Nexgrill 720-0125-LP manual

ST AINLESS STEEL GAS GRILL USE AND CARE GUIDE MODEL NO.:720-0125-LP FOR OUTDOOR USE ONL Y ® PLEASE CONT ACT 1-800-913-8999 FOR ASSIST ANCE DO NOT RETURN T O PLACE OF PURCHASE.[...]

* * * FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately ca ll you gas supplier or your fire department. FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP cylinder [...]

T ABLET ABLE OF CONTENTS SECTION TWO : Assembly instruction ………………4-1 1 Gas hook-Up ………………………. 12 Leak testing ….……………………. 12 Installer final ….…………………… .13 Propane tank Assemble ……………14 Operating instruction………………. 15 SECTION ONE : Precaution………………?[...]

PRECAUTIONS WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. TESTED IN ACCORDANCE WITH ANSI Z21.58a- 1995 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY . Check your local building code s for the proper method of installation. In the absence of local [...]

PRECAUTIONS When using the grill, do not touch the grill rack, burner grate or immediate surroundi n gs as these ar eas become extremely hot and coul d cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or potholders. Do not let poth olders touch hot [...]

ASSEMBLY INSTRUCTIONS PLEASE READ THE INSTRU CTIONS C AREFULLY AND FOLLOW STEP BY STEP . Attention: Please lock the caster during the process of installation of the grill. TOOLS REQUIRED: Philips head scre wdriver( not provide),monkey wrench(not provide) T h e G l a s s o T M Step1 ： . Assemble two regular casters to the right side panels and ca [...]

Step 2 : : Assemble bottom panel to side panels,back panel and tran som panel with eight( 14) 1/4’ *15 mm screws as shown figure belo w Step 3 : Assemble the head pa rt to the bo by w or k part. Rem ove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from the top with f our (4)1/4*13mm screws. Caution!! The[...]

Step 4 : First assem ble handle of side shel f,then assemble sp rice tray and cont rol panel of si de burner as the figure show below: Step5 : Remove the head unit of screws with four (8)1/4’*13mm screws. T M T h e G l a s s o 6[...]

Step 6 : Assemble the fortified steel to the main with (8)1/4’*13. . T M T h e G l a s s o Step7 : Assemble side shelf and side burner with four(8) 1/4*13mm screws as figure show below . T h e G l a s s o T M 7[...]

ASSEMBLY INSTRUCTIONS Side burner valve assembly: Step 1: Insert valve assembly through si de Step 2: Remove 4(four) screws & washers panel from the “U” brackets on the side burner Step 3: Insert valve stem assembly into burner Step 4: Insert valve stem assembly through kn ob venturi hole to the control panel Step 5: Replace “U” bracket[...]

Step 8: Assemble the door to the gr ill as the figure show below: T M T h e G l a s s o Step9 : Assemble the motor bracket to the fi re box with four (4) 1/4*10mm screws. T h e G l a s s o T M 9[...]

How to install a gas tank  Opening the front door and place gas tank into the gas tank holes.  Secure the gas tank by turning the retention screw at the right of the grill clockwise until it is tight . . 10[...]

Your gas grill is ready to use 11[...]

GAS HOOK-UP Only the pressure regulator and ho se assembly supplied with the grill should be used. Any replacement pressure regulator an d hose assembly must be specified by the grill manufacturer. This is a liquid propane co nfigured grill. Do not attempt to use a natural gas supply unless the grill has been reconfigured for natural gas use. Total[...]

BEFORE TESTING Make sure that all packing material i s removed from the grill including the bur ner tie-down straps. DO NOT SMOKE WHILE LEAK TESTING. NEVER LEAK TEST WITH AN OPEN FLAME. Make a soap solution of one part liquid d eterge nt and one part water. You will need a spra y bottle, brush, or rag to apply the solution to the fittings. For the [...]

PROPANE TANK ASSEMBLE Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below. LP gas cylinder must be fitted with a listed overfill prevention device (OPD) 14[...]

OPERATING INSTRUCTION General use of the grill Each main burner is rated at 12,000 Btu/ hr. The main grill burners encompass the entire cooking area and are side ported to minimize bl ockage from falling grease and debris. Above the bu rners are stainless steel radiant (flame covers). The igniter knobs are located on the lower cente r portion of th[...]

LIGHTING INSTRUCTIONS WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the ga s “ON”. If there is evidence of cuts, wear, o r abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose as sem bly supplied with the unit should be used. Ne[...]

USING THE SIDE BURNER WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the ga s “ON”. If there is evidence of cuts, wear o r abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. WARNING: Always keep your face a nd body as far away from the burner as possible[...]

LIGHTING ILLUSTRATIONS Step1. Make sure the lid is open Step 2. Push and turn one of main or side burner knobs to HI position Step 3. You may need 3 or 4 trials to light the burner. After the burner is lit, adjust the knob as desired 18[...]

Approximate 1 1/2 “ Flame Height 19[...]

TO MATCH LIGHT THE GRILL If the burner will not light after sev eral attempts t hen the burner can be match lit. If you ’ ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit light rod or lighter through the cooki[...]

CARE & MAINTENANCE OF SIDE BURNER BURNER CLEAN ING: Clean the exterior of the burner with a wire b ru sh. Clear any cl ogg ed burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a woode n toothpick as it may break off the clog the port. STAINLESS STEEL: There are many different stainle ss steel cleaners availa[...]

EXPLODED VIEW 37 39 38 30 29 28 19 18 17 11 10 09 08 07 06 05 04 03 02 01 31 13 27 26 23 25 24 21 22 20 12 32 15 16 14 36 34 35 33 22[...]

P AR TS LIST REF# DESCRIPTION Q’TY REF# DESCRIPTION QTY 01 Lid, Front 1 21 Side Burner Body 1 02 Heat Indicator 1 22 Bowl Assembly , Side Burner 1 03 Handle Assembly , Lid 1 23 Lid, Side Burner 1 04 W arming Rack 1 24 Orifice Base 1 05 Cooking Grid With Hole 2 25 Gas Pipe, Side Burner 1 06 Flame T amer 3 26 Gas V alve, Side Burner 1 07 Main Burne[...]

ORDERING PARTS HOW TO ORDER REPLACEMENT PARTS To make sure you obtain the correct replacement part(s) for your gas grill, please refer to the parts list on this page. The following information is required to assure getting the correct part. To obtain replace me nt parts, conta ct the dealer from which products was purchased. If dealer service is no[...]

GRILL COOKING CHART 25[...]

GRILL COOKING CHART 26[...]

GRILL COOKING CHART 27[...]

GRILL COOKING CHART BBQ SALMON 2 large salmon steaks 2 tbs. Oil Salt & pepper 2 oz. thin bacon slices 2 tbs. Butter 1 tbs. Lem on juice Spring of parsley Lemon wedges Preheat the BBQ. Brush the steaks with oi l and season with salt and pepper. Place on BBQ grill and cook for 10 minutes, turning s teaks over halfway cooking time. Meanwhile fry t[...]

GRILL COOKING CHART In blender, process 1/3 c. wate r, onion, s oy sauce, 2 tsp. oil and the next 8 ingredie nts until smooth. Pour over meat cubes and m arinate about 4 hours, turni ng occasionally. Drain and reserve marinade. Onto to four 12” skewers alternately thread meat, pepper, banana and mushrooms. Preheat grill. Brush the kabobs wit h oi[...]

GRILL COOKING CHART CHICKEN T ANDO ORI STYLE 8 large chicken thig hs or drumst icks 1 c. plain nonfat yogurt ½ c. lemon jui ce 2 tsp. salt ½ tsp. cayenne ½ tsp. black pepper ½ tsp. crushed garlic ½ tsp. grated ginger 1 tbs. corn oil Combine all the ingredients in a large mixing bowl and marinate the chicken for 8 hours in the refrigerator. Dra[...]

LIMITED WARRANTY MODEL NO.: 720-0125-LP STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrant s to the original co nsumer purchas er of each Out door Gas Grill that when subject to normal residential use, it is free from defect s in workmanship and materials for the periods specified below . This warranty excludes grills used in renta[...]