Regency Wraps F38-NG2 manual

07/18/07 Freestanding Gas Stove FOR YOUR SAFETY What to do if you smell gas: Do not try to light any appli- ance Do not touch any electri- cal switch: do not use any phone in your building. Immediately call your gas supplier from a neighbour's phone. Follow the gas sup- plier's instructions. If you cannot reach your gas supplier , call th[...]

2 Regency F38-2 Freestanding Gas Stove T o the New Owner: Congratulations! Y ou are the owner of a state-of-the-art Gas Stove by FIREPLACE PRODUCTS INTERNA TIONAL L TD. The Regency Gas Series of hand crafted appliances has been designed to provide you with all the warmth and charm of a woodstove, at the fl ick of a switch. The models F38-NG2, and [...]

Regency F38-2 Freestanding Gas Heater 3 T ABLE OF CONTENTS SAFETY LABEL Safety Label .................................................................. 5 INST ALLA TION General Information ....................................................... 5 Important ....................................................................... 5 Before Y ou Start .[...]

4 Regency F38-2 Freestanding Gas Stove This is a copy of the label that accompanies each Freestanding Gas Stove. We have printed a copy of the contents here for your review . The safety label is located on the inside of the drop down pedestal door . NOTE: Regency units are constantly being improved. Check the label on the unit and if there is a dif[...]

Regency F38-2 Freestanding Gas Heater 5 INST ALLA TION GENERAL SAFETY INFORMA TION 1) The appliance shall be installed in accord- ance with the manufacturer's installation instructions, local gas fi tting regulations, municipal building codes, water supply regulations, electrical wiring regulations, with AS5601-2004 (AGA gas installation code[...]

6 Regency F38-2 Freestanding Gas Stove INST ALLA TION CLEARANCES T O COMBUSTIBLES The clearances listed below are MINIMUM distances. Measure the clearance to both the appliance and the chimney connector . (The farthest distance is correct if the two clear- ances do not coincide.) For example, if the appliance is set as indicated in one of the fi g[...]

Regency F38-2 Freestanding Gas Heater 7 INST ALLA TION Flueing Requirements A100 mm diameter fl ue is required. For cosmetic or aesthetic purposes 6" outer fl ue can be used as long as an approved inner fl ue is installed. Fasten but do not penetrate the inner sleeve of the fl ue when tightening the screw . The minimum fl ue required is 3[...]

8 Regency F38-2 Freestanding Gas Stove INST ALLA TION CONVERSION KIT# 731-968 FROM NG T O LPG THIS CONVERSION MUST BE DONE BY A QUALIFIED GAS FITTER IF IN DOUBT DO NOT DO THIS CONVERSION !! 1) Shut off the gas supply . 2) Open the front door and carefully remove the logs and lava rock. Pilot assembly is now accessible for steps 4) to 9). LPG Conver[...]

Regency F38-2 Freestanding Gas Heater 9 INST ALLA TION AERA TION ADJUSTMENT The burner aeration is factory set but may need adjusting due to either the local gas supply or altitude. F38-2 with 38 mj F38-NG2 NG: Full open F38-LPG2 LPG: 6.4 mm open Caution: Carbon will be produced if the air shutter is closed too much. Note: Any damage due to carboni[...]

10 Regency F38-2 Freestanding Gas Stove Notch E)02-45 Bracket A)02-65 The bottom right edge of Log G)02-48 must sit snugly against the bracket Side V iew G)02-48 E)02-45 F)02-47 10) Position notch in Front Right Log G)02-48 on Log F)02-47 and push the bottom right edge against the bracket on the burner tray . G)02-48 11 ) T est fi re to ensure pro[...]

Regency F38-2 Freestanding Gas Heater 11 Note: If the fl ue is blocked or has a strong reverse fl ow , the thermally actuated safety switch mounted in the draft diverter will automatically shut off the gas supply within about 10 minutes. If the heater turns off be- cause of this during the spillage test, check for the cause of the lack of draft. [...]

12 Regency F38-2 Freestanding Gas Stove OPTIONAL REMOTE CONTROL Use the Regency Remote Control Kit approved for this unit. Use of other systems may void your warranty . The remote control kit comes with a hand held transmitter , a receiver and a wall mounting plate. 1) Choose a convenient location on the wall to install the receiver and the recepta[...]

Regency F38-2 Freestanding Gas Heater 13 WIRING CAUTION: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper and dangerous operation. W ARNING: Electrical Grounding Instructions This appliance is equipped with a three pronged (grounding) plug for your protection against shock hazard and should be plugged[...]

14 Regency F38-2 Freestanding Gas Stove OPERA TING INSTRUCTIONS 4) T urn the PILOT knob counterclockwise to pilot and align it with the arrow as shown in diagram 1. 5) Push in PILOT knob all the way in and hold. Immediately push IGNITOR button until pilot lights. Continue to hold the PILOT knob in for approximately one minute, then release the PILO[...]

Regency F38-2 Freestanding Gas Heater 15 COPY OF THE LIGHTING PLA TE INSTRUCTIONS W ARNING: DO NOT SPRA Y AEROSOLS IN THE VICINITY OF THIS APPLIANCE WHILE IN OPERA TION. OPERA TING INSTRUCTIONS 1 ) Push in the gas control knob slightly and turn clockwise t o  O FF. Do not force. FOR YOUR SAFETY READ BEFORE LIGHTING A ) This appliance has a pi[...]

16 Regency F38-2 Freestanding Gas Stove NORMAL OPERA TING SOUNDS OF GAS APPLIANCES It is possible that you will hear some sounds from your gas appliance. This is perfectly normal due to the fact that there are various gauges and types of steel used within your appliance. Listed below are some examples. All are normal operating sounds and should not[...]

Regency F38-2 Freestanding Gas Heater 17 MAINTENANCE CLOTHING OR OTHER FLAMMA- BLE MA TERIAL SHOULD NOT BE PLACED ON OR NEAR THE AP- PLIANCE. DO NOT USE THIS APPLIANCE IF ANY P ART HAS BEEN UNDER W A TER. IMMEDIA TEL Y CALL AN AUTHORIZED SERVICE TECHNI- CIAN TO INSPECT THE APPLIANCE AND TO REPLACE ANY P ART OF CONTROL SYSTEM AND ANY GAS CONTROL WHI[...]

18 Regency F38-2 Freestanding Gas Stove MAINTENANCE F AN MAINTENANCE If your fan requires maintenance or replacement, access to the fan is through the access panel on the rear wall of the fi rebox. If the unit is damaged or needs repair , it shall be repaired by the manufacturer or its service agent or similiarly qualifed person in order to avoid [...]

Regency F38-2 Freestanding Gas Heater 19 4) Remove the two outside frame pieces by removing two screws per side. See diagram below . REMOVING V AL VE If your valve requires maintenance or replace- ment, follow these instructions: NOTE: Always shut off the gas supply before removing the valve. 1) Open front pedestal door and unhook chain. Y ou may w[...]

20 Regency F38-2 Freestanding Gas Stove P ARTS LIST F38-2 MAIN ASSEMBL Y 1) 560-920 T op/Bottom Gold Louvre (Set) 560-922 T op/Bottom Black Louvre (Set) 2) 750-532 Safety Screen (Australia only) 9) 750-040 Fan Access Door 10) 730-034 Gasket for Fan Access Door 560-519 Fan Assembly 1 1) 910-169/P Fan Motor (240 V olt) 12) 910-714 Power Cord (240 V o[...]

Regency F38-2 Freestanding Gas Heater 21 F38-2 BURNER & LOG ASSEMBL Y Part # Description P ARTS LIST 52) 910-190 Piezo Ignitor & Nut 54) 910-373 Knob - S.I.T . V alve Extension 55) 910-372 Flame Adjusting Knob 56) 918-088 Control Panel Decal 57) * Control Panel Plate 750-527/P V alve Assembly - NG 750-526/P V alve Assembly - LPG 60) 910-478[...]

22 Regency F38-2 Freestanding Gas Stove F38-2 DOOR ASSEMBLIES 730-924 Gold Mitred Door - Complete 730-926 Black Mitred Door - Complete 730-932 Gold Wrap Door - Complete 730-928 Gold Panel Door - Complete 101) 650-920 Door Gasket Kit 105) * Ceramic Paper 106) 940-323/P Side Glass 107) 936-243 Glass Gasket 108) 940-322/P Centre Glass 1 1 1) * Door Fr[...]

Regency F38-2 Freestanding Gas Heater 23 WA R R A N T Y Exclusions: This limited Lifetime W arranty does not extend to or include paint, door or glass gasketing or trim. It does not cover installation and operational related problems such as over-fi ring, downdrafts or spillage caused by environmental conditions, nearby trees, buildings, hilltops,[...]

Printed in Canada © Copyright 2007, FPI Fireplace Products International Ltd. All rights reserved.[...]