Superior CDST-CMP manual

1 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. INST ALLA TION INSTRUCTIONS FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors or liquids in the vicin- ity of this or any other appliance. FOR YOUR SAFETY: What to do if you smell gas: • DO NOT light any appliance. • DO NOT touch any electrical switches. • DO NOT use any[...]

2 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Figure 1 CDPF CDST Millivolt Models - Millivolt models come standard with the manually-modulated gas valve; flame ap- pearance and heat output can be con- trolled at the gas valve. Input of millivolt models is shown in the following table: Electronic appliances are designed to operate on natural or[...]

3 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. * Each model has two burners. Each burner contains one of these orifices. s l e d o M c i n o r t c e l E e n a p o r P d n a l a r u t a N s l e d o M s a G ) H / U T B ( e t a r t u p n I e t a R d e x i F , N E C - F P D C , N E C - T S D C , N E C - R C D C , N E C - L C D C , P E C - F P D C ,[...]

4 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. h c t i P f o o R H ) t e e f ( 2 1 / 6 o t t a l F0 . 1 2 1 / 7 o t 2 1 / 6 r e v O5 2 . 1 2 1 / 8 o t 2 1 / 7 r e v O5 . 1 2 1 / 9 o t 2 1 / 8 r e v O0 . 2 2 1 / 0 1 o t 2 1 / 9 r e v O5 . 2 2 1 / 1 1 o t 2 1 / 0 1 r e v O5 2 . 3 2 1 / 2 1 o t 2 1 / 1 1 r e v O0 . 4 K C A B ) m m 3 1 ( . n i 2 / [...]

5 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 3" (76 mm) 12" (305 mm) T ermination Kit Combustible Projection greater than 2 ¹⁄₂ inches in length Horizontal Vent T ermination Clearances Combustible Projection 2 ¹⁄₂ inches or less in length 18" (457 mm) Ventilated Soffit Unventilated Soffit T op Louver Panel Unit Parts [...]

6 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Figure 8 EXTERIOR HORIZONTAL VENT TERMINATION CLEARANCE REQUIREMENTS * n o i t a l l a t s n I n a i d a n a C* * n o i t a l l a t s n I S U , h c r o p , a d n a r e v , e d a r g e v o b a e c n a r a e l C = A . y n o c l a b r o , k c e d * ) m c 0 3 ( s e h c n i 2 1* * ) m c 0 3 ( s e h c n [...]

7 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Gas Line Center of gas line is 3 in. (76 mm) up from floor . *41 ¹⁄₂ (1054) 48 ¹⁄₂ (1108) *This dimension can be reduced to 41 inches (1041 mm). This results in 0 in. (0 mm) clearance between framing and unit framing spacers. (The 41 ¹⁄₂ in. dimension permits easier fireplace install[...]

8 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. CDPF (Peninsula) 12 (305) 10 (254) TOP VIEW 40 ¹⁄₈ (1019) 3 ¹⁄₂ (89) ⁵⁄₈ (16) Stepped to Accept Drywall on T wo Corners FRAMING SP ACERS (T op and Side) FINISH WALL BRACKET (Front, back, and left edge of unit top) 6 ⁷⁄₈ (175) 10 ¹⁄₄ (260) 12 (305) (63.5) RIGHT SIDE VIEW 3[...]

9 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. CDCL (Corner-Left) CDCR (Corner-Right) 6 ⁷⁄₈ (175) 10 ¹⁄₄ (260) 12 (305) 12 (305) 10 (254) (63.6) RIGHT SIDE VIEW TOP VIEW 3 (76) FLUE (T op or Side) 40 ¹⁄₈ (1019) 3 ¹⁄₂ (89) FLUE (T op or Side) GAS INLET ELECTRICAL INLETS ⁵⁄₈ (16) Stepped to Accept Drywall FRAMING SPACER[...]

10 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. VENT RESTRICTOR INST ALLA TION (REAR VENT) RESTRICTOR APPLIANCE SIDE VENT OUTLET VENT RESTRICTOR INST ALLA TION (TOP VENT) RESTRICTOR APPLIANCE TOP VENT OUTLET Figure 19 Figure 20 Select Venting System - Horizontal or Vertical With the appliance secured in framing, deter- mine vent routing and ide[...]

11 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. T R A H C H T G N E L N O I T C E S T N E V l a n i m o N h t g n e L n o i t c e S ) s e h c n i ( 62 14 26 38 4 T O T A L Q T Y n o i t c e S t e N ) s e h c n i ( h t g n e L 2 / 1 - 42 / 1 - 0 12 / 1 - 2 22 / 1 - 4 32 / 1 - 6 4 t n e V f o t h g i e Hs n o i t c e S t n e V f o r e b m u N s e[...]

12 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 10 ¹⁄₂ ” Min. (267 mm) 10 ¹⁄₂ ” Min. (267 mm) First Vent Component Align the dimple (four places) with the opening of the locking incline channel on appliance collar . T wist vent component clockwise to engage and seal. Locking Incline Channel Dimple Appliance collar Vent / Appliance[...]

13 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Framing Dimensions for Roof Pitch C D 0/12 10 ¹⁄₂ in. 10 ¹⁄₂ in. (267 mm) (267 mm) 6/12 10 ¹⁄₂ in. 12 in. (267 mm) (305 mm) 12/12 10 ¹⁄₂ in. 17 ³⁄₄ in. (267 mm) (451 mm) C D Storm Collar 8 feet (2.4 m) Maximum SV4.5CGV-1 T ermination SV4.5F A OR SV4.5FB Flashing AND SV4.5S[...]

14 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. 40 feet (12.2 meters) Maximum *Ceiling Firestop/Spacer (SV4.5VF) A Vent Restrictor , as shown in Figure 19, page 10, must be used in this application *When using Secure Flex, use Firestop/Spacer SF4.5VF A E L B A T VM M U M I N I m u m i x a M H t e e f) m (t e e f) m ( 1) 5 0 3 . 0 (2 ) 1 6 . 0 ([...]

15 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. C E L B A T m u m i n i M Vm u m i x a M HH + H 1 m u m i x a M t e e f) m (t e e f) m (t e e f) m ( 1) 5 0 3 . 0 (2) 0 1 6 . 0 (5 ) 2 5 . 1 ( 2) 0 1 6 . 0 (4 ) 2 2 . 1 (0 1) 1 . 3 ( 3) 4 1 9 . 0 (6 ) 6 8 . 1 (5 1) 5 6 . 4 ( 4) 2 2 . 1 (8) 8 4 . 2 (0 2) 2 . 6 ( V + V 1 H + H + 1 . x a M ) m 4 . 2 [...]

16 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Vertical Rise SV4.5E90 Elbow Horizontal / Inclined Run SV4.5 HT T ermination *Firestop/Spacer SV4.5VF SV4.5L6/12/24/36/48 Vent Sections Support Bracket Spacing Every 5 ft (1.52 m) See Figure 25 on page 12 or Figure 26 on page 13 for vertical vent section support. Support Brackets Building Support [...]

17 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. M. Install the termination - J. Assemble vent run to exterior wall - If not previously measured, locate the center of the vent at the exterior wall. Prepare an opening as described in Step B . Assemble the vent system to point where the terminus of the last section is within 7 ¹⁄₂ in. (191 mm[...]

18 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. E E L B A T w o b l e e e r g e d 0 9 e n 0 = V . x a M ) m 4 1 9 . 0 ( t e e f 3 = H E L B A TF m u m i n i M Vm u m i x a M H t e e f) m (t e e f) m ( 1) 5 0 3 . 0 (5 ) 2 5 . 1 ( 2) 1 6 . 0 (0 1) 1 . 3 ( 3) 4 1 9 . 0 (5 1) 5 6 . 4 ( 4) 2 2 . 1 (0 2) 2 . 6 ( . x a M ) m 4 . 2 1 ( t e e f 0 4 = H [...]

19 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. H 1 V H **Wall Firestop/Spacer (SV4.5HF) *Ceiling Firestop/Spacer (SV4.5VF) *When using Secure Flex, use Firestop/Spacer SF4.5VF **When using Secure Flex, use Firestop/Spacer SF4.5HF **Wall Firestop/Spacer (SV4.5HF) G E L B A T m u m i n i M Vm u m i x a M HH + H 1 m u m i x a M t e e f) m (t e e [...]

20 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. HORIZONTAL VENT FIGURES/TABLES (continued) V H 2 H 1 H *Ceiling Firestop/Spacer (SV4.5VF) **Wall Firestop/Spacer (SV4.5HF) *When using Secure Flex, use Firestop/Spacer SF4.5VF **When using Secure Flex, use Firestop/Spacer SF4.5HF **Wall Firestop/Spacer (SV4.5HF) J E L B A T m u m i n i M Vm u m i [...]

21 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. See the appropriate sections and figures shown throughout the venting section for their installation requirements. GEAR CLAMPS Adapter (SV4.5RF) Apply ONL Y MIL-PAC BLACK HIGH TEMPERA TURE SEALANT (Catalog No. 10K81) to the outside surface of both collars of the adapter (be especially careful to f[...]

22 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Step 4. FIELD WIRING Refer to Section A for millivolt appliances and Section B for electronic appliances. The gas valve is set in place and pre-wired at the factory on both models. Note: The gas valve ON/OFF switch is shown in Figure 51, or 52 on page 23 . It is integral with the gas valve and sho[...]

23 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Figure 52 Figure 54 Figure 53 - GAS CONNECTION Turn on gas supply and test for gas leaks using a soapy water solution. Never use an open flame to check for leaks . A. Mix a 50% dish soap, 50% water solution. B. Light the appliance (refer to the lighting instructions provided in the Homeowner'[...]

24 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Glass Door Latch Control Compartment Access Panel and Hinge Front Glass Enclosure Panel Firebox Floor Bottom Vee-flange Glass Door Frame Top Flange Glass Door Frame Modesty Panel CDST SHOWN R E N R U B N I A M * * * G N I T T E S R E T T U H S Y R O T C A F s l e d o M s a G l a r u t a N s e h c [...]

25 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Combustible Finished Wall Materials This Area Must Remain Clear of Combustible Materials T op of Appliance 1" Min (25 mm) Combustible Wall Framing Spacer Clean Face Models T op of Door Frame Hood must be installed as shown. Radiant panel Drywall Bracket/Spacer Combustible Wall Framing T op of[...]

26 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. * All compressed flex vents can be expanded up to two times. INSTALLATION ACCESSORIES d e t s i L t n e V e r u c e S s t n e n o p m o C ™ . o N . t a C. o N l e d o Mn o i t p i r c s e D 8 6 9 1 H2 - T H 5 . 4 V Sn o i t a n i m r e T e r a u q S l a t n o z i r o H ) 0 8 K 6 9 ( r e c a p S [...]

27 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. t i K n o i s r e v n o C s a G e n a p o r P o T l a r u t a N . o N s l e d o Me p y T t i n U. o N g o l a t a C T S D C F P D C R C D C L C D C t l o v i l l i m5 6 L 5 8 c i n o r t c e l e9 7 L 5 8 t i K n o i s r e v n o C s a G l a r u t a N o t e n a p o r P . o N l e d o Me p y T t i n U[...]

28 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. The manufacturer reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. LHP 1110 West Taft Avenue • Orange, CA 92865 Printed i[...]