Mercedes-Benz 2010 S 400 Hybrid manual

S 400 HYBRID Supplemental Operating Instructions 221_ZA; 1; 21, en-US d2ureepe, Version: 2.11.8.1 2009-05-13T13:56:31+02:00 - Seite 1[...]

Symbols The following symbols are found in this Supplemental Operating Instructions Booklet: G Warning! Warning notices draw your attention to hazards that may endanger your health or life, or the health or life of others. ! Highlights hazards that may result in damage to your vehicle. i Helpful hints or further information you may find useful. X T[...]

Our company and staff congratulate you on the purchase of your new Mercedes-Benz. Your selection of our product is a demonstration of your trust in our company name. Furthermore, it exemplifies your desire to own an automobile that will be as easy as possible to operate and provide years of service. Your Mercedes-Benz represents the efforts of many[...]

221_ZA; 1; 21, en-US d2ureepe, Version: 2.11.8.1 2009-05-13T13:56:31+02:00 - Seite 2[...]

Index ....................................................... 4 Introduction ........................................... 7 Safety and security ............................... 9 Controls in detail ................................. 12 Practical hints ..................................... 20 Technical data ..................................... 32 Cont[...]

A ABS (Antilock Brake System) ............. 10 Warning lamp ................................... 24 Anticorrosion/antifreeze .................... 36 Antilock Brake System see ABS Automatic transmission Messages in the multifunction display ............................................. 21 Axle oils ................................................ 35 [...]

F Flat tire Spare wheel ..................................... 34 Fluids Automatic transmission fluid ........... 35 Brake fluid ....................................... 35 Capacities ........................................ 34 Engine coolant ................................. 35 Engine oil ......................................... 35 Power steering f[...]

Rear axle oil ......................................... 35 Recuperation statistics (COMAND) ... 16 Rims ...................................................... 33 Risk of fire see Sa fety no tes S Safety see Opera ting safety Safety notes ........................................... 9 Spare wheel ......................................... 34 SRS (Supp[...]

Enviromental protection Have the high-voltage battery disposed of in an environment-friendly manner by an authorized Mercedes-Benz Center. G Warning! The HYBRID system is energized by high voltage. The components of the HYBRID system are indicated by yellow warning labels. High-voltage cables are orange- colored. You could be seriously or even fata[...]

Proper use of the vehicle Proper use of the vehicle requires that you are familiar with the following information and rules: R the safety precautions in this manual R the “Technical data” section in this manual R the Operator's Manual R traffic rules and regulations R motor vehicle laws and safety standards 8 Introduction 221_ZA; 1; 21, en[...]

Safety notes Warning labels G Warning! Various warning labels are attached to your vehicle. These warning labels are intended to make you and others aware of various risks. Do not remove any of these warning labels unless explicitly instructed to do so by information on the label itself. Removing warning labels may cause you and others to be unawar[...]

Automatic HYBRID system switch-off The HYBRID system switches off automatically if R the Supplemental Restraint System (SRS) activates the restraint systems in an accident R a short circuit in the HYBRID system is detected R a plug connection of the HYBRID system is disconnected These measures help to prevent you from coming into contact with high [...]

When working on the RBS, certain precautions must be taken, e.g. when putting the brake system back into service. Contact an authorized Mercedes-Benz Center. Service conducted by qualified technicians is required particularly for safety- relevant work and work on safety-relevant systems such as the RBS. i For more information on the braking system [...]

Introduction The HYBRID technology combines an economical combustion engine with a powerful electric drive. The HYBRID system selects the most efficient operating mode for each driving situation automatically. You can drive the vehicle in the usual manner. The HYBRID system turns the combustion engine off when stopping as often as possible in order[...]

Overview HYBRID system Component : 12-volt battery ; Voltage transformer (transforms the voltage of the 12-volt battery and the high-voltage battery in both directions for best possible power management) = High-voltage battery Component ? Electric drive A Electric refrigerant compressor for the climate control system B Power electronics (control th[...]

Instrument cluster Function Page : ÷ ABS/ESC warning lamp 10, 24 ; $ Brake warning lamp, USA only 24 J Brake warning lamp, Canada only 24 = é Recuperative Brake System (RBS) warning lamp 24 ? Green or yellow READY indicator lamp for the HYBRID system 16 A Multifunction display with: Charging level high-voltage battery 15 Control system and COMAND[...]

Multifunction display and COMAND display examples Example illustration: Operating mode display 1 Combustion engine 2 Electric drive 3 High-voltage battery 4 Charging condition of high-voltage battery in percent 5 Flow of energy The HYBRID components that are currently active are highlighted in the multifunction display and the COMAND display. Multi[...]

Displaying fuel consumption and generated electric power The COMAND display indicates the fuel consumption and the generated electric power for the last 15 minutes of driving. X Select Vehicle Q Hybrid Q Consumption . 1 Fuel consumption 2 Generated electric power Each bar in the chart represents the average value for 1 minute. Average fuel consumpt[...]

ECO Start/Stop function When the green READY indicator lamp : in the instrument cluster is on, the combustion engine turns off automatically when R you stop the vehicle and keep the brake pedal depressed R you activate the HOLD function All vehicle systems remain active, for example the climate control system. When you remove the foot from the brak[...]

Brake to Shift from 'P' appears in the multifunction display: X Depress the brake pedal with somewhat greater force and select the desired transmission position. i Read and observe messages that may appear in the multifunction display ( Y page 20) For more information on driving off, refer to the Operator’s Manual. Driving Driving tips [...]

X Engage the electronic parking brake. The parking brake indicator lamp $ (USA only) or ! (Canada only) in the instrument cluster comes on. X Shift the automatic transmission into park position P . X Switch off the ignition. The green or yellow READY indicator lamp goes out. i For more information on parking and on turning off the combustion engine[...]

Vehicle status messages in the multifunction display Notes Warning and malfunction messages appear in the multifunction display located in the instrument cluster. Certain warning and malfunction messages are accompanied by an audible signal. High-priority messages are shown in red in the multifunction display. Messages of lower priority are also sh[...]

Text messages Display messages Possible causes/consequences and X Solutions Apply Brake to Shift from 'P' You have attempted to shift the automatic transmission into drive position D , reverse gear R or neutral position N without depressing the brake pedal or without depressing it fully. X Depress the brake pedal fully. Service Required D[...]

Symbol messages Display messages Possible causes/consequences and X Solutions L The hood is open. The combustion engine cannot be started. Risk of accident! X Close the hood. c Charging Hybrid Battery Please Wait The high-voltage battery is discharged. You have switched on the ignition while the 12-volt battery was being charged with an approved ch[...]

Display messages Possible causes/consequences and X Solutions d Malfunctio n The engine stalled when driving off. X Shift the automatic transmission into park position P . X Switch off the ignition and switch it back on. X Start the combustion engine. The HYBRID system is malfunctioning. The ECO Start/Stop function may have failed and the vehicle m[...]

What to do if ... Lamps in instrument cluster Problem Possible causes/consequences and X Solutions é The yellow RBS (Recuperative Brake System) warning lamp is on while the combustion engine is running. In addition, an acoustic warning may sound. The RBS is malfunctioning. Risk of accident! Brake pedal travel may be longer than usual and the braki[...]

Problem Possible causes/consequences and X Solutions The warning and indicator lamps in the instrument cluster fail to come on when switching on the ignition. The 12-volt battery is discharged. X Get a jump start ( Y page 29). or X Charge the 12-volt battery ( Y page 28). or X Contact an authorized Mercedes-Benz Center. Combustion engine Problem Po[...]

RBS (Recuperative Brake System) Problem Possible causes/consequences and X Solutions Less brake pedal pressure is required and the brake pedal travel is longer than usual. X Apply the brake pedal fully and release it. The required brake pedal pressure and the brake pedal travel are back to normal. The RBS is malfunctioning. Risk of accident! X Read[...]

G Warning! The electrolyte, i.e. the battery fluid, is toxic and caustic. Do not allow this fluid to come in contact with eyes, skin or clothing, for example in case of an accident. In case it does, immediately flush affected area with water and seek medical help immediately. For information on the location of the 12-volt battery and the high-volta[...]

X Place cover 1 onto the high-voltage battery carefully. X Push holder 2 onto pin 3 . X Turn locks 4 counterclockwise by 90°. The cover is locked. Removing/installing jump start contact cover X Remove the high-voltage battery cover, see ( Y page 27). Removing X Disengage tabs : . X Remove cover ; . X Store cover 2 in the trunk for example. Install[...]

X Connect the positive terminal clamp of the charge unit with jump start terminal 1 . X Connect the negative terminal clamp of the charge unit with jump start terminal 2 . X Charge the 12-volt battery. Charging the high-voltage battery With the ignition switched on, the discharged high-voltage battery is being charged via the voltage transformer, p[...]

i Jumper cables and additional information on jump starting are available at any authorized Mercedes-Benz Center. ! Jump starting should only be performed using the jump-start terminals located in the engine compartment. Avoid repeated and lengthy starting attempts. Do not attempt to start the engine using a battery quick-charge unit. If the engine[...]

Disconnecting the jumper cables X Disconnect the jumper cables in reverse order, starting with jump start terminal 4 ( Y page 30). X Install the jump start terminal cover ( Y page 28). X Install the high-voltage battery cover ( Y page 27). X Close the hood. X Drive the vehicle for some time in order to charge the 12-volt battery and the high- volta[...]

Identification labels i For more information on the identification labels, refer to the Operator’s Manual. Electric drive The engine number is engraved on the housing of the electric drive. For more information contact an authorized Mercedes- Benz Center. Vehicle specification S 400 HYBRID (221.195) The quoted data apply only to the standard vehi[...]

Main dimensions S 400 HYBRID Track, rear 63.2 in (1 606 mm) Turning circle 40.0 ft (12.2 m) Weights S 400 HYBRID Roof load max. 220 lb (100 kg) Trunk load max. 220 lb (100 kg) Rims and tires Same size tires S 400 HYBRID 18" wheels Rims (light alloy) Wheel offset 8.5 J x 18 H2 1.69 in (43 mm) All-season tires 3 255/45 R18 99H M+S Winter tires 3[...]

S 400 HYBRID 7 19" wheels Front axle AMG rims (light alloy) Wheel offset 8.5 J x 19 H2 1.69 in (43 mm) All-season tires 3 255/40 R19 100V XL (Extra Load) M+S Rear axle AMG rims (light alloy) Wheel offset 9.5 J x 19 H2 1.69 in (43 mm) All-season tires 3,6 275/40 R19 101V M+S Spare wheel S 400 HYBRID Rim (steel) 4.5 B x 19 H2 Wheel offset 1.38 i[...]

Model S 400 HYBRID Capacity Fuels, coolants, lubricants, etc. Engine with oil filter 8.5 US qt (8.0 l) Approved engine oils Automatic transmission 9.8 US qt (9.3 l) MB Automatic Transmission Fluid Rear axle 1.2 US qt (1.1 l) Hypoid gear oil Power steering approx. 1.1 US qt (1.0 l) MB Power Steering Fluid or approved Dexron III ATF Brake system 0.63[...]

Approved engine oils Use the table below to determine the MB sheet number. Model S 400 HYBRID Engine, type MB sheet number 272 229.5 i MB sheet numbers are printed on the outside of oil containers. i For more information on approved engine oils, refer to the Operator's Manual. Coolants The engine coolant is a mixture of water and anticorrosion[...]

Service and Literature Your authorized Mercedes-Benz Center has trained technicians and Genuine Mercedes- Benz Parts to service your vehicle properly. For expert advice and quality service, contact an authorized Mercedes-Benz Center. If you are interested in obtaining service literature for your vehicle, please contact an authorized Mercedes-Benz C[...]

Order no. 6515 2317 13 Part no. 221 584 48 87 Edition A 2010 É2215844887kËÍ 2215844887 221_ZA; 1; 21, en-US d2ureepe, Version: 2.11.8.1 2009-05-13T13:56:31+02:00 - Seite 38[...]