Monessen Hearth SS38 manual

Stratford                      ?[...]

46D0232 2 SS38 Direct V ent Gas Stove        ?[...]

3 46D0232 SS38 Direct V ent Gas Stove 4. Never install the stove • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 42" from the front, top, or sides of the stove • in high traffic areas • in windy or drafty areas 5. This stove reaches high temperatures. Keep children and adult[...]

46D0232 4 SS38 Direct V ent Gas Stove    12. Do not use this stove to cook food or burn paper or other objects. 13. Never place anything on top of stove. 14. Do not use any solid fuels (wood, coal, paper , card- board, etc.) in this stove. Use only the gas type indi[...]

5 46D0232 SS38 Direct V ent Gas Stove     • This appliance has been certified for use with either natural or propane gas. See appropriate data plates. • This appliance is not for use with solid fuels. • The appliance is approved f[...]

46D0232 6 SS38 Direct V ent Gas Stove   If this unit is installed in a mobile home it must be bolted securely to the floor with leg bolts.  Stratford SS38 model stove works without any electrical supply . Figure 2 - Stove Dimensions 26 56O ” (673 mm) 17” (432 mm) 31 5[...]

7 46D0232 SS38 Direct V ent Gas Stove     Figure 3 - T ypical Installations ST1100 stov e locations ST1 100   Plan for the installation of your stove. This includes deter- mining where the unit is to be installed[...]

46D0232 8 SS38 Direct V ent Gas Stove   Maintain the following minimum clearances for service and maintenance. • Stove must be at least 6" from the back wall. Figure 4 • Stove must be at least 9" from either side wall. See Fi[...]

9 46D0232 SS38 Direct V ent Gas Stove              ?[...]

46D0232 10 SS38 Direct V ent Gas Stove  When installing in a chase, you should insulate the chase as you would the outside walls of your home. This is especially important in cold climates. Insulation should be considered a combustible material. Maintain proper clearances to all combustible materials. ?[...]

1 1 46D0232 SS38 Direct V ent Gas Stove     V V V V V V V X X X D E B B B C B M B A J K F L VENT TERMINA TION AIR SUPPL Y INLET AREA WHERE TERMINAL IS NOT PERMITTED H I Fixed Closed Operable Operable Fixed Closed V B CFM145a DV T ermin Location 5/01/01 R[...]

46D0232 12 SS38 Direct V ent Gas Stove     A n y v e n t configuration within the s[...]

13 46D0232 SS38 Direct V ent Gas Stove          1. Determine the route your horizontal venting will take.  The location of the horizontal vent termin[...]

46D0232 14 SS38 Direct V ent Gas Stove    4. Apply a bead of non-hardening mastic around the outside edge of vent cap. Position the vent cap in the cent er of the 7 Zx " (190 mm) or 9 Zx " (24 1 mm) hole on the exterior wall with the word “UP” on the vent cap facing up. [...]

15 46D0232 SS38 Direct V ent Gas Stove      Figures 15 through 17 show different configurations for venting with horizontal termination. Each figure includes a chart with vertical minimum/maximum and horizontal maximum dimensions which mus[...]

46D0232 16 SS38 Direct V ent Gas Stove     1. Determine the route your vertical venting will take. If ceilin g joist, roof rafters or other framing will obstruc t the venting system, consider an offset. Figure 18 to avoid cutting load b[...]

17 46D0232 SS38 Direct V ent Gas Stove        1. C ut a 9 Zx " (241 mm) square hole in the ceiling using the locating hole as a center point The opening should be framed to 9 Zx " x 9 Zx " (241 [...]

46D0232 18 SS38 Direct V ent Gas Stove    Figures 23 through 26 show four dif ferent configurations for vertical termination.    Y ou must install a restrictor on all vertical installations. Figure 23 - V erti[...]

19 46D0232 SS38 Direct V ent Gas Stove H V H 1 ST1111 vert vent 2 elbows Figure 24 - V ertical Rigid Venting Configuration Using Three 90° Elbows with T wo Horizontal Runs     Install restrictor into 4" collar of stove or first vent secton as shown.  [...]

46D0232 20 SS38 Direct V ent Gas Stove FP1977 external regulator  Use proper gas type for the stove you are installing. If you have conflicting gas type, do not install stove. See dealer where you purchased the stove for proper stove for your gas type or conversion kit.  [...]

21 46D0232 SS38 Direct V ent Gas Stove                   ?[...]

46D0232 22 SS38 Direct V ent Gas Stove 1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal. If the gas supply is different from the stove,  Do not install the appliance. Contact your dealer immediately . 2. T o ease installation, a 30" (mm) flex line with manual shut-of f valve has been[...]

23 46D0232 SS38 Direct V ent Gas Stove     This stove will work without any electrical supply . Electricity is only needed to operate blower . NOTE: If installed in mobile home, stove must be bolted securely to floor .  ?[...]

46D0232 24 SS38 Direct V ent Gas Stove L G736 VS38 left base log          1. Carefully remove logs from wrapping. 2. Open front door of firebox. 3. Place rear log against back of [...]

25 46D0232 SS38 Direct V ent Gas Stove    L G737 VS38 right base log Figure 34 - Install Right Base Log Right Base Log LG737 5. P lace right base log on two pins against right side of firebox. Figure 34. Figure 35 - Install T op Left Log T op Left Log L G738 VS38 top left log LG738 6. Place top [...]

46D0232 26 SS38 Direct V ent Gas Stove L G741 VS38 embers L G740 VS38 top center log Figure 37 - Install T op Center Log Leave Air Space between Logs and Rock Wool Rock Wool Figure 38 - Install Rock Wool T op Center Log Embers Pins    8. Place top center log on top left log pins sand angle to bu[...]

27 46D0232 SS38 Direct V ent Gas Stove    This appliance is equipped with a pilot which must be lit with built-in battery ignitor while following these instructions exactly .  BEFORE OPERA TING smell all around the appliance area for gas. Be sure to smell next to th[...]

46D0232 28 SS38 Direct V ent Gas Stove   PILOT O F F P I L O T O N FP1935 control knob pilot  Y ou may check for gas leaks with the following methods only: • Soap and water solution • An approv[...]

29 46D0232 SS38 Direct V ent Gas Stove   PILOT O F F P I L O T O N O F F P I L O T O N PILOT FP1937 control knob on Figure 41 - On Position PILOT O F F P I L O T O N FP1935 control knob pilot Figure 40 - On/Off/RS Switch OFF ON RS ?[...]

Make sure the gas valve knob is in the “OFF” position. W ait at least five (5) minutes before start-ing maintenance.  A qualified agency should examine the venting system annu- ally .  Clean the ceramic glass periodically . Condensation will some- times form on [...]

31 46D0232 SS38 Direct V ent Gas Stove ST1115 air shutter open       The venturi of the burner is equipped with an air shutter . The opening of th[...]

46D0232 32 SS38 Direct V ent Gas Stove ST1117 VS38 replace glass  1. Put on gloves. Remove door from hinges by lifting the door up. Figure 48 2 . Remove the 7/8" rope from around glass frame. Figure 49 3. U sing a 5/16 " sock et, remov e hex nut s from glass retai n- ing brackets. Remo[...]

33 46D0232 SS38 Direct V ent Gas Stove    ST1118 blower White (Hi T emp) ST1119 VS38 wiring diagram[...]

46D0232 34 SS38 Direct V ent Gas Stove  Spark ignitor will not light the pilot after repeated pressing of spark ignitor . Pilot will not stay lit. Burner will not light when valve and burner switch are both on. Glass fogs up Blue flames Sooting  1. Battery nee[...]

35 46D0232 SS38 Direct V ent Gas Stove   1 4 17 9 14 13 6 15 16 19 7 10 5 1 1 12 2 21 24 22 3 18 AA Battery 25 23 20 8 2030245 VS38 par ts[...]

46D0232 36 SS38 Direct V ent Gas Stove           ?[...]

37 46D0232 SS38 Direct V ent Gas Stove    7" x 48" Pipe 902B 7" x 36" Pipe 903B 7" x 24" Pipe 904B 7" x 12" Pipe 906B 7" x 9" Pipe 907B 7" x 6" Pipe 908B 7" Adjustable (1 [...]

46D0232 38 SS38 Direct V ent Gas Stove  This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts. Any residence with a direct vent product must have a CO detector installed in the residence. Ins[...]

39 46D0232 SS38 Direct V ent Gas Stove MHSC warrants its products to be free of defects in material and workmanship and backs each product with a Limited Lifetime W arranty . This warranty is to the original purchaser of a MHSC product and is not transferable.   Covered under this warranty are the [...]

 149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com[...]