Char-Broil 7101366 инструкция обслуживания

FOR OUTDOOR USE ONL Y If you have questions or need assistance during assembly , please call . T o insure your satisfaction and for follow-up service, register your Oil-less Turkey Fryer online at www.grillregistration.com 1-800-241-7548 CA UTION: Read and follow all safety statements, assembly instructions, and use and care directions before attem[...]

2 • 07101366 Installation Safety Precautions • Use Oil-Less T urkey Fryer , as purchased, only with LP (propane) gas and the regulator/valve assembly supplied. • Oil-Less T urkey Fryer installation must conform with local codes, or in their absence of local codes, with either the National Fuel Gas Code, ANSI Z223.1/ 4, Natural Gas and Propane[...]

T ABLE OF CONTENTS F o r Y o u r S a f e t y ......................................2 G r i l l S e r v i c e C e n t e r ...................................2 Installation Safety Precautions . . . . . . . . . . . . . . . . . . . . . . . . . . 2 S a f e t y S y m b o l s ......................................2 U s e a n d C a r e ....................[...]

• NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full. • An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property damage, serious injury or death. • If you s[...]

WARNING If “growing” bubbles appear do not use or move the LP cylinder . Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto . (Refer to assembly section.) 2. T urn all control knobs to the OFF position. 3. T urn LP cylinder OFF by turning hand-wheel clockwise [...]

6. T urn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. NOTE: If you cannot complete the connection, discon[...]

24” . 3 ft 3 ft. WARNING 07101366 • 7 CA UTION • Putting out grease fires by closing the lid is not possible. This a ppliance is well ventilated for safety reasons. • Do not use water on a grease fire. Personal injury may result. If a grease fire develops, turn knobs and LP cylinder off. • Do not leave appliance unattended while burning o[...]

8 • 07101366 CA UTION If ignition does NOT occur in 5 seconds, turn the control knob OFF, wait 5 minutes and repeat the lighting procedure. If the burner does not ignite with the valve open, gas will continue to flow out of the burner and could accidently ignite with risk of injury. Turn control knob and LP cylinder OFF when not in use. WARNING I[...]

Cleaning the Burner Assembly (Continued) 7. Clean inner burner as recommended below , shown E . We suggest three ways to clean the burner tube. Use the one easiest for you. (A) Bend a stiff wire (a light weight coat hanger works well) into a small hook. Run hook through burner tube several times. (B) Use a narrow bottle brush with a flexible handle[...]

10 • 07101366 Food Safety Food safety is a very important part of enjoying the outdoor cooking experience. T o keep food safe from harmful bacteria, follow these four basic steps: Clean: W ash hands, utensils, and surfaces with hot soapy water before and after handling raw meat and poultry . Separate: Separate raw meats and poultry from ready-to-[...]

P ARTS DIAGRAM – Model No. 07101366 Key Qty Description Part # A 1 O u t e r B o d y ......................5 5 7 1 0 1 8 4 B 1 I n n e r B o d y ......................5 5 7 1 0 1 8 5 C 1 Body T op Ring . . . . . . . . . . . . . . . . . . . 55710186 D 1 B u r n e r ..........................5 5 7 1 0 1 8 7 E 1 H e a t S h i e l d .................[...]

ASSEMBL Y – Model No. 07101366 2 1 • Attach grease tray rails to body with #10-24x3/8" screws and #10-24 keps nuts. Qty: 8 #10-24x1/2" Screw Qty: 4 #10-24 Keps Nut Qty: 4 #10-24x3/8" Screw Grease Tray Rail Leg Assembly with Rating Label • Remove lid, roaster basket and cooking pot. • T urn fryer upside down. • Attach legs t[...]

07101378 • 13 3 Qty: 3 #10x3/8" Self-Tap Screw Ignitor Qty: 2 #6-32x3/8" Threaded Screw Qty: 2 #8x1/2" Self-Tap Screw #8x1/2" Self-Tap Screw #6-32x3/8" Threaded Screw Control Panel Louver Side Valve angles to side Hose angles downward Valve, Hose, Regulator Assembly Carefully insert valve end into burner tube making sure [...]

4 • T urn fryer upright on its legs. Push on control knob and ignitor knob (A). • If not already assembled, slide handle springs onto side handles (B). • Attach side handles to fryer body using two #10-24x1/2" screws on each handle (C). Qty: 4 #10-24x1/2" Screw A B C #10-24x1/2" Screw Control Knob Ignitor Knob 5 • Slide greas[...]

6 • Place cooking pot and roaster basket into fryer body and storage lid on top. • When cooking hang storage lid on handle as shown. Once seasoning is complete, the fryer is now ready for use. We recommend cooking foods on the “Low” setting, until you get familiar with your fryer . NOTE: Before cooking on your fryer for the first time, refe[...]

EMERGENCIES: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder . Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire coming through control panel. Grease fire or cont[...]

Troubleshooting ( continued ) Possible Cause • Rotary knob rotates without clicking. • Sparking between ignitor and electrode. • See “GAS ISSUES:” on previous page. • Match will not reach. • Improper method of match-lighting. • Out of gas. • Excess flow valve tripped. • V apor lock at coupling nut/LP cylinder connection. • Low[...]

Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase. The manufacturer reserves the right to require that defective parts be returned, po[...]

07101366 • 19 Page Intentionally Blank[...]

© 2007 Char-Broil, LLC Printed in China • Columbus, GA 31902 • ST OP Should you encounter a problem with our product CALL US FIRST Do not return this product to the store. WE CAN HELP GRILL SERVICE CENTER 1-800-241-7548 HOURS 8AM-6PM EST Mon-Fri Please ensure your warranty registration is complete. Oil-Less Turkey Fryer Safety Checklist Read a[...]