Weslo WLTL21130 manual

Model No. WL TL21 130 Serial No. Write the serial number in the space above for future reference. CAUTION Read all precautions and instruc- tions in this manual before using this equipment. Save this manual for future reference. USER'S MANUAL Serial Number Decal Visit our website at www .weslo.com new products, prizes, fitness tips, and much m[...]

2 T ABLE OF CONTENTS IMPORT ANT PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 BEFORE YOU BEGIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 ASSEMBL Y . . . . . . . . . .[...]

3 1. It is the responsibility of the owner to ensure that all users of this treadmill are adequately informed of all warnings and precautions. 2. Use the treadmill only as described. 3. Place the treadmill on a level surface, with at least eight feet of clearance behind it and two feet on each side. Do not place the treadmill on any surface that bl[...]

4 22. Never drop or insert any object into any opening. 23. DANGER: Always unplug the power cord immediately after use, before cleaning the treadmill, and before performing the maintenance and adjustment procedures described in this manual. Never remove the motor hood unless instructed to do so by an authorized service representative. Servicing oth[...]

5 BEFORE YOU BEGIN Handrails Console Latch Knob Key/Clip Circuit Breaker W alking Belt Foot Rails Incline Leg Incline Pin Power Cord FRONT RIGHT SIDE BACK Rear Roller Adjustment Bolts W ater Bottle Holder (No bottle is included) Upright Thank you for selecting the WESLO CADENCE ® CR12 treadmill. The CADENCE CR12 treadmill com- bines advanced techn[...]

6 ASSEMBL Y Assembly requires two persons. Set the treadmill in a cleared area and remove all packing materials. Do not dispose of the packing materials until assembly is completed. Note: The underside of the treadmill walking belt is coated with high-performance lubricant. During shipping, a small amount of lubricant may be transferred to the top [...]

7 3. With the help of a second person, tip the treadmill so the Base Pads (33) (see drawing 1) are lying flat on the floor . Raise the Uprights (14, 15) to the vertical position. Hold a Handrail Spacer (3) so the arrow between the two large holes is pointing upward. Thread the Wire Harness (53) through the upper large hole in the Handrail Spacer . [...]

8 6. Hold the Console (1 1) near the Console Base (87). T ouch the right Handrail (4) to discharge any static. Locate the two wires in the Wire Harness (53) that have L-shaped connectors on the ends. Press the connectors onto the two tabs on the switch shown in inset drawing 6a. Connect the other two wires in the Wire Harness (53) to the back of th[...]

9 9. Make sure that all parts used in assembly are properly tightened before you use the treadmill. Keep the included allen wrenches in a secure place for adjustment purposes (see page 16). T o protect the floor or carpet, place a mat under the treadmill. 8. Press the Latch Knob Sleeve (73) into the Left Upright (14). Remove the Latch Knob (54) fro[...]

10 OPERA TION AND ADJUSTMENT THE PERFORMANT LUBE TM W ALKING BEL T Y our treadmill features a walking belt coated with PERFORMANT LUBE TM , a high-performance lubricant. IMPORT ANT : Never apply silicone spray or other substances to the walking belt or the walking plat- form. Such substances will deteriorate the walking belt and cause excessive wea[...]

11 CAUTION: Before operating the console, read the following precautions. • Do not stand on the walking belt when turning on the power . • Always wear the clip (see the drawing below) while using the treadmill. When the key is removed from the console, the walking belt will stop. • Adjust the speed in small increments. • T o reduce the poss[...]

12 Follow the steps below to operate the console. Insert the key fully into the console. Inserting the key will not turn on the displays. The displays will turn on when the ON/RESET button is pressed or when the walking belt is started. Note: If you just installed batteries, the displays will already be on. Reset the speed control and start the wal[...]

13 HOW T O FOLD AND MOVE THE TREADMILL HOW TO FOLD THE TREADMILL FOR STORAGE Before folding the treadmill, unplug the power cord. CAUTION: Y ou must be able to safely lift 45 pounds (20 kg) in order to raise, lower or move the treadmill. 1. Hold the treadmill with your hands in the locations shown at the right. CAUTION: T o decrease the possibility[...]

HOW TO LOWER THE TREADMILL FOR USE 1. Hold the upper end of the treadmill with your right hand as shown. Using your left hand, pull the latch knob to the left and hold it. Pivot the treadmill down until the frame is past the latch pin. Slowly release the latch knob. 2. Hold the treadmill firmly with both hands, and lower the treadmill to the floor [...]

15 MAINTENANCE AND TROUBLESHOOTING Most treadmill problems can be solved by following the steps below . Find the symptom that applies, and follow the steps listed. If further assistance is needed, please call our Customer Service Department toll- free at 1-800-999-3756, Monday through Friday , 6 a.m. until 6 p.m. Mountain Time (excluding holidays).[...]

16 PROBLEM: The walking belt slows when walked on SOLUTION: a. Use only a single-outlet surge suppressor that meets all of the specifications described on page 10. b. If the walking belt is overtightened, treadmill perfor- mance may decrease and the walking belt may become damaged. Remove the key and UNPLUG THE POWER CORD . Using the allen wrench, [...]

17 CONDITIONING GUIDELINES The following guidelines will help you to plan your exercise program. For more detailed exercise informa- tion, obtain a reputable book or consult your physician. EXERCISE INTENSITY Whether your goal is to burn fat or to strengthen your cardiovascular system, the key to achieving the desired results is to exercise with th[...]

18 T raining Zone Exercise After warming up, increase the intensity of your exer- cise until your pulse is in your training zone for 20 to 60 minutes. (During the first few weeks of your exer- cise program, do not keep your pulse in your training zone for longer than 20 minutes.) Breathe regularly and deeply as you exercise—never hold your breath[...]

19 NOTES[...]

P ART LIST—Model No. WL TL21 130 R0903A 1 8 3” Bolt 2 2 Upright Lock Bracket 3 2 Handrail Spacer 4 2 Handrail 5 16 3/4” Screw 6 1 Key/Clip 7 1 Frame Guide 8 2 Incline Leg 9 2 1 1/4” T ek Screw 10 8 U-Nut 1 1 1 Console 12 1 Battery Cover 13 1 Reed Switch 14 1 Left Upright 15 1 Right Upright 16 4 Guide Screw/T ie Screw 17 8 Belly Pan Screw 18[...]

28 30 45 28 28 94 53 6 63 75 70 51 51 40 52 19 76 69 68 70 67 50 60 95 81 79 78 40 76 77 83 37 27 43 43 84 76 35 38 49 53 76 28 29 28 28 28 5 87 12 5 11 64 64 82 7 16 41 42 22 18 22 23* 26 25 24 19 20 21 48 17 17 17 33 17 33 34 17 9 9 17 89 74 13 19 37 57 76 72 65 8 72 65 8 78 40 60 46 47 51 51 71 32 32 41 42 22 44 44 49 57 19 5 4 3 3 1 4 5 5 66 59[...]

Part No. 201656 R0903A Printed in USA © 2003 ICON Health & Fitness, Inc. ORDERING REPLACEMENT P ARTS T o order replacement parts, call our Customer Service Department toll-free at 1-800-999-3756, Monday through Friday , 6 a.m. until 6 p.m. Mountain T ime (excluding holidays). When ordering parts, please be prepared to give the following inform[...]