Monessen Hearth WDV500 manual

      78D001 1 7/09 Rev . 2          ?[...]

2 78D001 1 WD V Series Gas F ireplace       [...]

78D001 1 3 WD V Series Gas F ireplace 4. Never install the fireplace • in a recreational vehicle • where curtains, furniture, clothing, or other flam- mable objects are less than 42" from the front, top, or sides of the fireplace • in high traffic areas • in windy or drafty areas 5. This fireplace reaches high temperatures. Keep chil- [...]

4 78D001 1 WD V Series Gas F ireplace    14. Do not use any solid fuels (wood, coal, paper , card- board, etc.) in this fireplace. Use only the gas type indicated on rating plate. 15. This appliance, when installed, must be electrically grounded in accordance with l[...]

78D001 1 5 WD V Series Gas F ireplace      Figure 1 - WDV Fireplace Features   • This appliance has been certified for use with either natural or propane gas. See appropriate da[...]

6 78D001 1 WD V Series Gas F ireplace              ?[...]

78D001 1 7 WD V Series Gas F ireplace       Plan for the installation of your appliance. This includes determining where the unit is to be ins tal led , th e vent confi gur ation to b e used , fram ing and fini s[...]

8 78D001 1 WD V Series Gas F ireplace 72” Minimum Ceiling 12” Max. Depth 2 1 / 2 ” Max Depth 6” Min. From Opening 12” Min. From Opening 6” Min. FP2421 mantel clearances      ?[...]

78D001 1 9 WD V Series Gas F ireplace FP2430 secure fireplac e 6” The fireplace must be secured to the floor and/or to framing studs as shown in Figure 6. Use two (2) wood screws or masonry/ concrete screws to secure fireplace to the floor . Use four (4) screws to attach fireplace to framing. The side nailing flanges are 1/2" or 5/8" to[...]

10 78D001 1 WD V Series Gas F ireplace    Consult local building codes before beginning the installation. The installer must make sure to select the proper vent system for installation. The approved 5 x 8 venting components are Simpson Duravent and Selkirk products listed on Pa[...]

78D001 1 1 1 WD V Series Gas F ireplace       There are two basic types of direct-vent installation: • Horizontal T ermination • V ertical T ermination It is important to select the proper length of vent pipe for the type of t[...]

12 78D001 1 WD V Series Gas F ireplace    Figure 8 - Horizontal V ent Termination Location V ent T erminal Air Supply Inlet Area Where T erminals Not Permitted Inside Corner Detail    ?[...]

78D001 1 13 WD V Series Gas F ireplace V G G=6" (152mm) F F=6" (152mm) V V G G = Combustible 24"(610mm) Noncombustible 18"(457mm) Combustible & Noncombustible H = 24" (610mm) J = 20" (508mm) V H J C = Maximum depth of 48" (1219mm) for alcove location D = Minimum width for back wall of alcove location Combustib[...]

14 78D001 1 WD V Series Gas F ireplace                  [...]

78D001 1 15 WD V Series Gas F ireplace    A 10’ B 7’ 10’ FP2426 max vent run w/elbows Figure 14 - Maximum V ent Run with Elbows A + B = 17' Maximum 90° Elbow = 3' FP2426 Example: Elbow 1 = 90° Elbow 2 = 45° Elbow 3 = 45° Elbow 4 = 90° T otal Angular V ariation = 270[...]

16 78D001 1 WD V Series Gas F ireplace       This gas fireplace has been approved for , • V ertical installations up to 40' (12 m) in height. Up to a 10&a[...]

78D001 1 17 WD V Series Gas F ireplace         1. Determine the route your vertical venting will take. If ceiling joist, roof rafters or other framing will obstruct the vent[...]

18 78D001 1 WD V Series Gas F ireplace    3. Cut a hole in the roof using the locating hole as a center point. (Cover any exposed open vent pipes before cutting hole in roof). The 10 Zx "x10 Zx " (241 x 241 mm) hole must be measured on the horizontal. Actual length may be la[...]

78D001 1 19 WD V Series Gas F ireplace    1. Flexible UL1777 listed venting may be used in any vent ing appl ication where rigid direct ven t compo nents can be used.     ?[...]

20 78D001 1 WD V Series Gas F ireplace    T ermination Cap Storm Collar Roof Support Flashing Rigid Pipe Length Flex to Pipe Adapter (FP A/8) Firestop UL1777 Flex PIpe DVF8A/8 Adapter Figure 26 - T ypical V ertical Flex Vent Installation FP1975 pipe connection Screws (3 Places equidi[...]

78D001 1 21 WD V Series Gas F ireplace     Use proper gas type for the fireplace you are installing. If you have conflicting gas type, do not install fireplace. See dealer where you purchased the fireplace for proper fireplace for your gas[...]

22 78D001 1 WD V Series Gas F ireplace     The gas line connection may be made using 1/2" rigid tubing or an approved flex connector . Sinc e some muni cipa lit ies have additio nal local codes it is always best to co nsu lt your loca l author iti es and the cu[...]

78D001 1 23 WD V Series Gas F ireplace     1. Check gas type. The gas supply must be the same as stated on the appliance’s rating decal. If the gas su[...]

24 78D001 1 WD V Series Gas F ireplace COMMAND CENTER 4-AA BA TTERY COMP ARTMENT MASTER SWTICH CONVERSION NG/LP RF RECEIVER ON/OFF BUTTON ON/HI OFF/LO LED IGNITER/SP ARKER SENSING RED/THERMOPILE BLACK/THERMOPILE PILOT GAS TUBING PILOT CONTROL BOX PLUG IN CONNECTOR CONTROL BOX TO COMMAND CENTER PLUG IN CONNECTOR STEPPER MOTOR T O CONTROL BOX PLUG IN[...]

78D001 1 25 WD V Series Gas F ireplace        ?[...]

26 78D001 1 WD V Series Gas F ireplace     1. Remove the front access door by lifting up and sliding the two (2) spring hinge pins inward and lifting off. 2. Rotate the three (3) cam levers in the [...]

78D001 1 27 WD V Series Gas F ireplace   1. For best results, place the stones first. 2. Place the stones randomly against the stone stop bracket, in front of and behind the burner . ?[...]

28 78D001 1 WD V Series Gas F ireplace     This appliance is equipped with an ignition device which automatically lights the pilot. Refer to the instructions for match lighting.  BEFORE OPERA TING smell all[...]

78D001 1 29 WD V Series Gas F ireplace      1.  Read the safety information above. 2. This appliance is equipped with an ignition device [...]

30 78D001 1 WD V Series Gas F ireplace       • Easy Access Function Operation and System Configura- tion • Operation Confirmati on/Fault Di[...]

78D001 1 31 WD V Series Gas F ireplace      System configuration/setup is done on the Command Center . ?[...]

32 78D001 1 WD V Series Gas F ireplace       ?[...]

78D001 1 33 WD V Series Gas F ireplace      Figure 39 The RFSC Remote Control has two (2) operating modes: Manual and Thermostatic. The control system can be set to a tem[...]

34 78D001 1 WD V Series Gas F ireplace  Figure 43 1. Hold AUT O button for five (5) seconds and one number and flame icon will appear in LCD screen. 2. Use the ON / ▲ or OFF / ▼ button to set the desired flame height to [...]

78D001 1 35 WD V Series Gas F ireplace     Figure 47 1. Press AUX button once to turn ON. AUX shows on the LCD. 2. Press AUX button again to turn OFF . AUX icon disappears. °F FP2149 A UX di[...]

36 78D001 1 WD V Series Gas F ireplace  The fla mes from the bu rner sh ould be visually checked as soon as the hea ter i s in sta lled and periodi cal ly durin g normal operation. In normal operation, at full rate, and after operating for about 15 to 30 minu tes , the flam e shoul d be yellow . Figure 582 If the[...]

78D001 1 37 WD V Series Gas F ireplace    The fireplace and venting system should be inspected before initial use and at least annually by a qualified field service person. Inspect the external vent cap on a regular basis to make sure that no[...]

38 78D001 1 WD V Series Gas F ireplace  OPERA TION Install batteries and/or plug in the AC board Flip the master switch (rocker switch) to the ON position Press the ON button on the Command Center F AUL T No beep in about 8 seconds No beep or no sound from the valve indicating pilot solenoid open No s[...]

78D001 1 39 WD V Series Gas F ireplace      1 2 3 5 7 6 780012 DVW firebox parts       1. Bulb 6 78D0007K 2[...]

40 78D001 1 WD V Series Gas F ireplace     780012 DVW SG par ts 6/09 1 2 3 4 15 5 6 7 8 9 14[...]

78D001 1 41 WD V Series Gas F ireplace            1. Gas V alve Assembly 1 80D0001 80D0002 2. P[...]

42 78D001 1 WD V Series Gas F ireplace HOT 1 2 3 4 5 6 9 7 8 10 730024 KHLDV vent parts   [...]

78D001 1 43 WD V Series Gas F ireplace                     [...]

44 78D001 1 WD V Series Gas F ireplace         1. White Stone #1 5 78D0122K 2. Light Gray Stone #2 5 78D0123K 3. Dark Gray Stone #3 5 78D0124K 4. Brown Stone #4 5 78D0125K 5. Sand Stone #5 5 78D012[...]

78D001 1 45 WD V Series Gas F ireplace[...]

46 78D001 1 WD V Series Gas F ireplace   This product must be installed by a licensed plumber or gas fitter when installed within the Commonwealth of Massachusetts. ?[...]

78D001 1 47 WD V Series Gas F ireplace     The following components are warranted for life to the original owner , subject to proof of purchase: Firebox, Com- bustion Chamber , Heat Exchanger , Grate and[...]

 149 Cleveland Drive • Paris, Kentucky 40361 www .mhsc.com        WDV500NTSC WDV500PTSC[...]