Weber SUMMIT 400 manual

NOTIC E T O INSTALLER : These instructions m ust be left with the owner and the owner should keep them for future us e . W ARNING : Follow all leak che c k procedures carefully in this manual prior to barbecue operation . Do this even if barbecue was dealer assembled. W ARNING : Do not try to light this appliance without reading "Lighting"[...]

2 D ANGER F a ilu re to f o l l o w the D ang e rs , W arn ing s and Ca uti on s c o nta in ed in thi s Own er ’ s M an u al m ay r esu l t in se rio us b od il y in ju ry or d ea t h, o r a f ir e or an e xpl o si on cau s in g d am a ge t o pr o p e rt y . W ARNINGS ■ Do not store a spare or disconnected LP t a n k under or near this barbecue[...]

3 T ABLE OF CONTENTS W arnings 2 W arranty 4 A W ord of Thanks 4 Standards and Codes Information 5 Storage 5 Operation 5 Natural Gas Supply T esting 5 *REFER TO YOUR STEP-BY-STEP SECTION AT THIS TIME Lighting 6 Crossover Ignition System 6 T o Extinguish 6 Manual Lighting 7 T o Extinguish 7 Cooking 8 Storage 8 Cleaning 8 Maintenance 9-13 Spider Stop[...]

4 A WORD OF THANKS W eber-Stephen Products Co. (Weber) hereby warrants to the ORIGINAL PURCHASER of this Weber Gas Barbecue that it will be free of defects in material and workmanship from the date of purchase as follows: Aluminum Castings, 25 years, Cooking Grates and Flavorizer Bars, 7 years, All Remaining Parts, 5 years, when assembled and opera[...]

5 Your Weber Gas Barbecue is a portable outdoor cooking appliance. With the Weber Gas Barbecue you can grill, barbecue, roast and bake with results that are difficult to duplicate with indoor kitchen appliances. The closed lid and Flavorizer Bars produce that "outdoor" flavor in the food. The Weber Gas Barbecue is portable so you can easi[...]

6 LIGHTING W ARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be dama ged in any wa y , do not use the barbecue. Contact your dealer. 1 ) Open the sliding work surfaces and splash guards. Figure 1. 2) Make sure all burner control knobs are OFF. (Push each burner control knob down and tur[...]

7 MANUAL LIGHTING EACH HEAT ZONE OPERATES INDEPENDENTL Y . 1) Open the sliding work surfaces and splash guards. Figure 2. 2) Make sure all burner control knobs are turned OFF . (Push each burner control knob down and turn clockwise.) 3) T urn on gas supply . 4) Select Heat Zone. 5) Put a match in the match holder and strike the match. 6) Push LEFT [...]

8 C AU T I O N : T urn yo ur W e ber Ga s Barb ecu e OFF an d wa it fo r it to c ool bef or e c l e a n i n g . C AU T I O N : Do not cl ean y our Fla v o r i z e r Bar s o r cook ing gr ates in a self -clea ning o v e n . R e p l a c e m e n t cooki ng grate s and Fl av o r i z er Bar s ar e av a i l a bl e t h r ough you r r et ail er or the W e [...]

9 Spider Stopper Guards Your Weber Gas Barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects. T h e y can nest in the venturi section of the burner tubes. T h i s blocks the normal gas flow, and can cause the gas to flow back out of the air shutter. Figure 4. This could result in a fire in and around the air shut[...]

10 MAINTENANCE Main Burner Cleaning Procedure T urn off the gas suppl y . Remove the manifold. Look inside each burner with a flashlight. Figure 7. Clean the inside of the burners with a wire (a straightened out coat hanger will work). Figure 8. Check and clean the air shutter opening at the ends of the burners. Check and clean the valve orifices a[...]

11 MAINTENANCE 10. Unlatch the Spider Stopper Guards and remove. Figure 11. Figure 11 Manifold 1 1. Pull the manifold out of the burners. Figure 12. Figure 12 9. Disconnect white and black wire from each igniter . Figure 10. Figure 10 Black wire White wire Summit 400 Summit 400 Manifold[...]

12 MAINTENANCE 12. Slide the burner assembly from each Heat Zone. The left and right burners are connected by the Crossover tube. Figure 13 (a). Figure 13 Crossover tube Pull out of here 13. Lift and twist the burner assembly slightly to separate the crossover tube from the burners. Remove the burners from the cooking box. Figure 14. Figure 14 Sepa[...]

13 MAINTENANCE Crossover Ignition System Operations If the Crossover Ignition System fails to ignite the Front burner, light the Front burner with a match. If the Front burner lights with a match, then check the Crossover Ignition System. ■ Check that both the white and black ignition wires are attached properly. Figure 17. ■ Check that the Cro[...]

14 TROUBLESHOOTING Problem Burners burn with a yellow or orange flame, in conjunction with the smell of gas. Burner does not light, or flame is low in HIGH position. Experiencing flare-ups: CAUTION: Do not line the bottom tray with aluminum foil. Burner flame pattern is erratic. Flame is low when burner is on HIGH. Flames do not run the whole lengt[...]

15[...]

16 EXPLODED VIEW FOR SUMMIT 400 NG[...]

17 1 Cooking grate 2 Flavorizer Bars (7) 3 Left work surface 4 Glides (4) 5 Phillips head 1/4-20 x 1 inch machine screws (4) 6 Cooking box (assembly) 7 Burner control knobs (4) 8 Igniter (2) 9 Igniter lock nut (2) 10 Igniter wire (black) (2) 11 Igniter wire (white) (2) 12 Gas catcher ignition chamber (2) 13 Manifold mounting clips (2) 14 Manifold a[...]

18 EXPLODED VIEW FOR SUMMIT 600 NG[...]

19 1 Cooking grates (3) 2 Flavorizer Bars (11) 3 Left work surface 4 Glides (4) 5 Phillips head 1/4-20 x 1 inch machine screws (4) 6 Cooking box (assembly) 7 Burner control knobs (6) 8 Igniter (3) 9 Igniter lock nut (3) 10 Igniter wire (black) (3) 11 Igniter wire (white) (3) 12 Gas catcher ignition chamber (3) 13 Manifold mounting clips (2) 14 Mani[...]

P A TENTS & TRADEMARKS © 1996 Weber-Stephen Products Co. Weber, the silhouette, Flavorizer and Crossover are registered U.S. trademarks; Summit, Grill Cozy, Gas Catcher, Spider Stopper, and Steam-N-Chips, are trademarks, all of Weber-Stephen Products Co., 200 East Daniels Road, Palatine, IL 60067-6266. U.S.A. Summit Series Gas Barbecues are co[...]