Superior NEC-LCDC manual

1 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. HOMEOWNER'S CARE AND OPERA TION INSTRUCTIONS RETAIN THESE INSTRUCTIONS FOR FUTURE REFERENCE FOR YOUR SAFETY: Do not store or use gasoline or other flammable vapors or liquids in the vicin- ity of this or any other appliance. FOR YOUR SAFETY: What to do if you smell gas: • DO NOT light any ap[...]

2 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. These appliances are designed to operate on natural or propane gas only. On Millivolt models the input of the appliance can be adjusted between 30,000 and 37,500 BTU/HR when using natural gas or propane gas. On Electronic models the input is fixed at 37,500 BTU/HR for both gas types. CONGRATULATION[...]

3 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Do not use these appliances if any part has been under water. Immediately call a qualified, professional service technician to inspect the appliance and to replace any parts of the control system and any gas control which have been under water. Ne pas se servir de cet appareil s'il a été plo[...]

4 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Glass Enclosure Panels - Removal and Installation. These are direct-vent appliances. They are de- signed to operate only with the glass enclosure panels properly installed. Generally the glass enclosure panels should not be removed ex- cept to gain access to the components within the firebox, and t[...]

5 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Periodically (After the Burning Season) Maintenance Task Accomplishing Person Procedure Cleaning Firebox Interior Check Flame Patterns and Flame Height Checking Vent System Cleaning Glass Enclosure Panels Homeowner Homeowner Homeowner Homeowner Carefully remove logs, decorative volcanic stone and g[...]

6 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Figure 5 Adjustment Rod Positions (when viewed from above): * Natural Gas - fully clockwise ** Propane - fully counter clockwise *** Settings shown are for each burner. Refer to Figure 4 and remove the front glass enclosure panel as follows: 1. Remove the top louver assembly or radiant panel. 2. Op[...]

7 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Log Placement Figure 7 Millivolt Appliance Checkout The pilot flame should be steady, not lifting or floating. Flame should be blue in color with traces of orange at the outer edge. The top ³⁄₈ " (10 mm) at the pilot generator (thermopile) and the top ¹⁄₈ " min (tip) of the quic[...]

8 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Electronic Appliance Checkout To light the burner, refer to the lighting instruc- tions on page 14 and 15 . Ensure the ignitor lights the pilot. The pilot flame should engulf the flame sensor as shown in Figure 10 Figure 10 With proper care and maintenance, your appli- ance will provide many years [...]

9 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Arch Door Kits Two types of arch door kits are available for the Multi-Open Series. Both types of kits are easy to install and do not require hardware to attach them to the standard door frame. These kits can be retrofitted to previously installed Multi-Open Series appliances. The decorative arch k[...]

10 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Deluxe Remote Control System (Model RCK-D) The Model RCL-T (Deluxe) Remote Control System has all of the features of the standard system along with an added easy to read LCD screen which presents access to many en- hancements, including; battery power level in- dicat[...]

11 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. ACCESSORY COMPONENTS CONTINUED Touch-Up Paint Kit (Black) 90L73 FTPK-B Touch-Up Paint Kit (Tan) 98K67 Touch-Up Paint Kit Repair of minor scratches and discoloration of the appliance black painted cabinet surfaces may be accomplished with the touch-up paint kit. Forced Air Blower Kits -Single Speed[...]

12 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. LIGHTING INSTRUCTIONS – MILLIVOLT GAS VALVE FOR YOUR SAFETY READ BEFORE LIGHTING A. This appliance has a pilot which must be lighted with a piezo ignitor. When lighting the pilot, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell[...]

13 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. INSTRUCTIONS D ’ ALLUMAGE – VANNE GAZ MILLIVOLT INSTRUCTIONS D'ALLUMAGE POUR VOTRE S É CURIT É , LISEZ CES INSTRUCTIONS AVANT L ’ ALLUMAGE A. Cet appareil est muni d’une veilleuse qui doit être allumée avec un allumeur piézo-électrique. Lorsque vous allumez la veilleuse, suivre [...]

14 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. A. When lighting the appliance, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas. Be sure to smell next to the floor because some gas is heavier than air and will settle on the floor. WHAT TO DO IF YOU SMELL GAS • Extinguish any open flame. • O[...]

15 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. INSTRUCTIONS D ’ ALLUMAGE — ELECTRONIC INSTRUCTIONS D ’ ALLUMAGE POUR VOTRE S É CURIT É , LISEZ CES INSTRUCTIONS AVANT L ’ ALLUMAGE A. Lorsque vous allumez l’appareil, suivez exactement ces instruc- tions. B. AVANT L ’ ALLUMAGE: Assurez-vous que vous ne détectez aucune odeur de gaz [...]

16 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. TROUBLESHOOTING THE MILLIVOL T GAS CONTROL SYSTEM 1. Spark ignitor will not light pilot after repeated triggering of ignitor button. 2. Pilot will not stay lit after carefully following the lighting instructions. 3. Pilot burning, no gas to burner, Valve knob “ON,” Wall Switch “ON.” 4. Fre[...]

17 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. TROUBLESHOOTING THE ELECTRONIC IGNITION SYSTEM SYMPTOM POSSIBLE CAUSES CORRECTIVE ACTION See Below. Disconnect the two black wires from the wire nuts. Test switch(s) for continuity with a multimeter. If continuity is not indicated, switch(s) is defective and must be replaced. Note: Before replacin[...]

18 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. REPLACEMENT PARTS LIST . o NN O I T P I R C S E D e n a p o r P d n a l a r u t a N . o N t r a P. y t Q. y t Q. y t Q. y t Q T S D CF P D CL C D CR C D C a 1. n i 4 2 - k c a l b , d o o HZ E 1 4 9 1 9 - B Le n o n1 1 1 b 1. n i 0 4 - k c a l b , d o o HZ C 1 4 9 1 9 - B L2 2 1 1 a 2. n i 4 2 - k[...]

19 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. GAS CONTROLS — HONEYWELL ELECTRONIC GAS CONTROLS — SIT MILLIVOLT . o NN O I T P I R C S E D l a r u t a Ne n a p o r P . o N t r a P. y t Q. o N t r a P. y t Q . 0 3T I S - e v l a V s a G1 0 7 0 K 3 41 1 0 3 5 J 8 81 . 1 3r e t i n g I o z e i P1 0 6 8 K 0 11 1 0 6 8 K 0 11 . 2 3y l b m e s s[...]

20 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. Printed in U.S.A. © 2002 by Lennox Hearth Products P/N 725,001M REV. F 09/2005 The manufacturer reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fire[...]