Zanussi ZCK98307XA manual

EN User & Installation Manual Cooker ZCK18307XA ZCK98307XA[...]

2 www .zanussi.com Contents Safety information Y ou have purchased one of our products for which we thank you. W e are confident that this new appliance, modern, functional and practical, made with top quality materials, will meet all your demands. This new appliance is easy to use but before installing and using it, it is important to read this h[...]

3 www .zanussi.com • Do not use the appliance bare footed. • Do not pull the power lead to take the plug out of the socket. • Do not leave the appliance outside under the sun, rain, etc. • Y oung children should be supervised to ensure that they not play with the appliance. • This appliance can be used by c hildren aged from 8 years and a[...]

4 www .zanussi.com out with maximum care and the proper attention of an authorised person. • For this reason we recommend you call our Service Centre. Warning! Be careful when you cut the plastic strip to avoid damaging the cable The installation must be carried out by a suitably qualified person, in accordance with the current version of the fo[...]

5 www .zanussi.com Right oven commutator/thermostat knob (fig.4) By rotating the knob in an anticlockwise direction, the following functions appear: = Closed position = Oven light on, which stays on for all function from 50 to Max = Oven temperatures = Grill heating element on fig. 4 Left oven -Multifunction selector knob (fig.5) By turning the [...]

6 www .zanussi.com the corresponding push button. N.B.: At the end of each setting session (except for the minute counter) the programmer turns the oven off. Check when next using the oven, if the programmer is not going to be used, that the latter is set on manual operation (see the instructions given further on). Setting the time (from 0.0 1 to 2[...]

7 www .zanussi.com Hob: general notes on safety When a gas cooker is being used it produces heat and humidity in the room where it is installed. For this reason the room must be well ventilated, keeping the natural ventilation openings free and switching on the mec hanical aeration system (suction hood or electric fan, see the “V entilation” an[...]

8 www .zanussi.com T urn the selector knob to the symbol and place the food you want to defrost inside the oven. The length of time required depends on the quantity and type of food. Selecting this function will only activate the fan. Mild air circulation around frozen food will slowly defrost it. It is particularly suitable for fruit and cakes. T [...]

9 www .zanussi.com heating elements are turned on, distributing heat to the food from the top and bottom. This type of baking is ideal for all types of food (meat, fish, bread, pizza, cakes..). Grill cooking T urn the commut ator/thermostat knob on the symbol. The top heating element is turned on and it distributes heat directly onto the food. Bes[...]

10 www .zanussi.com water during cooking to compensate for evaporation. • T urn the food half way through cooking. • If you are grilling fatty poultry (goose) pierce the skin so the fat can drip away . The aluminium can be easily corroded if it comes into contact with organic acids present in the foods or added during baking (vinegar , lemon ju[...]

11 www .zanussi.com Cooking/baking timetable Left oven cavity FOOD S W eight kg Position of the oven shelf from the bottom Cooking by Natural Convection Cooking by Forced Convection (with fan) T emperature in °C Cooking Time in minutes T emperature in °C Cooking Time in minutes M EA T L OAFS Roasted V eal Roastbeef Roasted Pork Roasted Lamb 1 1 1[...]

12 www .zanussi.com Cleaning and maintenance T o keep the surface of the hob and the various components in pristine condition (grill, enamelled covers, burner heads and flame diffusers, it is very important to wash them in warm soapy water , rinse and dry them well after each use. Do not leave vinegar , coffee, milk, salty water or the juice of le[...]

13 www .zanussi.com personnel. Just open the oven door and remove the support securing the glass (fig.4). Caution: T his operation can be done also with the door fitted on appliance, but in this way , pay attention that when the glass is pulled upwards, the force of the hinges can close the door roughly . LOCK A T LEAST ON E H I N G E (fig.6) T [...]

14 www .zanussi.com Fig.8 Oven seal The oven seal guarantees the correct functioning of the oven. W e recommend you: • clean it, avoiding abrasive tools or products. • chec k its state now and then. If the oven door seal has become hard or is damaged, contact our Service Centre and avoid using the oven until it has been repaired. Fig.9 Oven sid[...]

15 www .zanussi.com Some problems can be caused either as the results of simple maintenance operations or by incorrect selection of settings. Prior to contacting a Service Centre please check the following chart. Problem Remedy The appliance is not working • Make sure the gas tap is open • Check the plug is in • Check that the knobs are set c[...]

16 www .zanussi.com Particular attention must be paid to the instructions given below for ventilation and aeration. Installation Unpacking your cook er • Once the wrapping has been removed from the outer surfaces and the various inner parts, thoroughly chec k that the appliance is in perfect condition. If you have any doubts do not use the applia[...]

17 www .zanussi.com event of children standing on the oven door or where users put extreme weight on the door when in open position, two chains M UST B E fixed to the back of the oven which should at all times be secured to the threaded pins . The threaded pins should be secured to the wall at the back of the cooker. Assembly instructions (fig.6)[...]

18 www .zanussi.com B.S.P.) female threaded located just below the hotplate level on the rear right-hand side of the cooker. Any gas installation must be carried out by a competent person (GAS SAFE R EG I STE R engineer) to the relevant Gas Standards. The manufacturer will not accept liability , should the above instructions or any of the other saf[...]

19 www .zanussi.com • Install a multipolar switch that can withstand the appliance load, with a minimum opening between the contacts of 3 mm. Remember that the earth wire must not be cut out by the switch. Connecting the power cable The all-electric cookers and some combi versions are without supply cable and are adjusted for single-phase power, [...]

20 www .zanussi.com Gas information T o tighten some components apply the following torque forces: Aluminium pipes to burners, valves, thermostats: 1 5 Nm Thermocouples to top burners cups: 3 Nm Thermocouples to thermostats: 4 Nm Push-on connector: 20 Nm Injectors: 4 Nm Fig. 10 Conversions Replacing the injectors Our burners can be adapted to diffe[...]

21 www .zanussi.com Fig. 13 Changing the flexible gas hose In order to guarantee that the gas hose is always in excellent condition we strongly recommend changing it on the date you will find printed on it. Replacing the electrical components • The rear protection will have to be removed in order to change the electrical heating elements, spit [...]

22 www .zanussi.com T echnical information Outside cooker dimensions MO DEL height 1 /mm height 2 /mm width 3 /mm depth 4 /mm 1 00 x 60 91 0 ÷ 920 970 ÷ 9 8 0 1 000 600 90 x 6 0 885 ÷ 920 945 ÷ 9 80 900 600  Burner disposition and hob burner technical data table Burners Operating pressure gas Rate Diameter injector Sabaf Heat input By-pass N[...]

23 www .zanussi.com Electric components description Nominal data Fan of the rear heating element 25..29 W Oven lamp 2 x 15 W - E 14 - T 300 Power cable H05 R R-F 3 x 1.5 mm 2 Cooling fan motor 12 W Left cavity : T op heating element 1800+8 00 W Lower heating element 1400 W Rear circular heating element 2000 W Right cavity : T op heating element 4 7[...]

461308307_000 12 /2013 www .zanussi.com/shop[...]