Vermont Casting MO18 manual

20012914 7/05 Rev . 0 1 Models: MO18M, MO24M Majestic Burner/Hearth and Log Kits For Natural Gas Use Only Installation Instructions Check with your local building code agency before you begin installation to ensure compliance with local codes, including the need for permits and follow-up inspections. If you encounter any problems regarding code app[...]

20012914 7/05 Rev . 0 2 Read this manual before installing or operating this appliance. Please retain this owner ’ s manual for future reference. Congratulations on selecting a CFM gas log set—an elegant and clean alternative to burning wood. The CFM gas log set you have selected is designed to provide the utmost in safe- ty , reliability , and[...]

20012914 7/05 Rev . 0 3 T able of Contents 1 Listing and Code Approvals A. Appliance Certication ......................... 4 B. T able 1 ..................................... 4 2 Getting Started A. Size of Firebox ............................... 5 B. Negative Pressure ............................ 5 C. T ools and Supplies Needed .................[...]

20012914 7/05 Rev . 0 4 1 Lis ting and Code Appro v als A. Appliance Certication The Gas Log Hearth Kits have been tested and listed in the U.S. in accordance with ANSI Z21.84-2003 (Gas Log Set). They have been listed by OMNI T est Labs for installation and operation in the United States and Canada as described in these Installation and Operatin[...]

20012914 7/05 Rev . 0 5 2 Get ting Star ted A. Size of Firebox See T able 1 in Section 1.B. Asphyxiation Risk This appliance produces carbon monoxide (CO). • The fre e ope ni ng area s (in squa re inch es ) of the chimney damper as shown in the tables must be met. • User must make sure damper is locked open. • The installer is responsible to [...]

20012914 7/05 Rev . 0 6 E. Components of the Gas Hearth and Log Kit The Burner/Hearth Kit consists of the following: • Burner/Pan Assembly • Grate Assembly • Glowing Embers • Sand • Lava Rock • Damper Stop • Aluminum T ubing Assembly • Brass Elbow Connector • Brass Orice & Cap . Log Set Keep appliance dry . • M o l d o r [...]

20012914 7/05 Rev . 0 7 A. Gas Supply Connection Ensure ttings are of the appropriate size and type on the gas line connection. If the tubing has to be cut to length be sure to use the proper cutting and aring tool. Also, be care - ful not to crimp the tubing while bending. If the tubing be- comes crimped, do not use for installation. Fire Ri[...]

20012914 7/05 Rev . 0 8 C. Gas Pressure Proper input pressures are required for optimum appliance performance. Gas line sizing requirements need to be made following NFP A54 and CSA B-149. . Fire Risk Explosion Risk High pressure will damage valve. • Disconnect gas supply piping BEFORE pre ss ure test ing gas lin e at test press ur es above 1/2 p[...]

20012914 7/05 Rev . 0 9 For Use with BR, BC, SR, SC, TF and TL Series CFM Corporation Fireplaces This Damper Stop is designed to work on all CFM Corpora - tion BR, BC, SR, TF and TL series replaces. For all other replaces, refer to note bellow . When installing a decorative gas appliance in a replace, some local codes require this Damper S[...]

20012914 7/05 Rev . 0 10 Figure 4.2 Center Grate Over Burner Pan B. Install the Burner/Pan Assembly The burner/pan assembly is shipped ready for right-hand gas connection. See Section 3.B. for left-hand connection. • Remove the existing cap or gas jet assembly from the gas stub in your replace. Clean the threads using a wire brush or steel woo[...]

20012914 7/05 Rev . 0 1 1 E. Install the Logs F . Adjust the Burner Flame • The burner ame can be adjusted at the manual shutof f valve beside the replace to obtain the desired ame appearance. • The flame color will stabilize after ten minutes of operation. G. Inspect the V enting System The replace venting system is designed and co[...]

20012914 7/05 Rev . 0 12 5 Operating Instr uctions A. Lighting Instructions[...]

20012914 7/05 Rev . 0 13 B. Glass Doors If your replace is equipped with glass doors: • Glass doors should be in fully open poisition when appliance is operating. • Operating in the closed position will block the radiant heat output and may cause incomplete combustion of the gas and increase overheating of the system. C. Important Safeguards[...]

20012914 7/05 Rev . 0 14 6 Maintainin g and Ser v icing the Appliance A. Servicing Y our Appliance B. Cleaning Y our Appliance Y our gas logs require little care. Keep the burner assembly , logs and burner area surrounding the logs clean by vacuuming or brushing with a dry paint brush at least twice a year . • The logs become fragile after burnin[...]

20012914 7/05 Rev . 0 15 7 Referen ce Mater ials A. Replacement Parts Exploded Parts Diagram Replacement Parts CFM HeartH Kits 3 - Hearth Kit Assembly 1 - Burner Pan Assembly 2 - Grate Assembly Orice Connection Hardware Connector T ube Connection Hardware[...]

20012914 7/05 Rev . 0 16 Service Parts List Service Parts CFM HeartH Kits Description of Part MO18M MO24M Qty . Damper Stop Assy 4304045 4304045 1 Burner Pan Assy 20013012 20013013 1 Orce 20013017 20013018 1 Connector T ube 20013023 20013023 1 Sand 4310006 4310006 1 Lava Rock 4310010 4310010 1 Glowing Embers 4310001 4310001 1 Damper Stop for BR/[...]

20012914 7/05 Rev . 0 17 B. Optional Components Safety Pilot Burner/Hearth Kits 20013010 Hearth ember burner for 18 in. hearth kits 2001301 1 Hearth ember burner for 24 in. hearth kits Remote Ready Burner/Hearth Kits 20013019 Hearth ember burner for 18 in. hearth kits 20013020 Hearth ember burner for 24 in. hearth kits 20013021 on/off remote contro[...]

20012914 7/05 Rev . 0 18 B. Owner Registration/ W arranty Please complete and return your owner registration card to ensure proper warranty coverage. If you wish to communicate with the factory , write to LIMITED ONE YEAR W ARRANTY For CFM Corporation Decorative Gas Appliances CFM Corporation extends the warranties specied in para - graphs A and[...]