Weber 42097 manual

 W ARNING: Follow all leak-c heck pr ocedures carefully in this manual prior to barbecue operation. Do this e ven if the barbecue was dealer -assembled. NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them f or future use . THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONL Y .  W ARNING 1. Do[...]

A-2  Dangers &  W arnings  D ANGER Failure to f ollow the Danger s, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to pr oper ty .  W ARNINGS  Do not store a spare or disconnected liquid pr opane cylinder under or near this barbe[...]

A-3 Contents Danger & Warnings .................................................................................. A-2 W arranty .................................................................................................. A-4 General Instructions ................................................................................. A-5 Grilling[...]

A-4 W eber-Stephen Products Co . (W eber) hereby warr ants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of def ects in material and workmanship from the date of purchase as f ollows: when assembled and oper ated in accordance with the printed instr uctions accompanying it. W eber may require reasonab le proof of your da[...]

A-5 Gener al Instructions Y our W eber ® gas barbecue is a por table outdoor cooking appliance. With the Weber ® gas barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer ® bars produce that “outdoor” flav or in the f ood. The Weber ® ga[...]

A-6 Grilling Methods NO TE: If grill looses heat while cooking refer to the troubleshooting section of this man ual.  W ARNING: Do not move the W eber ® gas barbecue when operating or while barbecue is hot. Y ou can adjust the Left and Right burners in each b ur ner set as desired. The control settings are High (H), Medium (M), Low (L), or Off [...]

A-7 Exploded V iew 48 1 2 Summit ® Silv er C NG 012903 8 15 16 17 19 26 27 29 30 31 32 33 34 35 37 42 43 44 45 53 57 58 59 61 68 69 70 71 47 25 46 4 9 12 18 20 21 22 28 36 38 55 14 11 62 72 51 50 52 54 3 39 40 6 63 24 64 65 66 67 60 10 5 7 49 74 41 56 23 13 73[...]

A-8 Exploded V iew List 1. Hinge Pin 2. Ther mometer Hardware 3. Ther mometer Bez el 4. W ar m-Up ™ Bask et 5. Smoker Bo x 6. Left Fla vorizer ® Bar Assemb ly 7. Smoker Bo x Chip Grate 8. Cookbo x Assembly Hardw are 9. 1/4 - 20 He x Nut 10. Electrode Assembly 11. Electrode Assembly 12. Crossov er ® T ube 13. Smoker Burner T ube 14. Left Bur ner[...]

A-9 P arts List Side Bur ner - 1 Lid - 1 Cookbo x - 1 Left F rame Assemb ly - 1 Right F rame Assemb ly - 1 Side T ab le - 2 Bottom Shelf - 1 Rear P anel - 1 Left Door - 1 Right Door - 1 W ar ming Rack - 1 W ar m-Up ™ Rack - 1 F ront F rame Rail - 1 Rear F rame Rail - 1[...]

A-10 Hose - 1 Catch-P an Holder - 1 Catch-P an - 1 Disposable Drip P ans - 2 Wrench - 1 7/16 inch Wrench - 1 Flav or izor ® Bars - 2 Sets Smok er - 1 Stainless Steel Cooking Grates - 2 Bottom T r ay - 1 P arts List 1/2 inch Bolts (1/4 x 20 x 1/2 inch Bolt) - 8 Plastic W asher - 1 Hinge Pin- 2 Hair Pin Cotter- 2 1-1/4 inch Bolts (1/4 x 20 x 1-1/4 i[...]

B-a 1 Ba402_NG.a a b c (1) (2) (3) (3)  CA UTION: Bef ore proceeding to the ne xt step check that fr ame rail (2) is on the side with the s wing tables (3). The tab on frame rail (2) m ust be f acing tow ard the wheels. Place corregated from each side of the Cookbo x under the Caster and Wheel F rame Assembly to le vel the frames f or F rame Rai[...]

B-b 2 b a  A TTENTION! Only start these bolts. Do not tighten yet.[...]

B-c 3[...]

B-d b c a 1 2 4  A TTENTION! Completely remove both par tially started bolts from top rear frame rail  A TTENTION! Reinstall both bolts thr ough rear panel and into rear frame rail.[...]

B-e 5 a (1) (2) (2) (1) (2) (2)  A TTENTION! Remo ve packing tape holding the gas line and brac ket(1). When installing cookbo x route the gas line and brac ket(1) inside the frame rails(2).[...]

B-f (1) (2) (3) b 6[...]

B-g 7 (1) (2) (1) (2) c[...]

B-h 8 b a Matchlight Holder[...]

B-i 9 (1) (2) (3) a b[...]

B-j a b a b 10[...]

B-1 (1) (2) a b (1) 11 B407_NG.c NO TE: Igniter Wire (1) is located up under right side of control panel.[...]

B-2 c d (1) (2)  CA UTION: Hold burner cap (1) down while pushing side b ur ner ignition wire (2) on.[...]

B-3 a b 13 12[...]

B-4 14 15[...]

B-5 16 17[...]

B-6[...]

C-1 Gas Instructions Install Gas Supply General Specifications for Piping Note - Contact your local m unicipality for b uilding codes regulating outdoor gas barbecue installations. In absence of Local Codes, y ou must confirm to the latest edition of ANSI Z223.1. WE RECOMMEND THA T THIS INST ALLA TION BE DONE BY A PROFESSIONAL. Some of the f ollowi[...]

C-2 Gas Instructions (1) (1) (2) (2) a b Connect Gas Suppl y a) T o connect gas hose at the supply: Slide bac k the collar of the quick disconnect. Push male fitting of the hose into the quick disconnect, and maintain pressure(1). Slide the collar closed(2). If it does not engage or lock, repeat procedure. b) T o connect gas hose at the Grill: Slid[...]

C-3 Gas Instructions (1) (2) (3) (2) (4)  W ARNING : The gas connections of your Summit ® gas grill have been factory tested. We do ho wever recommend that y ou leak check all gas connections before operating y our Summit ® gas grill. Remove contr ol panel P ar t required: Phillips Screwdriver . Remov e the burner control knobs (1). The screws[...]

C-4 Gas Instructions Chec k for gas leaks  D ANGER Do not use an open flame to chec k for gas leaks. Be sure there are no sparks or open flames in the area while you c heck f or leaks. Sparks or open flames will result in a fire or explosion whic h can cause serious bodily injury or death and damage to pr oper ty .  W ARNING: Y ou should chec[...]

C-5 Gas Instructions Reinstall control panel P ar ts required: control panel, screws , and burner control knobs. Place the control panel back onto the control panel brack ets on either side of the front of the cooking bo x. Line up screws with scre w holes on both the control panel and control panel brac kets. Tighten screws . Reinstall burner cont[...]

D-1 Oper ating Instructions Grilling Methods NO TE: If grill looses heat while cooking refer to the tr oubleshooting section of this manual. Y ou can adjust the Left and Right burners in each burner set as desired. The control settings are High (H), Medium (M), Low (L), or Off (O). If burner s go out during cooking, turn off all burner s and wait 5[...]

D-2 Oper ating Instructions Indirect cooking The Indirect Method is similar to roasting, b ut with the added benefits of that grilled texture , flav or , and appearance you can ’ t get from an o ven. T o set up f or Indirect cooking, gas burners are lit on either side of the f ood but not directly beneath it. Heat rises, reflects off the lid and [...]

D-3 Oper ating Instructions Lighting Summar y lighting instructions are on the control panel.  D ANGER F ailure to open the lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodil y injury or death. Cr ossov[...]

D-4 Oper ating Instructions Manual Lighting  D ANGER F ailure to open lid while igniting the barbecue’ s burners, or not waiting 5 minutes to allow the gas to c lear if the barbecue does not light, may result in an explosive flame-up which can cause serious bodil y injury or death. 1) Open the lid. 2) Make sure all burner control knobs are tur[...]

D-5 Oper ating Instructions Side Burner Lighting Instructions  D ANGER F ailure to open the lid while igniting the side b urner , or not waiting 5 minutes to allow the gas to c lear if the side burner does not light, may result in an e xplosive flame-up which can cause serious bodily injury or death. Lighting only the side b urner . 1) Open the [...]

D-6 Oper ating Instructions Using the Smoker The smoker uses presoak ed wood chips. For best results with f aster cooking foods lik e steaks, b urgers and chops, etc., we recommend using finer w ood chips because they ignite and create smok e faster . For longer cooking f oods such as roasts, chic ken and turke ys, etc., we recommend using larger w[...]

D-7 Oper ating Instructions 4 4 1 7 2,3,9 6 8 5 Lighting the Smoker Burner  W ARNING: Check hose bef ore each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be dama ged in any wa y , do not use the grill. Replace using only Weber ® authorized replacement hose. Contact the Customer Service Representative in y our re[...]

D-8 Oper ating Instructions 4 4 1 5 7,9 2,3,10 8 Manuall y Lighting the Smoker Burner  W ARNING: Check hose before eac h use of grill for nicks, cracking, abrasions or cuts. If the hose is f ound to be damaged in any wa y , do not use the grill. Replace using only W eber ® authorized replacement hose. Contact the Customer Service Representative[...]

D-9 Main & Smoker Burner T r oubleshooting Pr oblem Chec k Cure Burner s burn with a yellow or orange flame, in conjunction with the smell of gas. Inspect W eber ® Insect/Spider Screens f or possible obstructions. (Blockage of holes .) Clean W eber ® Insect/Spider Screens. (See Section “ Ann ual Maintenance ” ) Burner does not light, or f[...]

D-10 Pr oblem Check Cure Side Burner does not light. Flame is low in HIGH position. Push button ignition does not work. Is gas supply off? T ur n supply on. Is the fuel hose bent or kink ed? Straighten hose . Does burner light with a match? If match lights b ur ner , checkigniter (see below). Side Burner maintenance  W ARNING: All gas controls a[...]

E-1 Maintenance (1) (1) Main Burner Flame P attern The W eber ® gas barbecue burners hav e been factory set f or the correct air and gas mixture. The correct flame pattern is shown. 1) Bur ner tube 2) Tips occasionally flick er yellow 3) Light blue 4) Dar k b lue If the flames do not appear to be unif or m throughout the burner tube, f ollow the b[...]

E-2 Maintenance Replacing Main Burners 1. Y our Summit ® gas grill must be OFF and cool. 2. T ur n gas OFF at source. 3. Disconnect regulator . 4. Remov e cooking grates . 5. Remov e Smoker bo x. 6. Remov e Flav orizer ® bars. 7. T o remov e control panel refer to “Remove the control panel” under “Check f or Gas Leaks. ” 8. Disconnect all[...]

E-3 Maintenance (a) (b) (b) 11. Lift and twist the burner assembly slightly , to separate the Crossov er ® tube (a) from the burners (b). 12. Remov e the Crossov er ® tube. 13. Pull the selected burner(s) tube(s) from manif old frame and replace with a ne w burner tube. 14. T o reinstall the manifold assemb ly , re verse steps 7 through 13.  C[...]

E-4 Maintenance Cr ossover ® Ignition System Operations If the Crossov er ® ignition system f ails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossov er ® ignition system. • Check that both ignition wires (1,2) are attached properly . • Check that the [...]