Woods Equipment 1013460 manual

I NST AL LA TION MAN U AL SA VE THIS MANU AL! Include it with the backhoe manual. It contains safety , operation, and repair part information not found in other manuals. 1013460 4-POINT SU B-FR AME MOUN TING KIT for Backhoe Models BH70-X, BH80-X, BH6 500, BH75 00 on New Holland ® Tr a c t o r s T2220, TC29DA, TC33DA, TC34DA FW A or Case IH ® Tr a[...]

2 Introduction SFMK (Re v . 2/20/2008) T O THE DEALER : Assemb ly and prop er installati on of this pro duct is the r esponsi bility of the Woods ® dealer. R ead manua l instr uctions and safet y rules . Make sure all item s on the Dea ler ’s Pre- Delivery and Deliv ery Che ck Lists in the O perator ’s Manual are com pleted befo re rele asin g[...]

Safety 3 4-Point SFMK (Rev . 5/8/2006) SAFETY RULES ATTENTION! BECOME ALER T! Y OUR SA FETY IS INV OLVED!  This Sub-Frame Mounting Kit is only fo r the backhoes and tractors specified in the Su b-Frame Mount Installation secti on of this manua l. Any other use or modific ation of this moun ting k it may result in se rious injury or deat h.  H[...]

4 Safety 4-Po int S FMK ( Rev . 5/ 8/20 06) SAFETY RULES ATTENTION! BECOME ALER T! YOUR SAFETY IS IN V OLV ED! (Safety R ules co ntinued from previous page)  Make su re al l hydraulic hoses , fittin gs, and valves are in good condition and not leaking before st arting power unit or using equipment. Check and route hoses car ef ully to pr event d[...]

Inst allation 5 MAN040 6 (Rev . 9/7/2007) BACKHOE SUB-FRAME INST ALLA TION T ractor Prep aration ■ Only us e 1013 460 4-P oint Sub -Fram e Mount- ing Kit for moun ting Woods BH70-X, BH80-X, BH6500, BH750 0 backho e on New Holl and ® T2220, TC29 DA, TC33DA, T C34DA tracto rs or Case IH ® DX34, Fa rmall ® 31 , Farmall 35 tractors equipped with W[...]

6 Installation MAN040 6 (Rev .9/7/2007) Inst all Front Mount s With W oods LS84 Loader Mount Attach front m ount (32) to the rig ht loade r mount using two cap scr ews (26 ), hardened flat was hers (23) an d hex nuts ( 27). 23. 57817 5/8 Harde ned fla t washer 26. 902 5/8 NC x 2 HHCS GR5 27. 230 5/8 NC Hex nut 32. 1026846 Front moun t (LS 84 only) [...]

Inst allation 7 MAN040 6 (Rev . 9/7/2007) Inst all T ractor Bracket s With W oods LS84 Loader Mount 1. P lace left tractor bracket (2) under left side of tractor . Use a hydrau lic fl oor jack to help rais e and hold tractor bracket i n positi on. 2. A ttach left tractor bracket (2 ) to left loader mount using two cap s crews (26) , hardened flat w[...]

8 Installation MAN040 6 (Rev .9/7/2007) Inst all T ractor Brac kets 1. Place le ft tractor brac ket (2 ) under le ft side of tractor . Use a hy draulic floor jack to help rais e and hold t ractor bracke t in posi tion. 2. Attach left tra ctor br acket to left fron t mount (8) using two ca p screws (26), harden ed flat washer s (23), and h ex nut (2[...]

Inst allation 9 MAN040 6 (Rev . 9/7/2007) Inst all Cross Brace 1. Remove PT O shield . 2. Attach cr oss br ace (7 ) to re ar of tr actor using tw o cap scre ws (2 4) and har dened fl at wash ers (23 ). 3. Attach to right and left tractor b rackets us ing four (two per s ide) c ap screw s (18) , harden ed fla t washers ( 22), and hex nuts (15). 4. I[...]

10 Installation MAN040 6 (Rev .9/7/2007) T orque Mounting Hardware Att ach Backhoe M ounts to Backho e NOTE: Lea ve a ll har dware l oose until back hoe has been mount ed to the tractor . 1. Attach right backh oe moun t (3) and le ft backhoe mount (4) to back hoe fram e. 2. Secu re into posi tion usin g six (thr ee per brack et) cap sc rews ( 25), [...]

Inst allation 11 MAN040 6 (Rev . 9/7/2007) HYDRAULIC INST ALLATION  Keep hands and body away from pres surized lines. Use p aper or cardboard, not hands or other body p arts to check for leaks. W ear safety gog- gles. Hydrauli c f luid under pressu re can easily penetrate skin and will cause ser ious injury or death.  Make sure that all opera[...]

12 Installation MAN040 6 (Rev .9/7/2007) Inst all Hydraulic Block and Fittings 1. Locate the hydrau lic m anifold b lock on the righ t side of the tractor just u nder the fende r (Figu re 19) and rem ove th e block -off cap. 2. Attach hydr aulic bl ock (18) to tr actor u sing new o- rings (1 4), thr ee cap sc rews ( 8) and one cap screw (9) p lu s [...]

Inst allation 13 MAN040 6 (Rev . 9/7/2007) Inst all Bulkhead Adapter on Backhoe Mount 1. Attach bul khead a dapter (1 ) to crossm ember between backhoe bracke ts. Secure with nu t sup- plied wit h adapte r . 2. Atta ch elbo w (10) and fem ale qui ck coup ler (1 6) to bulkhe ad adapter as sho wn in Figur e 23. 3. Positi on elbow and quic k couple r [...]

14 Installation MAN040 6 (Rev .9/7/2007) Mount Backhoe to T ractor  This mounting kit is designed to provide secure moun ting and adequ ate operator c lear- ance for mo st operators when p roperly inst alled. Check clearance dimensions shown below to be sure you have installed seat bracket corr ectly . In some cases it may be nec essary to ad ju[...]

Inst allation 15 MAN040 6 (Rev . 9/7/2007) Mount Backhoe to T r actor ( Continued) Refer to Figure 26. 5. Using th e back hoe h ydraul ics posit ion th e back - hoe brac kets at a sl ight a ngle, appr oximate ly 5 t o 10 degrees. 6. Raise bac khoe up by l owering stabili zers an d boom secti on until backhoe mou nting pins on backhoe brackets are s[...]

16 Installation MAN040 6 (Rev .9/7/2007) Remove Backhoe from T ractor  The only time the bac khoe may be operated from a position other than the operator seat is during backhoe a tt achme nt and remova l. Opera- tor must: • Read Mounting Kit Manual instructions on att aching and removing backhoe and use extreme c are. • Always stand betwee n[...]

Inst allation 17 MAN040 6 (Rev . 9/7/2007) STORAG E Connect Hydraulic Hoses TRACTOR: Conn ect male quic k co upler on end o f hose to femal e quic k coupler at bulkhea d bracke t when back hoe is remov ed from tra ctor . See F igure 28. NOTICE ■ Failure to connect hoses together will result in damage t o tractor hydraulic sy stem. BACKHOE: Connec[...]

18 Part s MAN040 6 (Rev . 9/7/20 07) 1013460 4-POINT SUB-FRAME MOU NTING KIT W ARNING PINCH POINT Keep hands clear . 1006885 31 - PN 1 006885 MODEL NO. SE R IAL NO. W oods Equipment Company Oregon, Illinois, U.S.A. Seria l Numb er Plate R E F P ART QTY DESCRIPTION 1 1013462 1 Right tractor brac ket 2 1013463 1 Left trac tor bracke t 3 1013464 1 Rig[...]

Part s 19 MAN0406 (Rev . 9/7/2007) 1013484 HOSE KIT R E F P ART QTY DESCRIPTION 1 1006144 1 Adapt er , bulkhe ad 3/8 N PTM x 3/4 JICM 2 1009493 1 Hose, 40" x 3/8 NPTM x 9/16 JICF 3 1009495 1 Adapt er , bulkhe ad 3/8 N PTM x 9/ 16 J ICM 4 1010924 1 Hose, 40" x 3/8 NPTM x 3/4 O RBM 5 1013479 1 Hose, 10" x 3/4 JIC F x 3/4 ORBM 6 10135 2[...]

20 Appendix Bolt T orque & Size Chart s (Rev . 3/28/2007) BOLT T O RQUE CHART Always tighten har dware to these v alue s unles s a different torque value or tighte ning p rocedure i s list ed for a specifi c applica tion . F ast eners must al wa ys be repla ced wi th the sam e grade as sp ecified in the m anual par ts list. Always use the prope[...]

Appendix 21 Bolt T orque & Siz e Chart s (Rev . 3/28/2007 ) BOLT SIZE CHART NOTE: Chart s hows b olt thr ead siz es an d corres pondin g head (w rench ) size s for standard SA E and metric bolts. ABBREVIATIONS AG ........ ............. ....... .......... ............. ...... ..... Agricu lture ASABE ............ ........ American Society of Agr[...]

F-8494 (Rev . 6/23/2005) W ARRANTY (Replacement Parts F or All Models Except Mow’ n Machine TM Zero-T urn Mowers and W oods Boundary TM Utility V ehicles ) W oods Equipm ent Compan y (“WOODS”) w arrants this prod uct to be free from defect in mate rial and workmansh ip for a period of nin ety (90) days from the date of deli very of the prod u[...]

F-3079 (Rev . 4/4/2008) W ARR ANTY (All Models Except Mow’ n Machine TM Zero-T urn Mo wers and W oods Boundar y TM Utility V ehicles) Ple ase En ter In fo rmat ion Be low an d Save for Fu ture Ref eren ce. Date P urch ased: ___ _____ _____ _______ _____ ___ From (Dea ler): ______ _______ _____ _____ _______ _____ _____ ___ Model Number : ___ ____[...]

P ART NO. MAN0406 © 2005 Woods Equipment Company . All rights reserved. WOODS, t he Woods logo, and "T ested. Proven. Unbeatable." are trademarks of Woods Equipment Company . All other trademarks, t rade names, or service m arks not own ed by W oods Equipment Company that appear in this ma nual are the property of t heir respective compa[...]