Sunrise Medical Guardian 93000 manual

I nstallation & I nstruction Manual G uar dian ® Easytrack S ystem 3-P ost Assembly M odel 93000[...]

T ABLE OF CONTENTS Intr oducti on .......................................................................................... 2 Important Safegu ards .............................................................................. 3 Requirem ents ......................................................................................... 4 Befor e Y ou B[...]

3-Post System IMPORT ANT S AFEGU ARDS Do not operate this equipment without fir st reading and understanding this manual. Should you be unable to under stand the warnings, cautions and instructions , contact our technical support or your local dealer befor e attempting to use this equipment– otherwise injury or damage may result. Important inform[...]

REQUIREMENTS Failur e to meet requirements listed belo w could result in serious bodily harm. Ceiling Requirements • Install to a rigid ceiling (must have a framework above it). • Must have a maximum of 24" (610mm) between the trusses in the ceiling. • Ceiling must be made of wood or 1/2"(12.7mm) sheet rock or thicker. • Ensure ce[...]

3-Post System BEFORE YOU BEGIN Read "Requirements" and “ Important Safeguards ” bef ore attempting to assemble the Easytr ack System. 1. Survey the room where you plan to install the Easytrack System. Make sure the room meets all the specifi- cations outlined in "Requirements". 2. Use the measurements below to determine the [...]

EASYTRA CK 3-POST SYSTEM KIT CONTENTS & P ART NUMBERS (Figure 6) Description P art # Qty 1 Pivoting e xtendable rail w/stan dard tr olley 900-0850 1 2 Extend able rail w/swivel trolley 900-0800 1 3 Pivot post ?? 1 4 P ost top for pivot post N/A 4 5 Stand ard post 900-0500 2 6 Blue locking han dle N/A 3 7 Round blue cap 900-0720 3 8 Allen key 90[...]

3-Post System 5. T ake the pivot post out o f the box and th e post top for pivot post. Insert th e post top into the post until it sn aps into place (Figur e 9). 6. T ake top plate and clip-on level out of th e box. Place the clip-on level onto th e post at approxim ately waist hei ght (Figur e 10). 7. Place the post onto th e foot plate and pr es[...]

12. Once th e bubble is in the center o f the clip-on level, con tinue to tigh t- en ONL Y un til the red zon e at the top of th e post is no long er visible (Figur es 16-A & B). Red zone must not be visible for the post to be safely secured. o not ov er-tighten the post. Tighten only until red zone disap- pears . Over-tightening post may cause[...]

3-Post System b . Find the en d stopper from insi de the top o f the rail. Th e top por- tion is th e section without th e small tr olley in it (Figure 20). c. U sing the Allen k ey provid ed, loosen the stopper in th e upper portion o f the rail an d slide it out of th e rail (Figur e 21). 20 . Place the end o f the rail with th e hooks on to the [...]

BEFORE USING THE EASYTRA CK SYSTEM GO THROUGH THE FOLLOWING CHECKLIST : ✓ Mak e sure the r ed zone on top of all posts ar e not visible . ✓ Mak e sure the posts ar e straigh t. (Did you use the clip-on level?) ✓ Mak e sure the r ail is locked into place (see step 15) an d that it looks level. ✓ Mak e sure the stopper is sn ug (see step 22b)[...]

3-Post System NOTE – M etal pins cannot be pressed in wh en there is d ownward pressur e on them. Pressur e must be released to pr ess in pins. 14. Remove th e post from the f oot plate by stepping on both sid es with your feet and pulling th e post up. 15. Place all pieces in to a box or bag to protect th em from dust an d/or damag e. 16. Repeat[...]

Upon receipt o f your Easytrack System: 1. Make sur e you received all componen ts listed in Figure 6. 2. Inspect all parts for possible d amage in tr ansit. 3. Ensure all compon ents are in workin g order . 4. Arrang e for repair/r eplacement o f any faulty parts . 5. Keep a log of an y repair/replacem ent requir ed. Befor e each use of the Easytr[...]

3-Post System T roubleshooting 13 TROUBLESHOOTING PROBLEM 1. T rolley moves substanti ally on its own when the Easytr ack System is fully assembled. 2. Extend ed rail comes completely apart durin g assembly . 3. Not able to push pin to assemble/disassem- ble post. 4. Not able to ti ghten post enough to hid e red zone . 5. P osts do not appear stabl[...]

EASYTRA CK PRODUCTS & ACCESSORIES Easytrack 2-P ost System ........................................................................... 92000 Easytrack 4-P ost System ........................................................................... 94000 Easytrack 2-P ost with T ub Bracket ............................................................. [...]

3-Post System W ARRANTY This warran ty is extend ed only to the origin al purchaser/user of Sunrise pr oducts. Sunrise Medi cal Inc. warr ants its prod ucts to be free fr om defects in material un der norm al use and servi ce and will, within the peri ods stated below , from th e date of pur chase. If within such warr anty period an y such prod uct[...]

Distributed by: Sunrise Medical 7477 East Dry Creek P arkway Longm ont, Colorad o 80503 (800) 333-4000 In Canad a (800) 263-3390 Printed in Can ada © 2001 Sunrise Medi cal 10.01 900-0610 Re v . A[...]