Weber 42373 manual

SUMMIT ® BUILT-IN NA TURAL GAS GRILL OWNER'S GUIDE 42373 US 04/01/04 NG US English # 42373 SUMMIT ® SILVER A NOTICE TO INST ALLER: These instructions must be left with the owner and the owner should keep them for future use.  DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open fl ames. 3. Open lid 4. If odor[...]

2  DANGERS &  W ARNINGS  DANGER Failure to follow the Dangers, W arnings and Cautions contained in this Owner ’ s Manual may result in serious bodily injury or death, or in a fi re or an explosion causing damage to property .  W ARNINGS  Do not store a spare or disconnected liquid propane cylinder under or near this barbecue. [...]

3 W ARRANTY W arranty Weber-Stephen Products Co. (W eber) hereby warrants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of defects in mate- rial and workmanship from the date of purchase as follows: when assembled and operated in accordance with the printed instructions accompanying it. Weber may require reasonable proof[...]

4 GENERAL INSTRUC TIONS CLEANING  W ARNING: T urn your Weber ® gas barbecue OFF and wait for it to cool before cleaning.  CAUTION: Do not clean your Flavorizer ® bars or cooking grates in a self-cleaning oven. For availability of replacement cooking grates and Flavorizer ® bars contact the Customer Service Representative in your region usi[...]

5 5 GAS INSTRUC TIONS Check for gas leaks  DANGER Do not use an open fl ame to check for gas leaks. Be sure there are no sparks or open fl ames in the area while you check for leaks. Sparks or open fl ames will result in a fi re or explosion which can cause serious bodily injury or death and damage to property .  W ARNING: Y ou should che[...]

6 6 GAS INSTRUC TIONS Remove the Front Panel by sliding the panel up and out of the slots. Check: 1) Gas line-to-manifold connections.  W ARNING: If there is a leak at connection (1), retighten the fi tting with a wrench and recheck for leaks with soap and water solution. If a leak persists after re-tightening the fi tting, turn OFF the gas. D[...]

7 7 OPERA TING INSTRUC TIONS The most important thing to know about grilling is which cooking method to use for a specifi c food, Direct or Indirect. The difference is simple: place the food directly over the fi re, or arrange the fi re on either side of it. Using the right method is the shortest route to great results—and the best way to ensu[...]

8 8 OPERA TING INSTRUC TIONS Indirect cooking The Indirect Method is similar to roasting, but with the added benefi ts of that grilled texture, fl avor , and appearance you can’t get from an oven. T o set up for Indirect cooking, gas burners are lit on either side of the food but not directly be- neath it. Heat rises, refl ects off the lid and[...]

9 9 OPERA TING INSTRUC TIONS *The grill illustrated may have slight differences than the model purchased. T o Extinguish Push down and turn each burner control knob clock- wise to the OFF position. T urn gas supply OFF at the source. 1 2 2 3 6 4,5,8 7 Lighting Summary lighting instructions are on the control panel.  DANGER Failure to open the li[...]

10 10 OPERA TING INSTRUC TIONS Manual Lighting *The grill illustrated may have slight differences than the model purchased. T o Extinguish Push down and turn each burner control knob clock- wise to the OFF position. T urn gas supply OFF at the source. 2 1 2 4,5,7 6 3  DANGER Failure to open lid while igniting the barbecue's burners, or not [...]

11 Problem Check Cure Burners burn with a yellow or orange fl ame, in conjunction with the smell of gas. Inspect Spider / Insect Screens for possible obstructions. (Blockage of holes.) Clean Spider / Insect Screens. (See Section “Annual Maintenance”) Burner does not light, or fl ame is low in HIGH position. Is LP fuel low or empty? Refi ll L[...]

12 12 MAINTENANCE WEBER ® SPIDER /INSECT SCREENS Y our Weber ® gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. They can nest in the venturi section(1) of the burner tubes. This blocks the normal gas fl ow , and can cause the gas to fl ow back out of the air shutter . This could result in a fi re i[...]

13 13 MAINTENANCE Replacing Main Burners 1. Y our Summit ® gas grill must be OFF and cool. 2. T urn gas OFF at source. 3. Disconnect regulator . 4. Remove cooking grates. 5. Remove Smoker box. 6. Remove Flavorizer ® bars. 7. T o remove control panel refer to “Remove the control panel” under “Check for Gas Leaks.” 8. Disconnect all ignitio[...]

14 14 MAINTENANCE 1 1. Lift and twist the burner assembly slightly , to sepa- rate the Crossover ® tube (a) from the burners (b). 12. Remove the Crossover ® tube. 13. Pull the selected burner(s) tube(s) from manifold frame and replace with a new burner tube. 14. T o reinstall the manifold assembly , reverse steps 7 through 13. (a) (b) (b) (2) (1)[...]

15 15 MAINTENANCE Crossover ® Ignition System Operations If the Crossover ® ignition system fails to ignite the LEFT burner in a burner set, light the LEFT burner with a match. If the LEFT burner lights with a match, then check the Crossover ® ignition system. • Check that both ignition wires (1,2) are attached prop- erly . • Check that the [...]