Vermont Casting NV360 manual

2261 D V360/580 cov er 1/24/00 djt Decorative Gas Appliance Model: NV360 NV580 Homeowner's Installation and Operating Manual CERTIFIED D E S I G N C E R T I F I E D 20003565 7/06 Rev . 7 PLEASE READTHIS MANUAL BEFORE INST ALLING AND USING APPLIANCE. W ARNING: IF THE INFORMA TION IN THIS MANUAL IS NOT FOLLOWED EX- ACTL Y , A FIRE OR EX[...]

2 NV360/580 Ser ies 20003565 T able of Contents Thank you and Congratulations on your purchase of a Majestic Fireplaces fireplace. PLEASE READ THE INST ALLA TION & OPERA TING INSTRUCTIONS BEFORE USING THE APPLIANCE IMPORT ANT : Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may r[...]

3 NV360/580 Ser ies 20003565 Installation & Operating Instructions This gas appliance should be installed by a qualified installer in accordance with local building codes and with current CSA-B149.1 Installation codes for Gas Burning Appliances and Equipment. If the unit is being installed in a mobile home, the installation should comply with [...]

4 NV360/580 Ser ies 20003565 Fireplace Dimensions Fig. 1 Fireplace specifications and framing dimensions. A S 3565a NV360 Specs 12/6/00 djt K J C L T - Rough Opening Width R D G C Rough Opening Height Electrical Access Rough Opening Depth Recessed Nailing Flange Gas Line Access M Outside Air         G F E Q P N O L B Ref. N[...]

5 NV360/580 Ser ies 20003565 Clearance to Combustibles Appliances T op .......................................................... 0” (0 mm) Bottom ..................................................... 0” (0 mm) Side ......................................................... 0” (0 mm) Back .......................................................[...]

6 NV360/580 Ser ies 20003565 Gas Line Installation When purging gas line the front glass must be removed. The gas pipeline can be brought in through the right side of the appliance. Knockouts are provided at conve- nient locations to allow for the gas pipe installation and testing of any gas connection. The gas line connection can be made with prop[...]

7 NV360/580 Ser ies 20003565 FP297A INST A VENT FREE UVHB26 GAS SUPPL Y  7/1/98 1/2" Gas Supply 1/2" NPT x 3/8" Flare Shut-off V alve 3/8" Flex Line (from valve) FP297a Fig. 4 T ypical gas supply installation. The fireplace valve must not be subjected to any test pressures exceeding 1/2 psi. Isolate or disconnect this [...]

8 NV360/580 Ser ies 20003565 Install the V enting System, Flashing and T ermination NOTE: The NV360 uses a 6" B-vent system. The NV580 uses an 8" B-vent system (refer to Accessories, Page 23 for adapter). Refer venting installation instructions provided by the B-V ent manufacturer . Refer to Page 4, Figure 1 to locate chimney centerline d[...]

9 NV360/580 Ser ies 20003565 FP567a 8' VENTING RUNS 12/00 V enting Runs 40 38 36 34 32 30 28 26 24 22 20 18 16 14 12 8 9 10 11 12 1 2 3 4 5 6 7 Horizontal Run (in feet) V ertical Run (in feet) A A: V ertical installations up to 40 feet (12m) in height. Up to an 8 ft. horizontal vent run can be installed within the vent system using a maximum o[...]

10 NV360/580 Ser ies 20003565 Operating Instructions Glass Information Only glass approved by CFM Corporation should be used on this fireplace. • The use of any non-approved replacement glass will void all product warranties. • Care must be taken to avoid breakage of the glass. • Do not operate appliance with glass front removed, cracked or [...]

1 1 NV360/580 Ser ies 20003565 1. Remove window frame assembly . (Refer to Page 10) 2. Remove logs from packaging. As with all plastics - these are not toys and should be kept away form children and infants. 3. Place rear log on rear bracket (ensure log is seated properly , leveled and centered to the unit), so it will not move form side to side an[...]

12 NV360/580 Ser ies 20003565 Inspecting the V enting System This appliance venting system was designed and con- structed to develop a positive flow adequate to remove flue gases to the outside atmosphere. Any foreign object in the venting system, except those designed specifically for the venting system, may cause spillage of flue gases. T o i[...]

13 NV360/580 Ser ies 20003565 is not, turn the unit off and check for causes creating the lack of adequate draft. Do not operate the unit until lack of ad- equate draft has been determined and rectified. First Firing Upon completing the gas line connection, a small amount of air will be trapped in the line. When first lighting the unit with pilot[...]

14 NV360/580 Ser ies 20003565 24 V AC HOT 24 V AC RTN "ON/OFF" SWITCH NOV A SIT 822 V AL VE HONEYWELL S8600 B IGNITION MODULE 120 V AC RTN 40V A TRANSFORMER 120 V AC HOT BLACK BLACK BLACK BLACK BLACK BLACK BLACK WHITE WHITE WHITE WHITE WHITE WHITE WHITE WHITE BLACK FP670 NOV A SIT 822 V AL VE WIRING DGRM. (w/ Honeywell S8600 B Ignition Mo[...]

15 NV360/580 Ser ies 20003565 3. Open control access panel. 4. Push in gas control knob slightly and turn clock- wise to " OFF ". Do not force. 5. Close control access panel. 1. STOP! Read the safety information above. 2. T urn OFF all electrical power to the fireplace. 3. For MN/MP/TN/TP appliances ONL Y , go on to Step 4. For RN/RP app[...]

16 NV360/580 Ser ies 20003565 Gas Supply ON • Supply line hooked up • Shutoff valve open NO NO NO NO • Lockout has engaged. W ait 60 seconds and try again. • For spark at electrode while depressing Piezo - 1/8" gap to pilot hood needed. • All wiring connections • Replace Piezo ignitor • For air in lines • Thermopile needs a min[...]

17 NV360/580 Ser ies 20003565 T roubleshooting SIT NOV A 820 MILLIVOL T V AL VE NOTE: Before troubleshooting the gas control system, be sure external gas shut off is in the "ON" position. W ARNING: BEFORE DOING ANY GAS CONTROL SER VICE WORK, REMOVE GLASS FRONT . SYMPTOM 1. Spark ignitor will not light. 2. Pilot will not stay lit after car[...]

18 NV360/580 Ser ies 20003565 Fuel Conversion Instructions T o convert the DV360/580 units for use with a different gas follow these instructions. Before proceeding, turn control knob on valve to “OFF” and turn gas supply OFF . T urn OFF any electricity that may be going to the appliance. CAUTION: Logs may be HOT! Allow to cool before proceedin[...]

19 NV360/580 Ser ies 20003565 4. Remove both air shutters from burner pan by remov- ing shutter retaining screw then air shutter . (Fig. 26) 5. Install air shutters supplied in kit on burner pan. Replace shutter retaining screw . For conversion to Natural Gas adjust new air shutters so slots are cov- ered. For conversion to Propane Gas, adjust new [...]

20 NV360/580 Ser ies 20003565 Maintenance Burner and Burner Compartment It is important to keep the burner and the burner com- partment clean. At least once per year the logs and lava rock/ember material should be removed and the burner compartment vacuumed and wiped out. Remove and replace the logs as per the instructions in this manual. Always ha[...]

21 NV360/580 Ser ies 20003565 CFM Corporation reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. NV360/580 Ref. Description NV360 NV580 1. Log Set 20002397 20002071 1a. Log Front Left B25 E 1b. Log Front Right B26 E2 1c. Log Rear B27 E3 1d. Log T op Left [...]

22 NV360/580 Ser ies 20003565 NV360/580 (continued) Ref. Description NV360 NV580 6. Ceramic T ile (single) 57803 57803 7. Manifold Assembly 10000765 10000765 8a. Ceramic Hearth Panel (Left) 20002274 20002322 8b. Ceramic Hearth Panel (Right) 20002275 20002323 9. Ceramic Panel (Rear) 20002273 20002319 10a. Ceramic Panel (Left Side) 20002271 20002321 [...]

23 NV360/580 Ser ies 20003565 NV360/580 (continued) Ref. Description NV360 NV580 44. Piezo Ignitor Replacement Kit - Honeywell V alve (not shown) 20000062 20000062 45. V ent Safety Switch 10002013 10002013 46a. Regulator Head - Natural 10001006 10001006 46b. Regulator Head - LP 10001007 10001007 Fuel Conversion Kits Conversion Kit, NG to LP NV360RN[...]

24 NV360/580 Ser ies 20003565 Accessories Fan Kits FK12 Fan Assembly 1. Open louvre assembly bottom. 2. Install FK12 fan in back of unit between hearth sup- ports. (Fig. 32) 3. Secure fan on velcro strips. 4. Power to the fan can be supplied by plugging the supply lead into a conveniently located wall socket or by using a hard-wired EB-1 connector [...]

25 NV360/580 Ser ies 20003565 Remote Controls Optional remote control units are available to control different functions of the appliance. Model Functions Controlled RC1 ON/OFF RC2 ON/OFF and T emperature MRC3 ON/OFF and T emperature control with a digital display and a programmable 24 hour clock IMT Wall mounted thermostat control Ceramic Refracto[...]

26 NV360/580 Ser ies 20003565[...]

27 NV360/580 Ser ies 20003565 © CFM Corporation BASIC W ARRANTY CFM Corporat ion (hereinafte r referred to collectively as the Company) warrants that your new V ermont Castings or Majestic Gas Fireplace/ Stove is free from manufacturing and material defects for a period of one year from the date of purchase, subject to the following conditions and[...]

2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3 800-668-5323 • www .cfmcorp.com CFM Corporation[...]