Opel Corsa (2012) manual

OPEL CORSA Owner's Manual[...]

[...]

Introduction .................................... 2 In brief ............................................ 6 Keys, doors and windows ............ 20 Seats, restraints ........................... 35 Storage ........................................ 52 Instruments and controls ............. 69 Lighting ........................................ 96 Climat[...]

2 Introduction Introduction[...]

Introduction 3 Vehicle specific data Please enter your vehicle's data on the previous page to keep it easily accessible. This information is available under the sections "Service and Maintenance" and "Technical data" as well as on the identification plate. Introduction Your vehicle is a designed combination of advanced tech[...]

4 Introduction Danger, Warnings and Cautions 9 Danger Text marked 9 Danger provides information on risk of fatal injury. Disregarding this information may endanger life. 9 Warning Text marked 9 Warning provides information on risk of accident or injury. Disregarding this information may lead to injury. Caution Text marked Caution provides informati[...]

Introduction 5[...]

6 In brief In brief Initial drive information Vehicle unlocking Turn the key in the driver's door lock to the front or press button q to unlock the doors and load compartment. Open the doors by pulling the handles. To open the tailgate, pull the button under the tailgate moulding. Radio remote control 3 20, Central locking system 3 22, Load co[...]

In brief 7 Seat backrests Turn handwheel. Do not lean on seat when adjusting. Seat adjustment 3 37, Seat position 3 36, Folding front passenger seat backrest 3 38. Seat height Lever pumping motion up = higher down = lower Seats 3 37, Seat position 3 36. Head restraint adjustment Press release button, adjust height, engage. Head restraints 3 35.[...]

8 In brief Seat belt Pull out the seat belt and engage in belt buckle. The seat belt must not be twisted and must fit close against the body. The backrest must not be tilted back too far (maximum approx. 25 °). To release belt, press red button on belt buckle. Seat belts 3 39, Airbag system 3 42, Seat position 3 36. Mirror adjustment Interior mirr[...]

In brief 9 Setting with four-way switch in version with electronic window operation First select the relevant exterior mirror then use the control to adjust. Electric adjustment 3 28, Convex exterior mirrors 3 28, Folding exterior mirrors 3 28, Heated exterior mirrors 3 29. Steering wheel adjustment Unlock lever, adjust steering wheel, then engage [...]

10 In brief Instrument panel overview[...]

In brief 11 1 Side air vents ...................... 110 2 Light switch .......................... 96 Instrument illumination ....... 101 Rear fog light ....................... 100 Front fog lights ................... 100 Headlight range adjustment ........................... 97 3 Turn and lane-change signals, headlight flash, low beam and high beam[...]

12 In brief[...]

In brief 13 Exterior lighting Turn light switch AUTO = Automatic light control: Exterior lighting is switched on and off automatically m = Activation or deactivation of the automatic light control 8 = sidelights 9 = low beam Press light switch > = Front fog lights r = Rear fog lights Lighting 3 96. Headlight flash, high beam and low beam headlig[...]

14 In brief Turn and lane-change signals right = lever up left = lever down Turn and lane-change signals 3 99, Parking lights 3 100. Hazard warning flashers Operated with the ¨ button. Hazard warning flashers 3 99. Horn Press j .[...]

In brief 15 Washer and wiper systems Windscreen wiper & = fast % = slow $ = timed interval wipe or automatic wiping with rain sensor § = off For a single wipe when the windscreen wiper is off, press the lever down. Windscreen wiper 3 71, Wiper blade replacement 3 149. Windscreen and headlight washer systems Pull lever. Windscreen and headlight[...]

16 In brief Climate control Heated rear window, heated exterior mirrors Heating is operated by pressing the Ü button. Heated rear window 3 32. Demisting and defrosting the windows Air distribution to l . Set temperature control to warmest level. Set fan speed to highest level. Cooling n on. Press button V . Climate control system 3 104. Transmissi[...]

In brief 17 Manual transmission automated N = neutral position o = drive position + = higher gear - = lower gear A = switch between automatic and manual mode R = reverse gear (with selector lever lock) Manual transmission automated 3 122. Automatic transmission P = park position R = reverse gear N = neutral position D = drive position The selector [...]

18 In brief Starting the engine ■ Turn key to position 1 ■ move the steering wheel slightly to release the steering wheel lock ■ operate clutch and brake, if the clutch pedel is not operated the engine might not start and the control indicator - could illuminate ■ automatic transmission in P or N ■ do not operate accelerator pedal ■ die[...]

In brief 19 Parking ■ Always apply the parking brake without pressing the release button. Apply as firmly as possible on a downhill slope or uphill slope. Depress the foot brake at the same time to reduce operating force. ■ Switch off the engine. Turn the ignition key to 0 and remove it. Turn the steering wheel until the steering wheel lock is [...]

20 Keys, doors and windows Keys, doors and windows Keys, locks ................................... 20 Doors ........................................... 25 Vehicle security ............................ 26 Exterior mirrors ............................ 28 Interior mirrors ............................. 30 Windows ...................................... [...]

Keys, doors and windows 21 Used to operate: ■ Central locking system, ■ Anti-theft locking system, ■ Anti-theft alarm system, ■ Power windows. The radio remote control has an approximate range of up to 5 metres. This range can be affected by outside influences. The hazard warning flashers confirm operation. Handle with care, protect from mo[...]

22 Keys, doors and windows Radio remote control synchronisation After replacing the battery, unlock the door with the key in the driver's door lock. The radio remote control will be synchronised when you switch on the ignition. Memorised settings Whenever the vehicle is locked, the following settings are automatically memorised by the key bein[...]

Keys, doors and windows 23 Central locking system with radio remote control Press button q . Two settings are possible: ■ To unlock only the driver's door, press button q once, to unlock the entire vehicle, press button q twice. ■ To unlock the entire vehicle, press button q once. Settings can be changed in the Driver Information Centre. V[...]

24 Keys, doors and windows Central locking button Press button m : the doors are locked or unlocked. The LED in the button m illuminates for approx. 2 minutes after locking with the radio remote control. If the doors are locked from the inside whilst driving, the LED remains lit. Fault in radio remote control Unlocking Turn the key in the driver&ap[...]

Keys, doors and windows 25 Insert the key into the opening above the lock on the inside of the door and operate the lock by lifting until it clicks. Then close the door. The procedure must be carried out for each door. The driver's door can also be locked from the outside with the key. The fuel filler flap and tailgate cannot be locked. Automa[...]

26 Keys, doors and windows Note The installation of certain heavy accessories onto the tailgate may affect its ability to remain open. Closing Use the interior handle. Do not press the button under the moulding while closing as this will unlock the tailgate again. Vehicle security Anti-theft locking system 9 Warning Do not use the system if there a[...]

Keys, doors and windows 27 Unlocking the vehicle deactivates both systems simultaneously. Light-emitting diode (LED) During the first 10 seconds of anti- theft alarm system activation: LED illuminates = Test, ignition delay, LED flashes quickly = Door, load compartment or bonnet open, or system fault. After the first 10 seconds of anti-theft alarm [...]

28 Keys, doors and windows Exterior mirrors Convex shape The convex exterior mirror contains an aspherical area and reduces blind spots. The shape of the mirror makes objects appear smaller, which will affect the ability to estimate distances. Electric adjustment Setting with four-way switch in version with manual window operation First select the [...]

Keys, doors and windows 29 Corsa OPC: For pedestrians safety, the exterior mirrors of the Corsa OPC are released from the holder if they are bumped. Fit mirror housing to holder with latching lugs and engage by striking gently. Manual The exterior mirrors can be folded in by pressing gently on the outer edge of the housing. Heated Operated by press[...]

30 Keys, doors and windows Interior mirrors Manual anti-dazzle To reduce dazzle, adjust the lever on the underside of the mirror housing. Automatic anti-dazzle Dazzle from following vehicles at night is automatically reduced. Windows Windscreen Heat-reflecting windscreen The heat-reflecting windscreen has a coating which reflects solar radiation. A[...]

Keys, doors and windows 31 Vignettes Do not attach vignettes or similar on the windscreen in the area of the interior mirror. Otherwise the detection zone of the sensor and the view area of the camera in the mirror housing could be restricted. Manual windows The door windows can be opened or closed with the window winders. Power windows 9 Warning T[...]

32 Keys, doors and windows Operating windows from outside Depending on the equipment level, the windows can be operated remotely from outside the vehicle. Press q or p until all windows have opened or closed. Overload If the windows are repeatedly operated at short intervals, the window operation is disabled for some time. Fault If the windows cann[...]

Keys, doors and windows 33 If the sun visors have integral mirrors, the mirror covers should be closed when driving. Roof Sunroof 9 Warning Take care when operating the sunroof. Risk of injury, particularly to children. Keep a close watch on the movable parts when operating them. Ensure that nothing becomes trapped in them as they move. Sunroof can[...]

34 Keys, doors and windows Caution When using a roof rack, check the free movement of the sunroof in order to avoid damage. It is only permitted to raise the sunroof. Note If the top of the roof is wet, tilt sunroof, allow water to run off and then open sunroof. Do not affix any stickers to sunroof. Close Hold down d until the sunroof is completely[...]

Seats, restraints 35 Seats, restraints Head restraints ............................ 35 Front seats ................................... 36 Seat belts ..................................... 39 Airbag system .............................. 42 Child restraints ............................. 46 Head restraints Position 9 Warning Only drive with the head re[...]

36 Seats, restraints Head restraints on rear seats The height of the head restraints can be set in two positions. To set in the first position, pull the head restraint upwards, in the second position press the spring marked in the illustration and push the head restraint right up to the top. To adjust downwards, press the spring marked in the illus[...]

Seats, restraints 37 ■ Sit with shoulders as far back against the backrest as possible. Set the backrest to an angle so that it is possible to reach the steering wheel with arms slightly bent. Maintain contact between shoulders and the backrest when turning the steering wheel. Do not tilt the backrest too far back. We recommend a maximum angle of[...]

38 Seats, restraints Seat height Lever pumping motion up = higher down = lower Seat folding Lift release lever and tilt backrest forwards. Lower release lever and backrest engages in lowered position. Slide seat forwards. To push the seat back to upright, it engages in its original position. Lift the release lever, move the backrest back to upright[...]

Seats, restraints 39 Heating Activate heating by pressing ß button for the seat with the ignition on. LED in button ß on: relevant front seat heating on. Seat heating is operational when the engine is running and during an Autostop. Seat belts The belts are locked during heavy acceleration or deceleration of the vehicle for the safety of the occu[...]

40 Seats, restraints Belt tensioners In the event of a head-on or rear-end collision of a certain severity, the front seat belts are tightened. 9 Warning Incorrect handling (e.g. removal or fitting of belts) can trigger the belt tensioners with risk of injury. Deployment of the belt tensioners is indicated by illumination of control indicator v 3 7[...]

Seats, restraints 41 9 Warning The belt must not rest against hard or fragile objects in the pockets of your clothing. Height adjustment 1. Pull belt out slightly. 2. Press button. 3. Adjust height and engage audibly. Adjust the height so that the belt lies across the shoulder. It must not lie across the throat or upper arm. Do not adjust while dri[...]

42 Seats, restraints Airbag system The airbag system consists of a number of individual systems. When triggered the airbags inflate within milliseconds. They also deflate so quickly that it is often unnoticeable during the collision. 9 Warning If handled improperly the airbag systems can be triggered in an explosive manner. Note The airbag systems [...]

Seats, restraints 43 The forward movement of the front seat occupants is decelerated, thereby considerably reducing the risk of injury to the upper body and head. 9 Warning Optimum protection is only provided when the seat is in the proper position 3 36. Keep the area in which the airbag inflates clear of obstructions. Fit the seat belt correctly a[...]

44 Seats, restraints Curtain airbag system The curtain airbag system consists of an airbag in the roof frame on each side. This can be identified by the word AIRBAG on the roof pillars. The curtain airbag system is triggered in the event of an accident of a certain severity. The ignition must be on. The risk of injury to the head in the event of a [...]

Seats, restraints 45 Control indicator W and LEDs in the button not on: Airbag systems for the front passenger are active. No child restraint systems can be installed. Control indicator W and LEDs in button on: Front passenger airbags are deactivated and will not inflate in the event of a collision. A child restraint system according to the chart C[...]

46 Seats, restraints Control indicator for airbag deactivation 3 79. Starting the engine terminates changing of the setting. The setting can then only be changed once the ignition has been switched off and then back on again. Child restraints Child restraint systems When a child restraint system is being used, pay attention to the following usage a[...]

Seats, restraints 47 Note Do not stick anything on the child restraint systems and do not cover them with any other materials. A child restraint system which has been subjected to stress in an accident must be replaced.[...]

48 Seats, restraints Child restraint installation locations Permissible options for fitting a child restraint system Weight and age class On front passenger seat On rear outboard seats On rear centre seat activated airbag deactivated airbag Group 0: up to 10 kg or approx. 10 months X U 1 U 2 X Group 0+: up to 13 kg or approx. 2 years X U 1 , 2 U 2 [...]

Seats, restraints 49 Permissible options for fitting an ISOFIX child restraint system Weight class Size class Fixture On front passenger seat On rear outboard seats On rear centre seat Group 0: up to 10 kg E ISO/R1 IL IL X Group 0+: up to 13 kg E ISO/R1 IL IL X D ISO/R2 X X X C ISO/R3 X X X Group I: 9 to 18 kg D ISO/R2 X X X C ISO/R3 X X X B ISO/F2[...]

50 Seats, restraints ISOFIX size class and seat device A – ISO/F3 = Forward-facing child restraint system for children of maximum size in the weight class 9 to 18 kg. B – ISO/F2 = Forward-facing child restraint system for smaller children in the weight class 9 to 18 kg. B1 – ISO/F2X = Forward-facing child restraint system for smaller children[...]

Seats, restraints 51 Isofix child restraint systems Fasten vehicle-approved ISOFIX child restraint systems to the mounting brackets. When using ISOFIX mounting brackets for seat mounting, universally approved child restraint systems for ISOFIX may be used. ISOFIX mounting brackets are indicated by a label on the backrest. Closely follow the install[...]

52 Storage Storage Storage compartments ................ 52 Load compartment ....................... 62 Roof rack system ......................... 66 Loading information ..................... 67 Storage compartments Glovebox The glovebox features: ■ a card holder in cheque card format ■ a pen holder ■ pocket torch holder. The glovebox should [...]

Storage 53 Underseat storage Lift at recessed edge and pull out. Maximum load: 1.5 kg. To close, push in and engage. Rear carrier system The rear carrier system (Flex-Fix system) allows bicycles to be attached to a pull-out carrier integrated into the vehicle floor. The transportation of other objects is not permitted. The maximum load of the rear [...]

54 Storage Pull release lever up. The system disengages and travels quickly out of the bumper. Completely pull out the rear carrier system until you hear it engage. Ensure that it is not possible to push in the rear carrier system without pulling the release lever again. 9 Warning It is only permissible to fit objects to the rear carrier system if [...]

Storage 55 Push the clamping lever down and push the lamp support into the retainer until it engages. Perform this procedure for both tail lamps. Check the cable and lamp position to make sure these are correctly installed and are securely located. Lock the rear carrier system Swivel the left clamping lever ( 1 ) first, followed by the right clampi[...]

56 Storage Remove the pedal crank mounts from the pedal crank recesses. Adapting the rear carrier system to a bicycle Press the release lever and withdraw the wheel recesses. Push the release lever on the strap retainer and remove the strap retainer.[...]

Storage 57 Prepare the bicycle for attachment Note The maximum width for the pedal crank is 38.3 mm and the maximum depth is 14.4 mm. Rotate the left pedal (without a chain cog) vertically downwards. The pedal on the left pedal crank must be horizontal. The front bicycle must have its front wheel facing left. The rear bicycle must have its front wh[...]

58 Storage Put on the bicycle. The pedal crank here must be placed in the pedal crank recess opening as shown in the illustration. Caution Make sure that the pedal does not touch the surface of the rear end carrier. Otherwise the crankset might be damaged during the transport. Insert pedal crank mount into outer rail of each pedal crank recess from[...]

Storage 59 If the two bicycles obstruct one another, the relative positions of the bicycles can be adapted by adjusting the wheel recesses and the rotary lever on the pedal crank recess until the bicycles no longer touch one another. Make sure there is sufficient clearance from the vehicle. Tighten the attachment screw for the pedal bearing mount t[...]

60 Storage Retracting the rear carrier system Push the pedal crank mounts into the pedal crank recess as shown in the illustration. Insert the strap retainer and pull tightly downwards as far as possible. Press release lever and slide in wheel recesses all the way as far as they will go. Disengage the locking lever on the diagonal support and fold [...]

Storage 61 Swivel first the right clamping lever ( 1 ) forwards, followed by the left clamping lever ( 2 ), until they can be engaged in their respective recesses. Push the clamping lever down and pull both lamp supports out of the recesses. Fold in the lamp supports on the backs of the tail lamps. First place the front tail lamp ( 1 ), then the re[...]

62 Storage Load compartment Load compartment extension The rear backrest, in a single unit or split, can be locked in an upright position for transporting bulky items. Pull the release handle, pull the backrest forwards to the vertical position and engage. When unlocking, a red marking appears next to the release lever. The backrest is only engaged[...]

Storage 63 Move rear seat backrests upright and allow locking mechanisms to engage audibly at both sides. Once the backrests are locked the red mark must no longer protrude. The rear seat backrests can be locked in two positions. Do not trap the seat belt when moving the backrest to the upright position. Install the load compartment cover. 9 Warnin[...]

64 Storage 3-door passenger vehicle Lift the cover backwards until it unlatches, set at an angle, then remove. Fit in reverse order. Stowing When the load compartment is fully loaded, stow the load compartment cover behind the rear seat backrests: Lift the cover backwards until it unlatches, then slide down in guides behind the seat backrests. Van [...]

Storage 65 Rear floor storage cover The double load-bay floor can be inserted in the load compartment in two positions: ■ directly beneath the cover for the spare wheel recess or the floor cover, ■ or in the upper openings in the load compartment. To remove, lift the load-bay floor using the lever and pull backwards. To insert, push the load-ba[...]

66 Storage Warning triangle Store warning triangle in rear load compartment wall: first fit warning triangle into recess on left and then insert in guide on right. To remove the warning triangle, lift to the right and pull out to the right. First aid kit Stow the first-aid kit (cushion) in the compartment in the left wall of the load compartment. T[...]

Storage 67 Fitting on model with sun roof Disengage covers concealing roof rack mounts by pushing sliders in direction of arrow (e.g. with coin) and remove upwards. To close roof rack mounts, first insert covers at front and engage sliders at rear. Attach roof rack at appropriate points, see enclosed roof rack system instructions. Loading informati[...]

68 Storage around inside the vehicle and cause personal injury or damage to the load or car. ■ The payload is the difference between the permitted gross vehicle weight (see identification plate 3 189) and the EC kerb weight. To calculate the payload weight, enter the data for your vehicle in the Weights table at the front of this manual. The EC k[...]

Instruments and controls 69 Instruments and controls Controls ....................................... 69 Warning lights, gauges and indicators ..................................... 75 Information displays ..................... 84 Vehicle messages ........................ 88 Trip computer ............................... 90 Vehicle personalisation ..[...]

70 Instruments and controls Heated steering wheel Activate heating in combination with the seat heating by pressing ß * button once or several times with the ignition on. LED ß on: driver seat heating on. LED ß and * on: driver seat heating and steering wheel heating on. LED * on: steering wheel heating on. The steering wheel is heated in the ar[...]

Instruments and controls 71 Windscreen wiper/washer Windscreen wiper The lever always springs back to its original position. & = fast % = slow $ = interval wiping § = off For a single wipe when the windscreen wiper is off, press the lever down. Run through the windscreen wiper stages by pushing the lever past the resistance point and holding i[...]

72 Instruments and controls Keep the sensor free from dust, dirt and ice. Windscreen washer Pull lever. Washer fluid is sprayed onto the windscreen and the wiper wipes a few times. Rear window wiper/washer Push lever forwards. The rear window wiper wipes in interval mode. Switch off by pushing lever forwards again. Do not use if the rear window is [...]

Instruments and controls 73 icy road conditions. : remains illuminated until the temperature reaches at least 5 °C. In vehicles with Graphic-Info-Display or Color-Info-Display, a warning message appears in the display as a warning for icy road conditions. There is no message below -5 °C. 9 Warning The road surface may already be icy even though t[...]

74 Instruments and controls Power outlets The power outlet is located in the centre console. Caution Do not damage the outlet by using unsuitable plugs. Connecting electrical accessories while the engine is off will discharge the battery. Do not exceed the maximum power consumption of 120 Watts. Do not connect any current-delivering accessories, e.[...]

Instruments and controls 75 The portable ashtray can be placed in the cupholders. Open cover to use. Warning lights, gauges and indicators Instrument cluster In some versions, the needles of the instruments briefly rotate to the end position when the ignition is switched on. Speedometer Indicates vehicle speed. Speed warning With the "Personal[...]

76 Instruments and controls Trip odometer The top line displays the recorded distance since the last reset. To reset, hold the reset knob depressed for a few seconds with the ignition on. Tachometer Displays the engine speed. Drive in a low engine speed range for each gear as much as possible. Upshift when indicated by the control indicator [ 3 81.[...]

Instruments and controls 77 1 off = petrol operation 1 illuminates = liquid gas operation 1 flashes = no switching is possible, one type of fuel is empty As soon as the liquid gas tanks are empty, petrol operation is automatically engaged until the ignition is switched off. Fuel for liquid gas operation 3 131. Service display The message InSP appea[...]

78 Instruments and controls Control indicators in the instrument[...]

Instruments and controls 79 Turn signal O illuminates or flashes green. Illuminates The control indicator illuminates briefly when the parking lights are switched on. Flashes The control indicator flashes if a turn signal or the hazard warning flashers are activated. Rapid flashing: failure of a turn signal light or associated fuse, failure of turn[...]

80 Instruments and controls Illuminates when the engine is running Stop, switch off engine. Battery is not charging. Engine cooling may be interrupted. In diesel engines, power to the brake servo unit may be cut. Seek the assistance of a workshop. Flashes during or after engine start Battery voltage too low. Have electrical system tested by a works[...]

Instruments and controls 81 On vehicle with automated manual transmission, R flashes for a few seconds when the ignition is switched off if the parking brake is not applied. On vehicles with automated manual transmission, R flashes when the driver's door is opened if no gear is engaged and the parking brake is not applied. Apply clutch pedal -[...]

82 Instruments and controls Illuminates for a few seconds when the ignition is switched on. Flashing during driving The system is actively engaged. Engine output may be reduced and the vehicle may be braked automatically to a small degree 3 128. Illuminates while driving The system is switched off or a fault is present. Continued driving is possibl[...]

Instruments and controls 83 Illuminates when the engine is running Caution Engine lubrication may be interrupted. This may result in damage to the engine and/or locking of the drive wheels. 1. Depress clutch. 2. Select neutral gear, set selector lever to N . 3. Move out of the flow of traffic as quickly as possible without impeding other vehicles. [...]

84 Instruments and controls Adaptive forward lighting B illuminates yellow. Illuminates when the engine is running Fault in system. Seek the assistance of a workshop. Illuminates after ignition is switched on Control indicator B illuminates for approx. 4 seconds as a functionality test. Control indicator B illuminates for approx. 8 seconds as a rem[...]

Instruments and controls 85 Graphic-Info-Display, Colour-Info-Display Displays time, outside temperature, date or Infotainment system (when it is on) and electronic climate control system. The Color-Info-Display displays the information in colour. The type of information and how it is displayed depends on the equipment of the vehicle and the settin[...]

86 Instruments and controls Function areas For each function area there is a main page (Main), which is selected at the top edge of the display (only with trip computer and Mobile Phone Portal): ■ Audio, ■ Telephone, ■ Trip computer. System settings Press the Settings button on the Infotainment system. For Infotainment system CD 30, no menu m[...]

Instruments and controls 87 Some transmitters do not send a correct time signal. In such cases, we recommend to switch off automatic time synchronisation. The function is activated by highlighting the field in front of Synchron. clock automatical. in the Time, Date menu. Language selection The display language for some functions can be selected. Se[...]

88 Instruments and controls Adjusting contrast ( Graphic-Info-Display) Select menu item Contrast from the Settings menu. Confirm the required setting. Setting display mode Display brightness is dependent on vehicle lighting. Additional settings can be made as follows: Select menu item Day / Night from the Settings menu. Automatic The colours are ad[...]

Instruments and controls 89 engine is running, a gear is engaged and the foot brake is not depressed. ■ Warning signal sounds three times if the rear carrier system is extended and reverse gear is selected. When the vehicle is parked and the driver's door is opened ■ When the key is in the ignition switch. ■ With exterior lights on. ■ [...]

90 Instruments and controls Trip computer The trip computer provides information on driving data, which is continually recorded and evaluated electronically. The functions can be selected via the buttons on the wiper lever. Turn the adjuster wheel to select: ■ Range ■ Instantaneous consumption ■ Distance travelled ■ Average speed ■ Absolu[...]

Instruments and controls 91 Average consumption Display of average consumption. The measurement can be reset at any time. Stop watch Measurement of the time from activation to deactivation. Press the 7 button to start and stop the measurement. Reset trip computer The measurement or calculation of the following trip computer information can be resta[...]

92 Instruments and controls When the fuel level in the tank is low, the message Range appears in the display. When the fuel tank is nearly empty, the message Please refuel! appears in the display. Instantaneous consumption Displays the instantaneous consumption. At low speeds, consumption per hour is displayed. Distance Display of distance travelle[...]

Instruments and controls 93 The information of the two trip computers can be reset separately, making it possible to evaluate data from different time periods. Select the required trip computer information and confirm. To reset all information of a trip computer, select menu item All values . Stop watch Select menu item Stop Watch from the Board Co[...]

94 Instruments and controls Driving Time incl. Stops The time the vehicle is in motion is recorded. The time the vehicle is stationary with the ignition switched on is included. Travel Time Measurement of the time from manual activation via Start to manual deactivation via Reset . Vehicle personalisation The vehicle-specific functions P1 to P7 can [...]

Instruments and controls 95 ■ Push the turn signal stalk (left) up or down and select the desired function P1 - P7 . ■ Push the wiper stalk (right) up or down and select status On or OFF , or input a value for speed ( P6 ) or value for volume ( P7 ). ■ Pull turn signal stalk (left) and wiper stalk (right) simultaneously to the steering wheel [...]

96 Lighting Lighting Exterior lighting ............................ 96 Interior lighting ........................... 101 Lighting features ........................ 103 Exterior lighting Light switch Turn light switch: AUTO = Automatic light control: Exterior lighting is switched on and off automatically depending on external lighting conditions. m [...]

Lighting 97 Automatic light control function When the automatic light control function is switched on and the engine is running, the system switches between daytime running light and low beam in dependence of lighting conditions. Daytime running light Daytime running light increases visibility of the vehicle during daylight. Tail lights are not on.[...]

98 Lighting 0 = Front seats occupied 1 = All seats occupied 2 = All seats occupied and load compartment laden 3 = Driver's seat occupied and load compartment laden Headlights when driving abroad The asymmetrical headlight beam extends visibility at the edge of the road at the passenger side. However, when driving in countries where traffic dri[...]

Lighting 99 Reversing function If the lights are on, reverse gear is engaged, and the turn signal is activated, the cornering light on the appropriate side is switched on. The cornering light stays on for 15 seconds once the turn signal has been switched off. Control indicator B 3 84. Hazard warning flashers Operated with the ¨ button. The hazard [...]

100 Lighting Front fog lights Operated with the > button. Light switch in position AUTO : switching on front fog lights will switch the low beam on automatically. Rear fog lights Operated with the r button. Light switch in position AUTO : switching on front fog lights will switch the low beam on automatically. The rear fog light can only be swit[...]

Lighting 101 Reversing lights The reversing lights come on when the ignition is on and reverse gear is selected. Misted light covers The inside of the light covers may mist up briefly in poor, wet and cold weather conditions, in heavy rain or after washing. The mist disappears quickly by itself; to help, switch on the exterior lights. Interior ligh[...]

102 Lighting Front courtesy light with reading lights Operated with the c button when the doors are closed. Rear courtesy lights Operated with switch. I = On 0 = Off centre = automatic Load compartment lighting The lighting switches on when opened. Reading lights Operated with a buttons with ignition on.[...]

Lighting 103 Lighting features Centre console lighting Spotlight in interior mirror housing. Daylight-dependent, automatically regulated centre console lighting. Entry lighting After unlocking the vehicle, the instrument panel lighting, the front and rear foot well lighting and the information display come on for a few seconds. Starting off 3 17. P[...]

104 Climate control Climate control Climate control systems ............. 104 Air vents ..................................... 110 Maintenance .............................. 111 Climate control systems Heating and ventilation system Controls for: ■ Temperature ■ Fan speed ■ Air distribution Heated rear window Ü 3 32. Temperature red = warm bl[...]

Climate control 105 ■ Open side air vents as required and direct them towards door windows. ■ For simultaneous warming of the foot well, set air distribution control to J . Note If the settings for demisting and defrosting are selected, an Autostop will be inhibited. If the settings for demisting and defrosting are selected while the engine is [...]

106 Climate control 9 Warning The exchange of fresh air is reduced in air recirculation mode. In operation without cooling the air humidity increases, so the windows may mist up from inside. The quality of the passenger compartment air deteriorates, which may cause the vehicle occupants to feel drowsy. Air distribution to l : Air recirculation is d[...]

Climate control 107 Controls for: ■ Temperature ■ Air distribution and menu selection ■ Fan speed AUTO = Automatic mode 4 = Air recirculating V = Demisting and defrosting Heated rear window Ü 3 32. The preselected temperature is automatically regulated. In automatic mode, the fan speed and air distribution automatically regulate the air flow[...]

108 Climate control To return to automatic mode: Press AUTO button. Demisting and defrosting the windows Press the V button. V appears in the display. Temperature and air distribution are set automatically and the fan runs at a high speed. To return to automatic mode: Press button V or AUTO . Switch on heated rear window Ü . Note If the V button i[...]

Climate control 109 If no cooling or drying is required, deactivate AC to save fuel. When the cooling system is switched off, no engine restart will be requested by the climate control system during an Autostop. Depending on the vehicle equipment, the display will indicate AC when cooling is activated or Eco when the cooling is deactivated. On vehi[...]

110 Climate control Auxiliary heater Air heater Quickheat is an electric auxiliary air heater which automatically warms up the passenger compartment more quickly. Coolant heater Diesel-engined vehicles have a fuel- powered auxiliary heater. Air vents Adjustable air vents At least one air vent must be open while cooling is on in order to prevent the[...]

Climate control 111 Maintenance Air intake The air intake in front of the windscreen in the engine compartment must be kept clear to allow air intake. Remove any leaves, dirt or snow. Pollen filter The pollen filter cleans dust, soot, pollen and spores from the air entering the vehicle through the air intake. Air conditioning regular operation In o[...]

112 Driving and operating Driving and operating Driving hints ............................... 112 Starting and operating ............... 112 Engine exhaust .......................... 116 Automatic transmission .............. 118 Manual transmission .................. 121 Manual transmission automated .................................. 122 Brakes ..[...]

Driving and operating 113 Ignition switch positions 0 = Ignition off 1 = Steering wheel lock released, ignition off 2 = Ignition on, for diesel engine: preheating 3 = Starting Starting the engine Operate clutch and brake, if the clutch pedel is not operated the engine might not start and the control indicator - could illuminate. Automatic transmiss[...]

114 Driving and operating Overrun cut-off The fuel supply is automatically cut off during overrun, i.e. when the vehicle is driven with a gear engaged but accelerator is released. Overrun cut- off is deactivated if catalytic converter temperature is high. Stop-start system The stop-start system helps to save fuel and to reduce the exhaust emissions[...]

Driving and operating 115 ■ the battery is sufficiently charged and in good condition ■ the engine is warmed up ■ the engine coolant temperature is not too high ■ the engine exhaust temperature is not too high, e.g. after driving with high engine load ■ the ambient temperature is not too low ■ the defrosting function is not activated ?[...]

116 Driving and operating ■ the climate control system requests an engine start ■ the air conditioning is manually switched on If the bonnet is not fully closed, a warning message is displayed in the Driver Information Centre. If an electrical accessory, e.g. a portable CD player, is connected to the power outlet, a brief power drop during rest[...]

Driving and operating 117 consumption may be higher during this period. The emission of smells and smoke during this process is normal. Under certain driving conditions, e.g. short distances, the system cannot clean itself automatically. If the filter requires cleaning and previous driving conditions did not enable automatic cleaning, control indic[...]

118 Driving and operating Caution Fuel grades other than those listed on pages 3 131, 3 194 could damage the catalytic converter or electronic components. Unburnt petrol will overheat and damage the catalytic converter. Therefore avoid excessive use of the starter, running the fuel tank dry and starting the engine by pushing or towing. In the event[...]

Driving and operating 119 The engine can only be started with lever in position P or N . When position N is selected, press brake pedal or apply parking brake before starting. Do not accelerate while engaging a gear. Never depress the accelerator pedal and brake pedal at the same time. When a gear is engaged, the vehicle slowly begins to creep when[...]

120 Driving and operating Activation Press the T button with P , R , N , D or 3 engaged. The vehicle starts off in 3rd gear. Deactivation The Winter programme is switched off by: ■ pressing the T button again, ■ manually selecting 2 or 1 , ■ turning off the ignition, ■ or if the transmission oil temperature is too high. Kickdown If the acce[...]

Driving and operating 121 3. Push the yellow catch forward with a screwdriver and move the selector lever out of P . If P is engaged again, the selector lever will be locked in position again. Have the cause of the power supply interruption remedied by a workshop. 4. Mount selector lever trim on centre console and refit. Manual transmission To enga[...]

122 Driving and operating Manual transmission automated The Easytronic transmission permits manual (manual mode) or automatic gear shifting (automatic mode), both with automatic clutch control. Transmission display Shows the mode and current gear. The display flashes for a few seconds when A , M or R is selected with the engine running and the foot[...]

Driving and operating 123 If neither the accelerator nor the brake pedal are depressed, no gear is engaged and A or R flashes for a brief time in the display. Stopping the vehicle In A , first gear is engaged and the clutch is released when the vehicle is stopped. In R , reverse gear remains engaged. Engine braking Automatic mode When driving downh[...]

124 Driving and operating Sport mode Shift times are reduced when the Sport mode is enabled, and the gears are shifted at higher engine speeds, although not when cruise control is activated. Activation Press the S button. Control indicator 1 3 81. Deactivation The Sport mode is switched off by: ■ pressing the S button again ■ turning off the ig[...]

Driving and operating 125 Kickdown If the accelerator pedal is pressed past the pressure point, the transmission shifts to a lower gear depending on engine speed. Fault To prevent damage to the manual transmission automated, the clutch is engaged automatically at high clutch temperatures. A illuminates in the event of a fault. Continued driving is [...]

126 Driving and operating 5. Using a flat-head screwdriver, turn the adjusting screw under the cap clockwise until clear resistance can be felt. The clutch has now been disengaged. 6. Refit cleaned cap. The cap must be in full contact with the housing. Caution Do not turn beyond the resistance since this could damage the transmission. Caution Towin[...]

Driving and operating 127 Fault 9 Warning If there is a fault in the ABS, the wheels may be liable to lock due to braking that is heavier than normal. The advantages of ABS are no longer available. During hard braking, the vehicle can no longer be steered and may swerve. Have the cause of the fault remedied by a workshop. Parking brake Always apply[...]

128 Driving and operating Ride control systems Electronic stability program Electronic stability program (ESP® Plus ) improves driving stability when necessary, regardless of the type of road surface or tyre grip. It also prevents the drive wheels from spinning. As soon as the vehicle starts to swerve (understeer/oversteer), engine output is reduc[...]

Driving and operating 129 Cruise control The cruise control can store and maintain speeds of approx. 30 to 200 km/h. Deviations from the stored speeds may occur when driving uphill or downhill. For safety reasons the cruise control cannot be activated until the foot brake has been operated once. Do not use the cruise control if it is not advisable [...]

130 Driving and operating Object detection systems Parking assist The parking assist makes parking easier by measuring the distance between the vehicle and obstacles. It is the driver, however, who bears full responsibility for parking. The system consists of four ultrasonic parking sensors bumper mounted. Control indicator r 3 81. Note Attached pa[...]

Driving and operating 131 Fuel Fuel for petrol engines Only use unleaded fuel that complies with European standard EN 228 or E DIN 51626-1 or equivalent. Your engine is capable to run with E10 fuel that fulfills these standards. E10 fuel contains up to 10 % bioethanol. Use fuel with the recommended octane rating 3 194. Use of fuel with too low an o[...]

132 Driving and operating The boiling point depends on the pressure and mixing ratio. At ambient pressure, it is between -42 °C (pure propane) and -0.5 °C (pure butane). Caution The system works at an ambient temperature of approx. -8 °C to 100 °C. Full function of the LPG system can only be guaranteed with liquid gas which complies with the mi[...]

Driving and operating 133 Caution Repairs and adjustments may only be made by trained specialists in order to maintain the safety and warranty on the LPG system. Liquid gas is given a particular odour (odorised) so that any leaks can be detected easily. 9 Warning If you smell gas in the vehicle or in the immediate vicinity, switch to petrol mode im[...]

134 Driving and operating 9 Danger Fuel is flammable and explosive. No smoking. No naked flames or sparks. If you can smell fuel in your vehicle, have the cause of this remedied immediately by a workshop. Caution In case of misfuelling, do not switch on ignition. Fuel filler flap is located at right rear side of vehicle. With a central locking syst[...]

Driving and operating 135 Fit the required adapter. ACME Adapter: Screw the nut of the filling nozzle onto the adapter. Press locking lever on filler nozzle down. DISH (Italy) filler neck: Place the filler nozzle into the adapter. Press locking lever on filler nozzle down. Bayonet filler neck: Place filler nozzle on the adapter and turn to the left[...]

136 Driving and operating ACME adapter: Belgium, Germany, Ireland, Luxembourg, Switzerland Bayonet adapter: Netherlands, Norway, Spain, United Kingdom EURO adapter: Spain DISH (Italy) adapter: Bosnia- Herzegovina, Bulgaria, Denmark, Estonia, France, Greece, Italy, Croatia, Latvia, Lithuania, Macedonia, Austria, Poland, Portugal, Romania, Sweden, Sw[...]

Driving and operating 137 General information The official fuel consumption and specific CO 2 emission figures quoted relate to the EU base model with standard equipment. Fuel consumption data and CO 2 emission data are determined according to regulation R (EC) No. 715/2007 (in the version respectively applicable), taking into consideration the veh[...]

138 Driving and operating The permissible trailer loads are specified in the vehicle documents. In general, they are valid for gradients up to max. 12 % The permitted trailer loads apply up to the specified incline and up to an altitude of 1000 metres above sea level. Since engine power decreases as altitude increases due to the air becoming thinne[...]

Driving and operating 139 When inserting, fit protective cap over rotary knob with key. Fitting the coupling ball bar Push both bolts inwards and remove the cover on the bumper. Disengage and fold down the socket. Remove the sealing plug from the opening for the coupling ball bar and stow it. Checking the tensioning of the coupling ball bar ■ The[...]

140 Driving and operating ■ Place the key in the lock and unlock the coupling ball bar. ■ Push the rotary knob onto the coupling ball bar and rotate right while pressed down until it engages. The key remains in the lock. Inserting the coupling ball bar Insert the tensioned coupling ball bar in the opening and push firmly upwards until it audibl[...]

Driving and operating 141 Eye for break-away stopping cable Attach breakaway stopping cable to eye. Check that the coupling ball bar is correctly installed ■ Green marking on rotary knob is visible. ■ There must be no gap between the rotary knob and the coupling ball bar. ■ The coupling ball bar must be firmly engaged in the opening. ■ The [...]

142 Vehicle care Vehicle care General Information ................... 142 Vehicle checks ........................... 143 Bulb replacement ....................... 150 Electrical system ........................ 162 Vehicle tools .............................. 166 Wheels and tyres ....................... 168 Jump starting .............................[...]

Vehicle care 143 ■ Open bonnet, close all doors and lock the vehicle. ■ Disconnect the clamp from the negative terminal of the vehicle battery. Beware that all systems are not functional, e.g. anti-theft alarm system. Putting back into operation Following must be done if the vehicle is putting back into operation: ■ Connect the clamp to the n[...]

144 Vehicle care 9 Danger The ignition system and Xenon headlights use extremely high voltage. Do not touch. The caps for topping up the engine oil, the coolant, the washing fluid and the oil dipstick handle are yellow for ease of identification. Bonnet Opening Pull the release lever and return it to its original position. Lift the safety catch upw[...]

Vehicle care 145 Engine oil Check the engine oil level manually on a regular basis to prevent damage to the engine. Ensure that the correct specification of oil is used. Recommended fluids and lubricants 3 186. Check with the vehicle on a level surface. The engine must be at operating temperature and switched off for at least 5 minutes. Pull out th[...]

146 Vehicle care Engine coolant The coolant provides freeze protection down to approx. -28 °C. Caution Only use approved antifreeze. Coolant level Caution Too low a coolant level can cause engine damage. If the cooling system is cold, the coolant level should be above the KALT/COLD mark. Top up if the level is low. 9 Warning Allow the engine to co[...]

Vehicle care 147 Brakes A squealing noise indicates that the brake lining is at its minimum thickness. Continued driving is possible but have the brake lining replaced as soon as possible. Once new brake linings are installed, do not brake unnecessarily hard for the first few journeys. Brake fluid 9 Warning Brake fluid is poisonous and corrosive. A[...]

148 Vehicle care Warning label Meaning of symbols: ■ No sparks, naked flames or smoking. ■ Always shield eyes. Explosive gases can cause blindness or injury. ■ Keep the battery out of reach of children. ■ The battery contains sulfuric acid which could cause blindness or serious burn injuries. ■ See the Owner’s Manual for further informa[...]

Vehicle care 149 Charging the battery 9 Warning On vehicles with an AGM battery, ensure that the charging potential does not exceed 14.6 volts when using a battery charger. Otherwise the battery might be damaged. Jump starting 3 177. Diesel fuel system bleeding If the tank has been run dry, the diesel fuel system must be bled. Switch on the ignitio[...]

150 Vehicle care Wiper blade on the rear window Lift wiper arm. Disengage wiper blade as shown in illustration and remove. Attach the wiper blade slightly angled to the wiper arm and push until it engages. Lower wiper arm carefully. Bulb replacement Switch off the ignition and switch off the relevant switch or close the doors. Only hold a new bulb [...]

Vehicle care 151 Low beam 1. Disengage wire clip and remove protective cover 1 . 2. Press base to the side and remove bulb from reflector. 3. Detach plug connector from bulb. 4. Insert new bulb in reflector so that the locating tab of the bulb holder aligns with the reflector recess. 5. Engage bulb. 6. Attach connector to bulb. 7. Put on protective[...]

152 Vehicle care 3. Disengage spring clip from retainer by moving and swivelling to the side. 4. Remove bulb from reflector housing. 5. When installing the new bulb, insert lugs in the reflector recesses. 6. Install spring clip, plug connector onto bulb. 7. Install protective cover. Daytime running light/Side light 1. Rotate bulb holder 3 anticlock[...]

Vehicle care 153 Adaptive forward lighting Headlights have separate systems for low and high beam 1 (outer bulb), cornering light 2 (inner bulb) and daytime running light/side light 3 . Low/high beam 1. Disengage wire clip and remove protective cover 1 . 2. Rotate bulb holder anticlockwise to disengage. Withdraw bulb holder from reflector. 3. Inser[...]

154 Vehicle care Daytime running light/Side light 1. Rotate bulb holder 3 anticlockwise to disengage. Withdraw bulb holder from reflector. 2. Remove bulb from socket, insert new bulb. 3. Insert bulb holder in reflector so that the locating tab of the bulb holder aligns with the reflector recess. 4. Rotate clockwise to engage. Cornering light 1. Rot[...]

Vehicle care 155 2. Detach wiring plug from bulb. 3. Disengage spring clip from retainer by moving and swivelling to the side. 4. Remove bulb from reflector housing. 5. When installing the new bulb, insert lugs in the reflector recesses. 6. Install spring clip, plug connector onto bulb. 7. Install protective cover. Front turn signal light 1. Diseng[...]

156 Vehicle care Fog lights The bulbs are accessible from the underside of the vehicle. 1. Turn the bulb holder anticlockwise and remove it from the reflector. 2. Disengage the bulb holder from the plug connector by pressing the retaining lug. 3. Remove and replace the bulb holder with bulb. 4. Attach the plug connector. 5. Insert the bulb holder i[...]

Vehicle care 157 2. Remove plug connector by pressing on bulb holder tab. 3. Hold bulb housing from the outside; unscrew two retaining nuts. 4. Detach bulb housing towards the rear. 5. Gently press the three locking lugs on the outside of the bulb holder outwards and remove bulb holder. 6. Push bulb into socket slightly, rotate anti-clockwise, remo[...]

158 Vehicle care 7. Engage bulb holder in bulb housing, ensuring that it properly engages. 8. Ensure that the bulb holder seal is positioned as illustrated. 9. Insert bulb housing in vehicle body, tighten securing nuts by hand. Engage plug connector. Close cover. After bulb replacement, check the tail lights for proper functionality: switch on the [...]

Vehicle care 159 2. Remove plug connector by pressing on bulb holder tab. 3. Hold bulb housing from the outside; unscrew two retaining nuts. 4. Remove tail light assembly. 5. Gently press the three locking lugs on the outside of the bulb holder outwards and remove bulb holder. 6. Push bulb into socket slightly, rotate anti-clockwise, remove and ren[...]

160 Vehicle care 7. Engage bulb holder in bulb housing, ensuring that it properly engages. 8. Ensure that the bulb holder seal is positioned as illustrated. Fit the round seal on the fastening bolt. 9. Insert bulb housing in vehicle body, and tighten securing nuts by hand. Engage plug connector. Close and lock cover. After bulb replacement, check t[...]

Vehicle care 161 4. Rotate bulb holder anti-clockwise to disengage. 5. Remove bulb from holder and renew bulb. 6. Insert bulb holder in bulb housing and rotate clockwise. 7. Connect wiring plug to bulb holder. 8. Insert and engage bulb housing. Interior lights Front courtesy light 1. Disengage and remove lens at the position located in the illustra[...]

162 Vehicle care Glovebox light, foot well light 1. Prise the lamp out with a screwdriver. 2. Press bulb slightly towards spring clip and remove. 3. Insert new bulb. 4. Install lamp. Electrical system Fuses Data on the replacement fuse must match the data on the defective fuse. There are three fuse boxes in the vehicle: ■ in the front left of the[...]

Vehicle care 163 Engine compartment fuse box The fuse box is in the front left of the engine compartment. Disengage the cover, lift it upwards and remove.[...]

164 Vehicle care No. Circuit 1 Starter 2 Air conditioning system 3 Diesel fuel filter heater 4 Horn 5 Manual transmission auto‐ mated, automatic transmission 6 Engine control unit 7 Fog lights 8 Engine cooling 9 Engine cooling 10 Automated manual transmis‐ sion 11 Glow plugs, ignition system 12 Headlight range adjustment, Adaptive forward light[...]

Vehicle care 165 In right-hand drive vehicles, the fuse box is located behind a cover in the glovebox. Open the glovebox and remove the cover. To close, first put on the cover, then lock it into position. No. Circuit 1 – 2 Instruments, info display 3 Radio 4 Ignition switch 5 Windscreen washer system 6 Central locking system, tailgate 7 Central l[...]

166 Vehicle care The fuse box is on the left side of the load compartment behind a cover. Remove the cover. No. Circuit 1 Adaptive forward lighting 2 – 3 Seat heater (left) 4 Seat heater (right) 5 – 6 – No. Circuit 7 – 8 Rear carrier system, towing equipment 9 – 10 – 11 – 12 – 13 – 14 – 15 Rear carrier system, towing equipment 1[...]

Vehicle care 167 Vehicles with spare wheel Variant 1: The jack and the vehicle tools are in the load compartment underneath the spare wheel. A label on the jack indicates the vehicles for which the jack can be used. Variant 2: The jack and the vehicle tools are in the right-hand compartment in the load compartment. Vehicles with tyre repair kit The[...]

168 Vehicle care Wheels and tyres Tyre condition, wheel condition Drive over edges slowly and at right angles if possible. Driving over sharp edges can cause tyre and wheel damage. Do not trap tyres on the kerb when parking. Regularly check the wheels for damage. Seek the assistance of a workshop in the event of damage or unusual wear. Tyres Tyres [...]

Vehicle care 169 Tyre pressure 3 209 and on the label on the inside of the fuel filler flap or on the front right door frame. The tyre pressure data refers to cold tyres. It applies to summer and winter tyres. Always inflate the spare tyre to the pressure specified for full load. The ECO tyre pressure serves to achieve the smallest amount of fuel c[...]

170 Vehicle care For safety reasons it is recommended that the tread depth of the wheels on one axle should not vary by more than 2 mm. The legally permissible minimum tread depth (1.6 mm) has been reached when the tread has worn down as far as one of the tread wear indicators (TWI). Their position is indicated by markings on the sidewall. If there[...]

Vehicle care 171 Tyre chains Tyre chains are only permitted on the front wheels. Always use fine mesh chains that add no more than 10 mm to the tyre tread and the inboard sides (including chain lock). 9 Warning Damage may lead to tyre blowout. Tyre chains are just permitted on tyre sizes 175/70 R 14, 185/60 R 15, 185/65 R 15 2) , 185/70 R 14, 195/5[...]

172 Vehicle care To open the compartment, disengage the cover and open it. 1. Take the sealant bottle and bracket with air hose from the insert. 2. Detach air hose from bracket and screw onto sealant bottle connection. 3. Position the sealant bottle on the bracket. Make sure that the bottle does not fall. 4. Unscrew valve cap from defective tyre. 5[...]

Vehicle care 173 8. Press on/off switch on the compressor. The tyre is filled with sealant. 9. The compressor pressure gauge briefly indicates up to 6 bar whilst the sealant bottle is emptying (approx. 30 seconds). Then the pressure starts to drop. 10. All of the sealant is pumped into the tyre. Then the tyre is inflated. 11. The prescribed tyre pr[...]

174 Vehicle care Note The driving characteristics of the repaired tyre is severely affected, therefore have this tyre replaced. If unusual noise is heard or the compressor becomes hot, turn compressor off for at least 30 minutes. The built-in safety valve opens at a pressure of 7 bar. Note the expiry date of the kit. After this date its sealing cap[...]

Vehicle care 175 Alloy wheels: Disengage wheel bolt caps with a screwdriver and remove. To protect the wheel, place a soft cloth between the screwdriver and the alloy wheel. 2. Install the wheel wrench ensuring that it locates securely and slacken each bolt by half a turn. 3. Ensure the jack is positioned correctly with the vehicle jacking points. [...]

176 Vehicle care Variant 2: Attach jack handle and with the jack correctly aligned rotate handle until wheel is clear of the ground. 5. Unscrew the wheel bolts. 6. Change the wheel. 7. Screw in the wheel bolts. 8. Lower vehicle. 9. Install the wheel wrench ensuring that it locates securely and tighten each bolt in a crosswise sequence. Tightening t[...]

Vehicle care 177 In the Corsa van the spare wheel is screwed down together with the floor cover. To lift the cover, undo the plastic nut. There is a spacer between the spare wheel and the floor cover. The spare wheel well is not designed for all permitted tyre sizes. If a wheel wider than the spare must be stowed in the spare wheel well after chang[...]

178 Vehicle care Note Any deviation from the instructions given in this paragraph may lead to a temporary deactivation of the stop- start system. ■ Never expose the battery to naked flames or sparks. ■ A discharged battery can already freeze at temperatures of 0 °C. Defrost the frozen battery before connecting jump leads. ■ Avoid contact wit[...]

Vehicle care 179 Position the leads so that they cannot catch on rotating parts in the engine compartment. To start the engine: 1. Start the engine of the vehicle providing the jump. 2. After 5 minutes, start the other engine. Start attempts should be made for no longer than 15 seconds at an interval of 1 minute. 3. Allow both engines to idle for a[...]

180 Vehicle care The towing eye is stowed with the vehicle tools 3 166. The towing eye is located in a recess. Screw in the towing eye as far as it will go until it stops in a horizontal position. Attach a tow rope – or better still a tow rod – to the towing eye. The towing eye must only be used for towing and not recovering the vehicle. Switch[...]

Vehicle care 181 Disengage cap at bottom and remove downwards. The towing eye is stowed with the vehicle tools 3 166. Screw in the towing eye as far as it will go until it stops in a horizontal position. The lashing eye at the rear underneath the vehicle must never be used as a towing eye. Attach a tow rope – or better still a tow rod – to the [...]

182 Vehicle care If using a car wash, comply with the car wash manufacturer's instructions. The windscreen wipers and rear window wiper must be switched off. Remove antenna and external accessories such as roof racks etc. If you wash your vehicle by hand, make sure that the insides of the wheel housings are also thoroughly rinsed out. Clean ed[...]

Vehicle care 183 Clean rims with a pH-neutral wheel cleaner. Rims are painted and can be treated with the same agents as the body. Paintwork damage Rectify minor paintwork damage with a touch-up pen before rust forms. Have more extensive damage or rust areas repaired by a workshop. Underbody Some areas of the vehicle underbody have a PVC undercoati[...]

184 Vehicle care Caution Close Velcro fasteners as open Velcro fasteners on clothing could damage seat upholstery. The same applies to clothing with sharp-edged objects, like zips or belts or studded jeans. Plastic and rubber parts Plastic and rubber parts can be cleaned with the same cleaner as used to clean the body. Use interior cleaner if neces[...]

Service and maintenance 185 Service and maintenance General information ................... 185 Recommended fluids, lubricants and parts .................................... 186 General information Service information In order to ensure economical and safe vehicle operation and to maintain the value of your vehicle, it is of vital importance that a[...]

186 Service and maintenance Fixed service interval When service is due, InSP appears in the odometer display for approximately 10 seconds when the ignition is switched on. Have the next service performed by a workshop within one week or 500 km (whichever occurs first). Flexible service interval The service interval is based on several parameters de[...]

Service and maintenance 187 aging control, whereas viscosity grade gives information on the oil's thickness over a temperature range. Dexos is the newest engine oil quality that provides optimum protection for gasoline and diesel engines. If it is unavailable, engine oils of other listed qualities have to be used. Recommendations for gasoline [...]

188 Service and maintenance Brake fluid should be stored in a sealed container to avoid water absorption. Ensure brake fluid does not become contaminated.[...]

Technical data 189 Technical data Vehicle identification .................. 189 Vehicle data ............................... 191 Vehicle identification Vehicle Identification Number The Vehicle Identification Number is stamped on the identification plate and on the floor pan, under the floor covering, visible under a cover. The Vehicle Identificati[...]

190 Technical data Information on identification plate: 1 = Manufacturer 2 = Type approval number 3 = Vehicle Identification Number 4 = Permissible gross vehicle weight rating in kg 5 = Permissible gross train weight in kg 6 = Maximum permissible front axle load in kg 7 = Maximum permissible rear axle load in kg 8 = Vehicle-specific or country spec[...]

Technical data 191 Vehicle data Recommended fluids and lubricants European service schedule Required engine oil quality All European countries ( except Belarus, Moldova, Russia, Serbia, Turkey) Only Israel Engine oil quality Petrol engines (including CNG, LPG, E85) Diesel engines Petrol engines (including CNG, LPG, E85) Diesel engines dexos 1 – ?[...]

192 Technical data International service schedule Required engine oil quality All countries outside Europe except Israel Only Belarus, Moldova, Russia, Serbia, Turkey Engine oil quality Petrol engines (including CNG, LPG, E85) Diesel engines Petrol engines (including CNG, LPG, E85) Diesel engines dexos 1 ✔ – – – dexos 2 – ✔ ✔ ✔ In c[...]

Technical data 193 All countries outside Europe except Israel Only Belarus, Moldova, Russia, Serbia, Turkey Engine oil quality Petrol engines (including CNG, LPG, E85) Diesel engines Petrol engines (including CNG, LPG, E85) Diesel engines ACEA A3/B3 ✔ – ✔ – ACEA A3/B4 ✔ ✔ ✔ ✔ ACEA C3 ✔ ✔ ✔ ✔ API SM ✔ – ✔ – API SN res[...]

194 Technical data Engine data Sales designation 1.0 1.2 1.2 1.4 Engine identifier code A10XEP A12XEL A12XER A14XEL Piston displacement [cm 3 ] 998 1229 1229 1398 Engine power [kW] 48 51 63 64 at rpm 5300 5600 5600 6000 Torque [Nm] 90 115 115 130 at rpm 4000 4000 4000 4000 Fuel type Petrol Petrol Petrol/LPG Petrol Octane rating RON recommended 95 9[...]

Technical data 195 Sales designation 1.4 1.4 1.6 OPC 1.6 OPC Nürburgring Edition Engine identifier code A14XER A14NEL A16LER A16LES Piston displacement [cm 3 ] 1398 1364 1598 1598 Engine power [kW] 74 88 141 155 at rpm 6000 4800-6000 5850 5850 Torque [Nm] 130 175 230 250 at rpm 4000 1750-4800 1980-5850 2250-5850 Fuel type Petrol Petrol Petrol Petr[...]

196 Technical data Sales designation 1.3 CDTI 1.3 CDTI 1.3 CDTI 1.3 CDTI 1.7 CDTI Engine identifier code Z13DTJ A13DTE Eco A13DTC A13DTR A17DTS Piston displacement [cm 3 ] 1248 1248 1248 1248 1686 Engine power [kW] 55 70 55 70 96 at rpm 4000 4000 4000 4000 4000 Torque [Nm] 170 190 190 210 300 at rpm 1750-2500 1750-3250 1750-2250 1750-2500 2000-2500[...]

Technical data 197 Performance 5-door vehicle Engine A10XEP A12XEL A12XER A14XEL A14XER A14NEL Maximum speed 2) [km/h] Manual transmission 155 160 172 3)4) 173 180 195 Manual transmission automated – – 172 – – – Automatic transmission – – – – 172 – Engine Z13DTJ A13DTC A13DTR A13DTE Eco A17DTS Maximum speed [km/h] Manual transmi[...]

198 Technical data 3-door vehicle Engine A10XEP A12XEL A12XER A14XEL A14XER Maximum speed [km/h] Manual transmission 155 160 172 3)4) 173 180 Manual transmission automated – – 172 – – Automatic transmission – – – – 172 Engine A14NEL A16LER A16LES A13DTE Eco Maximum speed [km/h] Manual transmission 195 225 230 177 Manual transmission[...]

Technical data 199 Engine Z13DTJ A13DTC A13DTR A17DTS Maximum speed [km/h] Manual transmission 163 163 173 200 Manual transmission automated – – – Automatic transmission – – – Van Engine A10XEP A12XEL A12XER Maximum speed [km/h] Manual transmission 155 160 172 Manual transmission automated – – 172 Automatic transmission – – – [...]

200 Technical data Vehicle weight Kerb weight, 5-door vehicle, basic model without any optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP 1145/1165 – – A12XEL 1163/1178 – – A12XER 1163 5) /1178 5) – – A14XEL 1163/1178 – 1188[...]

Technical data 201 Kerb weight, 5-door vehicle, basic model with all optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP –/1280 – – A12XEL –/1278 – – A12XER –/1278 6) – – A14XEL –/1278 7) – –/1317 A14XER –/1278 7)[...]

202 Technical data Kerb weight, 3-door vehicle, basic model without any optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP 1100/1120 – – A12XEL 1120/1135 – – A12XER 1120 8) /1135 8) – – A14XEL 1141/1156 – – A14XER 1141/115[...]

Technical data 203 Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] Z13DTJ 1205/1225 – – A13DTE ECO 1163/1173 1163/1173 – A13DTR 1235/1255 1235/1255 – A17DTS 1278/1298 – –[...]

204 Technical data Kerb weight, 3-door vehicle, basic model with all optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP –/1235 – – A12XEL –/1259 – – A12XER –/1259 11) – – A14XEL –/1278 – – A14XER –/1278 – –/1[...]

Technical data 205 Kerb weight, van, basic model without any optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP 1125/1145 – – A12XEL 1140 13) /1160 13) – – A12XER 1140 13) /1160 13) 1140 13) /1160 13) – Z13DTJ 1215 13) /1235 13)[...]

206 Technical data Kerb weight, van, basic model with all optional equipment Corsa Engine Manual transmission Manual transmission automated Automatic transmission without/with air conditioning/climate control [kg] A10XEP –/1230 – – A12XEL –/1245 14) – – A12XER –/1245 14) –/1245 14) – Z13DTJ –/1320 14) – – A13DTC –/1320 14)[...]

Technical data 207 5-door vehicle 3-door vehicle OPC Van Length of load compartment with folded rear seats [mm] 1348 1348 1348 – Load compartment width [mm] 944 944 944 944 Load compartment height [mm] 538 538 538 538 Wheelbase [mm] 2511 2511 2511 2511 Turning circle diameter [m] 10.2 10.2 10.2 10.2 Capacities Engine oil Engine A10XEP A12XEL, A12[...]

208 Technical data Fuel tank Engine A10XEP, A12XEL, A12XER A14XEL, A14XER, A14NEL A16LER, A16LES Z13DTJ, A17DTS A13DTE A13DTC, A13DTR Petrol/diesel, nominal capacity [l] 45 45 45 45 45 40 45 LPG nominal capacity [l] – 42 15) – – – – – 15) Fillable to 80% percent of its capacity.[...]

Technical data 209 Tyre pressures Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A10XEP 185/70 R14, 200/2.0 (29) 180/1.8 (26) 270/2.7 (39) 250/2.5 (36) 260/2.6 (38) 3[...]

210 Technical data Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A12XEL, A12XER, A14XEL, A14XER 185/70 R14, 200/2.0 (29) 180/1.8 (26) 270/2.7 (39) 250/2.5 (36) 260/2[...]

Technical data 211 Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A14NEL 195/65 R15, 230/2.3 (33) 210/2.1 (30) 280/2.8 (41) 260/2.6 (38) 250/2.5 (36) 320/3.2 (46) 196[...]

212 Technical data Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A13DTC 185/65 R15 21) , 200/2.0(29) 180/1.8 (26) 270/2.7 (39) 250/2.5 (36) 260/2.6 (38) 320/3.2 (46)[...]

Technical data 213 Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) A13DTR 185/60 R15 240/2.4 (34) 200/2.0 (29) 270/2.7 (39) 250/2.5 (36) 260/2.6 (38) 320/3.2 (46) 185/[...]

214 Technical data Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) Z13DTJ 185/70 R14 25) , 200/2.0 (29) 180/1.8 (26) 270/2.7 (39) 250/2.5 (36) 260/2.6 (38) 320/3.2 (46[...]

Technical data 215 Comfort with up to 3 people ECO with up to 3 people 16) With full load Engine Tyres front rear front rear front rear [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) [ kPa/bar] ([psi]) 185/60 R15 17) 260/2.6 (38) 220/2.2 (32) 270/2.7 (39) 250/2.5 (36) 260/2.6 (38) 320/3.2 (46) all Tem[...]

216 Technical data Towing hitch installation dimensions[...]

Customer information 217 Customer information Vehicle data recording and privacy ....................................... 217 Vehicle data recording and privacy Event data recorders Data storage modules in the vehicle A large number of electronic components of your vehicle contain data storage modules temporarily or permanently storing technical dat[...]

218 Customer information When using the vehicle, situations may occur in which these technical data related to other information (accident report, damages on the vehicle, witness statements etc.) may be associated with a specific person - possibly, with the assistance of an expert. Additional functions contractually agreed upon with the client (e.g[...]

Customer information 219[...]

220 Index A Accessories and vehicle modifications .......................... 142 Active head restraints ................... 36 Adaptive forward lighting .......... .................................... 84, 98, 153 Adjustable air vents ................... 110 Airbag and belt tensioners ........... 79 Airbag deactivation ................ 44, 79 Airbag[...]

221 Climate control ............................. 16 Climate control systems ............. 104 Clock ............................................ 73 Control indicators.......................... 77 Control of the vehicle ................. 112 Controls ........................................ 69 Convex shape .............................. 28 Coolant [...]

222 Heated rear window ..................... 32 Heated steering wheel ................. 70 Heating ........................................ 39 Heating and ventilation system . 104 High beam ............................. 83, 97 Hill start assist ........................... 127 Horn ....................................... 14, 70 I Identification plat[...]

223 R Radio Frequency Identification (RFID) ..................................... 218 Radio remote control ................... 20 Reading lights ............................ 102 Rear carrier system ...................... 53 Rear floor storage cover .............. 65 Rear fog light ............................... 84 Rear fog lights .................[...]

224 V Vehicle checks............................ 143 Vehicle data ................................ 191 Vehicle data recording and privacy ..................................... 217 Vehicle dimensions .................... 206 Vehicle Identification Number .... 189 Vehicle jack ................................ 166 Vehicle messages ....................[...]