Pride Mobility 610 manual

Exeter , P A S t. Catharines, ON 1-800-800-8586 www .pridemobility .com Owner’ s Manual[...]

www .pridemobility .com Jazzy 610 SAFETY GUIDELINES Copyright © 2006 Pride Mobility Products Corp. INFMANU2897/Rev C/January2006 The symbols below are used throughout this owner's manual and on the power chair to identify warnings and important information. It is very important for you to read them and understand them completely . WARNING! F [...]

Jazzy 610 www .pridemobility .com 3 I . INTRODUCTION .................................................................................................................................... 4 I I . SAFETY .................................................................................................................................................... [...]

4 www .pridemobility .com Jazzy 610 I. INTRODUCTION SAFETY WELCOME to Pride Mobility Products Corporation (Pride). The power chair you have purchased combines state-of- the-art components with safety , comfort, and styling in mind. W e are confident that these design features will provide you with the conveniences you expect during your daily activ[...]

Jazzy 610 www .pridemobility .com 5 I. INTRODUCTION PRIDE OWNERS CLUB As an owner of a Pride product, you are invited to register your product’ s warranty and enroll in the Pride Owners Club. Y ou may do so by filling out and returning your enclosed product registration card or by visiting Pride's web site at www .pridemobility .com. As a re[...]

6 www .pridemobility .com Jazzy 610 II. SAFETY Cor r osive chemicals contained in ba tter y . Use only AGM or Gel-Cell batteries to reduce the risk of leakage or explosive conditions. R ead and follo w the inf or mation in the o wner’s manual. Maximum seating weight. Locked and in drive mode. Place unit on level ground and stand behind or to one [...]

Jazzy 610 www .pridemobility .com 7 II. SAFETY Do not use a cell phone, walkie/talkie, laptop, or other radio transmitter while operating. Av oid exposure to rain, snow , ice, salt, or standing water whenev er possible. Maintain and store in a clean and dr y condition. R emoval of g rounding pr ong can cr eate electrical hazard. If necessar y , pr [...]

8 www .pridemobility .com Jazzy 610 II. SAFETY SAFETY MAND A T OR Y! Do not operate your new pow er chair for the first time without completel y reading and understanding this owner’s manual. Y our power chair is a state-of-the-art life-enhancement device designed to increase mobility . Pride provides an extensive variety of products to best fit [...]

Jazzy 610 www .pridemobility .com 9 II. SAFETY Weight Limitations Y our power chair is rated for a maximum weight capacity . Please refer to the specifications table for this limit. WARNING! Exceeding the weight capacity voids y our war ranty and may result in personal injur y and/or damage to your power c hair . Pride will not be held responsible [...]

1 0 www .pridemobility .com Jazzy 610 II. SAFETY Figure 1. Maximum Safe Slope (Ascending and Descending) WARNING! Even though your power chair is capable of climbing slopes greater than those illustrated in figure 1, do not, under any circumstances, exceed the incline guidelines or any other specifications pr esented in this manual. Doing so could [...]

Jazzy 610 www .pridemobility .com 1 1 II. SAFETY Freewheel Mode Y our power chair is equipped with two manual freewheel lever s to allow for manual maneuverability by a trained attendant. For more information about how to place your power chair into and out of freewheel mode, see III. “Y ou r Power Chai r . ” WARNING! Do not use your power chai[...]

1 2 www .pridemobility .com Jazzy 610 II. SAFETY T ransfers T ransferring onto and off of your power chair requires a good sense of balance. Always have an attendant or health- care professional present while learning to properly trans- fer yourself. T o eliminate the possibility of injury , Pride recommends that you or a trained attendant perform [...]

Jazzy 610 www .pridemobility .com 1 3 II. SAFETY Inclement Weather Precautions Exposure of your power chair to inclement weather conditions should be avoided whenever possible. If suddenly caught up in rain, snow , severe cold, or heat while operating your power chair proceed to shelter at the earliest opportunity . Thoroughly dry your power chair [...]

1 4 www .pridemobility .com Jazzy 610 II. SAFETY WARNING! Ba tter y posts, terminals , and related accessories contain lead and lead compounds. Wash hands after handling. WARNING! Always protect the batteries from freezing and ne ver charge a fro zen batter y . Char ging a fro zen battery ma y result in per sonal injur y and/or dama ge to the batte[...]

Jazzy 610 www .pridemobility .com 1 5 III. YOUR POWER CHAIR THE JAZZY 610 The Jazzy 610 has two main assemblies: the seat assembly and the power base assembly . See figure 5. T ypically , the seat assembly includes the armrests, seatback, and seat base. The power base assembly includes two motor/brake assemblies, two drive wheels, four caster wheel[...]

1 6 www .pridemobility .com Jazzy 610 III. YOUR POWER CHAIR J AZZY 610 SPECIFICA TIONS Suspension: Active-T rac Extreme (A TX) Drive Wheels: 10 in., pneumatic (10 in. solid optional) Front Caster Wheels: 5 in., solid Rear Caster Wheels: 6 in., solid Maximum S peed:¹ Up t o 4 m ph Brakes: “Intelligent Braking” electronic regenerative, disc park[...]

Jazzy 610 www .pridemobility .com 1 7 III. YOUR POWER CHAIR ELECTRICAL COMPONENTS The electrical components are located inside the power base. The ammeter and the charger power cord receptacle are located on the right side of the power base. The main circuit breaker is located on the front of the battery tray . The controller connector(s) are locat[...]

1 8 www .pridemobility .com Jazzy 610 III. YOUR POWER CHAIR Charger Inhibit Connector: The charger inhibit enables the onboard battery charger to disable the controller during charging. See VII. “Operation.” Controller Connector: This is where the controller connects to the power base. Main Circuit Br eaker: The main circuit breaker is a safety[...]

Jazzy 610 www .pridemobility .com 1 9 MANU AL FREEWHEEL LEVERS The Jazzy 610 has a manual freewheel lever on each motor . Manual freewheel levers enable you to disengage the drive motors from the gearboxes and maneuver the chair manually . WARNING! Do not use the power chair while the drive motors are disengaged! Do not disengage the drive motors w[...]

2 0 www .pridemobility .com Jazzy 610 INITIAL ASSEMBL Y Y our power chair may require some assembly either before initial use or after transportation. It may also require disassembly to make some comfort adjustments. Figure 10 details those parts of the power chair that are designed to be disassembled and assembled by an end user or by a qualified [...]

Jazzy 610 www .pridemobility .com 2 1 IV . ASSEMBL Y Seat Installation It may be necessary to install the seat either prior to initial operation or after transporting your power chair . Most seats are attached to the power base with the Universal Mount- ing System (UMS). The UMS consists of universal parts that may be attached to any medium-back or[...]

2 2 www .pridemobility .com Jazzy 610 V . COMFORT ADJUSTMENTS COMFORT ADJUSTMENTS After becoming familiar with your power chair ’ s operation, you may find the need to make some adjustments to increase your comfort, such as seat height and angle, armrest angle, foot platform height and angle, and controller position. If your power chair is equipp[...]

Jazzy 610 www .pridemobility .com 2 3 Figure 15. Seatback and Armrest Adjustment Figure 14. Seat P osition Adjustment V . COMFORT ADJUSTMENTS 1 1. Remove each screw from the trapeze bars and apply thread lock. 12 . Reinstall each screw into the trapeze bars and tighten. 13 . Reinstall the seat and flip down the seat latch safety . 1 4 . Reconnect t[...]

2 4 www .pridemobility .com Jazzy 610 Armrest Width Adjustment Y ou can change each armrest’ s width independently of the other . NOTE: Changing the armrest width may increase the overall width of your power chair . T o change the armrest width: 1. Locate the two armrest knobs on each side of the arm- rest receiver bracket. See figure 15. 2. Loos[...]

Jazzy 610 www .pridemobility .com 2 5 V . COMFORT ADJUSTMENTS the quick release fastener is unclamped. When the lever is closed, the quick release fastener is clamped. T o clamp the quick release fastener: 1. Make sure the lever is in the open position. 2. Turn the nut clockwise until it is snug. 3. Rotate the lever until it is in the fully closed [...]

2 6 www .pridemobility .com Jazzy 610 V . COMFORT ADJUSTMENTS 12 . Plug the controller connector(s) into the power base. 13 . Reinstall the rear shroud and tighten the fasteners. Swing-away Footrests Swing-away Footrests (SFRs) enable you to rotate the foot- rests to the side before you transfer onto or off or your power chair . See figure 20. T o [...]

Jazzy 610 www .pridemobility .com 2 7 A C D B B C D A Figure 23. Multi-Axis Foot Plate (ELR Shown) V . COMFORT ADJUSTMENTS SETSCREW LOCATION Heavy Duty Drop-in Leg Rests Y ou can adjust the forward/back position, as well as the length of the heavy duty drop-in leg rests. See figure 22. T o adjust the forward/back position: 1. Remove the adjustment [...]

2 8 www .pridemobility .com Jazzy 610 VI. BA TTERIES AND CHARGING BA TTERIES AND CHARGING Y our power chair uses two long-lasting, 12-volt, deep-cycle batteries. These batteries are sealed and maintenance free. Since they are sealed, there is no need to check the electrolyte (fluid) level. Deep-cycle batteries are designed to handle a longer and de[...]

Jazzy 610 www .pridemobility .com 2 9 VI. BA TTERIES AND CHARGING WARNING! Pr ev ent injur y and/or equipment damage! If your of f-board batter y charger has not been tested and approved for outdoor use, then do not expose it to adverse or extreme weather conditions. If the battery charger is exposed to adv er se or extreme weather conditions , the[...]

3 0 www .pridemobility .com Jazzy 610 VI. BA TTERIES AND CHARGING Frequently Asked Questions (F AQs) How does the charger work? The battery charger takes the standard electrical outlet voltage (alternating current) and converts it to 24 VDC (direct current). The power chair batteries use direct current to run your power chair . When the battery vol[...]

Jazzy 610 www .pridemobility .com 3 1 WARNING! Cor rosive chemicals contained in ba tteries . Use only AGM or Gel-Cell ba tteries to reduce the risk of leakage or explosive conditions. Why do my new batteries seem weak? Deep-cycle batteries employ a much different chemical technology than that used in car batteries, nickel-cadmium (nicads), or in o[...]

3 2 www .pridemobility .com Jazzy 610 VII. OPERA TION VSI ELECTRONIC CONTROLLER The electronic controller is what you use to operate your power chair . The electronic controller enables you to move the power chair , as well as monitor battery charge, electronic controller functions, and the condition of your electrical system. The VSI electronic co[...]

Jazzy 610 www .pridemobility .com 3 3 Figure 25. VSI Controller Ke ypad VII. OPERA TION Keypad The keypad is located in front of the joystick. It contains keys necessary to operate your power chair . See figure 25. On/Off Key The on/off key turns the VSI on and off. WARNING! Unless faced with an emergency situation, do not use the on/off key to sto[...]

3 4 www .pridemobility .com Jazzy 610 VII. OPERA TION Actuator Keys and Actuator Lights (For Optional Equipment) Actuator keys and actuator lights are used for optional equipment such as power elevating leg rests. For specific operation of the actuator keys and actuator lights, contact your authorized Pride Provider . Horn Key The horn key activate[...]

Jazzy 610 www .pridemobility .com 3 5 VII. OPERA TION Charger Inhibit Connector The charger inhibit connector connects the VSI to the onboard battery charger . This connection provides an inhibit that disables the VSI when the battery charger is on. The charger inhibit connector is coded with colored dots. The dots are positioned so that you align [...]

3 6 www .pridemobility .com Jazzy 610 VII. OPERA TION Figure 26. FLIGHT Controller 2 3 4 5 1 FLIGHT CONTROLLER The electronic controller is what you use to operate your power chair . It takes the battery voltage and sends it to the appropriate system. The electronic controller enables you to move the power chair , as well as monitor battery charge,[...]

Jazzy 610 www .pridemobility .com 3 7 VII. OPERA TION Figure 27. FLIGHT Controller Keypad On/Off Key The on/off key turns the FLIGHT on and off. WARNING! Unless faced with an emer- gency situation, do not use the on/off ke y to stop the chair . This will cause the power c hair to stop a br uptl y . WARNING! Always tur n the pow er of f w hen you ar[...]

3 8 www .pridemobility .com Jazzy 610 VII. OPERA TION Speed Keys There are two keys that control the speed. Press the hare key to increase the speed. Press the tortoise key to decrease the speed. The speed setting is displayed on the speed indicator . If your power chair was programmed with a drive profile, contact your authorized Pride Provider fo[...]

Jazzy 610 www .pridemobility .com 3 9 VIII. CARE AND MAINTENANCE CARE AND MAINTENANCE Y our Jazzy 610 is a sophisticated power chair . Like any motorized vehicle, it requires routine maintenance checks. Y ou can perform some of these checks, but others require assistance from your authorized Pride Provider . Preventive maintenance is very important[...]

4 0 www .pridemobility .com Jazzy 610 VIII. CARE AND MAINTENANCE ! Check all electrical connections. Make sure they are tight and are not corroded. Batteries must sit flat within the battery tray , with the battery terminals facing inward, toward each other . Refer to the battery wiring label for the correct wiring layout. ! All wheel bearings are [...]

Jazzy 610 www .pridemobility .com 4 1 VIII. CARE AND MAINTENANCE WARNING! If you fail to store the unit proper ly , the frame can r ust and the electronics can be damaged. Cleaning and Disinfection ! Use a damp cloth and mild, non-abrasive cleanser to clean the plastic and metal parts of your power chair . A void using products that may scratch the[...]

4 2 www .pridemobility .com Jazzy 610 VIII. CARE AND MAINTENANCE Battery Replacement A battery wiring diagram is printed on a decal located on the front battery tray . See VI. “Batteries and Char ging” for correct battery specifications. WARNING! Prev ent injur y . Do not replace batter y when seat is occupied. WARNING! Batter y posts, ter mina[...]

Jazzy 610 www .pridemobility .com 4 3 BATTERY WIRING DIAGRAM LABEL VIII. CARE AND MAINTENANCE Figure 30. Battery Installation REAR SHROUD FASTENERS REAR SHROUD FRONT BATTERY REAR BATTERY[...]

4 4 www .pridemobility .com Jazzy 610 VIII. CARE AND MAINTENANCE 15. Connect the battery harness to the rear battery . 16 . Reinstall the front cover . 17 . Reinstall the rear shroud and tighten the fasteners. 18 . Charge the batteries. See VI. “Batteries and Charging.” When to See Y our Authorized Pride Provider for Service The following sympt[...]

Jazzy 610 www .pridemobility .com 4 5 IX. WARRANTY LIFETIME LIMITED WARRANTY For the lifetime of your power chair from the date of purchase, Pride will repair or replace at our option to the original purchaser , free of charge, any of the following parts found upon examination by an authorized representative of Pride to be defective in material and[...]

4 6 www .pridemobility .com Jazzy 610 IX. WARRANTY RECONDITIONED UNITS WARRANTY All reconditioned units are covered by a six-month warranty from Pride effective from the date of purchase. WARRANTY EX CLUSIONS This warranty does not extend to those items which may require replacement due to normal wear and tear . ! ABS Plastic shrouds ! Motor brushe[...]

Quality Control- Model 14 0 0 *INFMANU2897* Thank you for making the Jazzy 610 your choice in power chairs. The following checkmarks indicate that we have thoroughly inspected and test driven your power chair . Fit and Finish Performance Pride keeps a more detailed r epor t on file at the factory . Quality Control - JAZZY 610 #1 In Quality Control [...]