Thermos 06401314 manual

MODEL 06401314 THIS GRILL IS FOR OUTDOOR USE ONL Y . If you have questions or need assistance during assembly , please call . 1-800-232-3398 T o insure your satisfaction and for follow-up service r e g i , ster your grill online at www.grillregistration.com 06401314 • 80008895 • 08-08-07 Owner ’ s Manual Assembly , Operation, Use and Care ® [...]

Important: Fill out W arranty information below Model Number Serial Number See rating label on grill for serial number . Date Purchased W arranty Information D ANGER Safety Symbols The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual. DANGER: Indicates an imminently hazar[...]

T able of Contents Limited W arranty For Y our Safety T o insure your satisfaction and for follow-up service, register your grill online at: www .g rillr e gistr a tion.com WARNING Do not attempt to repair or alter the hose/valve/regulator for any “assumed” defect. Any modification to this assembly will void your warranty and create the risk of[...]

Use and Care LP (Liquefied Petroleum Gas) • For Y our Safety • LP gas is highly flammable and may ignite unexpectedly when mixed with air . Is nontoxic, odorless and colorless when produced. , LP gas has been given an odor (similar to rotten cabbage) so that it can be smelled. Propane Cylinder Use (1 lb. Disposable) • • • • • Use only[...]

06401314 • 5 CA UTION If ignition does NOT occur in 5 seconds, turn the burner controls OFF , wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury . D ANGER • NEVER store a spare cylinder under or near the [...]

General Grill Cleaning Do not apply a caustic grill/oven cleaner to painted surfaces. Side Shelves: • Non-Stick Cooking Surface: • Do not mistake brown or black accumulation of grease and smoke for paint. Interiors of gas grills are not painted at the factory (and should never be painted). Apply a strong solution of detergent and water or use a[...]

Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry . Separate raw meats and poultry from ready-to-eat foods to avoid cross contamin[...]

CALL OUT LETTER PART NUMBER DESCRIPTION Q U A N TITY A 557103 16 LOG O P LAT E, TH ERM OS, GR I LL- 2-G O 1 B 800088 83 LI D ASS EMBLY 1 C 800088 57 H ANDLE LI GH T AS SEMBLY 1 D 557103 17 LI D H ANDLE 1 E 557103 18 COO KI N G G R AT E, SE T O F 2 1 F 800088 92 VA POR I Z ER B AR 2 G 557103 10 BUR NER , T UBU LAR, ST AI N LE SS 2 H 800088 62 BOT T [...]

P ARTS DIA GRAM Note: Some grill parts shown in assembly steps may differ slightly in appearance from those on your particular grill model, However the method of assembly remains the same. A B D E F G H O P K L I M J N O S U U V T Q Q R W 06401314 • 9 C[...]

1) Open legs and set grill upright sta nding on legs. Note: Legs will lock into slot on side handles. 2) Secure (4) caps over legs locking a rea. Threaded T abs #10-24x3” Screws 1) Lay bottom casting assembly upr ight on level ground. Best to place on top of protecti ve mat or cardboard to reduce scratch ing. 2) Insert each leg assembly onto bott[...]

Hitch Pin Qty: 2 Cotter Pin Qty: 2 Hinge Pin Grill Lid Cotter Pin Grill Bottom 1) Attach handle to grill lid using (4) # 10-24 x 3/8” screws. Use ONL Y ha nd driven screwdriver. Do not over tighten #10-24 x 3/8” Screw Qty: 4 Grill Lid Handle #10-24 x 3/8” Screw 1) Attach grill lid to grill bottom usi ng (2) hitch pins and (2) cotter pins. 064[...]

Handle Light Handle Handle Light Handle Release Button Handle Light Battery Cover AA Batteries Handle Light Handle Light 1) Remove (2) battery covers from han dle light by loosening (2) screws. 2) Insert (4) AA batteries (NOT INCLUDED), 2 per battery compartm ent as indicated on handle light. 3) Replace covers and secure screw s that were loosened [...]

Control Knob Rotary Ignitor Knob Rotary Ignitor Knob Control Knob Qty: 2 Rotary Ignitor Knob Control Knob Control Knob Right Side Shelf V aporizer Bar Cooking Grates Front of Grill Back side of Grill Qty: 1 Clear Protectors 1) Attach (2) control knobs and (1) rota ry ignition knob by aligning holes with contro l panel as shown. 2) Remove (4) clear [...]

Hose Left Side Shelf Hose Regulator Support Wires P l B ul ack Outer Ring Y ellow Cap Gas Inlet I n s e r t Remove 1) Close grill lid. 2) Insert hose regulator support wi res into holes provided in end of left side-shel f. 3) Remove yellow cap from gas inlet lo cated bottom rear side of grill. 4) Bring hose connector to the rear of gr ill. 5) Pull [...]

ST ORING & TRANSPORTING NOTE: Allow grill to c ool down to room temperature before handling. 1) Remove regulator hose assembl y . 2) Fold side shelves into bottom cas ting, and close lid. 3) Fold both legs inward towards cen ter underneath bottom casting. 4) Using match holder located at rea r of grill, secure legs together by inserting lo op e[...]

Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Burner(s) will not light using ignitor . Grease fire or continuous excessive flames above cooking surface Continued on next Poss[...]

T roubleshooting ( ) continued Problem Burner(s) will not light using ignitor . Burner(s) will not match light. Flames blow out. Flare-up. Persistent grease fire. Flashback... (fire in burner tube(s). Burner does not carry flame around to other side. Possible Cause ROT ARY IGNITION: • Rotary knob rotates without clicking. • Sparking between ign[...]

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective parts be returned, po[...]

Please register your grill online at: (If you register online, you do not need to send in this registration card.) WWW .GRILLREGISTRA TION.COM 06401314 • 19[...]

Char-Broil, LLC Printed in China • Columbus, GA 31902 • ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SER VICE CENTER HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. 1-800-232-3398 Grilling Safety Checklist Read and understand owners[...]