Sears 502493 manual

O WNERS MANU AL Model No. 502493 552493 Inc ludes Dec k Adapter #62468 CA UTION: Read Rules f or Saf e Oper ation and Instr uctions Carefully PRINTED IN U .S.A. FORM NO 40772 (06/29/07) CHIP-N-V A C Safety Assembl y Operating Maintenance Repair P arts[...]

2 T ABLE OF CONTENTS SAFETY R ULES ....................................................... 3,4 FULL SIZE HARD W ARE CHAR T ........................... 5,13 CAR T ON CONTENTS ................................................. 6 ASSEMBL Y .................................................................. 7 OPERA TION ..................................[...]

3 SAFETY Any po wer equipment can cause injury if operated improperly or if the user does not understand ho w to operate the equipment. Exercise caution at all times, when using po wer equipment. • Read and fo llow all instruct ions in this manual bef ore attemptin g to assemble or operate this equipment. F ailure[...]

4 W ARNING  • ReadOwner'sManualandallsafetylabelsonmac hinebeforestartingandusingmachine.  • DoNotremovetopco verorattempttoemptycontentsofcartwhileengineisrunning.  • DoNotstandbehindcar tinexhaustdisc hargearea?[...]

5 HARD W ARE P A CKA GE CONTENTS Ref. Qty . Description Cart V ac A 3 -- He x Bolt, 3/8" x 3" B -- 1 He x Bolt, 1/2" x 1-1/4" C 2 -- Hex Bolt, 3/8" x 1-1/4" D -- 2 He x Bolt, 1/4" x 1-1/4" E -- 2 He x Bolt, 1/4" x 1" F -- 6 He x Bolt, 5/16" x 3/4" G -- 14 He x Bolt, 1/4" x 3/4" H[...]

6 CART ON CONTENTS (Mo w-N-V ac Car ton) Ref. Qty . Description 1 1 F ront P anel 2 2 Side P anels 3 1 Rear Door 4 1 Cross Brace 5 2 Hose Clamp 6 1 Adapter Brack et 7 1 Deck Adapter Ref. Qty . Description 8 1 P oly Hard T op 9 1 Hitch Brac ket   10 1 HoseAdapter(Nozzle) 11 1 Hose Hanger Brack et 12 1 Elbow 13 1 Engine Base Assembl[...]

7 ASSEMBL Y FIGURE 3 FIGURE 1 This unit is shipped WITHOUT GASOLINE or OIL. After assembly , see separate engine manual f or proper fuel and engine oil recommendations. CA UTION: Do not leave the cart unattended in upright position dur ing assembly . A falling car tcancausepersonalinjur y!Pa yclose attention to the stability of[...]

8 FIGURE 4 8. T o prev ent accidental tipping during the follo wing assembly procedures , lower the cart to rest upside down, with the wheel support facing up , as shown in gure5. 9. Align the latch stand brack et so that the tab is at the rear . F asten the brac ket to the rear set of holes at the front of the car t using two 1/4" x 5/8[...]

9 FIGURE 8 13. Flip the cart over so that it rests on its wheels . 14. Assemb le the front tongue on top of the rear tongue using three 3/8" x 3" he x bolts and 3/8" nyloc k nuts. Seegure8. HINT : F or easier assembly , suppor t the rear tongue with a bloc k of wood. 15. Assemb le the hitch brac ket to the front tongue us- i[...]

10 FIGURE 11 20.  Placeasidepanelontopofthecartbedange, inside the lip of the front panel. F asten the side panel to the front panel using three 1/4" x 5/8" he x bolts and 1/4" nyloc k nuts. F asten the side panel to the car t bedangeusingtwo1/4"x5/8"he xbolt[...]

11 25. Assemb le a shor t tar p strap to rear door using one 1/4"x1-1/4"he xbolt,two1/4"atwashersandone 1/4" nyloc k nut. Assemble an "S" hook through loose endofstrap . Seegure15. Repeatonothersideof door . 26. Assemb le door to rear of car t by r[...]

12 33.  Assemb lethehoseadapter(nozzle)tothefrontof the impeller housing and secure with the three knobs. Make sure that the s witch actuator brac ket contacts thes witchonthehousing. Seegure19. FIGURE 22 FIGURE 20 34. Place a hose clamp onto one end of hose . Push hose ontohoseadapter([...]

13 ASSEMBLING THEDECKAD APTER(#62468) T O THE MO WER DECK ContentsofHard wareP ackf orDeckAdapter: See Figure 23. Ke y Qty . Description A 2 Hex Bolt, 5/16" x 1" B 4 Hex Bolt, 1/4" x 3/4" C 2 Carr iage Bolt, 5/16" x 3/4" D 3 Nylock Nut, 5/16" E 4 Nylock Nut, 1/4" F 3 Flat Stee[...]

14 FIGURE 25 5. Holding the adapter brack et and the deck adapter together , position the dec k adapter on the mower deck. K eeping the edge of deck adapter as close as possible to the offset in the adapter br ack et, see if the slot in the adapter brac ket can be aligned with one ortwoofthedeectorholesiny ourmowerdec [...]

15 FOR 1990 AND NEWER MURRA Y TRA CT ORS WITH A 38" OR 40" DECK 1. Cut out two templates and place on deck adapter as showningure29.  T apesmalleroneontopandlarger one on the side and bottom. After they are in place, carefully mark around the templates, then cut out adapter to obtain correct opening. 2.[...]

16 FIGURE 31 and/or leav es out of car t. 11. After car t is emptied, secure car t to tongue with latch and reattach the rear door and the vinyl boot. HO W T O USE Y OUR CHIP-N-V A C BEFORE ST ARTING 1. Y our Chip-N-V ac engine is shipped without oil or gasoline. Ser vice the Chip-N-V ac engine with oil and gas as instructed in the separate engine [...]

17 USING THE CHIPPER CHUTE 1. Mater ial such as stalks or heavy branches up to 3" in diameter ma y be fed into the chipper chute as sho wn ingure32.  2. Be sure to wear ey e protection and glov es when f eeding material into the chipper chute. 3. Use the tamper plug, not your hands, to f orce material down through the chipper chute[...]

18 MAINTENANCE Ser vice Dates Check f or loose f asteners X Check soft vin yl boot X Check tire pressure X Check engine oil le v el X Lubricate X Clean X X Maintain engine per instructions below and in engine manual. Before each use After each use Every season Before stor age CUST OMER RESPONSIBILITIES • Readandf ollowthemaintenanc[...]

19 ST ORA GE 3. If storing in an un ventilated or metal storage shed, coat metal par ts with light oil or silicone to prev ent rust. 4. Store unit in a clean, dry area. 1. Clean the engine and the entire unit thoroughly . 2. Refer to engine manual f or correct engine storage instructions. SER VICE AND ADJUSTMENTS FIGURE 33 SHARPENING OR REPLA CING [...]

20 TR OUBLESHOO TING PROBLEM POSSIBLE CA USE(S) CORRECTIVE A CTION Engine fails to star t 1. Spar k plug wire disconnected. 1. Connect wire to spar k plug.   2. Saf etys witchnotcontacted.  2. Correctlyinstallhoseadapternozzle. 3. Fuel tank empty , or stale fuel. 3. Fill tank with clean, fresh fuel. 4. Fuel[...]

21 P ARTS REP AIR P ARTS FOR MODEL 502493/552493 CAR T BOD Y 15 43088 2 W asher , Flat 1/4" 16 63917 1 T ongue W eldment Ass'y . (Rear) 17 63155 1 T ongue W eldment Ass'y . (F ront) 18 24614 1 Latch Lock Le v er 19 23475 1 Hitch Brac ket 20 43884 1 Hitch Pin 21 43343 1 Pin, Hair Cotter 1/8" 22 43087 2 He x Bolt, 3/8-16 x 1-1/4&q[...]

22 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C 42 43 32 41 TO TRA CT OR 26 24 25 27 23 4 39 40 58 12 35 13 21 20 28 33 13 33 35 34 37 13 13 36 35 31 35 13 1 2 2 3 4 4 6 8 8 8 9 10,11 14A 14B 16 17 19 19 18 29 30 40 51 52 53 A A 22 20 35 B B 4 13 15 5 8 13 8 13 13 8 40 40 40 40 40 35 35 35 35 44 44 44 12 12 12 47 45 46 47 48 50 49 AD APTER #[...]

23 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C REF . P ART QTY . DESCRIPTION NO . NO. 1 24080 1 Engine Base 2 24078 2 Brace, Housing 3 63226 1 Hose Hanger Brack et Ass'y . (Ref. item #16 on page 22.) 4 43182 14 Bolt, Hex 5/16-18 x 3/4" 5 43063 2 Bolt, Hex 5/16-18 x 1" 6 43085 4 Bolt, Hex 5/16-18 x 1-1/2" 7 8 43064 15 Nut[...]

24 REP AIR P ARTS FOR MODEL 502493/552493 CHIP-N-V A C IMPELLER HOUSING ASSEMBL Y REF . P ART QTY . DESCRIPTION NO . NO . REF . P ART QTY . DESCRIPTION NO . NO . 15 731-1613 1 Cov er , Switch 16 63226 1 Hose Hanger Brack et. Ass'y . 17 712-3046 3 Nut, He x Jam 5/16-18 Thd. 18 24606 1 Spacer , Housing 19 736-0247 1 Flat W asher , 13/32" x [...]

25 A PO WER POLE A CORNER OF A BUILDING OR A FENCE POST FOLD ALONG DO TTED LINE, REPRESENTING A 10 DEGREE SLOPE SIGHT AND HOLD THIS LEVEL WITH A VERTICAL TREE SLOPE GUIDE (Keepthissheetinasaf eplaceforfutureref erence .) Use this guide to determine if a slope is safe for the operation?[...]

26 NO TES[...]

NO TES[...]

28 REP AIR P ARTS 809 South Hamilton Sulliv an, IL. 61951 217-728-8388 www .ag ri-fab .com © 2002 Agri-F ab , Inc. This document (or manual) is protected under the U .S . Cop yright Laws and the cop yright laws of f oreign countries, pursuant to the Universal Cop yright Conv ention and the Berne conv ention. No par t of this document ma y be repro[...]