Bakers Pride BCO-E инструкция обслуживания

! ! W ARNING: Improper installation, adjustment, alterati on, service or maintenance can cause prop erty dama ge, injury or death. Read the Installation, Operating and Maintenance Instructions thorough ly before installing or servicing this equipment. ! ! FOR YOUR SAFETY : Do not store or use gasoline or other flammable vapors and liquids in the vi[...]

I. INST ALLA TION INSTRUCTIONS SECTION ITEM P AGE A Receiving 2 B Set-up/Mounting 2 C Installation with Casters 3 D Location & Minimum Clearances 3 E Electrical Connections 4 F Flue Connection V entilation 4 G Initial Cleaning 4 H System Check - Rotary Controls 5 II. OPERA TING INSTRUCTIONS SECTION ITEM P AGE A General Instructions 5 B Operatio[...]

3 (2) Using proper lifting equipment, lift up the left-hand side and attach two 31” legs on the left-hand side the same way . For a stack of two ovens: Refer to Figure 3 (1) Remove flue from top oven and replace with flue-adaptor supplied in the stacking kit. (2) T ilt lower unit over to the left side and position two 6" legs on the right si[...]

4 E. ELECTRICAL CONNECTION: Install according to the spacing requirements listed in the installation section of this manual. W e strongly recommend having a competent professional install this equipment. A licensed electrician should make the electrical connections and connect power to the unit. Local codes should always be used when connecting the[...]

5 H. SYSTEM CHECK- ROT ARY CONTROL (standard): (1) Open the oven door . (2) T urn Selector Switch to “HI.” The green indicator light near Selector Switch and oven light will illuminate. (3) Close the door . Oven lights will go off and fan will run. Make sure fan is rotating clockwise looking from front. (4) Press Oven Light switch. Oven light w[...]

6 Timed cooking rotary control: (1) Close the oven doors. (2) Turn Selector Switch to “HI” or “LO” position. The indicator light near the Selector Switch will be illuminated. (3) Turn the thermostat knob to the desired cooking temperature. (4) Upon reaching the set temperature, the indicator light near the thermostat will go out. (5) Load t[...]

7 OVEN INTERIOR: Clean The Racks And Rack Support Guides: Open the doors and remove all wire racks and rack support guides. T ake them to the sink and thoroughly clean in warm water with mild detergent or soap. Use a nylon scouring pad or stiff nylon brush. DO NOT USE STEEL WOOL. Clean The Stainless Steel Interior: Baked on splatter , oil, grease o[...]

8 D. SERVICING: NOTE: THIS APPLIANCE MUST BE SERVICED BY AN AUTHORIZED SERVICE AGENT . (1) Power supply to the unit must be disconnected before any service is performed. (2) Most of the service on the unit can be performed from the front and/or control panel side. (3) For proper servicing, access to the control panel side of the unit will be requir[...]

9 Figure 3 Item 1 Item 2 Item 3 E3770A E3771A 3/8”-16 Bolt ST ACKING INSTRUCTIONS FOR: BCO-E & GDCO-E CONVECTION OVENS Remove flue from top oven and replace with item 1 2 1 3 Attach part # 21818062 with 6 each 8-32 stainless screws Material: 14 ga 201 Stainless Remove flue from bottom oven, and re-install after top oven is in place. 1. Attach[...]

10 HELPFUL HINTS PROBLEM CAUSE SOLUTION Food browns unevenly Improper heating temperature. Preheat until desired temperature is reached. Several pans crowded together . Baking pans too large. Use smaller pan. Baking pan dark or glass. Lower oven temperature 25°F (-3.8°C) for this type of pan. Oven temperature too high Lower oven temperature Oven [...]

Wiring Diagram - BCO-E & GDCO-E 208V/240V , 1 Phase (Dial Control) Wiring Diagram - BCO-E & GDCO-E 208V/240V , 3 Phase (Dial Control) E. 1 1 P/N 8806655 P/N 8806650 BL UE PU RP L E W H IT E BL AC K R E D TI ME R M OT O R B U Z ZE R C O IL C O M M ON T IM E R BU ZZ ER 19 49 48 47 46 45 3 6 23 FUSE BOX AMBE R PILO T LIGHT GR EEN P OWER LIGH [...]

Wiring Diagram - GDCO-E 208V/240V , 3 Phase (Push-Button Control) Wiring Diagram - GDCO-E 208V/240V , 1 Phase (Push-Button Control) 12 P/N 8806661 P/N 8806662 R ED BL AC K WH ITE PU RPL E B LU E D DE TAIL D WIRE 24 WIRE 22 WIRE 48 WIRE 1 9 WIRE 21 43 48 48 45 46 45 7 6 10 30 31 47 44 3 2 1 4 5 11 42 41 39 38 49 4 POLES , 40 AMPS CONTAC TOR 37 36 34[...]

13 NOTES: Wiring Diagram - BCO-E & GDCO-E 230V/400V , 3 Phase, 4 Wire (Dial Control) - EXPORT P/N 8806656 R ED B L AC K W H IT E P U R P LE B L UE TI M ER M O TO R B U Z Z ER C O IL C O M M ON T IM E R/ BU ZZ E R L1 19 49 48 4 7 46 45 3 6 23 FUSE BOX AMBE R PILOT LIGHT GRE EN POWER LIGHT 2 SP EED 1725/ 850 4 POLE S, 40 AMPS CON TACTOR MO T 2 9 [...]

14 NOTES:[...]

WHA T IS COVERED This war ranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: ♦ The equipment has not been accidentally or intentionally damaged, altered or misused; ♦ The equipment is pr operly installed, adjusted, operated and maintained in accor dance with National and[...]

BAKERS BAKERS PRIDE PRIDE BAKERS PRIDE OVEN CO., INC . 30 Pine Street New Rochelle, NY 10801 (914) 576-0200 Phone (800) 431-2745 US & Canada (914) 576-0605 Fax www .bakerspride.com Web Address 16[...]