Weber Genesis Silver A 55275 manual

GENESIS ®  W ARNING: Follow all leak-c heck pr ocedures carefully in this manual prior to barbecue operation. Do this e ven if the barbecue was dealer -assembled. NO TICE T O INST ALLER: These instructions must be left with the o wner and the owner should keep them f or future use . THIS GAS APPLIANCE IS DESIGNED FOR OUTDOOR USE ONL Y .  W A[...]

A-2  Dangers &  W arnings  D ANGER Failure to f ollow the Danger s, W arnings and Cautions contained in this Owner’ s Manual ma y result in serious bodily injury or death, or in a fire or an explosion causing damage to pr oper ty .  W ARNINGS  Do not store a spare or disconnected liquid pr opane cylinder under or near this barb[...]

A-3 Contents Danger & W arnings .................................................................................. A-2 W arranty .................................................................................................. A-4 General Instructions ................................................................................. A-5 Cooking[...]

A-4 W eber-Stephen Products Co . (W eber) hereby warr ants to the ORIGINAL PURCHASER of this Weber ® gas grill that it will be free of def ects in material and workmanship from the date of purchase as f ollows: when assembled and oper ated in accordance with the printed instr uctions accompanying it. W eber may require reasonab le proof of your da[...]

A-5 Gener al Instructions Y our Weber ® gas barbecue is a portable outdoor cooking appliance. With the Weber ® gas barbecue y ou can grill, barbecue, roast and bak e with results that are difficult to duplicate with indoor kitchen appliances . The closed lid and Flav or izer ® bars produce that “outdoor” flav or in the f ood. The W eber ® g[...]

A-6 Cooking  W ARNING: Do not move the Weber ® gas barbecue when operating or while barbecue is hot. Y ou can adjust the FRONT and BA CK burners as desired. The control settings: High (H), Medium (M), Low (L), or Off (O) are described in your Weber ® cookbook. The cookbook uses these notations to describe the settings of the FRONT and BA CK bu[...]

A-7  W ARNING: Follow all safety instructions pr ovided with y our barbecue . Do not dr op cast iron grates, they will break. First Time Use - W ash thoroughly with a mild dishwashing liquid to remo ve the wax coating used f or protection in shipping. Rinse with warm water and dry completely with a soft cloth or paper tow el. NEVER ALLOW TO DRAI[...]

A-8 Exploded V iew Genesis ® Silv er-A NG 092601 1 2 3 4 5 6 7 8 10 9 11 12 15 16 18 19 20 21 22 23 24 25 26 27 29 30 31 32 33 34 35 36 37 38 39 40 41 31 42 44 45 17 28 13 14 43 46[...]

A-9 Exploded V iew List 1. Hinge Pin 2. Left Endcap 3. Shroud 4. Handle 5. W ar ming Rack 6. Cooking Grates 7. Flav or izer ® Bars 8. Cast Iron Cooking Bo x 9. 1/4-20 k eps nut 10. Slide Out Bottom T ra y 11. W ork Surface 12. Catch P an Holder 13. Left Rear T rim Assembly Arm 14. 1/4 - 14 x 5/8 inch bolt 15. Left T r im Piece 16. Left F ront T r [...]

A-10 P arts List Cooking Bo x Assembly - 1 Caster F rame - 1 Wheel F rame - 1 Bottom Rack - 1 Left T rim Assembly - 1 Side T ab le - 1 Right T rim Piece - 1 Fla vorizer ® Bars - 5 Wa rm ing Rac k - 1 Hose - 1 Bottom T ra y - 1 Catch-P an Holder - 1 Catch-P an - 1 Disposab le Dr ip P ans - 2 Thermometer - 1 1 inch Bolts (1/4 x 20 x 1 inch Bolt) - 6[...]

A-11 Unpac king 1 2 3 4[...]

B-a 1 • Push down firmly until Bottom Rack Loc k, "locks" under the rail. • Arrow stic ker to the front. b c a Ba201.d[...]

B-b • Push down firmly on both sides to ensure bottom ra ck is lock ed under the rails .  W ARNING: Do not go to ne xt step if bottom rack is not loc ked in place 2 a b[...]

B-c 3 • Install bolts at indicated locations. Use supplied tool to tighten. Finish tightening bolt with metal wrench provided or a 7/16” wrench.[...]

B-1 4 B205_NG.a 5[...]

B-2 6 7 a b[...]

B-3 10 11 8 9[...]

B-4[...]

C-1 C-1 Gas Instructions Install Gas Supply General Specifications for Piping Note - Contact your local m unicipality for b uilding codes regulating outdoor gas barbecue installations. In absence of Local Codes, y ou must confirm to the latest edition of ANSI Z223.1. WE RECOMMEND THA T THIS INST ALLA TION BE DONE BY A PROFESSIONAL. Some of the f ol[...]

C-2 C-2 Gas Instructions Remove contr ol panel and burner contr ol knobs Y ou will need: Phillips screwdriver . 1) Remove control knobs . 2) Remove scre ws through slots in trim with a Phillips screwdriver . 3) Pull up igniter button until it sticks in the up position and remov e control panel from grill. (3) (2) (1) 4) Replace control panel when L[...]

C-3 C-3 Gas Instructions Check f or gas leaks  D ANGER Do not use an open flame to chec k for gas leaks. Be sure there are no sparks or open flames in the area while y ou chec k for leaks. Sparks or open flames will result in a fire or explosion whic h can cause serious bodily injury or death and damage to property .  W ARNING: Y ou should ch[...]

C-1 D-1 Oper ating Instructions *The grill illustrated ma y hav e slight diff erences than the model purchased. To Extinguish Push down and turn each b urner control knob c lock- wise to the OFF position. T urn gas supply OFF at the source. Lighting Summar y lighting instructions are on the control panel.  D ANGER F ailure to open the lid while [...]

C-2 D-2 Oper ating Instructions To Extinguish Push down and turn each b urner control knob c lock- wise to the OFF position. T urn gas supply OFF at the source. *The grill illustrated ma y hav e slight diff erences than the model purchased. Manual Lighting  D ANGER F ailure to open lid while igniting the barbecue’ s burners, or not waiting 5 m[...]

C-3 D-3 T r oubleshooting Pr oblem Check Cure Burners b urn with a yellow or orange flame, in conjunction with the smell of gas. Inspect W eber Spider/Insect screens f or possible obstructions. (Blockage of holes .) Clean Weber Spider/Insect screens (See Section “ Annual Maintenance ” ) Burner does not light, or flame is low in HIGH position. I[...]

E-1 Maintenance (1) (1) Main Burner Flame P attern The Weber ® gas barbecue burners have been f actor y set f or the correct air and gas mixture. The correct flame pattern is shown. 1) Bur ner tube 2) Tips occasionally flicker y ellow 3) Light blue 4) Dar k blue If the flames do not appear to be unif or m throughout the burner tube, f ollow the b [...]

E-2 Maintenance Replacing Main Burner s 1) Y our Weber ® gas barbecue m ust be OFF and cool. 2) T ur n gas OFF at source. 3) T o remov e control panel: take off the b ur ner control knobs. Remove the scre ws holding the control panel in place. Lift off the control panel. 4) Unhook the manifold brac ket(1) and unscre w the two wing nuts(2) that hol[...]