Cal Flame BBQ08953P инструкция обслуживания

[...]

Copyright 2009-2010 LMS, Inc. All rights re- served. Duplication without writ ten consent is strictly prohibited. Cal Flame ® is a registered trademark. Due to continuous improvement programs, all models, operation, and/or specications are subject to change without prior notice. L TR50001082, R ev . B 5/26/11 250-407 Installation / Assembly Cab[...]

Safety Instructions 1 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Safety Instructions WARNING: Improper installation, adjustment, alter a- tion, service or maintenance can cause injury or property damage. R ead the installation, operating and maintenance instructions thoroughly before installing or servicing this equi[...]

2 Safety Instructions Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Operation Do not use side burner for oth • er than intended use. In the event that a burner goes out, turn burner knobs to the • full OFF position and let it air out. Do not attempt to use the side burner until the gas has had time to dissipate. K e[...]

Safety Instructions 3 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m garments while using your side burner . F abric may ignite and result in personal injury . Only use dry pot holders and do not use a towel or other bulky • cloth in place of pot holders. Moist or damp pot holders used on hot surfaces can cause burns. [...]

4 Installation / Assembl y Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Installation / Assembly Most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities ha ve codes requiring residential barriers such as fencing and/or self-closing gates on prop- erty to [...]

Installation / Assembl y 5 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m WIDTH DEPTH The dra wing at right shows the different types of cabinet cut-out dimensions f or drop-in side burn- ers. Gas Requirements and Connection Gas Requirements and Connection IMPOR T ANT : The Cal Flame side burner is manufactured to operat[...]

6 Installation / Assembl y Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Leak Testing Procedure Perf orm a leak test at least once a year whether the gas supply cyl- inder has been disconnected or not. In addition, whenever the gas cylinder is connected to the side burner or whenever any part of the gas system is discon[...]

Installation / Assembl y 7 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m LP Gas Tank Requirements For plumbed-in LP installation, use a convertible regulator and set it for LP gas. Maximum line pressure for plumbed-in propane is 14” WC (3.5 kPa). Minimum line pressure for pr opane is 11” WC. The side burner unit mus[...]

8 Installation / Assembl y Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Place the dust cap on the cylinder valve outlet whenever the cylinder is not in use. Only install the t ype of dust cap on the cylinder v alve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of pr[...]

Installation / Assembl y 9 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Natural Gas Requirements The installation of this appliance must conform with local codes or , in the absence of local codes, to the national fuel gas code, ANSI Z223.1a-1998. Installation in Canada must be in accordance with the standard CAN/CGA -[...]

10 Installation / Assembl y Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Installing Side Burner with a Grill If you are installing a side burner in conjunction with a gas grill, install it in the following manner . Assemble a 3/8” pipe nipple to the 3/8” pipe tee using T eon tape 1. or pipe sealant. Use only sea[...]

Installation / Assembl y 11 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m C B A B C A Connect the last open line to the side burner (Use gas rated tape seal on all connections) Then take other end of "T" adapter with hose attached and connect to end of male located underneath and at the back of the grill. (Use[...]

12 Using Y our Side Burner Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Using Your Side Burner Read all instructions before you operate your side burner. W e recommend you wash your side burner with soap and water prior to lighting it for the rst time. Oils are used during the manufacturing process and some residual[...]

Using Y our Side Burner 13 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m If connected to a propane cylinder, carefully inspect • the rubber hose attached to the regulator before each use. Ensure the propane cylinder, regulator, and rubber • hose are installed in a location not subject to heating above 125º F [...]

14 Using Y our Side Burner Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Manually Lighting the Side Burners WARNING: Do not use standard matches or cigarette lighters to per- form match lighting procedures. Serious burns can occur and lighters can explode. Open the hood. 1. If you have just attempted to light the burner[...]

Cleaning and Maintenance 15 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Cleaning and Maintenance T o ensure safe and proper maintenance, we recommend you follow these directions carefully . Clean the side burner regularly as determined by the amount of use and foods cooked. In addition, keep the area around your side [...]

16 Cleaning and Maintenance Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Cleaning Products and Materials Avoid using these common cleaning products and materials – they will damage the surface of your stainless steel. CLR • Lime-A way • Oven cleaner • Cleansers such as Ajax or Comet • Ammonia • Bleach • C[...]

Cleaning and Maintenance 17 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Clean 1. Thoroughly clean stains, food, and grime using a sponge or damp cloth with warm water and a mild dish soap. Use Fantastik or F or- mula 409 to remove hea vier soil. Rinse 2. Thoroughly rinse all surfaces and dry them completely with a cle[...]

18 Cleaning and Maintenance Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Rust Removal It is a common misconception that stainless steel does not rust. It does not stain, corrode, or rust as easily as ordinary steel (it stains less ), but it is not stain-proof . If not properly protected and maintained, it can corrode, [...]

Appendix 19 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Troubleshooting Problem: Smell of gas is present Solution: Check for loose connections in the gas line. Perf orm a leak test f ollowing the procedure described in this man- ual. Problem: Burner does not ignite Solution: Check the position of the sparker tip. It s[...]

20 Appendix Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Problem: Pluggedorice Solution: Unplug the orice as follows: Remov e burner rack and brass burner . • Using a 7mm socket or socket wrench, remove the • brass orice. Gently clear any obstruction with a ne wire. • Reinstall the orice and rep[...]

Appendix 21 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m WARNING! You must have an authorized service technician perform this procedure. If these instructions are not followed exactly, a re or explosion may result causing property dam - age, personal injury or loss of life. Lloyd’s Mater[...]

22 Appendix Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Replacement Covers Side Burner Model Cover Part Number Cover Size BBQ08852P Standard Single Flat Side Burner CVRSBR050-G 11” x 17 ¼” x 5 ½” BBQ08953P Standard Side By Side Burner CVRSBR052-G 24 ¼” x 19 ½” x 6 ¼” BBQ08899P Deluxe Double Side Burne[...]

Appendix 23 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Limited Warranty All Cal Flame models are manufactured with the highest quality ap- pliances and are warr anted to be free from defects in material and workmanship at time of delivery . LMS warrants side burners and associated hardwar e from deteriora- tion, corr[...]

24 Appendix Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m This warranty is void if the side burner has been subject to negligence, alteration, misuse, repairs, dings, dents, scr atches, or incorrect and / or prohibited applications, as specied in the owner’s manual. Gas lines must be installed by a licensed plumber[...]

Appendix 25 Cal Flame Side Burners L TR50001082, Rev . B w w w . c a l s p a s . c o m Legal Remedies This limited warrant y gives you specic legal rights. Y ou may have other rights, which may v ary from state to state. Customer Service For customer service, contact the authorized sel ling dealer immedi- ately . If you need additional informati[...]

L TR50001082, Rev . B 5/26/11 CONTACT INFORMATION For customer service, please contact y our authorized dealer immediately . If you need additional information and/or assistance, please contact: Customer Service Department 1462 East Ninth Street Pomona, CA 91766 T oll Free: 1-800-CAL -SPA S F ax: 1-909-629-3890 www.calamebbq.com[...]