problem. CORRECTIVE [...]

31 TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION See Below . Disconnect the two black wires from the wire nuts. T est switch(s) for continu- ity with a multimeter . If continuity is not indicated, switch(s) is defective and must be replaced. Note: Before replacing “OFF/ON” switch, be sure to check wiri[...]

32 REPLACEMENT P ARTS LIST . o NN O I T P I R C S E D e n a p o r P d n a l a r u t a N . o N t r a P. y t Q. y t Q T S V B EF P V B E a 1. n i 4 2 - k c a l B , t n a i d a R r e p p UY E 5 8 8 1 9 - B Le n o n1 b 1. n i 0 4 - k c a l B , t n a i d a R r e p p UY C 5 8 8 1 9 - B L2 2 a 2. n i 4 2 - k c a l B , d o o HY E 1 4 9 1 9 - B Le n o n1 b [...]

33 NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. W ARNING Fa il u r e to pos it ion th e pa r t s in ac co rda nc e wi th th es e diagrams or failure to use only parts specifically ap pr o v e d wi t h th is a p p li an ce m a y re s u l t i n pr o p e r t y damage or personal injury . A VERTISSEMENT Ri sq u e de do mm a g es o u de bl e s[...]

NOTE: DIAGRAMS & ILLUSTRA TIONS ARE NOT TO SCALE. REPLACEMENT P ARTS 2b 4b 5b 6b 1b 3b 42 7 10 11 15 31 37 43 41 45 32 33 12 50 14 44 13 35 36 Note: - EBVPF Shown - see the tables on pages 30 and 31 for replacement parts applicable to EBVST fireplaces. 9b 8 34 1a 2a 3a 4a 5a 6a 10 Cabinet Corner Post Location 17 9a 16 Inside Location 40 30[...]

35 Notes[...]

Printed in U.S.A. © 2004 LENNOX HEARTH PRODUCTS P/N 875026M REV . E 01/2011 Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. 1508ElmHillPik[...]