Weber 650 manual

SUMMIT TM 450 & 650 LP Gas Barbecues Operating Guide W E B E R W E B E R W E B E R W E B E R 72626 01/24/02 Read before assembly  D ANGER If y ou smell gas: 1. Shut off gas to the appliance. 2. Extinguish an y open flames. 3. Open lid. 4. If odor contin ues, keep awa y from the appliance and immediately call y our gas supplier or y our fire [...]

2  D ANGER Failure to f ollow the Dangers, W arnings and Cautions contained in this Owner’ s Manual may result in serious bodil y injury or death, or in a fire or an explosion causing dama g e to property .  W ARNINGS  Do not store a spare or disconnected liquid propane cylinder under or near this barbecue.  Improper assembl y may be [...]

3 T ABLE OF CONTENTS W arnings 2 W arranty 4 A W or d of Thanks 4 General Instructions 5 Operating Area 5 Storage 5 *REFER T O Y OUR STEP-BY-STEP SECTION A T THIS TIME Lighting 6-7 Crossov er Ignition System 6 T o Extinguish 7 Manual Lighting 7-8 T o Extinguish 8 Cooking 9 Storage 9 Cleaning 9 Steam-N-Chips Smoker 10 Refilling The Liquid Propane Cy[...]

4 Thank you for choosing a W eber Barbecue. Our family here at W eber has worked har d to produce the highest quality pr oducts for your satisfaction. While we give much attention to our products, an occasional err or may occur . Our knowledgeable Customer Service staf f is pr epared to help you with any pr oblems with parts or assembly . Call our [...]

5 GENERAL INSTRUCTIONS Y our W eber Gas Barbecue is a por table outdoor cooking appliance. With the W eber Gas Barbecue you can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flav orizer ® Bars produce that “ outdoor ” flav or in the f ood. The Weber Gas Barbecue[...]

1 3 2 1 3 2 6 Crosso ver Ignition System LIGHTING Crosso ver Ignition System Summit 450 Summit 650 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y Summar y lighting instructions are on the control panel.  DANGER Failure to open the lid while igniting the barbecue’ s burner s, or not waiting 5 minutes to allow the gas to clear if the barbecue does no[...]

7 EA CH HEA T ZONE OPERA TES INDEPENDENTL Y . 1) Open the lid. 2 ) Make sure all burner control knobs are tur ned OFF . (Push each burner control knob down and turn clockwise.)  W ARNING: The storage space under the cooking module is intended for stora g e of nonflammable items only .  D ANGER Failure to open lid while igniting the barbecue, [...]

8 3) T ur n the tank on by turning the tank valv e counterclockwise . 4) Select heat zone . 5) Put a match in the match holder and strike the match. 6) Inser t match holder and lit match through matchlight hole to ignite LEFT burner .  W ARNING: Do not lean over open barbecue. Keep your face and bod y at least one foot a way from the matchlight [...]

9 COOKING  W ARNING: T urn your W eber Gas Barbecue OFF and wait for it to cool bef ore cleaning.  CA UTION: Do not clean your Fla vorizer ® Bars or cooking grates in a self-cleaning o ven. For av ailability of replacement cooking grates and Flav orizer Bars contact the Customer Service Representative in your region using the contact informa[...]

10 The Steam-N-Chips Smoker cooks with both W eber FireSpice Wood Chips and Chunks . For best results with f aster cooking foods lik e steaks, burgers and chops , etc., we recommend using the FireSpice Chips because the y ignite and create smoke f aster . F or longer cooking foods such as roasts, chic ken and turke ys, etc., we recommend using Fire[...]

11 REFILLING THE LIQUID PROP ANE CYLINDER W e recommend that you refill the LP cylinder bef ore it is completely empty . Remov al of the LP cylinder 1) Close cylinder valv e (turn clockwise). 2) Unscre w regulator coupling by tur ning counterclockwise , by hand only . 3) Loosen cylinder loc k wing nut and tur n cylinder lock up out of the wa y . 4)[...]

12 Hook the liquid propane cylinder onto the fuel gauge. Loosen the cylinder lock wing n ut. Swing the cylinder loc k down. Tighten the wing nut. Remov e plastic dust cov er from the fuel cylinder valv e. Screw the regulator coupling onto the cylinder v alve(1), clockwise , or to the r ight. Hand tighten only . Note: This is a new type of connectio[...]

13 Spider/Insect screens Y our Gas Barbecue, as w ell as any outdoor gas appliance, is a target f or spiders and other insects. They can nest in the v enturi section V enturi(1) of the burner tubes. This bloc ks the nor mal gas flow , and can cause the gas to flow bac k out of the air shutter . Figure 5. This could result in a fire in and around th[...]

14 GENERAL MAINTENANCE Replacing Main Burners 1. Y our Weber Gas Barbecue m ust be OFF and cool. 2. T urn OFF gas at source. 3. Disconnect regulator . 4. T o remov e control panel ref er to “ Remo ve the control panel and the front panel ” in the Step-By-Step Guide. 5. Remov e cooking grates. 6. Remov e Flav or izer bars. 7. Remov e the manifol[...]

15 10. Slide the burner assembly from each Heat Zone . The left and right burners are connected by the Crossov er tube. ( 1) 9. Pull the manifold(1) out of the b ur ners. GENERAL MAINTENANCE Figure 13 Pull out of here Crossov er tube Summit 450 Summit 650[...]

16 GENERAL MAINTENANCE 11. Lift and twist the burner assembly slightly to separate the crossov er tube(1) from the burners. Remov e the burners from the cooking box. Separate here (1) 12. T o reinstall the burners, re verse steps 3 through 11.  CA UTION: The burner openings m ust be positioned properl y over the v alve orifices. Figure 15 (a). C[...]

17 Prob lem Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups:  CAUTION: Do not line the bottom tray with aluminum f oil. Burner flame pattern is erratic. Flame is low when b urner is on HIGH. Flames do not run the whole length of the[...]

18 P A TENTS & TRADEMARKS © 2000 W eber-Stephen Products Co . W eber , the silhouette, Fla vorizer and Crosso ver are registered U .S. trademarks; Summit, Grill Cozy , Gas Catcher , Spider Stopper , and Steam-N-Chips, are trademarks, all of W eber-Stephen Products Co ., 200 East Daniels Road, P alatine, IL 60067-6266. U .S.A. Summit Series Gas[...]